2009 TOYOTA PRIUS

AIR BAGS:FRONTAL:SENSOR/CONTROL MODULE-INACTIVE

Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.

Risk: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.

ENGINE AND ENGINE COOLING

Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 6, 2003, through March 30, 2009 and FCHV-adv vehicles manufactured December 12, 2008, through September 13, 2011. During manufacturing, a scratch may have occurred inside of the electrically driven water pump at the coil wire. The coil wire may corrode at the scratched portion.

Risk: The corroded coil wire may break and the water pump could stop. The corroded coil wire could cause a short circuit between coil wires and a possible open fuse, creating a stall-like condition of the hybrid system while the vehicle is being driven. This may increase the risk of a vehicle crash.

STEERING

Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 5, 2003, through March 30, 2009. The affected vehicles have a steering intermediate extension shaft assembly built with metal splines that complete the connection from the steering wheel to the steering gear. These splines may have been manufactured with an insufficient hardness.

Risk: Over time, the splines may wear and eventually fail resulting in a loss of steering ability, increasing the risk of a vehicle crash.

EQUIPMENT:OTHER:LABELS

GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.

Risk: THIS DOES NOT MEET THE STANDARD REQUIREMENTS.

UNKNOWN OR OTHER

Cooling system

SERVICE BRAKES

The brake actuator is failing. It’s making unusual noises when stepping on the brakes. A new additional noise started in the last month which is the pump connected to the brake actuator. The technician told me the brakes are about to fail. Toyota used to cover this issue but stopped a few years ago. It’s a $3,000.00 job at the dealer.

ENGINE

Breaking system failure do to ASB Actuator, breaks are locking and vehicle is engine braking.

ELECTRICAL SYSTEM

Breaking system failure do to ASB Actuator, breaks are locking and vehicle is engine braking.

FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING

Breaking system failure do to ASB Actuator, breaks are locking and vehicle is engine braking.

VEHICLE SPEED CONTROL

When I am coming to a stop or need to put on my brakes my car will accelerate at a jump ahead pace As if to take off instead of slowing down and stopping. Regardless whether I’m turning a corner or I’m continuing straight when I have to Put on the brakes it speeds up instead.

UNKNOWN OR OTHER

When I am coming to a stop or need to put on my brakes my car will accelerate at a jump ahead pace As if to take off instead of slowing down and stopping. Regardless whether I’m turning a corner or I’m continuing straight when I have to Put on the brakes it speeds up instead.

ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL

The contact owns a 2009 Toyota Prius. The contact stated that while driving at an undisclosed speed, extra effort was needed to stop the vehicle while depressing the brake pedal. In addition, the contact stated that the instrument panel intermittently went blank and failed to operate as needed. The vehicle was taken to an independent mechanic where the contact was informed that the ABS and the instrument cluster needed to be replaced. The manufacturer was not notified of the failure. The vehicle was not repaired. The failure mileage was approximately 157,000.