2016 VOLVO XC90

SEAT BELTS:CRITICAL FASTENERS

Volvo Car USA, LLC (Volvo Car) is recalling certain 2015-2024 XC90 vehicles. The second-row seat belt buckle and lower belt anchor bolts may not be tightened properly.

Risk: An improperly tightened seat belt buckle may not restrain an occupant as intended, increasing their risk of injury during a crash.

ELECTRICAL SYSTEM:SOFTWARE

Volvo Car USA, LLC (Volvo Car) is recalling certain 2016-2020 XC90 Excellence vehicles. Liquid or condensation on the rear seat control display may cause the front passenger seat to move back as far as possible.

Risk: The rear passenger may become trapped by the front seat without the ability to cancel the seat's movement, increasing the risk of injury.

ENGINE AND ENGINE COOLING:COOLING SYSTEM:HOSES/LINES/PIPING/FITTINGS

Volvo Cars of N.A., LLC (Volvo Cars) is recalling certain 2016 XC90 vehicles. Exposure to heat and humidity may cause the engine coolant bleeder hose to crack, resulting in a coolant leak.

Risk: If the coolant leak goes unnoticed, coolant may accumulate in the catalytic converter heat shield insulation and catch fire when the vehicle is stationary, increasing the risk of injury.

VISIBILITY:SUN/MOON ROOF ASSEMBLY

Volvo Car USA LLC (Volvo) is recalling certain model year 2016 XC90 vehicles manufactured January 27, 2015, to April 23, 2016. The sunroofs on the affected vehicles have a switch on the overhead console that may not be adequately recessed to prevent the switch from being unintentionally pressed. When pressed, the sunroof may fully close. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 118, "Power-Operated Window, Partition, and Roof Panel Systems."

Risk: If the switch is unintentionally pressed and the sunroof panel closes, there is an increased risk of occupant injury.

SEAT BELTS:FRONT:BUCKLE ASSEMBLY

Volvo Car USA LLC (Volvo) is recalling certain model year 2016-2017 XC90, S90, XC60, V60 Cross Country, V60, S60 Cross Country, S60, and S60 Inscription vehicles manufactured February 16, 2015, to August 22, 2016. On the affected vehicles, the front passenger seat belt buckle attaching stud may loosen, allowing the buckle to separate from the seat belt bracket. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 210, "Seat Belt Assembly Anchorages" and number 209, "Seat Belt Assemblies."

Risk: If the seat belt buckle separates from the bracket, the front seat passenger may not be adequately restrained in the event of a crash, increasing their risk of injury in the event of a crash.

AIR BAGS

Volvo Cars of North America, LLC (Volvo) is recalling certain model year 2016-2017 Volvo XC90 and S90 vehicles manufactured April 15, 2015 through September 19, 2016. In the affected vehicles, the drain hose for the air conditioning may leak into the passenger compartment due to a drain hose installation error during manufacturing.

Risk: Significant water drainage into the passenger compartment may adversely affect air bag deployment in the event of a crash, increasing the risk of occupant injury.

AIR BAGS:SIDE/WINDOW

Volvo Cars of N.A., LLC (Volvo) is recalling certain model year 2016 Volvo XC90 vehicles manufactured January 27, 2015, to May 19, 2015. The affected vehicles have front seats whose wiring harness for the Side Impact Protection System (SIPS) may have been routed incorrectly.

Risk: If the wiring harness is routed incorrectly, the wiring may be damaged, disabling the front seat side impact air bag, and increasing the risk of injury to the seat occupant in the event of a crash necessitating deployment of the front seat side impact air bag.

POWER TRAIN

Known supercharger leak on 2016 Volvo XC90 at 60,000 miles. Numerous reports of the same failure. Dealer and Volvo declined goodwill repair. Potential safety/fire issue if oil leakage worsens

UNKNOWN OR OTHER

The rear two car doors will not open. It started months ago with the left side and now is both doors. This is dangerous if anyone in the rear of the vehicle should need to exit in a timely manner. The dealership knows this is an issue, but says they are not obligated to fix it for free because there isn’t a recall yet.

ELECTRICAL SYSTEM

SRS warning light and was told that is is due to a faulty misassembled wiring in the seat harness. Possibility of the airbags not deploying correctly in case of a crash. The dealer has confirmed that it is the seat harness that needs to be replaced. Due to the Month/Year of the vehicle it does not fall under the original recall which was only for vehicles that were manufactured between Jan/May 2015.

AIR BAGS

SRS warning light and was told that is is due to a faulty misassembled wiring in the seat harness. Possibility of the airbags not deploying correctly in case of a crash. The dealer has confirmed that it is the seat harness that needs to be replaced. Due to the Month/Year of the vehicle it does not fall under the original recall which was only for vehicles that were manufactured between Jan/May 2015.

BACK OVER PREVENTION: SENSING SYSTEM: CAMERA

Backup camera not activating when in reverse sporadically. My recorded video of this happening: [XXX] Issue has been brought to the Volvo dealership service department. Remedy from the Volvo service has been to update software but it has not corrected the issue. Multiple of owners have encountered the same issue which is widely documented online. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

ENGINE

This car is consuming oil and has the potential to catastrophically fail, or catch fire.

STRUCTURE:BODY

I am filing a safety complaint regarding a failed rear door latch actuator in my 2016 Volvo XC90. This is a known issue among Volvo owners, yet there appears to be no recall or corrective action. The defect causes the door latch actuator to seize, rendering the affected rear door completely inoperable from both the inside and outside. This means passengers seated in the rear are unable to open the door to exit the vehicle. This is an extremely dangerous and potentially life-threatening hazard. In the event of an emergency—such as a fire, collision, or submersion—rear seat passengers would be trapped inside the vehicle with no way to escape. This failure compromises basic vehicle safety standards, as all doors should be fully functional to allow for emergency egress. I strongly urge the NHTSA to investigate this recurring defect in Volvo vehicles and require Volvo to address it promptly before it results in serious injury or death.

ENGINE

Piston ring failure, excessive oil consumption. There was an extended warranty regarding the issue, but it has since been closed. I know there have been multiple lawsuits regarding this issue.

UNKNOWN OR OTHER

The back door, or liftgate, closes automatically (without me pressing the close button). This is inconsistent, as it doesn't happen all the time. Each time the car has been off, and maybe it's on some kind of timer. It's happened 3 times, at random, where each time it caught me off guard. One time it hit me on the back of the head. The next time my kids were sitting in the back and I had to yell for them to tuck their legs inside. The third time, was just last week, and I had to run out from under it. There is no beeping or warning, and I'm afraid it's only a matter of time before it causes serious injury. I've had this vehicle for about 12 months, and it's only happened 3 times, but I can't figure out what the causes it.

STRUCTURE

The contact owns a 2016 Volvo XC90. The contact stated that water had been leaking into the vehicle on rainy days. The contact stated that the water intrusion was causing several warning lights to illuminate and unknown vehicle safety equipment failures. The contact stated that the front and rear carpets and the spare tire were saturated with water. The contact had taken the vehicle to a local dealer, where it was determined that water was leaking into the vehicle, but the dealer was unable to determine the point of intrusion. The vehicle was not repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 168,000.

ELECTRICAL SYSTEM

The contact owns a 2016 Volvo XC90. The contact stated that water had been leaking into the vehicle on rainy days. The contact stated that the water intrusion was causing several warning lights to illuminate and unknown vehicle safety equipment failures. The contact stated that the front and rear carpets and the spare tire were saturated with water. The contact had taken the vehicle to a local dealer, where it was determined that water was leaking into the vehicle, but the dealer was unable to determine the point of intrusion. The vehicle was not repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 168,000.

SEAT BELTS

Safety belt will not retract in pillar when unbuckled.

LATCHES/LOCKS/LINKAGES:DOORS:LATCH

Loaded children into second row of vehicle, confirmed all doors closed. Began driving, passenger rear door swung open. Child DID NOT engage door handle. Pulled over to attempt to close door. Door latch would not engage, could not close or lock door. Still unable to close and lock door.