MITSUBISHI OUTLANDER SPORT

SUSPENSION:FRONT:CONTROL ARM:LOWER ARM

Mitsubishi Motors North America, Inc. (MMNA) is recalling certain 2013-2015 Outlander Sport vehicles originally sold, or ever registered, in Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, and Wisconsin. The front lower control arms may detach due to the front cross member corroding from salt water exposure, such as from road salt use.

Risk: A detached front control arm can result in a loss of vehicle control, increasing the risk of a crash.

SUSPENSION:FRONT:CONTROL ARM:LOWER ARM

Mitsubishi Motors North America, Inc. (MMNA) is recalling certain 2008-2010 Lancer, 2009-2010 Lancer Sportback, 2008-2013 Outlander, and 2011-2016 Outlander Sport vehicles originally sold in, or ever registered in, Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, and Wisconsin. The front lower control arms may detach due to the front cross member corroding from salt water exposure such as from road salt use.

Risk: A detached front control arm can result in a loss of vehicle control, increasing the risk of a crash.

PARKING BRAKE

Mitsubishi Motors North America, Inc. (MMNA) is recalling certain 2016 Outlander and Outlander Sport vehicles. The rust prevention coating on the rear brake operating shafts could have been peeled off during the assembly process. As a result, water entering the rear brake caliper boot may cause the parking brake operating shafts to corrode and possibly bind.

Risk: If the parking brake operating shafts bind, the parking brakes may not engage or disengage fully. If the parking brakes do not engage properly, the vehicle could rollaway, increasing the risk of a crash.

PARKING BRAKE

Mitsubishi Motors North America, Inc. (MMNA) is recalling certain 2014-2016 Outlander and 2013-2016 Outlander Sport vehicles. Water may enter the rear brake calipers causing the parking brake actuator shafts to corrode and possibly bind.

Risk: If the parking brake actuator shaft binds, the parking brake may not engage or disengage fully. If the parking brake does not engage properly, the vehicle may move unexpectedly if it is parked on a slope, increasing the risk of a crash.

SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP

Mitsubishi Motors North America, Inc. (MMNA) is recalling certain 2018 Mitsubishi Outlander Sport vehicles equipped with a Forward Collision Mitigation (FCM) system and 2018 Mitsubishi Outlander PHEV and Eclipse Cross vehicles and 2017-2018 Outlander vehicles equipped with an Adaptive Cruise Control (ACC) system and/or an Electric Parking Brake (EPB) system. The software for the Hydraulic Unit Electronic Control Unit (ECU) may be incorrect, possibly preventing the intervention of a safety system such as automatic emergency braking, Anti-lock Braking (ABS), Electronic Stability Control (ESC), or the Brake Auto Hold (BAH) function when any of these systems are in use.

Risk: If the safety systems do not function as intended, it can increase the risk of a crash.

ELECTRICAL SYSTEM:SOFTWARE

Mitsubishi Motors North America (MMNA) is recalling certain 2018 Mitsubishi Outlander PHEV, Outlander Sport, 2018-2019 Eclipse Cross, and 2017-2018 Outlander vehicles equipped with a Forward Collision Mitigation (FCM) system that detects pedestrians. Due to incorrect software, the FCM-ECU (Electronic Control Unit) may apply braking for longer than needed, even after a pedestrian is no longer detected.

Risk: If the FCM-ECU software activates the brake for longer than necessary, the driver may react by applying additional braking. The resulting rapid deceleration of the vehicle can increase the risk of a rear-end collision.

ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:BELTS AND ASSOCIATED PULLEYS

Mitsubishi Motors North America, Inc. (MMNA) is recalling certain 2009-2012 Lancer, 2008-2012 Outlander, 2010-2012 Lancer Sportback, and 2011-2012 Outlander Sport vehicles equipped with either a 4B11 or 4B12 engine. The drive belt automatic tensioner flange may crack, allowing the accessory drive belt to detach.

Risk: If the drive belt detaches, the battery will discharge and the engine will stall, increasing the risk of a crash.

VISIBILITY:WINDSHIELD WIPER/WASHER:LINKAGES

Mitsubishi Motors North America, Inc. (MMNA) is recalling certain 2011-2016 Outlander Sport vehicles. Water may enter between the hood and windshield and cause the front wiper link ball joint to corrode, possibly resulting in the wiper link separating and the wipers becoming inoperative.

Risk: Loss of wiper function can reduce visibility and increase the risk of a crash.

ELECTRICAL SYSTEM:STARTER ASSEMBLY:RELAY

Mitsubishi Motors North America, Inc. (MMNA) is recalling certain 2015-2017 Outlander, 2015-2016 Lancer and Outlander Sport, and 2015 Lancer Evolution vehicles. These vehicles may have defective relays that can result in an engine stall, reduced engine power or the engine overheating.

Risk: If the engine stalls, there is an increased the risk of a crash.

UNKNOWN OR OTHER

When backing up the rear camera display is too dark to see. I have altered the settings for display from auto, to night, to day, and also adjusted the brightness level all the way up, but nothing changes. It remains the same and you can't safely see what is on the camera display.

ELECTRICAL SYSTEM

The contact owns a 2022 Mitsubishi Outlander Sport. The contact stated that while driving at various speeds, the navigational screen failed to function as intended. The contact was unable to connect the cell phone to the infotainment system or use Google Maps. The failure prevented the driver from safely operating the vehicle. In addition, the touch-screen icons failed to function as intended. The message "Maintenance Required" was displayed. The vehicle was taken to the dealer, where it was determined that the infotainment system had failed. The contact was informed that the system needed to be replaced. The contact was informed that a fix was not available. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 50,000.

AIR BAGS

Airbags did not deploy.

AIR BAGS

This is a follow-up and correction to a complaint previously submitted for VIN [XXX] regarding airbag non-deployment during a passenger-side T-bone collision on [XXX]. A [XXX] child was properly restrained in a rear-facing car seat in the rear passenger-side seat. The vehicle was struck directly on the passenger side at an estimated 30 mph. The front passenger door was deformed to the point it can no longer be opened. Despite this significant side impact and the presence of an occupied child seat in the rear, no side curtain airbags deployed—including those designed to protect rear outboard passengers. This vehicle is equipped with side curtain airbags as standard equipment. We believe this may constitute a failure of the Supplemental Restraint System (SRS) to perform as intended under FMVSS 214 and 226. We request that this report be associated with the prior complaint and considered in any manufacturer or regulatory investigation. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

AIR BAGS

On 05AUG25, my wife was involved in a frontal collision while driving our 2018 Mitsubishi Outlander Sport. The vehicle struck another vehicle at an estimated speed of over 30 mph, resulting in significant damage to the front passenger side, including deformation of the hood and front quarter panel. Despite the severity of the impact, no airbags deployed. My wife was properly restrained and sustained visible bruising across her torso. She is currently in her second trimester of pregnancy. The seatbelt force alone presented a serious safety risk to her and our unborn child. There were no airbag system warning lights prior to the collision, and the SRS appeared to be functioning normally. The failure of the airbags to deploy under these conditions indicates a potential defect in the supplemental restraint system. This appears to be a dangerous failure of the airbag system. We are requesting a formal investigation into the SRS components and crash sensor functionality of this vehicle model.

POWER TRAIN

The contact owns a 2015 Mitsubishi Outlander Sport. The contact stated that while driving at various speeds and while driving from a complete stop, the vehicle hesitated upon depressing the accelerator pedal. Additionally, the contact stated that the vehicle had failed to shift to reverse(R). The warning message "Service Transmission" was displayed. The contact drove the vehicle to an independent mechanic, where it was diagnosed that there were metal shavings in the transmission. The mechanic determined that the transmission needed to be replaced. The vehicle was not repaired. The contact related the failure to NHTSA Campaign Number: 16V563000(Power Train); however, the VIN was not included in the recall. The manufacturer was not informed of the failure. The failure mileage was 86,429.

POWER TRAIN

The contact owns a 2015 Mitsubishi Outlander Sport. The contact stated that the vehicle was experiencing rough idling, and the failure mainly occurred while the air conditioning system was activated. Additionally, while driving at various speeds or from a complete stop, the vehicle hesitated, jerked, and responded upon depressing the accelerator pedal. The transmission warning light was illuminated. The contact stated that the failure reoccurred while reversing. The contact stated that the failure had caused the vehicle to bump into nearby curbs while attempting to accelerate. The vehicle was taken to the dealer, where the cause of the failure could not be determined; however, the dealer cleaned the throttle body. The contact stated that the failure persisted. The vehicle was taken to the dealer approximately 4 to 5 times. The dealer was unable to diagnose the failure. The vehicle was not diagnosed or repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 30,000.

UNKNOWN OR OTHER

I am unsure of the proper name of the component with issues. There are several little issues but the main is, I believe it would be a software issue... Basically, on several different occasions (4) while driving at 60 mph and over, the vehicle suddenly stalled and shut off completely with no warning. The one incident which was the very first while I was driving less than 1 month ago. I was on a two lane road/freeway with another passenger in the back seat going somewhere between 60 and 65 mph. The car went completely black and everything shut down the entire vehicle, engine and all. I was in complete shock and end up scraping my front left rim on the curb I was next to, damaging the vehicle as a result. I am just recently out of my warranty and I do not have the funds to have it looked at just yet. I did inform the dealership that I purchased the vehicle from. I originally thought it was something maybe I had done to cause it. I also was completely unaware of any recalls on several of the year and model of my vehicle. When I looked up recalls on them, my vehicle has very similar issues to a lot of other cars like It that have already been recalled. I am upset because if I had known there were potential safety issues with these particular make and model car I would have not wanted to finance it, especially at the price point I have. It seems that several thousand were recalled a few months before I financed mine. Why wouldn’t I be notified that there could be potential safety issues when I was looking at the vehicle for purchase? Now here we are and I don’t think it is a safe vehicle. I need to do something.. I am not sure I want to keep it honestly ! What can I do? Please let me know at your earliest convenience. Thanks [XXX] [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

ELECTRICAL SYSTEM

I am unsure of the proper name of the component with issues. There are several little issues but the main is, I believe it would be a software issue... Basically, on several different occasions (4) while driving at 60 mph and over, the vehicle suddenly stalled and shut off completely with no warning. The one incident which was the very first while I was driving less than 1 month ago. I was on a two lane road/freeway with another passenger in the back seat going somewhere between 60 and 65 mph. The car went completely black and everything shut down the entire vehicle, engine and all. I was in complete shock and end up scraping my front left rim on the curb I was next to, damaging the vehicle as a result. I am just recently out of my warranty and I do not have the funds to have it looked at just yet. I did inform the dealership that I purchased the vehicle from. I originally thought it was something maybe I had done to cause it. I also was completely unaware of any recalls on several of the year and model of my vehicle. When I looked up recalls on them, my vehicle has very similar issues to a lot of other cars like It that have already been recalled. I am upset because if I had known there were potential safety issues with these particular make and model car I would have not wanted to finance it, especially at the price point I have. It seems that several thousand were recalled a few months before I financed mine. Why wouldn’t I be notified that there could be potential safety issues when I was looking at the vehicle for purchase? Now here we are and I don’t think it is a safe vehicle. I need to do something.. I am not sure I want to keep it honestly ! What can I do? Please let me know at your earliest convenience. Thanks [XXX] [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)