WINNEBAGO ADVENTURER

ELECTRICAL SYSTEM:WIRING

Winnebago Industries, Inc. (Winnebago) is recalling certain 2023-2025 Vista, Sunstar, and Adventurer motorhomes built on F53 chassis. The wiring may have been incorrectly routed, damaging the forward-facing camera wiring.

Risk: Damaged wiring can cause the camera to become inoperable, disabling active brake assist, lane keep assist, and auto high beams and increasing the risk of a crash.

EXTERIOR LIGHTING:TURN SIGNAL

Winnebago Industries, Inc. (Winnebago) is recalling certain 2013-2017 Tour, 2013-2018 Journey, 2014-2022 Forza, 2015-2016 Brave, 2015-2019 Grand Tour, 2015-2021 Vista, 2016-2018 Adventurer, Sightseer, 2016-2021 Commercial Vehicle, 2018-2021 Intent, Sunstar, 2018-2020 Horizon, Itasca 2013-2017 Ellipse, Meridian, 2014-2017 Solei, 2015-2016 Tribute, 2015-2018 Sunstar, 2016-2018 Suncruiser, and Sunova motorhomes. The turn signals may have a smaller than required luminous lens area. As such these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) Number 108, "Lamps, Reflective Devices, and Associated Equipment."

Risk: A small lens can make it difficult for other drivers to see the turn signal, increasing the risk of a crash.

STRUCTURE:BODY:HOOD:HINGE AND ATTACHMENTS

Winnebago Industries, Inc. (Winnebago) is recalling certain 2014-2018 Sightseer, Itasca Sunova, 2016-2025 Forza, Vista, and Itasca/Winnebago Sunstar, 2015-2025 Adventurer, 2015-2024 Commercial Vehicle, 2015-2028 Itasca Suncruiser, and 2016-2017 Itasca Solei recreational vehicles. The hood bracket adhesive may have been incorrectly applied which can allow the bracket to detach.

Risk: A detached hood bracket may become a road hazard and increase the risk of a crash.

EXTERIOR LIGHTING

Winnebago Industries, Inc. (Winnebago) is recalling certain 2023 Adventurer, Vista and Itasca Sunstar motorhomes. The motorhomes may be missing the rear reflectors. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."

Risk: Missing reflectors reduce the vehicle's visibility to other drivers, increasing the risk of a crash.

SEAT BELTS:CRITICAL FASTENERS

Winnebago Industries, Inc. (Winnebago) is recalling certain 2020-2023 Winnebago Shell, 2021-2023 Winnebago Inspire, 2022-2023 Winnebago Vista, Adventurer, Forza, Journey and Itasca Sunstar motorhomes. The seat belt attachment may have been improperly tightened. As such these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) 210, "Seat Belt Assembly Anchorages."

Risk: A loose seat belt attachment may not properly restrain the occupant in the event of a crash, increasing the risk of injury.

EQUIPMENT

Winnebago Industries, Inc. (Winnebago) is recalling certain 2021 Revel, Vista, Sunstar, and Adventurer Motorhomes. The power bed motor may experience an internal gear failure, causing the bed to extend prior to the safety strap engaging.

Risk: A bed that falls unexpectedly increases the risk of injury or death.

ELECTRICAL SYSTEM

Winnebago Industries, Inc (Winnebago) is recalling certain 2020 Adventurer motorhomes. When using 30 AMP service, the heat coil may not disengage when the Power Control System (PCS) calls to stop the air conditioner power.

Risk: If the heat coil does not disengage with the air conditioner, heat can increase inside the unit, increasing the risk of a fire.

ELECTRICAL SYSTEM

Winnebago Industries, Inc. (Winnebago) is recalling certain 2017-2020 Itasca Vista, Sunstar, and Adventurer 35F motorhomes. An electrical connector was mounted directly on the floor instead of to a standoff backet as intended.

Risk: If the floor gets wet where the electrical connection is mounted, there is an increased risk of an electrical short and fire.

ELECTRICAL SYSTEM

Winnebago Industries, Inc (Winnebago) is recalling certain 2016-2019 Winnebago Era, Travato, Fuse, View, Trend, Aspect, Paseo, Via, Adventurer, Journey, Tour, and Grand Tour motorhomes. These vehicles have an auxiliary solar charging port circuit that is not fused.

Risk: If solar panels are connected and they exceed the amperage capacity of the circuit, the unprotected circuit can increase the risk of a fire.

STRUCTURE

The contact owns a 2019 Winnebago Adventurer. The contact received notification of NHTSA Campaign Number: 24V826000 (Latches/Locks/Linkages, Structure); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact stated that while her husband was driving at approximately 65 MPH, there was an abnormal sound coming from the under the hood. The contact stated that after arriving at the intended destination, the contact’s husband lifted the hood and became aware that passenger’s side hood bracket had detached from the hood. The part was not recovered from the highway. The failure mileage was approximately 8,000.

LATCHES/LOCKS/LINKAGES

The contact owns a 2019 Winnebago Adventurer. The contact received notification of NHTSA Campaign Number: 24V826000 (Latches/Locks/Linkages, Structure); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact stated that while her husband was driving at approximately 65 MPH, there was an abnormal sound coming from the under the hood. The contact stated that after arriving at the intended destination, the contact’s husband lifted the hood and became aware that passenger’s side hood bracket had detached from the hood. The part was not recovered from the highway. The failure mileage was approximately 8,000.

STRUCTURE:BODY:HOOD:HINGE AND ATTACHMENTS

The epoxy that attaches the hood brackets and the grill to the body is failing. Both hood brackets have come loose, the bracket on the passenger side came loose and fell off of the motorhome on the road and the driver side bracket came off and I noticed it before it fell completely off. Two of the grill brackets are now loose also.

STRUCTURE:BODY

The epoxy that attaches the hood brackets and the grill to the body is failing. Both hood brackets have come loose, the bracket on the passenger side came loose and fell off of the motorhome on the road and the driver side bracket came off and I noticed it before it fell completely off. Two of the grill brackets are now loose also.