2023 TOYOTA RAV4 PRIME

ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL

The contact owns a 2023 Toyota Rav4 Prime. The contact stated that while the vehicle was parked and occupied, while attempting to start the vehicle, the contact became aware that the instrument panel was displaying a black screen. The local dealer was contacted. The vehicle was taken to the dealer where it was diagnosed, and determined that the instrument panel needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure but offered no assistance. The approximate failure mileage was 68,000.

ELECTRICAL SYSTEM

The digital dashboard (instrument cluster)on my 2023 Toyota RAV4 Prime, suddenly went completely black. This included the speedometer, warning lights, fuel gauge, and all other driver information. I was unable to monitor my speed, vehicle status, or receive safety alerts — a serious risk while operating the vehicle. I have not authorized repairs yet. I brought the issue to Toyota’s attention, but since the vehicle is out of warranty and over the mileage limit, the dealership is requiring a $200 diagnostic fee just to evaluate the problem. There has been no formal decision from Toyota yet on whether they will cover the cost. After researching online, I discovered that numerous other owners of 2023 RAV4 Prime vehicles are experiencing this same dashboard blackout issue, suggesting a broader defect. This is not a result of wear and tear, and it directly impacts safe operation of the vehicle. I am submitting this complaint because this is a safety-critical system failure that should not occur in a new vehicle. If this is a common defect, it warrants investigation and potentially a recall. Toyota should not place the burden of diagnosis or repair on consumers for what appears to be a growing, safety-related manufacturing issue.

SERVICE BRAKES

On the night of [XXX] at approximately [XXX] PM, I was driving from Tracy, California to Lancaster, California via the [XXX]. The freeway had no traffic at the time, and I set my cruise control to maintain a speed of 75 mph for a safer ride. While driving in the left lane near Santa Nella, my car suddenly deployed the ABS brakes. The steering wheel locked, and the car began to slip—its tires locked as if on a roller coaster going downhill. The driver’s side then rolled over and crashed. Fortunately, the road was empty, and I did not hit anyone during the accident. I thought I was going to die, but I am lucky to be alive. suddenly Abs brakes deployed steering wheel lock right side this reason I have very accident. I believe the car has manufacturer defects. First, the door handle on the driver’s side is positioned too close to the driver’s left arm. Second, the center console on the right side—intended for resting the driver’s arm or storing extra items—repeatedly hit my ribs during the accident. During the crash, the driver-side door handle struck my left arm multiple times. Orthopedic surgeons reviewed my X-ray and found that my forearm was fractured in three places. They recommended surgery. The center console also struck my right ribs repeatedly, causing swelling and pain. Fortunately, my ribs were not broken. My chest & ribs swelling and pain right side shoulder I have pain my head & neck pain My car was declared a total loss. I respectfully request that these issues be investigated, as I believe another driver could sustain similar injuries in a future accident involving this vehicle model. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

STEERING

On the night of [XXX] at approximately [XXX] PM, I was driving from Tracy, California to Lancaster, California via the [XXX]. The freeway had no traffic at the time, and I set my cruise control to maintain a speed of 75 mph for a safer ride. While driving in the left lane near Santa Nella, my car suddenly deployed the ABS brakes. The steering wheel locked, and the car began to slip—its tires locked as if on a roller coaster going downhill. The driver’s side then rolled over and crashed. Fortunately, the road was empty, and I did not hit anyone during the accident. I thought I was going to die, but I am lucky to be alive. suddenly Abs brakes deployed steering wheel lock right side this reason I have very accident. I believe the car has manufacturer defects. First, the door handle on the driver’s side is positioned too close to the driver’s left arm. Second, the center console on the right side—intended for resting the driver’s arm or storing extra items—repeatedly hit my ribs during the accident. During the crash, the driver-side door handle struck my left arm multiple times. Orthopedic surgeons reviewed my X-ray and found that my forearm was fractured in three places. They recommended surgery. The center console also struck my right ribs repeatedly, causing swelling and pain. Fortunately, my ribs were not broken. My chest & ribs swelling and pain right side shoulder I have pain my head & neck pain My car was declared a total loss. I respectfully request that these issues be investigated, as I believe another driver could sustain similar injuries in a future accident involving this vehicle model. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING

On the night of [XXX] at approximately [XXX] PM, I was driving from Tracy, California to Lancaster, California via the [XXX]. The freeway had no traffic at the time, and I set my cruise control to maintain a speed of 75 mph for a safer ride. While driving in the left lane near Santa Nella, my car suddenly deployed the ABS brakes. The steering wheel locked, and the car began to slip—its tires locked as if on a roller coaster going downhill. The driver’s side then rolled over and crashed. Fortunately, the road was empty, and I did not hit anyone during the accident. I thought I was going to die, but I am lucky to be alive. suddenly Abs brakes deployed steering wheel lock right side this reason I have very accident. I believe the car has manufacturer defects. First, the door handle on the driver’s side is positioned too close to the driver’s left arm. Second, the center console on the right side—intended for resting the driver’s arm or storing extra items—repeatedly hit my ribs during the accident. During the crash, the driver-side door handle struck my left arm multiple times. Orthopedic surgeons reviewed my X-ray and found that my forearm was fractured in three places. They recommended surgery. The center console also struck my right ribs repeatedly, causing swelling and pain. Fortunately, my ribs were not broken. My chest & ribs swelling and pain right side shoulder I have pain my head & neck pain My car was declared a total loss. I respectfully request that these issues be investigated, as I believe another driver could sustain similar injuries in a future accident involving this vehicle model. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

SERVICE BRAKES

On [XXX], I was pulling into a parking spot in a parking lot [XXX] in San Francisco. When I engaged the brakes, the vehicle did not stop and continued moving forward. The vehicle accelerated a bit and climbed over the parking lot barrier, onto the pedestrian sidewalk, and into the street despite continued brake depression. The right side of the vehicle made contact with the parking meter on the sidewalk for street parking. The brakes were depressed and engaged the entire duration of the incident, and the vehicle did not stop until impact with the parking meter. Standard safety features were enabled (ie. pre-collision system, road sign assist). Dynamic radar cruise control is disabled. I reported this incident to the Toyota dealership, whom sent a vehicle safety inspector, and I emphasized my concern for the safety of the vehicle. Per Toyota’s investigation report, Toyota concluded the vehicle was mechanically functioning properly at the time of the incident and the vehicle is overall safe to drive. (Written by [XXX] on behalf of my mom, [XXX] ) INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL

Our dashboard has gone completely blank. This means we can’t track speed, charge and fuel remaining, and other important aspects of the car’s health.

EXTERIOR LIGHTING

Our dashboard has gone completely blank. This means we can’t track speed, charge and fuel remaining, and other important aspects of the car’s health.

ELECTRICAL SYSTEM

Our dashboard has gone completely blank. This means we can’t track speed, charge and fuel remaining, and other important aspects of the car’s health.