2008 TOYOTA PRIUS

ENGINE AND ENGINE COOLING

Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 6, 2003, through March 30, 2009 and FCHV-adv vehicles manufactured December 12, 2008, through September 13, 2011. During manufacturing, a scratch may have occurred inside of the electrically driven water pump at the coil wire. The coil wire may corrode at the scratched portion.

Risk: The corroded coil wire may break and the water pump could stop. The corroded coil wire could cause a short circuit between coil wires and a possible open fuse, creating a stall-like condition of the hybrid system while the vehicle is being driven. This may increase the risk of a vehicle crash.

STEERING

Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 5, 2003, through March 30, 2009. The affected vehicles have a steering intermediate extension shaft assembly built with metal splines that complete the connection from the steering wheel to the steering gear. These splines may have been manufactured with an insufficient hardness.

Risk: Over time, the splines may wear and eventually fail resulting in a loss of steering ability, increasing the risk of a vehicle crash.

UNKNOWN OR OTHER

Trunk lock will not unlock or allow opening, back latch malfunctions, when car battery dies or car looses power《• you cannot open the trunk and access emergency tools/equipment and battery to jump car. •》You have to access by climbing through the front of the car if you are able-bodied too. There is no opening handle from the inside of the trunk to be let out, scariest and one of the most important major safety concerns, theres no emergency exit from inside vehicle. Water/snow/ice also falls down into the vehicle when opening hatchback, it slides inward from hood of car or slides back from rear windshield and door, causes water to be pooled up in my battery compartment.

ELECTRICAL SYSTEM

Trunk lock will not unlock or allow opening, back latch malfunctions, when car battery dies or car looses power《• you cannot open the trunk and access emergency tools/equipment and battery to jump car. •》You have to access by climbing through the front of the car if you are able-bodied too. There is no opening handle from the inside of the trunk to be let out, scariest and one of the most important major safety concerns, theres no emergency exit from inside vehicle. Water/snow/ice also falls down into the vehicle when opening hatchback, it slides inward from hood of car or slides back from rear windshield and door, causes water to be pooled up in my battery compartment.

STRUCTURE:BODY

Trunk lock will not unlock or allow opening, back latch malfunctions, when car battery dies or car looses power《• you cannot open the trunk and access emergency tools/equipment and battery to jump car. •》You have to access by climbing through the front of the car if you are able-bodied too. There is no opening handle from the inside of the trunk to be let out, scariest and one of the most important major safety concerns, theres no emergency exit from inside vehicle. Water/snow/ice also falls down into the vehicle when opening hatchback, it slides inward from hood of car or slides back from rear windshield and door, causes water to be pooled up in my battery compartment.

UNKNOWN OR OTHER

Randomly my instrument panel goes blank while in motion and can only be retrieved by hard turning the car off when stopped, you loose your speedometer, lights, and all until reset. Other issue with speedometer readings that are consistently off between 5-15mph with no fix, resolutions or repairs.

VEHICLE SPEED CONTROL

Randomly my instrument panel goes blank while in motion and can only be retrieved by hard turning the car off when stopped, you loose your speedometer, lights, and all until reset. Other issue with speedometer readings that are consistently off between 5-15mph with no fix, resolutions or repairs.

ELECTRICAL SYSTEM

Randomly my instrument panel goes blank while in motion and can only be retrieved by hard turning the car off when stopped, you loose your speedometer, lights, and all until reset. Other issue with speedometer readings that are consistently off between 5-15mph with no fix, resolutions or repairs.

SERVICE BRAKES

ABS failed and mechanic tells me my actuator needs replacement which is a known issue with my generation of Prius.

ELECTRICAL SYSTEM:INSTRUMENT PANEL:SPEEDOMETER/ODOMETER

Odometer Fraud. The contact purchased a 2008 Toyota Prius. The contact discovered that there was a mileage discrepancy. The vehicle was a direct purchase from the previous owner on August 3, 2025. The contact made other reports with a personal lawyer, the State Attorney General's Office, and AZ.FraudReport Agency. The contact had not heard back from the other contact regarding the other reports made. At the time of purchase, the vehicle mileage was 50,000 miles, and at the time of registration, it was discovered that the mileage was over 200,000.

ELECTRICAL SYSTEM

The contact owns a 2008 Toyota Prius. The contact stated that while driving at various speeds, the instrument panel failed to function as intended. The contact stated that the instrument panel went blank. The contact stated that the failure was intermittent at first but had become a permanent failure. In addition, the front headlights and rear taillights failed to function as intended. The vehicle was taken to the dealer; however, no cause for the failure was found. The vehicle was not repaired due to the cost. The contact stated that on a separate occasion, while driving at various speeds, the front headlights failed to work as intended. Upon inspection, the contact noticed that the bulbs had melted into the wiring harness. The contact stopped driving the vehicle at night. The manufacturer was not notified of the failure. The failure mileage was approximately 90,000.

VEHICLE SPEED CONTROL

My name is [XXX] ,i am filing this report on behalf of My daughter [XXX] the driver of the vehicle that involved with the unintended acceleration on the 2009 Toyota Prius .On a good clear morning on [XXX] . My daughter drove the 2009 Toyota Prius to work- when she enter to the parking lot at the speed round 5 mile/hour . Just when she was making a left turn on to the entrance gate with her left foot on the brake pedal . On a sudden the vehicle RPM unintended rev up too high and the vehicle had an unintended accelerating to move forward aggressively causing lose control of the steering . Also she could not brake even though her left foot was on the brake pedal and pressing hard to try to stop the vehicle . . This dangerous incident causing her Prius to bumped into the electrical gate panel control box . The accident caused some damages to her Prius and to the entrance gate control box though no body was hurt . But it got us through the terrible experience because it could kill some one for sure . My daughter been driving this commute car daily in the past 5 years and she has the skill of 20 year driving with good record . This Prius of her still have all OEM equipments with no add- on parts-,no modifying part on any systems what so ever- and NO extra floor mat cause we been warned before about the possible of unintended acceleration causing by aftermarket floor mat to any vehicles. . We feel unsafe after the mystery accelerating problem on Toyota Vehicle that could take people lives . So the mystery unintended accelerating on car is REAL . I am currently checked and find out her Prius has 2 incomplete recalls (un-notice to us ) but none of them related to the unintended acceleration problem . We would like the NHTSA to take this problem seriously to save people life . I will included photos of this incidents and willing to provide all information if needed to address this problem, again to save lives . INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 5

ENGINE

My name is [XXX] ,i am filing this report on behalf of My daughter [XXX] the driver of the vehicle that involved with the unintended acceleration on the 2009 Toyota Prius .On a good clear morning on [XXX] . My daughter drove the 2009 Toyota Prius to work- when she enter to the parking lot at the speed round 5 mile/hour . Just when she was making a left turn on to the entrance gate with her left foot on the brake pedal . On a sudden the vehicle RPM unintended rev up too high and the vehicle had an unintended accelerating to move forward aggressively causing lose control of the steering . Also she could not brake even though her left foot was on the brake pedal and pressing hard to try to stop the vehicle . . This dangerous incident causing her Prius to bumped into the electrical gate panel control box . The accident caused some damages to her Prius and to the entrance gate control box though no body was hurt . But it got us through the terrible experience because it could kill some one for sure . My daughter been driving this commute car daily in the past 5 years and she has the skill of 20 year driving with good record . This Prius of her still have all OEM equipments with no add- on parts-,no modifying part on any systems what so ever- and NO extra floor mat cause we been warned before about the possible of unintended acceleration causing by aftermarket floor mat to any vehicles. . We feel unsafe after the mystery accelerating problem on Toyota Vehicle that could take people lives . So the mystery unintended accelerating on car is REAL . I am currently checked and find out her Prius has 2 incomplete recalls (un-notice to us ) but none of them related to the unintended acceleration problem . We would like the NHTSA to take this problem seriously to save people life . I will included photos of this incidents and willing to provide all information if needed to address this problem, again to save lives . INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 5

SERVICE BRAKES

My name is [XXX] ,i am filing this report on behalf of My daughter [XXX] the driver of the vehicle that involved with the unintended acceleration on the 2009 Toyota Prius .On a good clear morning on [XXX] . My daughter drove the 2009 Toyota Prius to work- when she enter to the parking lot at the speed round 5 mile/hour . Just when she was making a left turn on to the entrance gate with her left foot on the brake pedal . On a sudden the vehicle RPM unintended rev up too high and the vehicle had an unintended accelerating to move forward aggressively causing lose control of the steering . Also she could not brake even though her left foot was on the brake pedal and pressing hard to try to stop the vehicle . . This dangerous incident causing her Prius to bumped into the electrical gate panel control box . The accident caused some damages to her Prius and to the entrance gate control box though no body was hurt . But it got us through the terrible experience because it could kill some one for sure . My daughter been driving this commute car daily in the past 5 years and she has the skill of 20 year driving with good record . This Prius of her still have all OEM equipments with no add- on parts-,no modifying part on any systems what so ever- and NO extra floor mat cause we been warned before about the possible of unintended acceleration causing by aftermarket floor mat to any vehicles. . We feel unsafe after the mystery accelerating problem on Toyota Vehicle that could take people lives . So the mystery unintended accelerating on car is REAL . I am currently checked and find out her Prius has 2 incomplete recalls (un-notice to us ) but none of them related to the unintended acceleration problem . We would like the NHTSA to take this problem seriously to save people life . I will included photos of this incidents and willing to provide all information if needed to address this problem, again to save lives . INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 5

SERVICE BRAKES

Incident Summary: While relocating from northern to southern Alabama, I experienced a sudden and concerning failure in the vehicle’s braking system. While driving, multiple dashboard warning indicators were triggered simultaneously, including: •Brake warning light •ABS light •VSC (Vehicle Stability Control) light •Additional system fault alerts This happened unexpectedly and severely impacted my ability to drive the vehicle safely. Given the nature of these warnings and the critical systems they pertain to, I immediately took the vehicle to a certified Toyota dealership for diagnostics and repair. Following inspection, I was informed that the ABS actuator and related components had failed and would require replacement at an estimated cost of nearly $3,000. I was further advised that while this issue had been part of a previous recall or customer support program, that program is no longer active. Rationale for Cost Coverage Request: 1) Known Safety Issue: This ABS/VSC failure aligns with prior technical service bulletins and recall actions issued by Toyota for Prius models of this era. The abrupt system failure while driving raises significant safety concerns. 2) Purchased from Certified Dealership: The vehicle was purchased from an authorized Toyota dealership. I trusted that all known recall issues would have been properly addressed prior to sale. 3) Recall Program Timing & Fairness: The original recall or warranty enhancement was tied to a timeframe or mileage limit, but given that this issue has not been resolved and is now manifesting as a serious failure, I believe an exception should be made—especially since it was known to affect vehicles like mine. 4) Customer Loyalty and Safety Assurance: I have maintained this vehicle responsibly and expect Toyota, as a brand committed to quality and safety, to assist with this issue in good faith. Request: I respectfully request that Toyota cover the full cost of diagnosing and repairing the ABS system issue.

SERVICE BRAKES

I recently took my vehicle to the dealership because all the hazard lights on the dash came on. They diagnosed it as an issue with the inverter water pump and suggested that the engine was overheating, which was causing the hazard light to appear on the dashboard. So I had them replace that part and everything was fine. A week later, I went to drive to work and my entire dashboard was out. My radio, clock, blinkers, and brakes worked, but I could not see the speedometer, gas gauge, odometer or any other dashboard features. When I tried to restart the car, it wouldn't turn off. I tried several times and even got my husband to try. When we couldn't turn it off, I drove blindly straight to the dealership. They diagnosed the issue as being a problem with the combination meter. Recently, I found out that there was a Customer Support Program through Toyota that replaced the combination meter in my same car model. This service expired in 2017. I got the car in 2020-21. Thankfully I was home, and was able to follow my husband to the dealership. I'm not sure what I would've done if this happened while I was out. I am also have traction issues with the brakes. When I try to brake on a slope or incline, the glide hazard lights come on. It's happened several times when it's raining, but it's been happening more when it's not. I typically give enough space between myself and the car in front of me, but it's concerning that the brakes lock up when I'm on any type of sloped surface.

ELECTRICAL SYSTEM

I recently took my vehicle to the dealership because all the hazard lights on the dash came on. They diagnosed it as an issue with the inverter water pump and suggested that the engine was overheating, which was causing the hazard light to appear on the dashboard. So I had them replace that part and everything was fine. A week later, I went to drive to work and my entire dashboard was out. My radio, clock, blinkers, and brakes worked, but I could not see the speedometer, gas gauge, odometer or any other dashboard features. When I tried to restart the car, it wouldn't turn off. I tried several times and even got my husband to try. When we couldn't turn it off, I drove blindly straight to the dealership. They diagnosed the issue as being a problem with the combination meter. Recently, I found out that there was a Customer Support Program through Toyota that replaced the combination meter in my same car model. This service expired in 2017. I got the car in 2020-21. Thankfully I was home, and was able to follow my husband to the dealership. I'm not sure what I would've done if this happened while I was out. I am also have traction issues with the brakes. When I try to brake on a slope or incline, the glide hazard lights come on. It's happened several times when it's raining, but it's been happening more when it's not. I typically give enough space between myself and the car in front of me, but it's concerning that the brakes lock up when I'm on any type of sloped surface.

SERVICE BRAKES

Brake actuator fails. Subject to prior recalls, but they're continuing to be an issue. This vehicle, and thousands of others like it, the electric brake actuator/pump starts running constantly then fails entirely. When that happens, as has to mine, the vehicle has NO power brakes, which can and does cause the vehicle to crash. The replacement part is over a thousand dollars. Toyota has engineered a failure mode that creates massive continuing profits.

SERVICE BRAKES

The error lights related to the ABS, VSC braking system can suddenly come on, the antilock brakes stop working, and breaking power is greatly diminished. This occurs without warning and when it does, the brakes do not work safely and it is more difficult to bring the car to a stop. I have taken the car in to repair shops who have confirmed the issue. This malfunction produces error code C1256 and multiple mechanics have confirmed it is related to a faulty ABS Actuator Assembly and recommend immediate replacement of the unit. This is a common and known issue with these cars. I have been quoted a range of $2,100+tax to $2950+tax to perform the repair using a brand new part from Toyota.

SERVICE BRAKES

brake actuator assembly failed