2016 TOYOTA RAV4

ELECTRICAL SYSTEM:12V/24V/48V BATTERY

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2013-2018 RAV4 vehicles. Certain replacement 12-volt batteries may not fit properly in the battery tray, allowing the battery to move and contact the hold-down bracket, possibly causing a short circuit.

Risk: A battery short circuit increases the risk of a fire.

SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2016 Toyota RAV4 vehicles manufactured October 30, 2015, to February 3, 2016, 2016 Lexus RX350 vehicles manufactured October 26, 2015, to February 8, 2016, and 2016 Lexus ES350 vehicles manufactured September 1, 2015, to February 29, 2016. These vehicles are equipped with an ABS actuator that may have a damaged O-ring which could result in improper brake fluid pressure control during ABS, Traction Control, or Stability Control activation. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 126, "Electronic Stability Control Systems."

Risk: Insufficient brake fluid pressure may cause a loss of vehicle control, increasing the risk of a crash.

SEAT BELTS

Rear seat belt passenger side would not unlatch, trapping the passenger. This was and is the only time we have ever used this seat belt.It took two people to help get her thru the upper part of seat belt,had to exit over the top of back seat passenger. This life saving mechanism was and is unsafe and could of caused death if in the event of accident with fire. We have Owned two other Toyota's. Never any other dangerous life threatening events. Our request is the right thing to do. Replace this inoperative major defective part at an authorized Toyota Dealership here in. Dayton Ohio? Do we need to report this to the Highway Safety Dept.? [XXX] & [XXX] . Please respond. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

ELECTRICAL SYSTEM

The contact leased a 2016 Toyota Rav4. The contact received notification of NHTSA Campaign Number: 23V734000 (Electrical System) and requested to be removed from the recall distribution list because the contact no longer had the vehicle. The dealer and the manufacturer were contacted.

ELECTRICAL SYSTEM

The contact owns a 2016 Toyota Rav4. The contact received notification of NHTSA Campaign Number: 23V734000 (ELECTRICAL SYSTEM); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

UNKNOWN OR OTHER

UNKNOWN - UNABLE TO COMPLETE REPAIR IN VEHICLE’S CURRENT LOCATION. This car is currently being stored in England and requires shipment back to the United States per my lienholder and military orders. Because of the recall that is currently open, the government’s provided shipment service (Mildenhall VPC) refuses to ship the vehicle unless I can get this repair performed locally. I’ve contacted numerous Toyota dealerships regarding this recall, and none of them have been able to address the repair due to the car not being made within the country, lack of OEM parts, etc. I’ve been back in the United States for over a month now, and the car is being stored with my friend/power of attorney until I’m able to get some resolution to this situation. I’ve tried to ship it numerous times now and they are refusing to do so unless the repair can be performed (which isn’t possible) or it is cleared from the VIN’s recall notice.

STRUCTURE:BODY

While shopping at the grocery store, I experienced an incident upon leaving the parking lot. After reaching my first red light, I noticed smoke rapidly billowing from under the hood of my vehicle. My husband, who was driving behind me, immediately saw the smoke and instructed me to pull over. Once I stopped, he asked me to pop the hood. Upon opening it, he urgently removed his shirt to try and extinguish the fire. The damage was extensive — a hole burned through the hood, significantly compromising the vehicle’s crash safety rating. Additionally, melted plastic covered the battery area, and the radiator hose was damaged, rendering the vehicle unsafe to drive.

ENGINE

While shopping at the grocery store, I experienced an incident upon leaving the parking lot. After reaching my first red light, I noticed smoke rapidly billowing from under the hood of my vehicle. My husband, who was driving behind me, immediately saw the smoke and instructed me to pull over. Once I stopped, he asked me to pop the hood. Upon opening it, he urgently removed his shirt to try and extinguish the fire. The damage was extensive — a hole burned through the hood, significantly compromising the vehicle’s crash safety rating. Additionally, melted plastic covered the battery area, and the radiator hose was damaged, rendering the vehicle unsafe to drive.

ELECTRICAL SYSTEM

While shopping at the grocery store, I experienced an incident upon leaving the parking lot. After reaching my first red light, I noticed smoke rapidly billowing from under the hood of my vehicle. My husband, who was driving behind me, immediately saw the smoke and instructed me to pull over. Once I stopped, he asked me to pop the hood. Upon opening it, he urgently removed his shirt to try and extinguish the fire. The damage was extensive — a hole burned through the hood, significantly compromising the vehicle’s crash safety rating. Additionally, melted plastic covered the battery area, and the radiator hose was damaged, rendering the vehicle unsafe to drive.

ELECTRICAL SYSTEM

The contact owns a 2016 Toyota Rav4. The contact received a notification of NHTSA Campaign Number: 23V734000 (Electrical System); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

ELECTRICAL SYSTEM

The contact owned a 2016 Toyota Rav4. The contact received notification of NHTSA Campaign Number: 23V734000 (Electrical System); and requested to be removed from the recall distribution list. The local dealer was not contacted; however, the manufacturer was contacted.

ELECTRICAL SYSTEM

The contact owns a 2016 Toyota Rav4. The contact received notification of NHTSA Campaign Number: 23V734000 (ELECTRICAL SYSTEM); however, the part to do the recall repair was unavailable. The local dealer was contacted, and it was confirmed that the part was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact stated that the battery charge was reduced, and the vehicle would not immediately start and the vehicle occasionally stalled. The contact also stated that the battery was replaced on four occasions. The vehicle was towed to the local dealer. The cause of the failure was not yet determined. The failure mileage was 91,475. Parts distribution disconnect.

ELECTRICAL SYSTEM

The contact owns a 2016 Toyota Rav4. The contact stated that the battery warning light was illuminated, and the battery was replaced at the local independent mechanic. The contact received notification of NHTSA Campaign Number: 23V734000 (Electrical System); however, the part to do the recall repair was not yet available. The local dealer was contacted; however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure. The failure mileage was approximately 70,000. Parts distribution disconnect.

EXTERIOR LIGHTING

Headlights and taillights are fogging/hazing up to where they dimmed out the lights when turned on making is somewhat difficult to see or others behind me to see me.

ELECTRICAL SYSTEM

The contact owns a 2016 Toyota Rav4. The contact received notification of NHTSA Campaign Number: 23V734000 (Electrical System); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

POWER TRAIN

shudder in the torque converter of certain 2013–2018 Toyota RAV4 models. The shudder could occur while driving at light throttle between 25–50 miles per hour. 

VISIBILITY/WIPER

I had a significant car accident in 2020 and luckily only broke my thumb. I was rear ended. The car I had at the time was a brand new Toyota Rav4, which luckily did have side airbags and they deployed appropriately. However, I have since had the opportunity to drive other vehicles and would like to ensure the safety of myself and others on the road whether the car be foreign or domestic. Please see the following requests: 1. Toyota's electronics freeze intermittently. This is not the first Toyota Rav4 that I have had and it seems to have done this in the majority of them (2/3). This is dangerous as it can become a distraction to the driver if not familiar with this abnormality. The backup camera also variously changes it's functions, preferences, and layout. 2. The navigation system has to be updated by a chip instead of updated wirelessly. 3. It is not an electric vehicle. 4. I should not have to pay for gasoline or electricity if the sun can be used as a fuel source. Please research the and utilize solar cell panel paint to charge all electric cars and implement that into all domestic and foreign electric cars as soon as possible due to the inflating economy. 5. With full self driving availability please ensure that all cars on the road, whether they be electric or gas, have this capability due to safety issues as well as the extent of morbidity and mortality cases due to trauma patients. I have already emailed you on this problem. Please follow up. 6. Due to the younger generation and their addiction to social media as well as their cell phones, please ensure that there is voice capability within all cars. It may also be beneficial for a camera to be installed inside of the car since the younger generation is so prone to filming themselves. This would also help with liability issues if an accident were to occur. 7. Ensure there is a way to charge a cell phone without needing to plug in the phone.

ELECTRICAL SYSTEM

I had a significant car accident in 2020 and luckily only broke my thumb. I was rear ended. The car I had at the time was a brand new Toyota Rav4, which luckily did have side airbags and they deployed appropriately. However, I have since had the opportunity to drive other vehicles and would like to ensure the safety of myself and others on the road whether the car be foreign or domestic. Please see the following requests: 1. Toyota's electronics freeze intermittently. This is not the first Toyota Rav4 that I have had and it seems to have done this in the majority of them (2/3). This is dangerous as it can become a distraction to the driver if not familiar with this abnormality. The backup camera also variously changes it's functions, preferences, and layout. 2. The navigation system has to be updated by a chip instead of updated wirelessly. 3. It is not an electric vehicle. 4. I should not have to pay for gasoline or electricity if the sun can be used as a fuel source. Please research the and utilize solar cell panel paint to charge all electric cars and implement that into all domestic and foreign electric cars as soon as possible due to the inflating economy. 5. With full self driving availability please ensure that all cars on the road, whether they be electric or gas, have this capability due to safety issues as well as the extent of morbidity and mortality cases due to trauma patients. I have already emailed you on this problem. Please follow up. 6. Due to the younger generation and their addiction to social media as well as their cell phones, please ensure that there is voice capability within all cars. It may also be beneficial for a camera to be installed inside of the car since the younger generation is so prone to filming themselves. This would also help with liability issues if an accident were to occur. 7. Ensure there is a way to charge a cell phone without needing to plug in the phone.

FUEL/PROPULSION SYSTEM

I had a significant car accident in 2020 and luckily only broke my thumb. I was rear ended. The car I had at the time was a brand new Toyota Rav4, which luckily did have side airbags and they deployed appropriately. However, I have since had the opportunity to drive other vehicles and would like to ensure the safety of myself and others on the road whether the car be foreign or domestic. Please see the following requests: 1. Toyota's electronics freeze intermittently. This is not the first Toyota Rav4 that I have had and it seems to have done this in the majority of them (2/3). This is dangerous as it can become a distraction to the driver if not familiar with this abnormality. The backup camera also variously changes it's functions, preferences, and layout. 2. The navigation system has to be updated by a chip instead of updated wirelessly. 3. It is not an electric vehicle. 4. I should not have to pay for gasoline or electricity if the sun can be used as a fuel source. Please research the and utilize solar cell panel paint to charge all electric cars and implement that into all domestic and foreign electric cars as soon as possible due to the inflating economy. 5. With full self driving availability please ensure that all cars on the road, whether they be electric or gas, have this capability due to safety issues as well as the extent of morbidity and mortality cases due to trauma patients. I have already emailed you on this problem. Please follow up. 6. Due to the younger generation and their addiction to social media as well as their cell phones, please ensure that there is voice capability within all cars. It may also be beneficial for a camera to be installed inside of the car since the younger generation is so prone to filming themselves. This would also help with liability issues if an accident were to occur. 7. Ensure there is a way to charge a cell phone without needing to plug in the phone.

ELECTRICAL SYSTEM

The contact owns a 2016 Toyota Rav4. The contact stated that after driving and parking the vehicle, the vehicle failed to restart. The contact opened the hood and saw smoke. The contact stated that the battery had melted. There were no warning lights illuminated. The local dealer was contacted, and the vehicle was inspected at the residence. The contact received notification of NHTSA Campaign Number: 23V734000 (Electrical System); however, the part to do the recall repair was not yet available. The local dealer was contacted. The vehicle was towed to the local dealer, where it was diagnosed and determined that the failure was related to the electrical system. There was also fluid leaking from the battery. The vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The failure mileage was approximately 130,000. VIN tool confirms parts not available.