2016 SUBARU OUTBACK

AIR BAGS: AIR BAG/RESTRAINT CONTROL MODULE

Subaru of America, Inc. (Subaru) is recalling certain 2016-2017 Outback vehicles. A replacement air bag control module may have been installed that is not compatible with the passenger air bag module, possibly affecting air bag deployment.

Risk: In the event of a crash necessitating passenger frontal air bag deployment, the air bag may not deploy properly, increasing the risk of injury.

STEERING:COLUMN

Subaru of America, Inc. (Subaru) is recalling certain model year 2016-2017 Legacy and Outback vehicles manufactured February 29, 2016, to May 6, 2016. The steering column on the affected vehicles may have been improperly machined, and as a result, turning the steering wheel may have no effect on the direction of the wheels.

Risk: The loss of steering ability would increase the risk of a crash.

POWER TRAIN:DRIVELINE:DRIVESHAFT

Subaru of America, Inc. (Subaru) is recalling certain model year 2016 Legacy vehicles manufactured October 24, 2015, to November 16, 2015, and Outback vehicles manufactured October 24, 2015, to November 17, 2015. Due to the improper tightening of the securing nuts, the drive shaft may separate from the rear differential.

Risk: If the drive shaft detaches from the rear differential, it may strike the fuel tank and result in a fuel leak, increasing the risk of a fire.

UNKNOWN OR OTHER

I reached under the steering well to the foot well because it seemed that my AC was not putting out any air. I touched something and received a burn on my hand. I reached out to the SOA but was told to take it to the dealer. Then they asked me to call back and discuss further. When I called back I was told to take it to the dealer. I'm not sure I want to take it to the dealer to be charged a diagnosis fee. It seems the "kick panel" should cover this hot part to not allow access.

UNKNOWN OR OTHER

Horn quit working

ENGINE

The contact owns a 2016 Subaru Outback. The contact stated that while driving at an undisclosed speed, the low oil warning light illuminated. The vehicle was taken to the dealer, where it was diagnosed and determined that the engine seal had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 110,000.

ELECTRICAL SYSTEM

EYE SIGHT GOES OUT SHORTLY AFTER RECONFIGURATION (HAS HAPPENED SEVERAL TIMES), BRAND NEW BATTERY HAS BEEN DRAINED CAUSING COMPLETE SHUT DOWN, HAS BEEN IN SHOP FOR SIX WEEKS AND DEALERSHIP CANNOT FIND REASON FOR THIS HAPPENING AND HAS REPLACED BATTERY AND DRIVEN THE CAR WAITING FOR A REPLICA TO HAPPEN. MY RESEARCH LEANS TOWARD DCM/ECM/PARASITIC BATTERY DRAIN ISSUES BUT THERE DOES NOT SEEM TO BE A RECALL FOR THESE ELECTRONIC ISSUES.

ENGINE

Safety concern - Exhaust entering into the car. Smells of exhaust. Warranty should be extended to 15 years, 150,000 miles as was done on identical part 2017-2018MY Subaru Forrester Exhaust Pipe Front (EPF) Bellows Cracking. This part is known to be defective. 1. My 2016 Subaru Outback 2.5L if manufactured 12/9/2013 - 9/30/2015 is covered. My Subaru just outside this window, manufactured 12/2015. Service Program Bulletin Number: WUJ-95. 2. My Subaru is within the 80,000 routine emissions warranty, though 1 year outside the 8 years. 3. This Exhaust Pipe Front (EPF) Bellows Cracking happens on the identical part in the Forester and has an Exhaust Pipe (Front) Warranty Extension (W122-013) to 150,000, 15 years. Attached - Repair estimate, Service Program Bulletin WUJ-95 dealing with this year Outback, Service Bulletin Number 09-84-22 dealing with identical part 2017-8 Subaru Forester

ENGINE

Exhaust leak in or near exhaust manifold / bellows / flex pipe identical to problem identified in WUJ-95 recall, confirmed by both dealer and independent mechanic. Problem produces 'growl' and fumes in passenger cabin. This problem likely existed when we purchased the car used from LaFontaine Subaru in Commerce, MI.

UNKNOWN OR OTHER

Known battery drain likely from DCM and also they designed the alternator not to completely charge battery causing frequent dead battery without warning and for no operator error and causing frequent need to replace car batteries over the years.There was a class action lawsuit but no recall for these issues so has not been addressed properly.

ELECTRICAL SYSTEM

Known battery drain likely from DCM and also they designed the alternator not to completely charge battery causing frequent dead battery without warning and for no operator error and causing frequent need to replace car batteries over the years.There was a class action lawsuit but no recall for these issues so has not been addressed properly.

UNKNOWN OR OTHER

Exhaust gas smells in the driver cabin and the exhaust shield and the pipe is breaking off.

ENGINE

Exhaust gas smells in the driver cabin and the exhaust shield and the pipe is breaking off.

ENGINE

The contact owns a 2016 Subaru Outback. The contact stated that there was an exhaust odor entering into the cabin of the vehicle, which was most noticeable when the heater was activated. The contact stated that while the vehicle was idling, there was an abnormally loud sound as if the exhaust was releasing in large amount of fumes. There were no warning lights illuminated. The contact stated that the failure was related to the emissions and was related to NHTSA ID Number: 10182196 (Engine and Engine Cooling, Equipment, Equipment Adaptive/Mobility). The vehicle was not diagnosed or repaired. The manufacturer was informed of the failure and confirmed that the VIN was not covered under NHTSA ID Number: 10182196 (Engine and Engine Cooling, Equipment, Equipment Adaptive/Mobility) or under warranty. The manufacturer opened a case and referred the contact to the NHTSA Hotline to report the failure. The failure mileage was unknown.

ENGINE AND ENGINE COOLING

The contact owns a 2016 Subaru Outback. The contact stated that there was an exhaust odor entering into the cabin of the vehicle, which was most noticeable when the heater was activated. The contact stated that while the vehicle was idling, there was an abnormally loud sound as if the exhaust was releasing in large amount of fumes. There were no warning lights illuminated. The contact stated that the failure was related to the emissions and was related to NHTSA ID Number: 10182196 (Engine and Engine Cooling, Equipment, Equipment Adaptive/Mobility). The vehicle was not diagnosed or repaired. The manufacturer was informed of the failure and confirmed that the VIN was not covered under NHTSA ID Number: 10182196 (Engine and Engine Cooling, Equipment, Equipment Adaptive/Mobility) or under warranty. The manufacturer opened a case and referred the contact to the NHTSA Hotline to report the failure. The failure mileage was unknown.

ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE

The contact owns a 2016 Subaru Outback. The contact stated while the vehicle was occupied and parked at residence and attempting to start the vehicle, there was an abnormal sound coming from the underneath the vehicle. The contact stated while driving at various speeds there was exhaust fumes entering the cabin of the vehicle. The vehicle was taken to the dealer where it was diagnosed and determined that front exhaust manifold connected to the catalytic converter needed to be replaced. The contact stated that the technician inspected the vehicle and became aware that the exhaust pipe was rusted. The vehicle was not repaired. The manufacturer was notified of the failure but offered no assistance. The manufacturer informed the contact that there were no recalls associated with the VIN. The contact related the failure to a Service Program Bulletin: WUJ-95R (Exhaust Pipe Front (EPF) Bellows Cracking); however, the VIN was not included in the bulletin. The contact was referred to the NHTSA Hotline for assistance. The failure mileage was 171,000.

UNKNOWN OR OTHER

There’s an open recall on an exhaust leak for similar models and years and my car needs the same work done but it’s not covered under the recall

UNKNOWN OR OTHER

The 8 month old battery on my 2016 Subaru Outback just died. I understand that the warranty on the DCM was extended by a year, but the dealership said that if it turned out the DCM was not defective, I would have to pay for the test ($185) . The warranty only covers having the battery recharged or replaced. If the DCM is the cause of the battery drain, than the warranty should pay for replacing the DCM, in addition to replacing the battery. Otherwise the problem will continue to reoccur. There should be a recall on the DCM!

STEERING

The steering warning light came on and my steering wheel stiffened. Luckily I was able to make it home, but when I went back to crank it. The light was still on and it would only move forward of backwards; because I wasn't able at all to turn the steering wheel.

ELECTRICAL SYSTEM

The steering warning light came on and my steering wheel stiffened. Luckily I was able to make it home, but when I went back to crank it. The light was still on and it would only move forward of backwards; because I wasn't able at all to turn the steering wheel.