2022 TOYOTA COROLLA CROSS

AIR BAGS:FRONTAL

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2022-2023 Corolla Cross vehicles. The instrument panel may have been produced without the required perforation, which could result in the front-passenger air bag not deploying properly. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safey Standard number 208, "Occupant Crash Protection."

Risk: An air bag that does not deploy as intended increases the risk of injury during a crash.

ENGINE

under normal driving conditions on a state highway the Engine Malfunction error displayed on my Multi-Information Display. The error indicated that I find a dealership and have the car inspected. The error would go off then come back during acceleration. after two days at the local Toyota Dealership I was told the Coolant Bypass Valve was stuck in the closed position and it would have caused stalling during acceleration and engine overheating at normal speeds. the dealership replaced the valve and flushed the 100K coolant at my expense of over $800. The issue reappeared moments after I took delivery of the repaired vehicle as I was accelerating onto the highway from their parking lot. this is a well known issue that affects 2019-2023 Camry and RAv4 models and I believe the 2022 Corolla Cross has the same defective part in its engine (all engines come from Japan) no matter where the vehicle is assembled.

POWER TRAIN

under normal driving conditions on a state highway the Engine Malfunction error displayed on my Multi-Information Display. The error indicated that I find a dealership and have the car inspected. The error would go off then come back during acceleration. after two days at the local Toyota Dealership I was told the Coolant Bypass Valve was stuck in the closed position and it would have caused stalling during acceleration and engine overheating at normal speeds. the dealership replaced the valve and flushed the 100K coolant at my expense of over $800. The issue reappeared moments after I took delivery of the repaired vehicle as I was accelerating onto the highway from their parking lot. this is a well known issue that affects 2019-2023 Camry and RAv4 models and I believe the 2022 Corolla Cross has the same defective part in its engine (all engines come from Japan) no matter where the vehicle is assembled.

ENGINE AND ENGINE COOLING

Car is 76000 miles , I just purchased the vehicle however coolant bypass valve decide to make car say Engine maintenance require even after having it serviced for an oil change. After I replaced the valve , now the pop up Engine maintenance light did not pop up after that. That was the problem .

FUEL/PROPULSION SYSTEM

Twice in 2 years the fuel gauge didn't go past 3/4 mark after it was filled all the way. After 2 days and refilled, the gauge went back to the full mark.

ENGINE

Bypass coolant valve for the engine needed replacement, multiple other Toyotas within the year range needed the same fix right after warranty ended at a specific mileage. Was told my engine would fail if not addressed or fixed.

STEERING

It was around 7pm. It was raining & wipers were on. Auto stop/start setting is on. I was at a stop light waiting to turn left. The light turns green and I try to go, but the engine stalled. I was unable to move forward into the lane, and turn the wheel. A sign on the dashboard showed up saying "engine stopped, steering power low". I try to the turn the wheel and was unable to, I tried to turn off the engine and the car shuts off. I turn the key again to start the car but it wasn't starting. It was about 3 min until the car engine throttles on and I pull over to the left into the parking lot. It was really scary. I managed to get home, which was less than a mile away. Grateful I got home. My safety was at risk at a busy and rainy intersection. Many cars went around me.

ENGINE

It was around 7pm. It was raining & wipers were on. Auto stop/start setting is on. I was at a stop light waiting to turn left. The light turns green and I try to go, but the engine stalled. I was unable to move forward into the lane, and turn the wheel. A sign on the dashboard showed up saying "engine stopped, steering power low". I try to the turn the wheel and was unable to, I tried to turn off the engine and the car shuts off. I turn the key again to start the car but it wasn't starting. It was about 3 min until the car engine throttles on and I pull over to the left into the parking lot. It was really scary. I managed to get home, which was less than a mile away. Grateful I got home. My safety was at risk at a busy and rainy intersection. Many cars went around me.

SEATS

The driver seat goes down after a few days of driving my Corolla Cross LE 2022. I have to manually lift it up every time.

UNKNOWN OR OTHER

Hello. The moonroof appears to malfunction as it doesnt improperly close and doesnt know have proper sensor to shut or stop sliding. I got soaked during carwash but thankfully not soaking the interior electronics. Please consider for possible recall.

UNKNOWN OR OTHER

I was driving on [XXX] in Miami, FL. As I stopped at a red light, the STOP/START process powered the car down. Then, all systems turned off. I put the car in park and turned the key, the engine would not turn over. I was stranded in the middle of traffic. To no avail, I tried to start the engine at least five times. Strangers helped me to push the car to the side of the road. After about 15 minutes, the car turned on weakly. I drove immediately to the Toyota dealership. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

ELECTRICAL SYSTEM

I was driving on [XXX] in Miami, FL. As I stopped at a red light, the STOP/START process powered the car down. Then, all systems turned off. I put the car in park and turned the key, the engine would not turn over. I was stranded in the middle of traffic. To no avail, I tried to start the engine at least five times. Strangers helped me to push the car to the side of the road. After about 15 minutes, the car turned on weakly. I drove immediately to the Toyota dealership. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

ENGINE

I was driving in the rain using the windshield wipers came to a stop and the engine start stop. The engine stopped and a warning sign came on saying the engine is stopped. \ power fluid low/ The steering wheel also would not turn. I had to put my hazard lights on, put the car in park and then restart the car.. this could be dangerous if I had been on the freeway.