Van Hool N.V. (Van Hool) is recalling certain 2010-2014 C2045 and T2145 motorcoaches, 2014-2015 TX40 motorcoaches, 2014-2017 TX45 motorcoaches, 2011-2015 TD925 motorcoaches, 2014-2016 CX45 motorcoaches and 2010-2013 T2140 motorcoaches. When the vehicle is started in low temperatures, the steering wheel may be difficult to turn.

Risk: Reduced steering ability can increase the risk of a crash.

2013 VAN HOOL T2140

1612 vehicles affected

16V857000

STEERING

Van Hool N.V. (Van Hool) is recalling certain model year 2010-2014 C2045 and T2145; 2010 C3045; 2016 CX35; 2014-2016 CX45 and TX45; 2009-2016 TD925; 2015-2016 TDX25 and TX40 and 2010-2013 T2140 motorcoaches. In the affected vehicles, the front steering knuckle carriers may crack.

Risk: Cracking of a steering knuckle carrier may result in its total failure, allowing a wheel to separate from the vehicle, increasing the risk of a crash.

2012 VAN HOOL T2140

203 vehicles affected

12V286000

ENGINE AND ENGINE COOLING:ENGINE:DIESEL

VAN HOOL IS RECALLING CERTAIN MODEL YEAR 2011-2012 C2045, T2140, AND T2145 VEHICLES, EQUIPPED WITH A DETROIT DIESEL DD13 ENGINE. THE PUMP TO RAIL HIGH PRESSURE FUEL LINE SUPPORT SYSTEM USED ON THESE ENGINES IS SENSITIVE TO ASSEMBLY TORQUE AND MAY BE DAMAGED DURING SERVICE WORK. AS A RESULT OF OTHER REPAIRS, THE LINE SUPPORTS MAY LOOSEN, POTENTIALLY LEADING TO FUEL LINE CRACKING AND A FUEL LEAK.

Risk: A FUEL LEAK COULD CREATE A ROAD HAZARD, INCREASING THE RISK OF A CRASH. ALSO A FUEL LEAK IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.

2012 VAN HOOL T2140

17 vehicles affected

12V257000

ELECTRONIC STABILITY CONTROL (ESC)

VAN HOOL IS RECALLING CERTAIN MODEL YEAR 2010-2012 C2045, 2011-2012 T2140, 2010-2011 T2145 AND 2011 TD925 MOTORCOACHES, EQUIPPED WITH MERITOR WABCO ELECTRONIC STABILITY CONTROL (ESC) MODULES, MANUFACTURED FROM AUGUST 2005, THROUGH SEPTEMBER 2011. UNDER CERTAIN ROAD AND DRIVING CONDITIONS, VEHICLE BODY ROLL AND ROAD INCLINATION CHARACTERISTICS MAY ADVERSELY AFFECT THE SLIP ANGLE CALCULATION OF THE ELECTRONIC STABILITY CONTROL (ESC) SYSTEM. THIS MIGHT CAUSE THE ESC TO PERCEIVE AN OVER STEERING SITUATION AND THEREFORE APPLY THE OUTER WHEEL BRAKE ON THE FRONT AXLE UNTIL THE VEHICLE IS PERCEIVED TO BE STABLE.

Risk: THE VEHICLE MAY DEVIATE FROM THE INTENDED LINE OF TRAVEL, INCREASING THE RISK OF A CRASH.

2011 VAN HOOL T2140

138 vehicles affected

12V495000

ELECTRICAL SYSTEM:ALTERNATOR/GENERATOR/REGULATOR

Van Hool is recalling certain model year 2011 and 2012 C2045, and model year 2011 T2140 and T2145 motorcoaches manufactured from September 2010 through September 2011, equipped with a Daimler DD13 engine without ground cables installed on the Prestolite AC172 alternators. Internal corrosion may cause the alternator components to overheat.

Risk: If the alternator overheats, the components may melt, possibly resulting in smoke and creating the potential risk of a vehicle fire.

2010 VAN HOOL T2140

1673 vehicles affected

10V603000

VISIBILITY:REARVIEW MIRRORS/DEVICES:INTERIOR

VAN HOOL IS RECALLING CERTAIN MODEL YEAR 2002 THROUGH 2011 TRANSIT BUSES AND MOTORCOACHES MANUFACTURED FROM AUGUST 2002 THROUGH OCTOBER 2010, EQUIPPED WITH HADLEY REMOTE MIRROR SWITCHES, PART NUMBERS 509VH AND 509VH1F. THE REAR VIEW MIRROR SWITCH MAY OVERHEAT, CAUSING THE PLASTIC HOUSING TO MELT.

Risk: EXCESSIVE HEATING CAN CAUSE A FIRE RESULTING IN SMOKE, OPERATOR DISTRACTION, OR PERSONAL INJURY. AN OVERHEATED MIRROR SWITCH COULD CAUSE THE EXTERIOR REAR VIEW MIRRORS TO NOT OPERATE. THE MIRRORS MAY NOT ADJUST PROPERLY FROM THE INTERIOR SWITCH OR OPERATE POORLY. THEREFORE, THE DRIVER MAY NOT BE ABLE TO HAVE FULL USE OF THE REAR VIEW MIRROR, INCREASING THE RISK OF A CRASH.

Recent Complaints

No recent complaints found.