FORD EXPEDITION

BACK OVER PREVENTION:SOFTWARE

Ford Motor Company (Ford) is recalling certain 2018-2022 Transit Connect, 2019-2020 MKZ, Edge, Continental, F-150, Nautilus, Fusion, 2019-2023 Ranger, Mustang, 2020-2021 EcoSport, Expedition, Navigator, 2020-2022 Escape, F-250 SD, Corsair, 2020-2023 Aviator, Transit, 2020-2024 Explorer, 2021-2024 Bronco Sport, and 2022-2024 Maverick vehicles. A software error may cause the rearview camera to display a blank image, or the image may remain on the display after the backing event has ended.

Risk: A rearview camera that displays a blank image can reduce the driver's view behind the vehicle. A rearview image that continues to be displayed after the vehicle is shifted out of reverse may distract the driver. Both of these situations can increase the risk of a crash.

ELECTRICAL SYSTEM:BODY CONTROL MODULE:SOFTWARE

Ford Motor Company (Ford) is recalling certain 2020 Expedition and Navigator vehicles that were repaired incorrectly under recall 20V262. The Pre-Collision Assist features, such as forward collision warning and automatic emergency braking, are not functional due to a software error.

Risk: Inoperative pre-collision assist features that fail to perform as expected can increase the risk of a crash or injury.

BACK OVER PREVENTION: SENSING SYSTEM: CAMERA

Ford Motor Company (Ford) is recalling certain 2015 F-250, F-350, F-450, Expedition, Lincoln Navigator, and MKC vehicles. The rearview camera printed circuit board terminal header connector may be loose or damaged, which can result in a blank or distorted image.

Risk: A blank or distorted rearview camera image can reduce the driver's view of what is behind the vehicle, increasing the risk of a crash.

BACK OVER PREVENTION: SENSING SYSTEM: CAMERA

Ford Motor Company (Ford) is recalling certain 2021 Expedition, 2021-2022 Super Duty F-250, F-350, F-450, F-550, F-600, and 2020-2022 Lincoln Corsair vehicles. The rearview camera may display a blank or distorted image.

Risk: Rearview camera failure can reduce the driver's view of what is behind the vehicle, increasing the risk of a crash.

FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP

Ford Motor Company (Ford) is recalling certain 2021-2023 Bronco, Explorer, Lincoln Aviator, F-250 SD, F-350 SD, F-450 SD, F-550 SD, 2021-2022 Lincoln Navigator, Mustang, F-150, and 2022 Expedition vehicles. The low-pressure fuel pump may fail, which can result in an engine stall while driving.

Risk: An engine stall increases the risk of a crash.

AIR BAGS:FRONTAL

Ford Motor Company (Ford) is recalling certain 2025 Navigator and Expedition vehicles. The passenger side air bag may have been manufactured incorrectly, which can cause the air bag to deploy with excessive force during a crash.

Risk: An air bag that deploys with excessive force can increase the risk of injury during a crash.

SEAT BELTS:PRETENSIONER

Ford Motor Company (Ford) is recalling certain 2018-2020 Expedition and Lincoln Navigator vehicles. The seat belt pretensioner in the driver and/or front passenger seat may inadvertently lock the seat belt, which will not allow the belt to retract or extend.

Risk: Seat belts that do not retract or extend can fail to restrain an occupant as intended, increasing the risk of injury in a crash.

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS

Ford Motor Company (Ford) is recalling certain 2022-2024 Navigator and Expedition vehicles. The front brake lines may contact the engine air cleaner outlet pipe and become damaged, possibly resulting in a brake fluid leak and reduced brake function.

Risk: A loss of brake function increases the risk of a crash.

SERVICE BRAKES, HYDRAULIC:POWER ASSIST

Ford Motor Company (Ford) is recalling certain 2017-2018 F-150, Expedition, and Lincoln Navigator vehicles. The brake master cylinder may allow brake fluid to leak from the front wheel circuit into the brake booster.

Risk: A brake fluid leak can cause reduced brake function and extend the distance required to stop, increasing the risk of a crash.

BACK OVER PREVENTION

The contact owns a 2012 Ford Expedition. The contact stated that the image displayed on the back over prevention screen was either upside down, distorted, static only, or completely black. The failure was intermittent. During the failure, the contact was able to restart the vehicle to fix the image; however, the fix was intermittent. The vehicle was not taken to the dealer. The vehicle was not diagnosed or repaired. The contact researched and found information on NHTSA Campaign Number: 25V270000 (Back Over Prevention); however, the VIN and model year was not included. The vehicle was not repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 78,000.

POWER TRAIN

The vehicle has not been inspected by anybody so the problem is not been reproduced. It just happened this morning. There have not been any check engine lights or anything related pop up on the dash. I was leaving my house I just reached highway speeds 50 to 60 miles per hour I was in 5th or 6th Gear. The transmission suddenly downshifted on its own to first gear it downshifted so hard and so fast that it barked the tires really hard the RPMs went up to 5 to 6,000 I thought that it had somehow been hit into reverse or park or something I am the only one in the vehicle. I shift the vehicle into neutral and then I went back down to manual and cycled up and down a gear and then put it back in Drive.

ELECTRICAL SYSTEM

Vehicle was taken to Chipola Ford for Blower Motor Recall April 2025 and was replaced under recall. Since then, the blower motor intermittently fails and and no air will come out of the dash. The wiring for the blower motor under the dash gets extremely hot when the blower motor fails.

FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING

July 17th on highway going near highway speed of 65-70mph in congested heavier traffic, person merging from on ramp caused abrupt slow to stop and rear ended a F250 truck causing MAJOR front end damage, couldn’t get front doors open, frame bent, vehicle totalled with $22k or more in damages. Seatbelt locked and air bags NEVER deployed. Ford dealership and insurance company very very suprised that given impact, speed, etc airbags never went off. Also emergency braking system did give collision detection warning and then seemed to entirely take over braking as I attempted to brake very hard nothing seemed to be happening for brakes. Seemed crash could have been entirely avoided. Vehicle totalled and gone to salvage yard. Thank goodness no injury very badly bruised

UNKNOWN OR OTHER

July 17th on highway going near highway speed of 65-70mph in congested heavier traffic, person merging from on ramp caused abrupt slow to stop and rear ended a F250 truck causing MAJOR front end damage, couldn’t get front doors open, frame bent, vehicle totalled with $22k or more in damages. Seatbelt locked and air bags NEVER deployed. Ford dealership and insurance company very very suprised that given impact, speed, etc airbags never went off. Also emergency braking system did give collision detection warning and then seemed to entirely take over braking as I attempted to brake very hard nothing seemed to be happening for brakes. Seemed crash could have been entirely avoided. Vehicle totalled and gone to salvage yard. Thank goodness no injury very badly bruised

UNKNOWN OR OTHER

I purchased my 2019 Ford Expedition Max Limited on [XXX]. When we purchase the vehicle we signed a notice that we would have the recalls completed within a reasonable time. I took my vehicle for the recall to Feyer Ford in Edenton, North Carolina on May 30th. Prior to the recall I was having no issues at all with the vehicle. Once I pick the vehicle up on [XXX] and started my traveling home. Within 10 minutes of leaving, the vehicle made a loud screeching noise. The wrench light came on, and the vehicle seemed to not accelerate forward. I was able to pull off the road and turn the vehicle off. I called Feyer Ford to make them aware of the problem and they told me that it was because the PCM had been reprogrammed and would need to relearn how I drive. I had the same issue happen again further down the road, this is a very serious safety hazard that my vehicle suddenly stopped moving forward in traffic. I called Feyer Ford once again and was told that I had to drive the vehicle 1,000 miles before the PCM would relearn my driving patterns. I took the vehicle in on June 4th to have it checked out and was told that I would need a valve body replacement and torque converter replacement. That essentially my transmission was bad. Since that date the vehicle has gone into reverse numerous times when I put it in Drive, it will also get stuck in 4th 7th or 10th gear when you are trying to drive it in a parking lot or going slow on the road. When it gets stuck in those gears the vehicle will not go forward it will only allow you to go backwards. My car has been at Feyer Ford since July 29 trying to have the warranty cover the fix, but it was denied for warranty coverage because they stated the vehicle was broken by the recall. We were told we could pick up our un-fixed vehicle on Aug 27. We got the key and proceeded to leave only to find the car not put back together from a different seat belt recall. It is still at Feyer Ford today, September 6th 2025. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA),

POWER TRAIN

I purchased my 2019 Ford Expedition Max Limited on [XXX]. When we purchase the vehicle we signed a notice that we would have the recalls completed within a reasonable time. I took my vehicle for the recall to Feyer Ford in Edenton, North Carolina on May 30th. Prior to the recall I was having no issues at all with the vehicle. Once I pick the vehicle up on [XXX] and started my traveling home. Within 10 minutes of leaving, the vehicle made a loud screeching noise. The wrench light came on, and the vehicle seemed to not accelerate forward. I was able to pull off the road and turn the vehicle off. I called Feyer Ford to make them aware of the problem and they told me that it was because the PCM had been reprogrammed and would need to relearn how I drive. I had the same issue happen again further down the road, this is a very serious safety hazard that my vehicle suddenly stopped moving forward in traffic. I called Feyer Ford once again and was told that I had to drive the vehicle 1,000 miles before the PCM would relearn my driving patterns. I took the vehicle in on June 4th to have it checked out and was told that I would need a valve body replacement and torque converter replacement. That essentially my transmission was bad. Since that date the vehicle has gone into reverse numerous times when I put it in Drive, it will also get stuck in 4th 7th or 10th gear when you are trying to drive it in a parking lot or going slow on the road. When it gets stuck in those gears the vehicle will not go forward it will only allow you to go backwards. My car has been at Feyer Ford since July 29 trying to have the warranty cover the fix, but it was denied for warranty coverage because they stated the vehicle was broken by the recall. We were told we could pick up our un-fixed vehicle on Aug 27. We got the key and proceeded to leave only to find the car not put back together from a different seat belt recall. It is still at Feyer Ford today, September 6th 2025. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA),

POWER TRAIN

See attached document for complaint.

ELECTRICAL SYSTEM

See attached document for complaint.