FORD F-350

BACK OVER PREVENTION: SENSING SYSTEM: CAMERA

Ford Motor Company (Ford) is recalling certain 2015 F-250, F-350, F-450, Expedition, Lincoln Navigator, and MKC vehicles. The rearview camera printed circuit board terminal header connector may be loose or damaged, which can result in a blank or distorted image.

Risk: A blank or distorted rearview camera image can reduce the driver's view of what is behind the vehicle, increasing the risk of a crash.

POWER TRAIN:AXLE ASSEMBLY

Ford Motor Company (Ford) is recalling certain 2020 F-350 trucks equipped with 7.3L gas engines and ambulance prep packages. These vehicles were ordered with Wide Track rear axles, but were built with base (narrower) axles. Depending on the body installed by the body builder, the inner tires on the dual wheel rear axle may contact the body.

Risk: Inner tire contact with the body could result in a tire blowout, potentially causing a loss of vehicle control, increasing the risk of crash.

POWER TRAIN:AXLE ASSEMBLY

Ford Motor Company (Ford) is recalling certain 2019 F-250 and F-350, single rear wheel and dual rear wheel, 4X4 vehicles. The front axles may contain a wheel end yoke that was not properly welded to the axle tube end.

Risk: An improperly welded axle may affect vehicle control, increasing the risk of a crash.

EQUIPMENT

VCI Emergency Vehicle Specialists (VCI) is recalling certain 2017-2018 Ford F-550, 2014 E-350 and E-450, 2015 F-250 and F-450, 2016 E-450, 2017 E-350, F-450 and E-450, 2018 F-350, 2010 E-450, 2005-2006 E-450, 2009 E-450 and Chevrolet C4500-based Type I and Type III ambulances equipped with ASA Electronics Voyager monitors used to display the back-up camera image. The monitors may unexpectedly revert back to the factory default settings which may cause the camera image to be reversed.

Risk: The driver may inadvertently turn the wrong direction to avoid an object behind the vehicle, increasing the risk of a crash.

SEATS:FRONT ASSEMBLY:RECLINER

Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 and 2019-2020 F-250, F-350, F-450, and F-550 Super Duty pickup trucks, and 2018-2019 Ford Explorer, 2019-2020 Expedition, and 2020 Escape vehicles equipped with driver and/or passenger's manual front seat back recliner mechanisms. Also included are certain 2020 Ford Explorer and Lincoln Aviator vehicles equipped with rear outboard seats and manual seat back recliner mechanisms. The recliner mechanisms may be missing the third pawl required for seat back strength, resulting in a loose seat back. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202, "Head Restraints" and 207, "Seating Systems."

Risk: A seat back with an improperly assembled recliner mechanism may have reduced strength and may not adequately restrain an occupant in a crash, increasing the risk of injury.

POWER TRAIN:AXLE ASSEMBLY:AXLE SHAFT

Ford Motor Company (Ford) is recalling certain 2019 F-250 and F-350 vehicles equipped with electronically locking rear differentials. The passenger side rear axle shaft may fail prematurely due to a material issue.

Risk: A broken passenger side rear axle could result in a loss of drive power and the inability to hold the vehicle still when in Park. If the parking brake is not applied, unintended vehicle movement can occur, increasing the risk of a crash.

ENGINE

Ford Motor Company (Ford) is recalling certain 2015-2019 Ford F-150 and 2017-2019 Ford F-250 Super Duty, F-350 Super Duty, F-450 Super Duty, and F-550 Super Duty pick-up trucks equipped with an engine block heater. Water and contaminants may get into the block heater cable's splice connector causing corrosion and damage.

Risk: When the heater is plugged in, prolonged corrosion could cause a resistive short, increasing the risk of overheated or melted wiring which can increase the risk of a fire.

STRUCTURE:BODY:DOOR

Ford Motor Company (Ford) is recalling certain 2015-2017 F-150, and 2017 F-250, F-350, F-450, and F-550 vehicles originally produced with black or body colored exterior door handles that may have been subsequently equipped with a chrome exterior door handle cover accessory kit purchased from a Ford dealer. These accessory door handle covers may cause the doors to unlatch in a side impact collision. As such, these vehicles may fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 206, "Door Locks and Door Retention Components."

Risk: If the doors unlatch and open in a side impact collision, the occupants have an increased risk of injury.

ELECTRICAL SYSTEM

Monroe Truck Equipment (Monroe) is recalling certain model year 2006, 2008 and 2009 Chevrolet C7500 vehicles, 2005-2006 Chevrolet Tahoe vehicles, and 2009 Ford F-350, and F-450 vehicles, equipped with Sure Power-brand battery equalizers or DC-DC converters containing a particular epoxy sealing, aka 'potting', compound. The specific potting compound used in the subject products for insulation was found to be capable of conducting electricity after being exposed to heat.

Risk: Once electrically conductive, the material is capable of melting and burning, increasing the risk of a fire.

ELECTRICAL SYSTEM

The contact owns a 2021 Ford F-350. The contact stated that while driving 65 MPH, the Disconnect/Reconnect message was displayed on the instrument panel. The contact stated that while depressing the brake pedal with the trailer brake control, the system indicated that there was no trailer detected. An independent mechanic was contacted. The vehicle was taken to an independent mechanic to be diagnosed; however, the diagnostic result was unknown. The contact stated that the fuses, wiring harness, and trailer brake control were replaced. The contact related the failure to NHTSA Campaign Number: 22V193000 (ELECTRICAL SYSTEM); however, the VIN was not included in the recall. The manufacturer was notified of the issue and informed the contact that a mechanic would be sent to inspect the vehicle. The failure mileage was 200,000.

WHEELS

I WAS DRIVING FORWARD APPROX 5 MPH AND LOST ALL CONTROL OF THE STEERING. THE STEERING WHEEL WAS NOT MOVING THE FRONT TIRES AT ALL. THERE WAS NO WARNING, AND INDICATION THAT THE STEERING WAS GOING BAD. THE TRUCK IS 2020 WITH APPROX 80,0000 MILES. NOT LIFTED, NO OFF ROADING. THE STEERING WHEEL WILL JUST SPIN NO STOP TO IT IN EITHER DIRECTION. MY UNDERSTANING WITH THIS TRUCK IS THERE IS NO INTERMIDATED SHAFT SO IT DIDNT SLOWLY GO OUT. THE NIGHT BEFORE MY FAMILY AND I WERE COMING DOWN FROM LAKE TAHOE WITH A BOAT ATTACHED. HAD THIS HAPPENED AT THAT SPPED WITH A TRAILER IT WOULD HAVE BEEN A VERY DIFFERENT OUTCOME.

STEERING

I WAS DRIVING FORWARD APPROX 5 MPH AND LOST ALL CONTROL OF THE STEERING. THE STEERING WHEEL WAS NOT MOVING THE FRONT TIRES AT ALL. THERE WAS NO WARNING, AND INDICATION THAT THE STEERING WAS GOING BAD. THE TRUCK IS 2020 WITH APPROX 80,0000 MILES. NOT LIFTED, NO OFF ROADING. THE STEERING WHEEL WILL JUST SPIN NO STOP TO IT IN EITHER DIRECTION. MY UNDERSTANING WITH THIS TRUCK IS THERE IS NO INTERMIDATED SHAFT SO IT DIDNT SLOWLY GO OUT. THE NIGHT BEFORE MY FAMILY AND I WERE COMING DOWN FROM LAKE TAHOE WITH A BOAT ATTACHED. HAD THIS HAPPENED AT THAT SPPED WITH A TRAILER IT WOULD HAVE BEEN A VERY DIFFERENT OUTCOME.

STRUCTURE:BODY

We were just driving when the truck started smoking and the brakes wouldn’t work. After a few minutes the truck completely caught on fire.

UNKNOWN OR OTHER

We were just driving when the truck started smoking and the brakes wouldn’t work. After a few minutes the truck completely caught on fire.

FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING

We were just driving when the truck started smoking and the brakes wouldn’t work. After a few minutes the truck completely caught on fire.

FUEL/PROPULSION SYSTEM

When exiting the interstate and coming to a complete stop at the bottom of the exit ramp we went to make a right turn onto a two lane mountain road when we felt a hesitation and within seconds the engine began to sputter, we lost power and the check engine light came on. This was a two lane 55MPH road with no shoulder pull off. Thankfully there was no oncoming traffic in the other lane and there was also an abandoned fruit stand parking lot which were were able to drift across the road and stop in. We experienced a COMPLETE loss of power. Had there been oncoming traffic or no open parking lot just across the road we might have experiened a crash. It is important to note that we were on a vacation in the mountains and thankfully our RV was parked at the Campground we were not towing it at this time. We had to find a tow service to have the vehicle towed to the nearest Ford Dealership in the area. The Dealership notified us that there were metal shavings/flakes in the lower fuel filter housing. They told us that this was a Complete Fuel System Failure and that we would need a complete fuel system replacement of all parts. We had been notified of the recall (Safety Recall Notice 24S78/NHTSA Recall 24V957) in January 2025 and we had taken it to the local Ford Dealership who advised there was no fix for the problem at this time. The Dealership that our truck was towed to after this incident advised us that we would have to pay for all the repair costs (excess of $10,000) as this was still an open recall. We feel that this is a MAJOR safety issue - we were due to leave for home the following morning where we would have been towing a 7500lbs travel trailer on the interstate roads. Had we experienced this failure then it could have been truley tragic for not only us but other motorists. After this incident we called Ford Motor Company and advised them and they told us it was still considered an open recall with no fix available.

STEERING

The contact owns a 2015 Ford F-350. The contact stated that while driving at an undisclosed speed, the contact became aware that the electronic power steering was not functioning properly, requiring the steering wheel to be manually returned to center after completing a turn. The vehicle returned to normal functionality, but the failure became a regular occurrence. No warning lights were illuminated. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 120,000.

VISIBILITY/WIPER

My back up camera is not working.