2021 THOR MOTOR COACH FOUR WINDS

EQUIPMENT:APPLIANCE:OVEN/STOVE/COOKTOP

Thor Motor Coach (TMC) is recalling certain 2021 Four Winds motorhomes, equipped with Dometic 3 burner cooking stoves. The saddle valve securing bolt may be overtightened, possibly damaging the o-ring seal and causing a continuous gas leak.

Risk: A gas leak can increase the risk of a fire.

ELECTRICAL SYSTEM:12V/24V/48V BATTERY:CABLES

Thor Motor Coach (TMC) is recalling certain 2021 Daybreak, Four Winds, Quantum, Chateau, and Freedom Elite motorhomes built on the 2020 Ford E-Series chassis. The battery cable may not have been properly secured within the chassis rail, which can cause it to contact the exhaust manifold and heat shield.

Risk: Battery cable contact with the exhaust manifold and heat shield can increase the risk of a fire.

VISIBILITY:GLASS, SIDE/REAR

Thor Motor Coach (TMC) is recalling certain 2020-2021 ACE, 2021 Four Winds and 2020 Gemini, Axis, Compass, Delano, Windsport, Hurricane, Outlaw, and Vegas motorhomes. The adhesive bond between the glass and the metal hinge frame of the frameless windows may fail which would then allow the glass to detach and fall out.

Risk: If the window glass detaches while the vehicle is moving it could become a projectile, increasing the risk of a crash.

SEAT BELTS

Thor Motor Coach (TMC) is recalling certain 2020-2021 Daybreak 23DB, 2018-2021 Four Winds 23U, and 2018-2021 Chateau 23U motorhomes. Bolts of the wrong size were used to secure the barrel chair pedestals, allowing the pedestal to separate from the floor in the event of a crash. As such, these motorhomes fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 207, "Seating Systems" and number 210, "Seat Belt Assembly Anchorages."

Risk: If the pedestal were to separate from the floor during a crash, the seat belt anchorages may fail, increasing the risk of injury.

ELECTRICAL SYSTEM:WIRING

Thor Motor Coach (Thor) is recalling certain 2020-2021 Daybreak, Four Winds, Quantum, Delano, Tiburon, Chateau and Freedom Elite motorhomes and 2020 Gemini, Chateau Citation, Compass, Siesta, and Synergy motorhomes built on Sprinter Van chassis (platform 970 (VS30), equipped with swivel seats. The wiring harnesses for the front seats may have been routed incorrectly and could become jammed and damaged in the swivel seat frames.

Risk: If the wiring harness is damaged, the side air bag within the seat may deploy inadvertently or not deploy as designed in the event of a crash, increasing the risk of injury to vehicle occupants.

ELECTRICAL SYSTEM:WIRING

Thor Motor Coach (TMC) is recalling certain 2019-2021 Freedom Elite, and 2021 Four Winds motorhomes. A 100amp converter breaker was incorrectly installed at the battery tray when a 70amp breaker is required, possibly resulting in the wiring connected to the breaker overheating.

Risk: Overheated wires can increase the risk of a fire.

POWER TRAIN:DRIVELINE:DRIVESHAFT

Thor Motor Coach (TMC) is recalling certain 2020 Chateau 31W and 31WV, Quantum KW29 and LF31, Vegas 24.1 and Axis 24.1 motorhomes and 2020-2021 Four Winds 24F, 28Z, and 31E motorhomes built on a Ford chassis. The rear axle differential may have an insufficient amount of fluid, possibly resulting in a failure of the rear axle assembly and a driveshaft separation.

Risk: If the driveshaft separates, there may be a loss of drive, increasing the risk of crash. Additionally, if the parking brake is not applied, unintended vehicle movement can occur if the transmission is left in Park, increasing the risk of injury or crash.

ELECTRICAL SYSTEM

Thor Motor Coach (TMC) is recalling certain 2020-2021 Daybreak, Four Winds, Chateau, Freedom Elite, Quantum motorhomes built on a Chevrolet chassis. The BIM (Battery Isolation Manager)/BIR (Battery Isolation Relay) is not watertight when exposed to engine compartment heat.

Risk: Water may get into the BIM/BIR and create electrical arcing, increasing the risk of a fire.