2009 TOYOTA CAMRY

SEATS:FRONT ASSEMBLY:SEAT HEATER/COOLER

Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.

Risk: If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.

VISIBILITY:POWER WINDOW DEVICES AND CONTROLS

Toyota Motor Company (Toyota) is recalling certain model year 2009-2011 Tundra, Sequoia, Corolla, Corolla Matrix and Scion xB, 2008-2011 Highlander and Highlander Hybrid, 2007 Camry and Camry Hybrid, 2009 Camry and Camry Hybrid, 2006-2011 RAV4, 2006-2010 Yaris, and 2009-2010 Scion xD and Pontiac Vibe vehicles. During the manufacturing of the Power Window Master Switch (PWMS), grease lubricant may have been inconsistently applied to the sliding electrical contacts.

Risk: If the sliding electrical contacts are not protected by lubricant, debris and moisture that get into the switch may cause a short circuit and the switch assembly may overheat and melt, increasing the risk of a fire.

SEATS:FRONT ASSEMBLY:SEAT HEATER/COOLER

Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.

Risk: Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.

AIR BAGS:FRONTAL:SENSOR/CONTROL MODULE-INACTIVE

Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.

Risk: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.

EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH

TOYOTA IS RECALLING CERTAIN MODEL YEAR 2009 CAMRY VEHICLES MANUFACTURED FROM JULY 1, 2008, THROUGH FEBRUARY 28, 2009, AND MODEL YEAR 2009-2011 VENZA VEHICLES MANUFACTURED FROM OCTOBER 20, 2008, THROUGH JANUARY 4, 2011. DURING ASSEMBLY OF THE CONTACT-TYPE STOP LAMP SWITCH, SILICONE GREASE MAY HAVE COME IN CONTACT WITH THE SURFACE OF THE SWITCH WHICH COULD CAUSE CONTACT RESISTANCE. IF THIS OCCURS, WARNING LAMPS COULD ILLUMINATE, A NO START CONDITION COULD RESULT, THE SHIFT LEVER MAY NOT SHIFT FROM THE “PARK” POSITION, OR THE VEHICLE’S BRAKE LIGHTS COULD BECOME INOPERATIVE.

Risk: INOPERATIVE BRAKE LIGHTS WOULD NOT WARN OTHER DRIVERS THAT THE VEHICLE IS SLOWING OR STOPPING, INCREASING THE RISK OF A CRASH.

VISIBILITY:POWER WINDOW DEVICES AND CONTROLS

Toyota is recalling certain model year 2007-2009 Camry, Camry Hybrid, RAV4, Corolla, Corolla Matrix, Tundra, Sequoia, Highlander, Highlander Hybrid, Yaris, Scion xB, Scion xD and Pontiac Vibe vehicles. The power window master switch assemblies in some of these vehicles were built using a less precise process for lubricating the internal components of the switch assemblies. Irregularities in this lubrication process may cause the power window master switch assemblies to malfunction and overheat.

Risk: If the switch overheats, it may melt, possibly resulting in a fire.

EQUIPMENT:OTHER:LABELS

GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.

Risk: THIS DOES NOT MEET THE STANDARD REQUIREMENTS.

VEHICLE SPEED CONTROL:ACCELERATOR PEDAL

TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 AVALON, MODEL YEAR 2007-2010 CAMRY, MODEL YEAR 2009-2010 COROLLA, COROLLA MATRIX, RAV4, MODEL YEAR 2010 HIGHLANDER, MODEL YEAR 2008-2010 SEQUOIA, AND MODEL YEAR 2007-2010 TUNDRA VEHICLES. DUE TO THE MANNER IN WHICH THE FRICTION LEVER INTERACTS WITH THE SLIDING SURFACE OF THE ACCELERATOR PEDAL INSIDE THE PEDAL SENSOR ASSEMBLY, THE SLIDING SURFACE OF THE LEVER MAY BECOME SMOOTH DURING VEHICLE OPERATION. IN THIS CONDITION, IF CONDENSATION OCCURS ON THE SURFACE, AS MAY OCCUR FROM HEATER OPERATION (WITHOUT A/C) WHEN THE PEDAL ASSEMBLY IS COLD, THE FRICTION WHEN THE ACCELERATOR PEDAL IS OPERATED MAY INCREASE, WHICH MAY RESULT IN THE ACCELERATOR PEDAL BECOMING HARDER TO DEPRESS, SLOWER TO RETURN, OR, IN THE WORST CASE, MECHANICALLY STUCK IN A PARTIALLY DEPRESSED POSITION.

Risk: THE ACCELERATOR PEDAL MAY BECOME HARD TO DEPRESS, SLOW TO RETURN TO IDLE, OR, IN THE WORST CASE, MECHANICALLY STUCK IN A PARTIALLY DEPRESSED POSITION, INCREASING THE RISK OF A CRASH.

STRUCTURE:INTERIOR PANELS:DASHBOARD

The contact owns a 2009 Toyota Camry. The contact stated that the dashboard was sticky and melting. The contact stated that since moving to the desert, the dashboard coating had degraded and deteriorated. The shine created a glare on the windshield, preventing the contact from driving at night. The vehicle was taken to the dealer. The contact was informed that it was an aesthetic issue, and the Customer Support Program warranty period had ended. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was unknown.

VISIBILITY/WIPER

I purchased a 2009 Toyota Camry on [XXX]. After a few years, the dashboard became soft and sticky. During the summer of 2018, I noticed it melting on a hot sunny day. I looked into having it replaced. There was a warranty enhancement notification letter previously sent to me, which stated this type of known problem would be covered for up to 10 years since car was first placed in service. Unfortunately, I didn’t determine this was enough of a problem to me until [XXX]. I missed the warranty extension by 5 days. I contacted Newbold Toyota on June 29, 2018, and the service manager said that after the 10 years, it was the manufacturer's responsibility and there is nothing they can do, except to charge me for the repair. The repair was estimated at approx. $1,500 for the dashboard replacement. At first, I thought "Oh well, I can live with this." But now the dashboard has melted so much that it now reflects sunlight into the windshield so badly that it is has become a safety hazard. It is very difficult to see through the windshield when driving towards the sun or with the sun directly above on a sunny day (even while wearing sunglasses). So the defective dashboard is now causing a very hazardous driving condition. So I contacted the national Toyota Customer Service Center, and they said essentially the same thing as Newbold Toyota. There was nothing they can do now. Since this design/material flaw has caused such a serious hazard when driving the car, and this is now a safety issue, I believe Toyota should be held responsible and should pay for the repair to fix this safety issue. When I purchased this car, I had no idea the dashboard had an expiration date. Had I noticed the melting a few days earlier they would have paid for the replacement. So why does their responsibility to fix this defect/safety issue end after 10 years? I don’t believe Toyota considers this a safety issue, or I believe they would fix it. Thank you. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U

ENGINE

The contact owns a 2009 Toyota Camry. The contact stated that while his daughter was driving, the "Check Oil" warning light illuminated. The contact added oil to the engine. The contact was informed that the check oil warning light was illuminated. The contact took the vehicle to the dealer where an oil consumption test was performed. The dealer diagnosed the vehicle and determined that the engine was consuming an excessive amount of engine oil. The contact was adding several quarts of oil every 1,000 miles driven. The vehicle was not repaired due to cost. The manufacturer was made aware of the failure and informed the contact that the Extended Warranty had been exceeded. The failure mileage was approximately 137,000.

STRUCTURE:INTERIOR PANELS:DASHBOARD

The contact owns a 2009 Toyota Camry. The contact stated while driving at an undisclosed speed, the reflection from the melted dashboard impaired his view while driving. The contact stated that the dashboard was sticky and shiny and reflected on the windshield while driving. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The manufacturer was made aware of the failure but provided no assistance. The contact was informed that the Extended Warranty coverage on the vehicle had expired. The failure mileage was approximately 60,000.

ENGINE

The engine burned excessive oil and finally the rings and head gasket failed causing the engine to misfire and finally break down at 186,000 miles.

STRUCTURE:BODY

The contact owns a 2009 Toyota Camry. The contact stated that the dashboard had started to fracture in several places. The dealer was contacted, and an appointment was scheduled; however, the vehicle had not been taken to the dealer. The vehicle was not repaired. The manufacturer was made aware of the failure and opened a case for the failure. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was 20,000. The VIN was not available.

ENGINE

I have 2009 Toyota Camry LE, the problem is engine oil, if I changed/filled the engine oil in certified stores, but after 400 miles the engine oil is not in the engine chamber I checked the leaks or any other sort of damage but there's nothing like that I verified the same thing with the dealership too. Basically my point is due to extensive consumption of engine oil the engine will brake in the middle of driving and there are chances it will explode and there's a DANGER while driving the car it's like pulled the granite pin and sit above it. And due to this the braking system will fail and the person loose his life and the dependses will be suffered a lot. Please look at this issue. Thank you.

SERVICE BRAKES

I have 2009 Toyota Camry LE, the problem is engine oil, if I changed/filled the engine oil in certified stores, but after 400 miles the engine oil is not in the engine chamber I checked the leaks or any other sort of damage but there's nothing like that I verified the same thing with the dealership too. Basically my point is due to extensive consumption of engine oil the engine will brake in the middle of driving and there are chances it will explode and there's a DANGER while driving the car it's like pulled the granite pin and sit above it. And due to this the braking system will fail and the person loose his life and the dependses will be suffered a lot. Please look at this issue. Thank you.

STEERING

I have 2009 Toyota Camry LE, the problem is engine oil, if I changed/filled the engine oil in certified stores, but after 400 miles the engine oil is not in the engine chamber I checked the leaks or any other sort of damage but there's nothing like that I verified the same thing with the dealership too. Basically my point is due to extensive consumption of engine oil the engine will brake in the middle of driving and there are chances it will explode and there's a DANGER while driving the car it's like pulled the granite pin and sit above it. And due to this the braking system will fail and the person loose his life and the dependses will be suffered a lot. Please look at this issue. Thank you.