TOYOTA BZ4X

VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2023-2025 bZ4X, Lexus RZ, and Subaru Solterra vehicles. During certain HVAC system faults, such as electrical compressor failure, the defroster and defogger system may become inoperative.

Risk: An inoperative defroster and defogger system can decrease the driver's visibility under certain driving conditions, increasing the risk of a crash.

EQUIPMENT:OTHER:LABELS

Gulf States Toyota, Inc. (GST) is recalling certain Toyota 2023 GR Supra, 2024 4 Runner, Corolla, Grand Highlander, Grand Highlander Hybrid, Land Cruiser Hybrid, Tacoma, Tacoma Hybrid, 2023-2024 BZ4X, Corolla Cross Hybrid, GR Corolla, GR86, Highlander, Highlander Hybrid, Prius, Prius Prime, Sequoia Hybrid, Tundra, Tundra Hybrid, Venza Hybrid, 2023-2025 Crown, and 2025 Camry Hybrid vehicles equipped with GST accessories. The load carrying capacity modification label may display inaccurate added weight values. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 110, "Tire Selection and Rims."

Risk: A vehicle with an incorrect maximum capacity weight value may be overloaded, which can increase the risk of a crash.

ELECTRICAL SYSTEM

The 12 volt battery does not maintain a charge. I have had it replaced twice. I purchased new January 2025; first battery replaced on March 20, 2025; second battery replaced August 13, 2025. I am currently having the same issue with the battery management system which controls temperature and battery usage. After sitting overnight, I drove my car approximately three miles parked and attempted to use the key fob to secure the vehicle, it failed. I had no problem or indication at the start of my trip. I had to secure the door with my physical key. I returned to the vehicle 15 minutes later and the key fob would not work at all. I accessed the vehicle with the physical key. The alarm was activated upon entry. I tried to use my key fob to get the vehicle to deactivate the alarm system but it would not work. Approximately five minutes later and after several attempts, the alarm stopped and the vehicle was showing ‘Ready’ but ‘No Key Detected’ was flashing on the information screen and vehicle would not change mode from park to reverse or drive. After several attempts of holding the key fob directly over the ‘START/STOP’ button, the car showed ‘ READY’ and I was able to change modes. The vehicle started flashing ‘NO KEY DETECTED’ continuously while I quickly drove back home. I parked in my driveway and made an appointment with Toyota for service. Later in the day, I attempted my key fob again, to no avail. I was able to get the key detected, display showed ‘Ready’ and mode changed. My car does not start (READY) until after several attempts. The dealership advised the battery failed a load test overnight and was replaced (August 15th) After the second replacement my car sat overnight. I drove a few miles to a charging station. I placed the car in ‘My Room Mode’ to have access to the climate control system and radio. The car started flashing ‘low voltage/battery’, I turned off the accessory mode, returned to the dealer, and awaiting resolution. Case filed with NCDS/CDSP.

VISIBILITY:REARVIEW MIRRORS/DEVICES:EXTERIOR

I am very concerned about potential accidents for my self and others driving this vehicle. I have multiple close call accidents because the left view mirror does't have proper view to see cars on left side especially if they are close. The way seat and the side of the vehicle is shaped its very hard to still see manually with head turned to the left rear side. The mirror or the shape or position needs to be changed for safety to prevent accidents.

SEATS

I am very concerned about potential accidents for my self and others driving this vehicle. I have multiple close call accidents because the left view mirror does't have proper view to see cars on left side especially if they are close. The way seat and the side of the vehicle is shaped its very hard to still see manually with head turned to the left rear side. The mirror or the shape or position needs to be changed for safety to prevent accidents.

LANE DEPARTURE: BLIND SPOT DETECTION

I am very concerned about potential accidents for my self and others driving this vehicle. I have multiple close call accidents because the left view mirror does't have proper view to see cars on left side especially if they are close. The way seat and the side of the vehicle is shaped its very hard to still see manually with head turned to the left rear side. The mirror or the shape or position needs to be changed for safety to prevent accidents.

STRUCTURE:BODY

LEFT FRONT FENDER AND HOOD CONTACTED UPON GOING INTO A DIP IN THE ROAD DURNING ROAD CONTRUCTION PERFORMED BY BITUMINOUS ROADWAYS, INC. DAMAGE TO FENDER AND HOOD. VEHICLE BODY AND OR FRAME WISTED. BROUGHT THE VEHICLE TO LAMETTRY'S IN BURNSVILLE MINNESOTA. THEY STAED THAT THE DIP IN THE ROAD MAY HAVE CAUSED THIS CONDITION AS SEEN FROM THE SCRAPE MARKS ON LATCH. TOYOTA DEALER INSPRSTION AND CASE OPENED. CRUNCH NOISE HEARD DURING INCIDENT.

AIR BAGS

Driver sustained severe hand injuries due to airbag deployment while the hand was on the horn pad. Possible over-aggressive deployment or module failure. Incident occurred on [XXX], while driving a 2024 Toyota BZ4X (VIN: [XXX] ). Requesting formal investigation into the airbag system and front structural integrity of this vehicle model. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

STRUCTURE:BODY:BUMPERS

On [XXX], while driving through a common roadway puddle at a safe speed, the front bumper on my BZ4X detached from the undercarriage shield and tore away from the clips. This type of damage is clearly disproportionate to the conditions and reflects a deficiency in structural design. After researching this issue, I found that many other BZ4X owners have experienced the same bumper detachment and undercarriage shield failure under minimal driving conditions. These consistent reports indicate a widespread manufacturing defect, not isolated driver error or negligence. For example: On multiple owner forums and complaint sites like NHTSA.gov and Reddit, BZ4X owners have documented similar instances of bumpers tearing off from puddles or light snow. A widely circulated post on Reddit’s r/Toyota described a nearly identical issue, stating that “driving through a shallow puddle at a slow speed caused the bumper to rip off like paper.” The issue has even reached automotive press outlets and consumer advocate blogs, highlighting growing concern over the poor mounting of the bumper and the fragile undercarriage shield. Given the consistency and severity of these reports, this clearly represents a design flaw. The bumper is failing to withstand routine driving conditions, and this undermines not only the durability of the vehicle but also customer confidence and safety. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

STRUCTURE:FRAME AND MEMBERS:UNDERBODY SHIELDS

On [XXX], while driving through a common roadway puddle at a safe speed, the front bumper on my BZ4X detached from the undercarriage shield and tore away from the clips. This type of damage is clearly disproportionate to the conditions and reflects a deficiency in structural design. After researching this issue, I found that many other BZ4X owners have experienced the same bumper detachment and undercarriage shield failure under minimal driving conditions. These consistent reports indicate a widespread manufacturing defect, not isolated driver error or negligence. For example: On multiple owner forums and complaint sites like NHTSA.gov and Reddit, BZ4X owners have documented similar instances of bumpers tearing off from puddles or light snow. A widely circulated post on Reddit’s r/Toyota described a nearly identical issue, stating that “driving through a shallow puddle at a slow speed caused the bumper to rip off like paper.” The issue has even reached automotive press outlets and consumer advocate blogs, highlighting growing concern over the poor mounting of the bumper and the fragile undercarriage shield. Given the consistency and severity of these reports, this clearly represents a design flaw. The bumper is failing to withstand routine driving conditions, and this undermines not only the durability of the vehicle but also customer confidence and safety. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

ELECTRICAL SYSTEM

UNKNOWN , 11/26/2024 car in garage would not start, car was tow to Toyota and Toyota replaced the battery. then on 02/06/2025 vehicle was in garage and would not start and vehicle was tow again to Toyota dealer. Where dealer replaced 12 volt battery at 5,283 miles. And told us to put a battery charger on the battery.