Tiffin Motorhomes, Inc. (Tiffin) is recalling certain 2025 Zephyr motorhomes with floorplan 45PZ. The secondary emergency exit is incorrectly located on the same side as the primary emergency exit.

Risk: Incorrect placement of the emergency exit increases the risk of injury during an emergency.

2025 TIFFIN ZEPHYR

679 vehicles affected

24V566000

ELECTRICAL SYSTEM:IGNITION

Tiffin Motorhomes, Inc. (Tiffin) is recalling certain 2022-2025 Phaeton, Allegro Bus, and Zephyr motorhomes. The PowerGlide chassis controller may have insufficient circuit protection, which can result in a blown fuse and cause an engine shutdown.

Risk: An engine shutdown increases the risk of a crash.

2022 TIFFIN ZEPHYR

507 vehicles affected

24V036000

SEATS

Tiffin Motorhomes, Inc. (Tiffin) is recalling certain 2022 Allegro Bus, Phaeton, Allegro Red 360, and Zephyr motorhomes. The pedestal mounting plate on the driver's seat may be improperly welded, which can cause the plate to separate and the seat assembly to loosen or detach.

Risk: A loose or detached seat assembly increases the risk of injury.

2022 TIFFIN ZEPHYR

450 vehicles affected

23V406000

ELECTRICAL SYSTEM

Tiffin Motorhomes, Inc. (Tiffin) is recalling certain 2022-2023 Phaeton, Allegro Bus, and Zephyr motorhomes built on PowerGlide chassis. A fuse will trip during an a/c compressor failure, causing a loss of power to the chassis.

Risk: Loss of power to the chassis can cause an engine stall, increasing the risk of a crash.

2024 TIFFIN ZEPHYR

1188 vehicles affected

23V643000

EQUIPMENT:APPLIANCE:OVEN/STOVE/COOKTOP

Tiffin Motorhomes, Inc. (Tiffin) is recalling certain 2016-2024 Allegro Bus, and 2017-2024 Zephyr motorhomes. The 240-Volt induction cooktop may not be grounded, which can create an electrical shock hazard if the wires short-circuit.

Risk: An electrical shock can increase the risk of injury.

2021 TIFFIN ZEPHYR

10409 vehicles affected

21V680000

SEAT BELTS:REAR/OTHER:ANCHORAGE

Tiffin Motorhomes, Inc. (Tiffin) is recalling certain 2018-2022 Allegro Breeze, Allegro Red, Allegro, Allegro Bus, Phaeton, and 2018-2021 Zephyr recreational vehicles. The sofa seat belts may not have been installed correctly, which could result in unsecured passengers. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 210, "Seat Belt Assembly Anchorages."

Risk: Unsecured passengers have an increased risk of injury in the event of a crash.

2020 TIFFIN ZEPHYR

643 vehicles affected

20V433000

VISIBILITY:WINDSHIELD WIPER/WASHER:SWITCH/WIRING

Tiffin Motorhomes, Inc. (Tiffin) is recalling certain 2019-2020 Tiffin Bus and 2018-2020 Zephyr motorhomes. The windshield wipers may not work due to the control module being improperly wired.

Risk: The wipers may stop working during inclement weather, causing limited visibility, increasing the risk of a crash.

2018 TIFFIN ZEPHYR

2289 vehicles affected

19V228000

ELECTRICAL SYSTEM

Tiffin Motorhomes, Inc. (Tiffin) is recalling certain 2018-2019 Phaeton, Allegro Bus, and Zephyr motorhomes. The alternating current electrical wires may have been improperly secured in the Energy Management Module, causing increased electrical resistance.

Risk: The additional resistance can cause the wires to overheat, increasing the risk of a fire.

2018 TIFFIN ZEPHYR

1223 vehicles affected

18V341000

STRUCTURE:BODY:DOOR

Tiffin Motorhomes, Inc. (Tiffin) is recalling certain 2018-2019 Tiffin Allegro RED, Allegro Open Road, Breeze, Bus, Phaeton, and Zephyr motorhomes. The entry door on these vehicles may have been improperly assembled, allowing the door to open while the vehicle is moving.

Risk: If the door comes open while the motorhome is moving, there is an increased risk of injury to the motorhome occupants.

2015 TIFFIN ZEPHYR

36005 vehicles affected

17V841000

EQUIPMENT

Tiffin Motorhomes, Inc. (Tiffin) is recalling certain 2009-2018 Allegro and Allegro RED, Bus and Phaeton vehicles, 2009-2010 Bay vehicles, 2011-2018 Breeze vehicles, and 2009-2015, and 2017-2018 Zephyr vehicles. These motorhomes are equipped with Kidde Plastic-Handle or Push Button 'Pindicator' Fire Extinguishers that may become clogged, preventing the extinguisher from discharging as expected or excessive force may be needed to activate the extinguisher. Additionally, in certain models, the nozzle may detach from the valve assembly with enough force that it could cause injury and also render the product inoperable. For a full list of the affected fire extinguisher models visit: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17E062-5427.pdf

Risk: In the event of a fire, if the fire extinguisher does not function properly, it can increase the risk of injury.

Recent Complaints

No recent complaints found.