2025 WINNEBAGO EKKO

TIRES:VALVE

Winnebago Industries, Inc. (Winnebago) is recalling certain 2024-2025 Ekko recreational vehicles. The inner wheel tire valve extension may be damaged through contact with the outer wheels, causing the inner tire to lose air pressure and overload the outer tire.

Risk: Overloading may cause the outer tire to fail, increasing the risk of a crash.

ELECTRICAL SYSTEM:WIRING

Winnebago Industries, Inc. (Winnebago) is recalling certain 2025-2026 Revel Sport, 2024-2025 Vita, 2025 Porto, Adventure Wagon, 2024-2026 View, Revel, Navion, and Ekko motorhomes. Supplemental Restraint System (SRS) wires can be caught in the seat mechanism when the driver or passenger seats are adjusted.

Risk: Damaged wires can prevent air bags from deploying in a crash, increasing the risk of injury.

ELECTRICAL SYSTEM:WIRING

Winnebago Industries, Inc. (Winnebago) is recalling certain 2017-2025 Revel, 2020-2025 Navion, Porto, View, Vita, 2022-2023 Adventure Van, and 2024-2025 Ekko motorhomes. Supplemental Restraint System (SRS) wires can be caught in the seat mechanism when the driver or passenger seats are adjusted.

Risk: Damaged wires can prevent air bags from deploying in a crash, increasing the risk of injury.

EQUIPMENT:RECREATIONAL VEHICLE/TRAILER

Winnebago Industries, Inc. (Winnebago) is recalling certain 2025 Winnebago View, Navion, and 2024-2025 Ekko recreational vehicles equipped with certain GE air conditioners. The air conditioner soft start device may fail and overheat.

Risk: An air conditioner soft start device that overheats increases the risk of a fire.

EQUIPMENT:RECREATIONAL VEHICLE/TRAILER

Winnebago Industries, Inc. (Winnebago) is recalling certain 2021-2025 Ekko motorhomes. The solar charging system was incorrectly designed without sufficient over-current protection, which can allow the circuit to overheat and melt the fuse.

Risk: A melted fuse increases the risk of a fire.

ENGINE

NOTE: The VIN shows as a 4x2 Sprinter, but this vehicle is a 4x4. While driving, the engine suddenly caught fire. Within one minute, flames approximately 10 feet high were coming from the motor. This is the second Winnebago Ekko reported to catch fire in such a dramatic way. One fire extinguisher was not enough to put out the blaze. The fire was extremely intense and caused catastrophic damage. The vehicle is currently at Mercedes awaiting inspection. However, more than three weeks have passed and the inspection has not yet been scheduled. Mercedes will not allow anyone else to examine the vehicle, and they have not responded to my emails. I am requesting an independent inspection, as I am concerned Mercedes may seek to avoid accepting liability. Can anyone help with that? I am not sure what to do.

ENGINE

On [XXX] while driving my 2025 Winnebago Ekko 23B at elevations between 5,000 and 6,000 feet, the vehicle repeatedly lost engine power and stalled under specific conditions, creating a significant safety hazard. The issue occurred when the house batteries were below 100% charge, the engine was at idle or low RPM (below 1,250), and the secondary alternator began charging the Lithionics battery system, causing RPMs to drop below 500, complete loss of propulsion (unable to move forward or reverse), and occasional activation of the check engine light with codes P0506, P3002E6, and P30059B. This happened four times, including twice when attempting to pull out from stops, which could have resulted in a collision if traffic had been present—imagine suddenly stalling in an intersection with family aboard. The problem resolved at lower elevations (below 2,000 feet) or when maintaining higher RPMs before charging initiated, but it was reproducible every time the conditions were met at altitude. Despite diagnostics at a Mercedes-Benz dealership , where systems were cleared and no faults found (suspecting the Winnebago-installed secondary alternator), and repairs at the Winnebago Factory Service Center in Forest City, IA , where the Wakespeed regulator was unnecessarily replaced and the issue blamed on Mercedes (suggesting an unsubstantiated "learning mode" at elevation), the root cause remains unaddressed. This defect, reported by multiple other Ekko owners in online forums and directly to Winnebago, violates Mercedes upfitting guidelines against drawing alternator power below 1,200 RPM and poses an ongoing risk of sudden power loss in traffic or on highways. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

ELECTRICAL SYSTEM

On [XXX] while driving my 2025 Winnebago Ekko 23B at elevations between 5,000 and 6,000 feet, the vehicle repeatedly lost engine power and stalled under specific conditions, creating a significant safety hazard. The issue occurred when the house batteries were below 100% charge, the engine was at idle or low RPM (below 1,250), and the secondary alternator began charging the Lithionics battery system, causing RPMs to drop below 500, complete loss of propulsion (unable to move forward or reverse), and occasional activation of the check engine light with codes P0506, P3002E6, and P30059B. This happened four times, including twice when attempting to pull out from stops, which could have resulted in a collision if traffic had been present—imagine suddenly stalling in an intersection with family aboard. The problem resolved at lower elevations (below 2,000 feet) or when maintaining higher RPMs before charging initiated, but it was reproducible every time the conditions were met at altitude. Despite diagnostics at a Mercedes-Benz dealership , where systems were cleared and no faults found (suspecting the Winnebago-installed secondary alternator), and repairs at the Winnebago Factory Service Center in Forest City, IA , where the Wakespeed regulator was unnecessarily replaced and the issue blamed on Mercedes (suggesting an unsubstantiated "learning mode" at elevation), the root cause remains unaddressed. This defect, reported by multiple other Ekko owners in online forums and directly to Winnebago, violates Mercedes upfitting guidelines against drawing alternator power below 1,200 RPM and poses an ongoing risk of sudden power loss in traffic or on highways. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)