WINNEBAGO TRAVATO

STRUCTURE:BODY

Winnebago Industries, Inc. (Winnebago) is recalling certain 2017-2024 Travato motorhomes. The retractable awning may extend unintentionally during transit.

Risk: An awning that extends during transit may become a distraction or road hazard, increasing the risk of a crash.

FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS

Winnebago Industries, Inc. (Winnebago) is recalling certain 2020-2023 Travato, 2021-2023 Solis, and 2022-2023 Ekko motorhomes, equipped with certain Cummins Onan QG 2800i, and Onan QG 2800i EVAP generator sets. The fuel hose between the fuel filter and Injection Pump Module (IPM) may not be properly secured, which can cause a gas leak.

Risk: A gas leak in the presence of an ignition source increases the risk of a fire.

EQUIPMENT:APPLIANCE:OVEN/STOVE/COOKTOP

Winnebago Industries, Inc. (Winnebago) is recalling certain 2020-2023 Solis, 2021-2023 Travato, and 2022-2023 Ekko motorhomes, equipped with certain Suburban Manufacturing Company (Suburban) SDS2 2-Burner Drop-in Cooktops with part number 3032AST. The internal aluminum burner tubes that connect to the gas valves may fracture and cause a gas leak.

Risk: A gas leak in the presence of an ignition source can increase the risk of a fire.

STRUCTURE:BODY

Winnebago Industries, Inc. (Winnebago) is recalling certain 2019-2023 Winnebago Travato motorhomes. The retractable awning may extend unintentionally during transit.

Risk: An awning that extends during transit, may become a distraction or road hazard, increasing the risk of a crash.

ELECTRICAL SYSTEM:WIRING

Winnebago Industries, Inc. (Winnebago) is recalling certain 2019-2022 Travato and 2021-2022 Boldt vehicles. The wire harness may have been built incorrectly, resulting in the loss of over-current protection.

Risk: Loss of over-current protection can cause the wires to overheat, increasing the risk of a fire.

SEAT BELTS:REAR/OTHER:RETRACTOR

Winnebago Industries, Inc. (Winnebago) is recalling certain 2021-2022 Solis, Travato, and Ekko vehicles, equipped with GE-ES Double Flipseats. The seat belt retractors may lock up when the vehicle is on a slight incline. As such, these seats fail to comply with the requirements of Federal Motor Vehicle Safety Standards numbers 208, "Occupant Crash Protection" and 209, "Seat Belt Assemblies."

Risk: If the seat belt retractor locks, a passenger may believe they are trapped in the vehicle, increasing the risk of injury.

EQUIPMENT:MECHANICAL:CARRIER/RACK

Winnebago Industries, Inc (Winnebago) is recalling certain 2018 Winnebago Travato and 2018-2019 Winnebago Era, and Revel recreational vehicles. The roof rack may not have been installed with the correct fasteners, possibly resulting in the roof rack detaching from the vehicle while moving.

Risk: If the roof rack detaches while moving, it could become a road hazard, increasing the risk of a crash.

ELECTRICAL SYSTEM

Winnebago Industries, Inc (Winnebago) is recalling certain 2016-2019 Winnebago Era, Travato, Fuse, View, Trend, Aspect, Paseo, Via, Adventurer, Journey, Tour, and Grand Tour motorhomes. These vehicles have an auxiliary solar charging port circuit that is not fused.

Risk: If solar panels are connected and they exceed the amperage capacity of the circuit, the unprotected circuit can increase the risk of a fire.

EQUIPMENT:RECREATIONAL VEHICLE/TRAILER:LPG SYSTEMS:LINES AND FITTINGS

Winnebago Industries, Inc. (Winnebago) is recalling certain 2016-2017 Travato recreational vehicles. The liquid propane (LP) hose may contact the emergency brake cable, potentially damaging it and causing it to leak propane.

Risk: A propane leak can increase the risk of a fire or an explosion.

EQUIPMENT:RECREATIONAL VEHICLE/TRAILER

RE: NHTSA recalls 22V-696 and 23V-62 While parked at a State Camp Ground the Carefree Awning opened violently. If someone had been standing outside near the Van they surely would have bee hit/injured. Conditions; Sunny afternoon, no Wind, Flat surface. I am the 2nd Owner of the Winnebago Travato Camper Van. Through my own research prior to buying the Van I was aware that there had been issues with the Carefree Awnings. The Seller of my Van completed the recalls with repairs at the dealership where the Van was purchased. I am concerned that the issue does not seem to be completely resolved. I contacted Winnebago and La Mesa RV in the Phoenix AZ area for assistance. La Mesa RV replied directing me to Contact Winnebago.....no response yet. I am hoping that this report will further the investigation as to why Winnebago has not simply replaced the defective awnings with a comparable and SAFE product.

UNKNOWN OR OTHER

RE: NHTSA recalls 22V-696 and 23V-62 While parked at a State Camp Ground the Carefree Awning opened violently. If someone had been standing outside near the Van they surely would have bee hit/injured. Conditions; Sunny afternoon, no Wind, Flat surface. I am the 2nd Owner of the Winnebago Travato Camper Van. Through my own research prior to buying the Van I was aware that there had been issues with the Carefree Awnings. The Seller of my Van completed the recalls with repairs at the dealership where the Van was purchased. I am concerned that the issue does not seem to be completely resolved. I contacted Winnebago and La Mesa RV in the Phoenix AZ area for assistance. La Mesa RV replied directing me to Contact Winnebago.....no response yet. I am hoping that this report will further the investigation as to why Winnebago has not simply replaced the defective awnings with a comparable and SAFE product.

EQUIPMENT:RECREATIONAL VEHICLE/TRAILER

May 24,2025 as we were driving, the awning completely deployed out causing us to quickly drive on a safer lane to the side to avoid any risk to other drivers. This is definitely a safety risk for travel that can put ourselves and others at harm or crash collision. There were no prior warning whatsoever on our dash board or driver console at all during this incident.