2020 TOYOTA COROLLA

AIR BAGS:SENSOR:OCCUPANT CLASSIFICATION

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2020-2021 Avalon, Avalon Hybrid, Corolla, Highlander, Highlander Hybrid, RAV4, RAV4 Hybrid, Lexus ES350, Lexus RX350, Lexus RX450H, 2021 Sienna Hybrid, Lexus ES250, 2020-2022 Camry, Camry Hybrid, and ES300H vehicles. A short circuit may develop in the Occupant Classification System (OCS) sensor, preventing the front passenger air bag from deploying.

Risk: An air bag that does not deploy during a crash increases the risk of injury.

FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2018-2019 4Runner, 2019-2020 Avalon, 2019 Corolla Hatchback, 2017-2019 Highlander, 2018-2020 Camry, 2020 Corolla, 2018-2019 Land Cruiser, 2017-2020 Tacoma, 2019-2020 RAV4, 2019-2020 Sequoia, 2017-2020 Sienna, 2019-2020 Tundra, 2018-2020 Lexus ES350, 2017 Lexus GS200t, 2017-2019 Lexus GS350, 2019 Lexus GS300, 2018-2020 Lexus LC500h, 2019-2020 Lexus LS500, 2018-2019 Lexus GX460, 2017 Lexus IS200t, 2019 Lexus IS300, 2019 Lexus IS350, 2018-2020 Lexus LC500, 2018 Lexus LS500, 2019 Lexus LS500h, 2018-2019 Lexus LX570, 2017 Lexus RC200t, 2019 Lexus RC300, RC350, 2017 and 2019-2020 Lexus RX350, 2018-2020 RX350L, 2019 Lexus UX200, 2018-2019 Lexus NX300 vehicles. The low-pressure fuel pump inside the fuel tank may fail.

Risk: If the fuel pump fails, the engine can stall while driving, increasing the risk of a crash.

ELECTRICAL SYSTEM

The contact’s mother owns a 2020 Toyota Corolla. The contact stated that while looking in the list of features on the infotainment center, the Forward Collision, Brakes, Accelerator, Lane Assist, On-Board Collision, and other safety features were flagged as malfunctioning. The contact stated that the list of malfunctioning systems seemed to have increased over time. The vehicle failed to turn off intermittently, causing the driver to make several attempts to turn off the vehicle. The vehicle was not taken to the dealer to be diagnosed or repaired. The manufacturer was not informed of the failure. The failure mileage was 80,000.

ELECTRICAL SYSTEM

SOS is malfunctioning. Rebooting every thirty seconds. Interferes with handfree phone calls messages pop up asking to call for operator. Google this and it very common. The sos is for emergencies to get you help and it cuts off every thirty seconds.Your phone calls. Were the person you're talking to cannot hear you until it stops.

POWER TRAIN

The contact owns a 2020 Toyota Corolla. The contact stated while driving at an undisclosed speed, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. The contact became aware of an abnormal clunking sound, and that the check engine warning light was illuminated. The contact stated the failure had occurred while driving on a busy road. The contact attempted to shift the gear shifter into different driving modes; however, the vehicle failed to accelerate as intended. The contact stated that several good Samaritans pushed the vehicle into a nearby driveway. The vehicle was taken to an independent mechanic where it was diagnosed with transmission failure. The contact was informed that the transmission needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 64,000.

ENGINE

I have experienced a message saying 'Engine Maintenance Required' and after experiencing the same instances as many people have online, it seems the engine coolant bypass valve is faulty and needs to be replaced. No code can be read using a code reader either.

ELECTRICAL SYSTEM

The contact owns a 2020 Toyota Corolla. The contact stated that while operating the vehicle, the message "Communication Module Failure" was activated. The cause of the failure was not yet determined. The local dealer and the manufacturer were contacted regarding the failure, but no assistance was provided. The failure mileage was 37,000.

UNKNOWN OR OTHER

Engine Maintenace required light came on. I was told that my coolant bypass valve needed to be replaced. This is happening on all Toyota vehicles from 2018-2024 common issue but the repair to fix something that should be covered under warranty.

ENGINE

Engine Maintenace required light came on. I was told that my coolant bypass valve needed to be replaced. This is happening on all Toyota vehicles from 2018-2024 common issue but the repair to fix something that should be covered under warranty.

AIR BAGS

The current recall on this car (passenger front seat weigh sensor issue) has been going on for too long (since 2023). Based on the recall info, i have not been able to drive with anyone sitting on the front passenger seat.

SERVICE BRAKES

The contact owns a 2020 Toyota Corolla. The contact stated that while driving approximately 10 MPH and making a left turn, the Forward Collision Avoidance system activated ad the vehicle stopped independently. The contact stated there was no warning light illuminated. The contact stated that the braking function resumed, and the contact was able to continue driving. The contact had taken the vehicle to a local dealer, where it was diagnosed and determined that the Forward Collision Avoidance was functioning correctly and there were no failure found with the brakes. The vehicle was not repaired. Additionally, the contact reported that the vehicle had started to shake abnormally while driving at speeds under 40 MPH. The contact stated no warning light was illuminated. The contact had not taken the vehicle back to a dealer or mechanic to be diagnosed. The manufacturer was not informed of the failure. The failure mileage was approximately 116,000.

FORWARD COLLISION AVOIDANCE

The contact owns a 2020 Toyota Corolla. The contact stated that while driving approximately 10 MPH and making a left turn, the Forward Collision Avoidance system activated ad the vehicle stopped independently. The contact stated there was no warning light illuminated. The contact stated that the braking function resumed, and the contact was able to continue driving. The contact had taken the vehicle to a local dealer, where it was diagnosed and determined that the Forward Collision Avoidance was functioning correctly and there were no failure found with the brakes. The vehicle was not repaired. Additionally, the contact reported that the vehicle had started to shake abnormally while driving at speeds under 40 MPH. The contact stated no warning light was illuminated. The contact had not taken the vehicle back to a dealer or mechanic to be diagnosed. The manufacturer was not informed of the failure. The failure mileage was approximately 116,000.

AIR BAGS

My airbag sensory notifications keeps coming on. When I start my car normally it isn’t on but once I start driving the notification will come on along with the ding noise it makes when you don’t have on a seat belt. I notice there was a recall on this issue for the later model Corolla and wanted to see if possibly this could be considered for the 2020 Corolla’s.

ENGINE

Coolant Bypass Valve

BACK OVER PREVENTION: WARNINGS

Fuel pump system failure causing vehicle warning lights to come on and not turn off, affecting vehicle performance for going up hill as well as vehicle completely shutting off in middle of road . Major safety hazard

FORWARD COLLISION AVOIDANCE: WARNINGS

Fuel pump system failure causing vehicle warning lights to come on and not turn off, affecting vehicle performance for going up hill as well as vehicle completely shutting off in middle of road . Major safety hazard

FUEL/PROPULSION SYSTEM

Fuel pump system failure causing vehicle warning lights to come on and not turn off, affecting vehicle performance for going up hill as well as vehicle completely shutting off in middle of road . Major safety hazard

ENGINE

On June 19, 2025, I was driving and out of nowhere, there was a warning notification that said "A warning light was turned on. Would you like to call an operator?" On the digital cluster, there was a message that said "Engine Maintenance Required - Visit Your Dealer. Mileage noted down was 79,632. I asked around for some insight and people are telling me it's the water/coolant bypass valve that's leaking and the Op code is 24TE04R1. Will this be a covered service?

ENGINE

The engine maintenance required message appeared on the dash. I was travel from work to home (about 40 miles). I pulled over immediately at a store, left my car and walked over a mile to the mechanic shop down the road (in 95° weather with a knee that has been through 3 surgeries in less than 5 years). The gentleman took me back to my car. Followed me as i took my car back to the repair shop since it was close and did not have any lights on the dash and I was not overheating. He plugged a reader in it and the error was a coolant bypass valve issue (i can't remember the exact verbage). I purchased a replacement valve 6-17-25, along with toyota coolant. I am having to wait and save up the money to have the valve replaced at the shop got the message code from. I can not afford the dealerships cost to replace the valve. The valve and coolant was expensive in itself. I have read many forums and blogs. Toyota knew there was an issue and I am requesting my reimbursement for the cost of replacing a part you knew was faulty.

UNKNOWN OR OTHER

Front windshield has bubbles on all the edges and they are getting bigger i took it to the warranty ofrece and they say it not a defect, but i hace sean more tan 100 cars With the same problem ,and i don't fiel sale wathching then grow or break. I hope You can verify , just look at any corolla and You Will see what i say on the edges of the windshield, thank

ENGINE

Flow Shut-off Valve Coolant Leak

VISIBILITY/WIPER

The windshield wipers stop in the middle of the windshield at times when set to intermittent. Sometimes they will not shut off when they are turned off. This can be a hazard while you are driving and you never know when it will happen.

VISIBILITY/WIPER

While driving with the windshield wipers on during a rain storm , the wipers would stop working suddenly. The Car was taken to dealer and windshield motor was replaced. Without working wipers, it was dangerous to drive.

ENGINE

I have an error that appeared displaying “Engine Maintenance Required” after some investigation snd research, I have noticed that this is a common issue associated with the OEM Engine Coolant Bypass Valve. This occurred as I was driving home from work when I was driving down the freeway, I did not run into any obstacles or have an accident, it appeared out of thin air.

ENGINE

unknown. i know that my car was doing fine and then randomly the coolant was low and my car was overheating on my way to work. i have yet to get it fixed, as i dont know how much it could cost me. but i read that 2020-2021 toyota makes were having issues with their coolant.

AIR BAGS

ocs sensor recall. the potential of this recall makes me very nervous to drive the car. they haven't tested or inspected the part until the remedy is in. no lights on dash at this time.

UNKNOWN OR OTHER

An engine maintenance required warning popped up. The pop up wasn't going away. My engine sounds louder than usual when turning my A/C on.

ENGINE

An engine maintenance required warning popped up. The pop up wasn't going away. My engine sounds louder than usual when turning my A/C on.

UNKNOWN OR OTHER

Coolant bypass valve. Code is P2681, part will fail and vehicle will consistently display a Engine Maintenance Required Visit Your Dealer on the MID. Dealerships will try and charge 500+ to repair it when the part is under 100+. Problem started to appear since end of March. It's May 15th as of this report. Upon using an OBD tool this is the following message: "STATUS CONFIRMED / PENDING - ENGINE COOLANT BYPASS VALUVE 'A' CONTROL CIRCUIT/OPEN : CIRCUIT SHORT TO BATTERY OR OPEN". Part has NOT been inspected by Toyota, nearby service centers are scumbags and will charge a fortunate to fix it.

FORWARD COLLISION AVOIDANCE: WARNINGS

The automatic emergency breaking and forward collision warning failed to alert and turn on and I wrecked into an object. My life was put at risk and I wrecked my car. The problem has not been reproduced or confirmed by the independent service center. The vehicle is currently being inspected by insurance estimator. There was no other alerts or messages to alert prior to collision.

FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING

The automatic emergency breaking and forward collision warning failed to alert and turn on and I wrecked into an object. My life was put at risk and I wrecked my car. The problem has not been reproduced or confirmed by the independent service center. The vehicle is currently being inspected by insurance estimator. There was no other alerts or messages to alert prior to collision.

UNKNOWN OR OTHER

Engine Coolant Bypass Valve

ENGINE

I received a "voluntary Customer Support Program" letter from Toyota saying that a small engine coolant leak can occur that "can allow coolant to drip on other parts of the vehicle. This can cause 'Engine Maintenance Required' to be displayed or cause the A/C not to function normally." Then it concludes that repair with a new "flow shut-off valve" will fix the problem, "under the terms of this Customer Support Program." I thought this was a recall and took my car in only to find that they wanted nearly $700 for the repair, because I did not have an extended warranty. When asked whether this could cause a safety problem if unfixed the reply from the Service Advisor was yes -- the coolant leak could potentially cause the engine to seize up on the highway. I was shocked that a defective part in the car I purchased new for $20,000 plus would not be replaced free of charge. I have put less than 16,000 miles on the car and now I find the resale value is essentially zero. And I now may be driving a potentially risky vehicle that could crash or leave me stranded somewhere. I feel there should be a repair at no charge.

AIR BAGS

It’s been almost 2 years with this recall been waiting for a fix. I am feeling in safe in the vehicle, I’m driving.

FUEL/PROPULSION SYSTEM

after shortly pumping gas, I received a alert on my car that I needed to check my fuel cap, after checking fuel cap I proceeded to drive on the highway during this time a multitude of sensors started to go off on my car, and it started to drive weird there were light such as my interlock, being deactivated, parking, brake, deactivated, malfunction of VSC, collision deactivated. Then suddenly while driving at an accelerated speed, and trying to slow down, my engine turned itself off, and I was not able to re-crank my car. There is an active recall with Toyota for the fuel pump, which I was told by Toyota was the issue, but due to my VIN not being associated they would not repair as a recall

STEERING

after shortly pumping gas, I received a alert on my car that I needed to check my fuel cap, after checking fuel cap I proceeded to drive on the highway during this time a multitude of sensors started to go off on my car, and it started to drive weird there were light such as my interlock, being deactivated, parking, brake, deactivated, malfunction of VSC, collision deactivated. Then suddenly while driving at an accelerated speed, and trying to slow down, my engine turned itself off, and I was not able to re-crank my car. There is an active recall with Toyota for the fuel pump, which I was told by Toyota was the issue, but due to my VIN not being associated they would not repair as a recall

ELECTRICAL SYSTEM

after shortly pumping gas, I received a alert on my car that I needed to check my fuel cap, after checking fuel cap I proceeded to drive on the highway during this time a multitude of sensors started to go off on my car, and it started to drive weird there were light such as my interlock, being deactivated, parking, brake, deactivated, malfunction of VSC, collision deactivated. Then suddenly while driving at an accelerated speed, and trying to slow down, my engine turned itself off, and I was not able to re-crank my car. There is an active recall with Toyota for the fuel pump, which I was told by Toyota was the issue, but due to my VIN not being associated they would not repair as a recall

ENGINE

Car is currently at 56k miles and the "Engine maintenance required" popped up on my dashboard I'm pretty sure this is the engine coolant bypass valve which I read is a constant problem for new toyotas like mine

ENGINE

Drive start control malfunction occurred when turning the car on. Second time this has happened. First time was a charcoal canister and engine coolant valve. It was replaced under warranty at 50k miles but now at 96k miles the dealer says it is not covered under the extended warranty. Not sure how this problem happened.

POWER TRAIN

Drive start control malfunction occurred when turning the car on. Second time this has happened. First time was a charcoal canister and engine coolant valve. It was replaced under warranty at 50k miles but now at 96k miles the dealer says it is not covered under the extended warranty. Not sure how this problem happened.

ENGINE

Once I parked my car and turned on the A/C a couple mins later I received a warning message on my car screen saying “ Engine Maintenance Required Visit Your Dealer”. After having my car for 4 years I’ve never received this message till now (04/22/25). I thought it was because I needed an oil change but I was wrong because my oil is good. I checked my car and saw that the issue is the “coolant bypass valve”. I don’t even use my car that much for this to happen. I saw this is a common issue with a Toyota Corolla 2020 but the dealership does not want to fix this issue for free.

UNKNOWN OR OTHER

Once I parked my car and turned on the A/C a couple mins later I received a warning message on my car screen saying “ Engine Maintenance Required Visit Your Dealer”. After having my car for 4 years I’ve never received this message till now (04/22/25). I thought it was because I needed an oil change but I was wrong because my oil is good. I checked my car and saw that the issue is the “coolant bypass valve”. I don’t even use my car that much for this to happen. I saw this is a common issue with a Toyota Corolla 2020 but the dealership does not want to fix this issue for free.

POWER TRAIN

The "Engine Maintenance Required" message on a 2020 Toyota Corolla SE keep coming on after I have reset numerous time. The "Engine Maintenance Required" message on a 2020 Toyota Corolla SE typically indicates a problem with the coolant bypass valve, not the regular maintenance schedule. This message is distinct from the "Maintenance Required" light that usually prompts oil changes. The coolant bypass valve issue often results in a DTC code and may require replacement.

ENGINE

I own a 2020 Toyota Corolla, and without any prior warning, the “Engine Maintenance Required” message appeared on my dashboard at approximately 79,575 miles. There were no unusual symptoms—no overheating, strange noises, or performance issues—before the light turned on. I had my vehicle inspected by Golling Toyota of Warren, where they diagnosed the issue as a faulty Engine Coolant Bypass Valve. I was informed that the valve needed to be replaced and flushed. The total cost of the repair was $932.21, which I had to pay out of pocket. Because the message specifically said “Engine Maintenance Required,” I was concerned that it could be a serious engine issue. Out of caution, I avoided driving the vehicle until it was inspected, as I didn’t know whether it could result in engine damage, performance failure, or a sudden breakdown while on the road. The fear of an unknown engine-related malfunction created a genuine safety concern for me and others —especially since the warning came without any prior symptoms. I later learned that the problem was tied to the Engine Coolant Bypass Valve, which is known to fail prematurely in Toyota vehicles. This failure can affect engine performance and temperature regulation, increasing the risk of engine damage or failure while driving. There is already a class-action lawsuit concerning this issue, yet Toyota has not issued a recall. Owners like myself are being left to pay out of pocket for a known defect that poses real safety risks. I’m submitting this complaint in hopes that Toyota will be held accountable and that the NHTSA will take appropriate action to protect consumers from this recurring and potentially dangerous defect.

ENGINE

“Engine maintenance required” alert received, related to a faulty coolant bypass valve which will need replacement. Vehicle is currently at 51,049 miles. Alert message can’t be dismissed from the dashboard. It obstructs a significant portion of the speedometer.

FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL

The anti-lock brake system (ABS) malfunctioned when the vehicle was still very new, with only 25,000 miles. Diagnostics from two independent service centers confirmed that the ABS electronic control unit is failing due to an external failure. Both specialists stated that such a failure is highly uncommon and is a clear quality issue related to the electronic components. A critical system like ABS should not fail this early, raising serious concerns about the durability and reliability of the vehicle’s braking system.

FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING

The anti-lock brake system (ABS) malfunctioned when the vehicle was still very new, with only 25,000 miles. Diagnostics from two independent service centers confirmed that the ABS electronic control unit is failing due to an external failure. Both specialists stated that such a failure is highly uncommon and is a clear quality issue related to the electronic components. A critical system like ABS should not fail this early, raising serious concerns about the durability and reliability of the vehicle’s braking system.

SERVICE BRAKES

The anti-lock brake system (ABS) malfunctioned when the vehicle was still very new, with only 25,000 miles. Diagnostics from two independent service centers confirmed that the ABS electronic control unit is failing due to an external failure. Both specialists stated that such a failure is highly uncommon and is a clear quality issue related to the electronic components. A critical system like ABS should not fail this early, raising serious concerns about the durability and reliability of the vehicle’s braking system.

ENGINE

Coolant bypass valve broken dealers are charging $800, class action lawsuit pending

ENGINE

Engine Maintenance Required displays see dealer displays in Panel. I have taken to my local shop Engine coolant bypass valve replaced. Still having same issue.

POWER TRAIN

Approximately one month ago the clutch pedal on my manual 2020 Corolla went all the way to the floor and stuck in place. Had it towed to my mechanics shop and it took them nearly 2 weeks just to get a slave cylinder to replace the defective part with. Fast-forward a week later and exactly the same thing happened. According to several different threads I have read online, this seems to be a problematic situation with the manual Corollas. Hopefully I will not experience any further problems however it appears that the defective slave cylinder part is to blame.

UNKNOWN OR OTHER

Front is very low. Right side is tilted without anyone inside. Very unusual tire wear on inside edges of both front tires. Immediately after starting the engine the front ricked side took side and made loud noises.

WHEELS

Front is very low. Right side is tilted without anyone inside. Very unusual tire wear on inside edges of both front tires. Immediately after starting the engine the front ricked side took side and made loud noises.

SUSPENSION

Front is very low. Right side is tilted without anyone inside. Very unusual tire wear on inside edges of both front tires. Immediately after starting the engine the front ricked side took side and made loud noises.

UNKNOWN OR OTHER

Coolant bypass valve needs to be replaced

AIR BAGS

The contact owns a 2020 Toyota Corolla. The contact received notification of NHTSA Campaign Number: 23V865000 (Air Bags); however, the part to do the recall repair was not yet available. An unknown local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

ENGINE

Valve matic is messed up. According to my research this is a known issue with 2020 Toyota corollas.

ENGINE

Vehicle maintenance light won’t turn off, stays off if car started with AC off but comes on and stays on while AC is running. Coolant overflow valve malfunction

ENGINE

Engine maintenance required. Visit dealer message appeared about 2 years ago. The message appears when I turn on the A/C or heater and will not go away, which affects multiple functions such as speedometer and text function.

ENGINE

Engine coolant leak from an issue with a valve that allows coolant to drip on other parts of the vehicle. “Engine Maintenance Required” is displayed on the instrument cluster and causes the A/C to not function normally.