2021 VOLVO XC90

ELECTRICAL SYSTEM:SOFTWARE

Volvo Car USA, LLC (Volvo Car) is recalling certain 2020-2021 S90, 2020-2022 S60, V60, XC60, XC90, and 2022 V90 plug-in hybrid vehicles. The high-voltage battery may experience a short circuit within the battery module when the battery is fully charged and the vehicle is parked.

Risk: A short circuit in a high-voltage battery increases the risk of a fire.

SEAT BELTS:CRITICAL FASTENERS

Volvo Car USA, LLC (Volvo Car) is recalling certain 2015-2024 XC90 vehicles. The second-row seat belt buckle and lower belt anchor bolts may not be tightened properly.

Risk: An improperly tightened seat belt buckle may not restrain an occupant as intended, increasing their risk of injury during a crash.

STEERING

Volvo Car USA, LLC (Volvo Car) is recalling certain 2019-2022 V60CC, XC60, and XC90 vehicles. During steering gear assembly, double screws may have been assembled on top of each other, which can cause a screw to fall into the gearbox housing.

Risk: A screw inside the gearbox housing can cause the steering wheel to lock up and increase the risk of a crash.

SERVICE BRAKES, HYDRAULIC

Volvo Car USA, LLC (Volvo Car) is recalling certain 2021 S90L, 2020-2021 XC60, and XC90 vehicles. An improperly welded rotor and shaft may separate within the integrated brake system.

Risk: Separation of the rotor and shaft may cause a reduction in braking assistance and a loss of the Antilock Brake System (ABS) and Electronic Stability Control (ESC), increasing the risk of a crash.

SEAT BELTS

Volvo Car USA, LLC (Volvo Car) is recalling certain 2021 XC40, XC 40 Recharge, V60CC, V90, V90CC, XC90, and 2021-2022 V60, XC60, S60 vehicles. The seat belt automatic locking retractors may deactivate early, which can prevent the child restraint system from securing properly. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."

Risk: An unsecured child restraint system can increase the risk of injury during a crash.

BACK OVER PREVENTION: WARNINGS

The vehicle’s Start/Stop system began displaying warning messages and malfunctioning prior to the expiration of the factory warranty. The issue first appeared before 50,000 miles and reappeared at 49,997 miles, when a warning was displayed on the dashboard. The vehicle was taken to an authorized dealer for inspection. A diagnostic review confirmed the need to replace the Start/Stop auxiliary battery and repair the Park Assist system. A diagnostic fee was charged, and both system failures were documented. The Start/Stop system’s failure raises a potential safety concern because the vehicle may not reliably restart after automatically stopping at intersections or in traffic. This could lead to dangerous situations if the vehicle stalls unexpectedly or fails to re-engage power at a critical moment. Although the issue has not caused a crash or injury, it introduces unpredictable behavior that could compromise safe operation. The Park Assist system also failed, triggering system warnings and disabling parking assistance features. If a driver is relying on these systems during low-speed maneuvers, a sudden or silent failure may increase the risk of collision with objects, pedestrians, or other vehicles. The dealership confirmed the problem through inspection and diagnostic testing. The manufacturer was contacted and declined to cover the repairs under warranty, despite the vehicle being within the mileage limit when the issue was first documented and presented for service.

UNKNOWN OR OTHER

The vehicle’s Start/Stop system began displaying warning messages and malfunctioning prior to the expiration of the factory warranty. The issue first appeared before 50,000 miles and reappeared at 49,997 miles, when a warning was displayed on the dashboard. The vehicle was taken to an authorized dealer for inspection. A diagnostic review confirmed the need to replace the Start/Stop auxiliary battery and repair the Park Assist system. A diagnostic fee was charged, and both system failures were documented. The Start/Stop system’s failure raises a potential safety concern because the vehicle may not reliably restart after automatically stopping at intersections or in traffic. This could lead to dangerous situations if the vehicle stalls unexpectedly or fails to re-engage power at a critical moment. Although the issue has not caused a crash or injury, it introduces unpredictable behavior that could compromise safe operation. The Park Assist system also failed, triggering system warnings and disabling parking assistance features. If a driver is relying on these systems during low-speed maneuvers, a sudden or silent failure may increase the risk of collision with objects, pedestrians, or other vehicles. The dealership confirmed the problem through inspection and diagnostic testing. The manufacturer was contacted and declined to cover the repairs under warranty, despite the vehicle being within the mileage limit when the issue was first documented and presented for service.

ELECTRICAL SYSTEM

The vehicle’s Start/Stop system began displaying warning messages and malfunctioning prior to the expiration of the factory warranty. The issue first appeared before 50,000 miles and reappeared at 49,997 miles, when a warning was displayed on the dashboard. The vehicle was taken to an authorized dealer for inspection. A diagnostic review confirmed the need to replace the Start/Stop auxiliary battery and repair the Park Assist system. A diagnostic fee was charged, and both system failures were documented. The Start/Stop system’s failure raises a potential safety concern because the vehicle may not reliably restart after automatically stopping at intersections or in traffic. This could lead to dangerous situations if the vehicle stalls unexpectedly or fails to re-engage power at a critical moment. Although the issue has not caused a crash or injury, it introduces unpredictable behavior that could compromise safe operation. The Park Assist system also failed, triggering system warnings and disabling parking assistance features. If a driver is relying on these systems during low-speed maneuvers, a sudden or silent failure may increase the risk of collision with objects, pedestrians, or other vehicles. The dealership confirmed the problem through inspection and diagnostic testing. The manufacturer was contacted and declined to cover the repairs under warranty, despite the vehicle being within the mileage limit when the issue was first documented and presented for service.

AIR BAGS

Title: Possible Defect – Uneven Airbag Deployment Description: On July 20, 2025, around 5:30 PM, i was driving a 2021 Volvo XC90 on a main road when another vehicle suddenly entered from the right side without stopping at a stop sign. I was unable to avoid a collision and my vehicle T-boned the other car (front impact on my vehicle). During the crash, I believe the front airbag system did not deploy properly or deployed unevenly. I felt like the left side of the airbag (from the steering wheel) was full of air but not the right side (that side was flat when it deployed), and I believe I hit my head on the steering wheel. I experienced severe injuries to my head, face, and right eye, including commotio retinae, lens displacement, corneal abrasion, corneal edema, phacodonesis, iridodonesis, and concussion. I am concerned that the Supplemental Restraint System (SRS) malfunctioned, contributing to the severity of my injuries. No modifications have been made to the airbag system. I request that NHTSA investigate whether there is a defect in the airbag deployment of the 2021 Volvo XC90, particularly for asymmetric or partial deployment. The automatic emergency braking (AEB) system also did not activate despite the imminent collision. There were no warning lamps, messages, or unusual symptoms prior to the crash. The issue has not yet been reproduced or confirmed by a dealer or service center, but The police was at the scene. My insurance company has inspected the vehicle. I have also reported this to the customer care team at Volvo.

UNKNOWN OR OTHER

I plugged my usb to usb-c charging cable into my iphone 20 seconds after starting the vehicle. I proceeded to exit my driveway when the infotainment screen went completely blank and the same thing to the driver's display 10 seconds later. I drove to the end of my street to a stop light where the car completely shut off and automatically restarted within a few seconds. I was traveling with my wife and [XXX] daughter. I have yet to reproduce the problem but have an appointment scheduled with the dealership later this week. Zero warnings or messages were present before, during or after the incident. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

ELECTRICAL SYSTEM

I plugged my usb to usb-c charging cable into my iphone 20 seconds after starting the vehicle. I proceeded to exit my driveway when the infotainment screen went completely blank and the same thing to the driver's display 10 seconds later. I drove to the end of my street to a stop light where the car completely shut off and automatically restarted within a few seconds. I was traveling with my wife and [XXX] daughter. I have yet to reproduce the problem but have an appointment scheduled with the dealership later this week. Zero warnings or messages were present before, during or after the incident. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)