VOLVO C70

EQUIPMENT:OTHER:LABELS

VOLVO IS RECALLING CERTAIN MODEL YEAR 2006-2012 C70 VEHICLES MANUFACTURED FROM NOVEMBER 15, 2005, THROUGH JULY 31, 2011, AND MODEL YEAR 2011-2012 S60 VEHICLES MANUFACTURED FROM JULY 14, 2010, THROUGH APRIL 16, 2011, THAT WERE EQUIPPED WITH OPTIONAL ACCESSORY SPARE TIRE KIT. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NUMBER. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES DO NOT CONTAIN THE CORRECT INFORMATION FOR VEHICLES EQUIPPED WITH THE OPTIONAL ACCESSORY SPARE TIRE AND WHEEL KIT.

Risk: A MISPRINTED LABEL COULD LEAD TO IMPROPER TIRE INFLATION WHICH COULD RESULT IN A TIRE FAILURE, INCREASING THE RISK OF A CRASH.

STRUCTURE:BODY

The drivers side door keeps opening while driving. I see recalls for other volvo models but not mine. This is very concerning when driving on the highway

LATCHES/LOCKS/LINKAGES:DOORS:LATCH PLATE

While in transit, the passenger door periodically unlatches on its own. There is a safeguard that prevents the door from completely swinging open when this happens. This problem has not been inspected by a professional. The warning light appears after the door unlatches while in motion. Because I never have a passenger, I am not able to immediately close the door. The last time this happened was at 65 mph on [XXX]. This problem has existed for years. The vehicle is available for inspection upon request. The cause is unknown, and timing is unpredictable. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

LATCHES/LOCKS/LINKAGES:DOORS:LATCH

Both cabin doors (initially only the passenger door) will pop half-open from a closed position while driving, particularly with the windows and/or roof down. This occurs seemingly at random and regardless of lock position or firmness of door closing. The effect is a startling noise as the door opens slightly, the window retracts, and the cabin lights and door warning alarm engage. This can pose a hazard to safe driving. Neither door has as-of-yet come fully unlatched, remaining instead in a half-latched position until the driver can pull over and close the door fully once more. Lubrication of the latches by a mechanic did not alleviate the issue, and a cursory browsing of Volvo forums suggests that this is a common issue for which no recall or service bulletin has been issued.

SERVICE BRAKES

The car developed an electronic communication issue that would cause random failure messages for the ABS, anti-skid system, transmission control and a "brake failure" message that would put the car into limp mode even at highway speeds. If you come to a complete stop, it would not allow you to pull away at any speed which makes you a traffic hazard and at risk for a rear end collision. I took the car to the dealer and they said it was the steering module so I had them replace it which ended up not resolving the problem. More alarming, the mechanic said that the factory original windshield had become unbonded and needed resealed. He showed me by flexing the windshield out at the top. I paid a windshield shop to reseal the windshield but I am reporting this since it's bond to the body is integral to keeping occupants from being ejected in the event of a rollover and the owner is unlikely to ever notice the issue.

POWER TRAIN

The car developed an electronic communication issue that would cause random failure messages for the ABS, anti-skid system, transmission control and a "brake failure" message that would put the car into limp mode even at highway speeds. If you come to a complete stop, it would not allow you to pull away at any speed which makes you a traffic hazard and at risk for a rear end collision. I took the car to the dealer and they said it was the steering module so I had them replace it which ended up not resolving the problem. More alarming, the mechanic said that the factory original windshield had become unbonded and needed resealed. He showed me by flexing the windshield out at the top. I paid a windshield shop to reseal the windshield but I am reporting this since it's bond to the body is integral to keeping occupants from being ejected in the event of a rollover and the owner is unlikely to ever notice the issue.