2025 TOYOTA TACOMA

Chest Clip, Buckle, Harness

I am filing this complaint regarding my Nuna RAVA convertible car seat. The seat’s harness straps have loosened unexpectedly, even when fully tightened according to the instruction manual. While I have been able to get them to stay tight, I have to constantly monitor them for potential slippage. This unpredictability is concerning because it could compromise my child’s safety in the event of a crash.

Carry Handle, Shell, Base

I am filing this complaint regarding my Nuna RAVA convertible car seat. The seat’s harness straps have loosened unexpectedly, even when fully tightened according to the instruction manual. While I have been able to get them to stay tight, I have to constantly monitor them for potential slippage. This unpredictability is concerning because it could compromise my child’s safety in the event of a crash.

UNKNOWN OR OTHER

I think it’s a serious safety issue for Toyota not to include a trailer brake controller or at least a connector to install an aftermarket trailer brake controller on my truck. This has been mentioned numerous times by customers. My truck is rated to tow 6,400 with no way to add a trailer brake controller. I don’t see how Toyota can legally sell this truck without at least giving an option to install an aftermarket controller, even though Toyota doesn’t recommend it.

SUSPENSION

Turning a corner my left axle broke and I only have 3100 miles on this vehicle. Still is not fixed because of warranty issues. When I do get it back I don’t know how I’m suppose to feel safe driving it. Upon checking on YouTube and Internet I see there is a problem with this happing to others. Thank you for your time.

POWER TRAIN

Turning a corner my left axle broke and I only have 3100 miles on this vehicle. Still is not fixed because of warranty issues. When I do get it back I don’t know how I’m suppose to feel safe driving it. Upon checking on YouTube and Internet I see there is a problem with this happing to others. Thank you for your time.

STEERING

Turning a corner my left axle broke and I only have 3100 miles on this vehicle. Still is not fixed because of warranty issues. When I do get it back I don’t know how I’m suppose to feel safe driving it. Upon checking on YouTube and Internet I see there is a problem with this happing to others. Thank you for your time.

STEERING

Turning a corner heard a loud clunk and steering went out in the middle of the street.I could of got hit

SERVICE BRAKES

Driving home and truck started acting like it was dragging and not going the correct speed. Then we got messages on the truck display . Parking Brake malfunction and System malfunction. We pulled over and called Sun Toyota. We then called Toyota roadside assistance and had it towed to them. They checked it out.

STEERING

I purchased a brand-new 2025 Toyota Tacoma TRD Off-Road. From the first day, the steering wheel was off-center and the vehicle vibrated while driving. At around 500 miles, I noticed severe instability and abnormal tire wear. A wheel alignment report showed: Thrust angle: +0.15° (spec: 0° ± 0.05°) Rear toe: Left 0.23°, Right -0.10° (difference: 0.33°, spec ≤ 0.15°) Front caster: Both sides out of specification (shown in red on report) Driving symptoms include: Cannot maintain straight-line driving; requires constant steering correction. Excessive body roll during lane changes or turns. Continuous vibration of the vehicle and steering wheel on smooth roads. Vehicle bounces and momentarily loses control on uneven surfaces. Steering wheel rotation does not match front wheel steering angle. When stationary, turning the steering to full lock causes the body to rise; releasing it causes it to drop. Attempts to repair at Toyota of Manhattan (June 2025 – August 2025) were unsuccessful. The dealership repeatedly refused to perform proper inspections, provide reports, or acknowledge the defect, despite multiple appointments and a case opened with Toyota corporate. The defect presents a serious safety risk: reduced vehicle stability, increased stopping distance, loss of steering control during maneuvers, excessive and uneven tire wear, and abnormal fuel consumption (13.5 MPG with no load). The problem exists from new and has not been corrected.

ENGINE

I purchased a brand-new 2025 Toyota Tacoma TRD Off-Road. From the first day, the steering wheel was off-center and the vehicle vibrated while driving. At around 500 miles, I noticed severe instability and abnormal tire wear. A wheel alignment report showed: Thrust angle: +0.15° (spec: 0° ± 0.05°) Rear toe: Left 0.23°, Right -0.10° (difference: 0.33°, spec ≤ 0.15°) Front caster: Both sides out of specification (shown in red on report) Driving symptoms include: Cannot maintain straight-line driving; requires constant steering correction. Excessive body roll during lane changes or turns. Continuous vibration of the vehicle and steering wheel on smooth roads. Vehicle bounces and momentarily loses control on uneven surfaces. Steering wheel rotation does not match front wheel steering angle. When stationary, turning the steering to full lock causes the body to rise; releasing it causes it to drop. Attempts to repair at Toyota of Manhattan (June 2025 – August 2025) were unsuccessful. The dealership repeatedly refused to perform proper inspections, provide reports, or acknowledge the defect, despite multiple appointments and a case opened with Toyota corporate. The defect presents a serious safety risk: reduced vehicle stability, increased stopping distance, loss of steering control during maneuvers, excessive and uneven tire wear, and abnormal fuel consumption (13.5 MPG with no load). The problem exists from new and has not been corrected.

SUSPENSION

I purchased a brand-new 2025 Toyota Tacoma TRD Off-Road. From the first day, the steering wheel was off-center and the vehicle vibrated while driving. At around 500 miles, I noticed severe instability and abnormal tire wear. A wheel alignment report showed: Thrust angle: +0.15° (spec: 0° ± 0.05°) Rear toe: Left 0.23°, Right -0.10° (difference: 0.33°, spec ≤ 0.15°) Front caster: Both sides out of specification (shown in red on report) Driving symptoms include: Cannot maintain straight-line driving; requires constant steering correction. Excessive body roll during lane changes or turns. Continuous vibration of the vehicle and steering wheel on smooth roads. Vehicle bounces and momentarily loses control on uneven surfaces. Steering wheel rotation does not match front wheel steering angle. When stationary, turning the steering to full lock causes the body to rise; releasing it causes it to drop. Attempts to repair at Toyota of Manhattan (June 2025 – August 2025) were unsuccessful. The dealership repeatedly refused to perform proper inspections, provide reports, or acknowledge the defect, despite multiple appointments and a case opened with Toyota corporate. The defect presents a serious safety risk: reduced vehicle stability, increased stopping distance, loss of steering control during maneuvers, excessive and uneven tire wear, and abnormal fuel consumption (13.5 MPG with no load). The problem exists from new and has not been corrected.

SUSPENSION

The vehicle is unstable and easy to lose control! The vehicle height is asymmetrical! The vehicle body shakes! The tires are abnormally worn! The geometry deviation of the vehicle's rear axle is too large

STEERING

The vehicle is unstable and easy to lose control! The vehicle height is asymmetrical! The vehicle body shakes! The tires are abnormally worn! The geometry deviation of the vehicle's rear axle is too large

VISIBILITY/WIPER

On several occasions in the previous two months, I have been driving during heavy rain. On the first occasion, while high speed wipers were on, they suddenly stopped working. I slowed down, but was able to get them going again prior to pulling to the shoulder of the highway. I had to switch to the slow wiper speed to get them going. I switched back to the high speed wipers due to heavy rain, and kept stopping each time. It continued this cycle and stayed on after about 15 attempts. Today, on [XXX], I drove down [XXX] from Flint, MI towards Detroit at approximately [XXX]. The wipers again quit working and I had to switch the wiper speed to get it working again while at full highway speed during a deluge of rain and nearly had to stop in a construction zone with no shoulder and heavy traffic, nearly causing a collision until I was able to get the wipers to begin working again. On a previous occasion, I turned them on. When the rain stopped, I was unable to stop the wipers, but was eventually able to stop them by carefully moving the intermittent delay wheel to a position between on and off. It appeared that there may be a short in the wiper circuit. This was a definite safety issue in that my attention was taken away from driving to try to fix the wiper situation. In speaking with my service adviser at Randy Wise Toyota in Grand Blanc, MI, he went out to their lot and tried to duplicate the problem, which he confirmed happened on that same Toyota Tacoma model. I attempted to get this repaired under warranty. Their response was that there was nothing they could do since it appeared to be in the design of the wiper system. My opinion is that this is a serious safety issue which needs to be addressed immediately. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

UNKNOWN OR OTHER

The XM radio fades out when ever you go under a tree and on its own when going down the road. It says that it is trying to locate a satellite! The dealership has replaced the radio and the antenna and checked the antenna cable, with no improvement! They said that they can’t do anything else about the radio problem. Toyota said to file a complaint with NHTSA. Toyota's case number is 250707000269. The truck is 3 weeks old! With 453 miles on it.

STRUCTURE:BODY

This complaint is about the rear passenger side window on the vehicle. It is available for inspection upon request. This was a huge safety risk for me today. I had the rear passenger side door open (with the window rolled all the way up) gathering my things from the back seat. I closed the door with a normal amount of force and the window completely shattered causing me to be covered in glass shards. Luckily, no one was sitting in the back seat and at least I didn't get glass in my eyes. However, this is quite concerning. I don't believe the glass was under any stress or pressure. The temperature was 78 degrees and cloudy outside today, which doesn't seem extreme to me. The window was in perfect condition as I just bought the truck 2 months ago. After the window broke, I went directly to the dealership I bought it from, where they inspected it, and taped a trash bag over it. They told me there was a recall on windows for the new Toyota Tundra models, however, not yet the Tacoma. I believe this is a potential danger to many people and it should investigated.

UNKNOWN OR OTHER

Hood prop up rod comes loose in windy conditions. The was captured on my CCTV cameras and is also duplicatable. Simply shake the hood when it’s open and the rod comes loose Toyota was notified and instructed me to show the dealer. Dealer was notified and we duplicated the problem in their presence. They informed me that there was nothing they can do and they noted in in the maintenance report. Video can be viewed at this YouTube link [XXX] _ INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

SERVICE BRAKES, HYDRAULIC

The contact owns a 2025 Toyota Tacoma. The contact received a notification of NHTSA Campaign Number: 25V058000(Service Brakes, Hydraulic); however, the part to do the recall repair was not yet available. The vehicle was left at the local dealer for the recall repair. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

UNKNOWN OR OTHER

Transmission problems slipping and clunky at only 1800 miles

POWER TRAIN

Vehicle was set in tow/haul mode. Tow/haul mode provides higher acceleration by changing the operation of transmission. Vehicle was towing 2500lb cargo trailer on interstate. Driver stopped at rest area and turned off engine and left vehicle. Driver returned to vehicle 5 minutes later. Driver started engine and proceeded to leave the rest area. Driver was on highway entrance ramp. Entrance ramp merges with right lanr Driver attempted to accelerate to enter highway in such a way that there would be safe distance between end of trailer and car on highway approaching end of trailer. Vehicle would not accelerate as quickly as it was accelerating for the past 2 hours. Driver was surprised and distracted. Margin of safety between rear end of trailer and car on highway was greatly reduced. Some time after the incident Driver realized that car forgot it was in tow haul mode whenever engine is turned off. There is no warning that mode changed. This means that car does not behave as reasonably expected after an ignition cycle