2018 VOLKSWAGEN BEETLE

AIR BAGS:FRONTAL:DRIVER SIDE:INFLATOR MODULE

Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2017-2019 Beetle, Beetle Convertible, 2012-2014 Passat, 2017 Passat Wagon, and 2006-2007 Passat Sedan vehicles. The driver's side frontal air bag inflator may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.

Risk: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:MASTER CYLINDER

Tenneco Automotive (Tenneco) is recalling certain Beck/Arnley Master Cylinders, part number 072-9831, sold as aftermarket or replacement parts for 2004-2018 Volkswagen Jetta, and 2012-2019 Volkswagen Beetle vehicles. The fluid seal crimp on the master cylinder may be insufficient, causing brake fluid to leak or the cylinder to come apart.

Risk: If there is a brake fluid leak, it can reduce braking ability, increasing the risk of a crash.

STEERING:COLUMN LOCKING:ANTI-THEFT DEVICE

Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2015-2019 GTI, 2015-2016 and 2018-2019 Golf, 2012-2019 Beetle and Beetle Convertible, 2017-2019 Golf SportWagen and 2011-2018 Jetta vehicles equipped with an automatic transmission, manual handbrake and keyless entry. A build-up of silicate on the shift lever micro switch contacts may enable the key to be removed from the ignition when the transmission shift lever is not in "Park."

Risk: Removing the key while the shift lever is in a position other than "Park" increases the risk of an unintended vehicle rollaway that may result in personal injury or a crash.

AIR BAGS

The contact's wife owns a 2018 Volkswagen Beetle. The contact’s wife received notification of NHTSA Campaign Number: 24V834000 (Air Bags); however, the part to do the recall repair was not yet available. The local dealer was made aware of the issue and confirmed that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.

UNKNOWN OR OTHER

The ignition failed to release the key and turn off the engine. According to the service writer at New Century Volkswagen in Glendale, CA, this is a known problem with older model Volkswagens. The part which will fix the ignition, is back-ordered for six months, leaving many vehicles in a dangerous state. I have written to.volkswagen of America customer service but no solution or resolution was provided.

AIR BAGS

The contact owns a 2018 Volkswagen Beetle. The contact stated while driving 40-50 MPH, the vehicle started jerking and there was smoke coming from underneath the hood of the vehicle before the vehicle stalled. The contact stated that several unknown warning lights were illuminated, and an alarm sounded. The vehicle was pushed to the side of the road with assistance. The towing agent informed the contact that there was a strong fuel odor coming from the vehicle. The vehicle was towed to an independent mechanic, where it was diagnosed with a major fuel leak. The mechanic replaced an unknown part with a part purchased from a Volkswagen dealer. The contact stated that the fuel leak was corrected; however, an unknown repair needed to be performed. The vehicle was not repaired. The Kia dealer the vehicle was purchased from, was notified of the failure, and informed the contact to tow the vehicle to their location for diagnostic testing and repair. The vehicle was not repaired. Additionally, the contact became aware that the VIN was included in NHTSA Campaign Number: 24V834000 (Air Bags); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not notified of the failure. The failure mileage was approximately 78,000.

FUEL SYSTEM, GASOLINE

The contact owns a 2018 Volkswagen Beetle. The contact stated while driving 40-50 MPH, the vehicle started jerking and there was smoke coming from underneath the hood of the vehicle before the vehicle stalled. The contact stated that several unknown warning lights were illuminated, and an alarm sounded. The vehicle was pushed to the side of the road with assistance. The towing agent informed the contact that there was a strong fuel odor coming from the vehicle. The vehicle was towed to an independent mechanic, where it was diagnosed with a major fuel leak. The mechanic replaced an unknown part with a part purchased from a Volkswagen dealer. The contact stated that the fuel leak was corrected; however, an unknown repair needed to be performed. The vehicle was not repaired. The Kia dealer the vehicle was purchased from, was notified of the failure, and informed the contact to tow the vehicle to their location for diagnostic testing and repair. The vehicle was not repaired. Additionally, the contact became aware that the VIN was included in NHTSA Campaign Number: 24V834000 (Air Bags); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not notified of the failure. The failure mileage was approximately 78,000.

UNKNOWN OR OTHER

I've owned this car for nearly two years. On April 3, 2025, I took my car to Niello VW. A service person told me he'd just had a VW Beetle with the same problem, just the passenger's side. Since there was nothing jamming the glide rails, there was no reason for the seat to be stuck. I took the car to a car upholstery shop because they specialize in removing car seats. The person had a hard time removing my seat, but he did. He said one of metal teeth like glides or steel buttons was broke. There are three on each side of the car seat. It was only on the right side of the driver's seat. The driver's seat is stuck and unable to be adjusted to the driver's leg length. There was nothing jammed in the lock that caused this to be stuck. I have owned 4 VW Beetles and I've never had a problem like this. It's very expensive about $1000 to repair. Mine is 2018 VW Beetle. I should not have a problem like this. I am reporting this because other VW Beetle owners have had to same problem. I did have the air bags repaired a recall.

SEATS

I've owned this car for nearly two years. On April 3, 2025, I took my car to Niello VW. A service person told me he'd just had a VW Beetle with the same problem, just the passenger's side. Since there was nothing jamming the glide rails, there was no reason for the seat to be stuck. I took the car to a car upholstery shop because they specialize in removing car seats. The person had a hard time removing my seat, but he did. He said one of metal teeth like glides or steel buttons was broke. There are three on each side of the car seat. It was only on the right side of the driver's seat. The driver's seat is stuck and unable to be adjusted to the driver's leg length. There was nothing jammed in the lock that caused this to be stuck. I have owned 4 VW Beetles and I've never had a problem like this. It's very expensive about $1000 to repair. Mine is 2018 VW Beetle. I should not have a problem like this. I am reporting this because other VW Beetle owners have had to same problem. I did have the air bags repaired a recall.