2022 TESLA MODEL S

ELECTRICAL SYSTEM:HORN

Tesla, Inc. (Tesla) is recalling certain 2021-2024 Model S and 2021-2025 Model X vehicles. An air bag with the incorrect horn pad may have been installed, preventing the horn from sounding.

Risk: An inoperative horn may prevent the driver from alerting other drivers, increasing the risk of a crash.

ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL

Tesla, Inc. (Tesla) is recalling certain 2012-2023 Model S, 2016-2024 Model X, 2017-2023 Model 3, 2019-2024 Model Y, and 2024 Cybertruck vehicles. An incorrect font size is displayed on the instrument panel for the Brake, Park, and Antilock Brake System (ABS) warning lights. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 105, "Hydraulic and Electric Brake Systems" and 135, "Light Vehicle Brake Systems."

Risk: Warning lights with a smaller font size can make critical safety information on the instrument panel difficult to read, increasing the risk of a crash.

LATCHES/LOCKS/LINKAGES:HOOD:LATCH

Tesla, Inc. (Tesla) is recalling certain 2021-2024 Model 3, Model S, Model X, and 2020-2024 Model Y vehicles. The hood latch assembly may fail to detect an unlatched hood condition after the hood has been opened.

Risk: An unlatched hood can fully open, obstructing the driver's view and increasing the risk of a crash.

SEAT BELTS:FRONT:WARNING LIGHT/DEVICES

Tesla, Inc. (Tesla) is recalling certain 2012-2024 Model S, 2015-2024 Model X, 2017-2023 Model 3, and 2020-2023 Model Y vehicles. In the event of an unbelted driver, the seat belt warning light and audible chime may not activate as intended. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."

Risk: A seat belt warning system that fails to alert occupants of an unbelted seat belt can increase the risk of injury during a crash.

AIR BAGS:FRONTAL:DRIVER SIDE:CUSHION

Tesla, Inc. (Tesla) is recalling certain 2021-2025 Model S and Model X vehicles. The driver's air bag could tear during deployment. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 208, "Occupant Crash Protection" and 212, "Windshield Mounting."

Risk: A torn air bag may not adequately protect an occupant in a crash, increasing the risk of injury.

AIR BAGS:FRONTAL

Tesla, Inc. (Tesla) is recalling certain 2021-2024 Model S and Model X vehicles. An incorrect air bag may have been installed when the steering yoke or round steering wheel was replaced with a different style of yoke or steering wheel.

Risk: An air bag that is not designed to function with the replacement steering yoke or wheel may deploy incorrectly, increasing the risk of injury during a crash.

STEERING:AUTOMATED/ADAPTIVE STEERING

Tesla, Inc. (Tesla) is recalling certain 2016-2023 Model S, Model X, 2017-2023 Model 3, and 2020-2023 Model Y vehicles equipped with Full Self-Driving Beta (FSD Beta) software or pending installation.  The FSD Beta system may allow the vehicle to act unsafe around intersections, such as traveling straight through an intersection while in a turn-only lane, entering a stop sign-controlled intersection without coming to a complete stop, or proceeding into an intersection during a steady yellow traffic signal without due caution. In addition, the system may respond insufficiently to changes in posted speed limits or not adequately account for the driver's adjustment of the vehicle's speed to exceed posted speed limits.

Risk: FSD Beta software that allows a vehicle to exceed speed limits or travel through intersections in an unlawful or unpredictable manner increases the risk of a crash.

SEAT BELTS:FRONT

Tesla, Inc. (Tesla) is recalling certain 2021-2023 Model S and Model X vehicles. The front-row seat belts may not be connected properly to the pretensioner anchors, which can cause the seat belts to detach.

Risk: A detached seat belt may not properly restrain an occupant during a crash, increasing the risk of injury.

ELECTRICAL SYSTEM:ADAS:AUTONOMOUS/SELF DRIVING:SOFTWARE

Tesla, Inc. (Tesla) is recalling 2012-2023 Model S, 2016-2023 Model X, 2017-2023 Model 3, and 2020-2023 Model Y vehicles equipped with all versions of Autosteer leading up to the version(s) that contains the recall remedy. In certain circumstances when Autosteer is engaged, the prominence and scope of the feature's controls may not be sufficient to prevent driver misuse of the SAE Level 2 advanced driver-assistance feature.

Risk: In certain circumstances when Autosteer is engaged, and the driver does not maintain responsibility for vehicle operation and is unprepared to intervene as necessary or fails to recognize when Autosteer is canceled or not engaged, there may be an increased risk of a crash.

LATCHES/LOCKS/LINKAGES:DOORS:LATCH

Tesla, Inc. (Tesla) is recalling certain 2021-2023 Model S and X vehicles. The cabin doors can be unlocked during a crash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 214, "Side Impact Protection."

Risk: An unlocked door may unlatch and open during a crash, increasing the risk of injury.

ELECTRICAL SYSTEM:SOFTWARE

Tesla, Inc. (Tesla) is recalling certain 2020-2022 Model S, Model X, Model Y, and 2017-2022 Model 3 vehicles. The Boombox function allows sounds to be played through an external speaker while the vehicle is in motion, which may obscure the Pedestrian Warning System (PWS) sounds. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 141, "Minimum Sound Requirements for Hybrid and Electric Vehicles."

Risk: Pedestrians may be unaware of an approaching vehicle if the PWS sounds are obscured, increasing the risk of a crash.

VISIBILITY:POWER WINDOW DEVICES AND CONTROLS

Tesla, Inc. (Tesla) is recalling certain 2017-2022 Model 3, 2020-2022 Model Y, and 2021-2022 Model S and Model X vehicles. The window automatic reversal system may not react correctly after detecting an obstruction. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 118, "Power-Operated Window Systems."

Risk: A closing window may exert excessive force by pinching a driver or passenger before retracting, increasing the risk of injury.

AIR BAGS:SIDE/WINDOW:CURTAIN:INFLATOR

Tesla, Inc. (Tesla) is recalling certain 2021-2022 Model S vehicles. The right or left side curtain air bag inflators may have been assembled incorrectly.

Risk: An incorrectly assembled inflator can cause a delayed or improper deployment of the side curtain air bag, increasing the risk of injury during a crash.

SUSPENSION

Michelin Pilot Sport 4S T2 295/30R/21 102Y. These tires are engineered by Michelin specifically for a Tesla Model S 2022+ hence the T2 mark. These are a second generation as the previous ones were a T1. Everything is supposed to be factored in by Michelin to cater to the vehicles specifications and needs. I bought a set of 4 of these mentioned tires brand new from Discount Tire. In less 10000 miles and 7 months the sidewalls have completely decoupled from the tread section/rest of the tire. The treadwear itself shows and even smooth normal wear pattern. Discount tire and Michelin are trying to claim this is an alignment issue citing too much camber. This is a false claim. The area of separation is not in the contact patch with the surface of the road. This is a defect in engineering and construction in the tire itself. This calls for a mass recall. I put the trust of my pregnant wife into these tires and she complained to me about a wallowing car ride with a decrease in handling, especially over bumps and on the highway. I could not see an issue. A few days later she informed me of a tire pressure indicator on the dashboard. It indicated tow low rear tires. Upon inspecting the tires I found both sides with a decoupled sidewall. Driver side being far worse than passenger. I immediately drove to Discount tire and the tire pressure sank from 26psi to 8psi in less than 4 miles. This could have proved fatal for my wife and unborn child on the highway. The tire company and the stores dont want to accept accountability. The stores just want to sell more tires. I am having them replaced at a cost of $610 per tire. Thats equaling to almost $3000 spent on tires in 7-8 months. Please investigate this matter. This is a defect. Not wear. The vehicle previously had Falken tires that lasted 24000 miles with smooth and even treadwear. No issues, no defects.

SEAT BELTS

The front right door top hinge bolts fell out. Believe the bottom one is broke off. Also have vehicle has a seat belt warning alarm indicated. There is a vehicle appointment scheduled for the Thursday August 14, 2025. Did not notice any warning signs. The door separated in the parking lot of a food establishment.

STRUCTURE:BODY:DOOR:HINGE AND ATTACHMENTS

The front right door top hinge bolts fell out. Believe the bottom one is broke off. Also have vehicle has a seat belt warning alarm indicated. There is a vehicle appointment scheduled for the Thursday August 14, 2025. Did not notice any warning signs. The door separated in the parking lot of a food establishment.

STRUCTURE:BODY:DOOR:HANDLE:INTERIOR

Driver door does not unlock after a trip, with passengers inside the vehicle. Driver is unable to exit the vehicle from the driver door. This has happened a couple times now, a Tesla mechanic stopped by after the first time, but didn’t find any issue. It’s happening again.

LATCHES/LOCKS/LINKAGES:DOORS:LATCH

Driver door does not unlock after a trip, with passengers inside the vehicle. Driver is unable to exit the vehicle from the driver door. This has happened a couple times now, a Tesla mechanic stopped by after the first time, but didn’t find any issue. It’s happening again.

FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING

The contact owns a 2022 Tesla Model S. The contact stated while driving 35 MPH in inclement weather with no other vehicles nearby, the vehicle came to an abrupt stop. The contact stated that the brakes were applied without driver input. The contact stated that the emergency stop message was displayed during the failure. The contact stated that on another occasion, while driving 45 MPH, the vehicle suddenly stopped. The contact had since stopped using the Forward Collision Avoidance: Adaptive Cruise Control. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was approximately 50,320.

FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL

The contact owns a 2022 Tesla Model S. The contact stated while driving 35 MPH in inclement weather with no other vehicles nearby, the vehicle came to an abrupt stop. The contact stated that the brakes were applied without driver input. The contact stated that the emergency stop message was displayed during the failure. The contact stated that on another occasion, while driving 45 MPH, the vehicle suddenly stopped. The contact had since stopped using the Forward Collision Avoidance: Adaptive Cruise Control. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was approximately 50,320.

ELECTRICAL SYSTEM:12V/24V/48V BATTERY

The contact owns a 2022 Tesla Model S. The contact stated while the vehicle was parked and occupied, the message “Electrical System Power Reduce - Vehicle will Shut down” was displayed. The contact stated the vehicle had stopped charging and turned off once removed from the charger. The contact stated that the message “Climate Keeper Unavailable Due to System Fault” was displayed. The vehicle was towed to the dealer where it was diagnosed and determined that the battery needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 47,000.

SEAT BELTS

The rear seatbelt on the left stopped latching all of a sudden creating a safety issue to ride with family.

VISIBILITY/WIPER

While driving at approximately 5 MPH, the front passenger side window spontaneously shattered without any external or internal impact. I was alone in the vehicle and no one was seated in the front passenger seat. There were no objects in the car that could have made contact with the glass, and there was no indication of any road debris or other outside force. The window failure caused microshards of glass to scatter into the cabin, creating a potential safety hazard to the driver and any possible occupants. There were no warning lights, alerts, or symptoms before the failure occurred. The vehicle was inspected by a manufacturer service center, but the request for an engineering-level inspection was denied. The service center did not identify any external cause for the failure but still refused warranty coverage and did not escalate the issue for further analysis. The issue has not been reproduced but has not been properly investigated by the manufacturer either. Given the complete absence of impact and the sudden nature of the failure, this appears to be a glass defect or an installation issue. The broken component is available for inspection.

LATCHES/LOCKS/LINKAGES:DOORS:LATCH

The manual door release on the front passenger side of my car was released automatically without anyone in the seat. I was the only one in the car. I was making a turn off of an exit and went over the seam between the bridge and the street. After I went over the seam, the front passenger door manual release was triggered and opened the door. I was able to pull over the close the door immediately after. This is a route I take daily for work and haven't had this problem before. This is a safety issue should someone been sitting in that seat or if there was a car to the right of me and the door fully opened outward. This could result in someone potentially falling out of the car or an accident if someone hit the door if it had swung out. I have tried to reproduce the problem and it has not done it since 3/13/2025 at 4:27pm when the original incident occurred. I did receive an error on the screen stating the manual release button was triggered when I went over the bump. I have tried to book an appointment with Tesla to investigate, but the earliest appointment they had available was April 1, 2025.

VISIBILITY:REARVIEW MIRRORS/DEVICES:EXTERIOR

The driver side rear view mirror vibrates at most speeds in a way that renders it useless. This is a well described issue. Tesla is aware of it but refuses to fix it. It renders the mirror useless at some speeds.