2012 VAN HOOL C2045

EQUIPMENT ADAPTIVE/MOBILITY:WHEELCHAIR LIFT/RAMP

Van Hool N.V. (Van Hool) is recalling certain 2000-2014 C2045, 2016 CX45, and 1998-2013 T2145 vehicles equipped with Ricon Baylift Wheelchair Lifts. When the lift's outer barrier is fully deployed, it may not withstand a sufficient amount of force, which could cause it to fail. As such, these lifts fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 403, "Platform Lift Systems."

Risk: In the event that a mobility device pushes into the outer barrier, the barrier may fail, increasing the risk of injury for the lift occupant.

STEERING:GEAR BOX (OTHER THAN RACK AND PINION)

Van Hool N.V. (Van Hool) is recalling certain 2010-2014 C2045 and T2145 motorcoaches, 2014-2015 TX40 motorcoaches, 2014-2017 TX45 motorcoaches, 2011-2015 TD925 motorcoaches, 2014-2016 CX45 motorcoaches and 2010-2013 T2140 motorcoaches. When the vehicle is started in low temperatures, the steering wheel may be difficult to turn.

Risk: Reduced steering ability can increase the risk of a crash.

STEERING

Van Hool N.V. (Van Hool) is recalling certain model year 2010-2014 C2045 and T2145; 2010 C3045; 2016 CX35; 2014-2016 CX45 and TX45; 2009-2016 TD925; 2015-2016 TDX25 and TX40 and 2010-2013 T2140 motorcoaches. In the affected vehicles, the front steering knuckle carriers may crack.

Risk: Cracking of a steering knuckle carrier may result in its total failure, allowing a wheel to separate from the vehicle, increasing the risk of a crash.

ENGINE AND ENGINE COOLING:ENGINE:DIESEL

VAN HOOL IS RECALLING CERTAIN MODEL YEAR 2011-2012 C2045, T2140, AND T2145 VEHICLES, EQUIPPED WITH A DETROIT DIESEL DD13 ENGINE. THE PUMP TO RAIL HIGH PRESSURE FUEL LINE SUPPORT SYSTEM USED ON THESE ENGINES IS SENSITIVE TO ASSEMBLY TORQUE AND MAY BE DAMAGED DURING SERVICE WORK. AS A RESULT OF OTHER REPAIRS, THE LINE SUPPORTS MAY LOOSEN, POTENTIALLY LEADING TO FUEL LINE CRACKING AND A FUEL LEAK.

Risk: A FUEL LEAK COULD CREATE A ROAD HAZARD, INCREASING THE RISK OF A CRASH. ALSO A FUEL LEAK IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.

ELECTRONIC STABILITY CONTROL (ESC)

VAN HOOL IS RECALLING CERTAIN MODEL YEAR 2010-2012 C2045, 2011-2012 T2140, 2010-2011 T2145 AND 2011 TD925 MOTORCOACHES, EQUIPPED WITH MERITOR WABCO ELECTRONIC STABILITY CONTROL (ESC) MODULES, MANUFACTURED FROM AUGUST 2005, THROUGH SEPTEMBER 2011. UNDER CERTAIN ROAD AND DRIVING CONDITIONS, VEHICLE BODY ROLL AND ROAD INCLINATION CHARACTERISTICS MAY ADVERSELY AFFECT THE SLIP ANGLE CALCULATION OF THE ELECTRONIC STABILITY CONTROL (ESC) SYSTEM. THIS MIGHT CAUSE THE ESC TO PERCEIVE AN OVER STEERING SITUATION AND THEREFORE APPLY THE OUTER WHEEL BRAKE ON THE FRONT AXLE UNTIL THE VEHICLE IS PERCEIVED TO BE STABLE.

Risk: THE VEHICLE MAY DEVIATE FROM THE INTENDED LINE OF TRAVEL, INCREASING THE RISK OF A CRASH.