2023 TESLA MODEL 3

STEERING:ELECTRIC POWER ASSIST SYSTEM

Tesla, Inc. (Tesla) is recalling certain 2023 Model 3 and Model Y vehicles operating software prior to 2023.38.4. The printed circuit board for the electronic power steering assist may experience an overstress condition, causing a loss of power steering assist when the vehicle reaches a stop and then accelerates again.

Risk: A loss of power steering assist can require greater steering effort, especially at low speeds, increasing the risk of a crash.

ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL

Tesla, Inc. (Tesla) is recalling certain 2012-2023 Model S, 2016-2024 Model X, 2017-2023 Model 3, 2019-2024 Model Y, and 2024 Cybertruck vehicles. An incorrect font size is displayed on the instrument panel for the Brake, Park, and Antilock Brake System (ABS) warning lights. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 105, "Hydraulic and Electric Brake Systems" and 135, "Light Vehicle Brake Systems."

Risk: Warning lights with a smaller font size can make critical safety information on the instrument panel difficult to read, increasing the risk of a crash.

LATCHES/LOCKS/LINKAGES:HOOD:LATCH

Tesla, Inc. (Tesla) is recalling certain 2021-2024 Model 3, Model S, Model X, and 2020-2024 Model Y vehicles. The hood latch assembly may fail to detect an unlatched hood condition after the hood has been opened.

Risk: An unlatched hood can fully open, obstructing the driver's view and increasing the risk of a crash.

SEAT BELTS:FRONT:WARNING LIGHT/DEVICES

Tesla, Inc. (Tesla) is recalling certain 2012-2024 Model S, 2015-2024 Model X, 2017-2023 Model 3, and 2020-2023 Model Y vehicles. In the event of an unbelted driver, the seat belt warning light and audible chime may not activate as intended. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."

Risk: A seat belt warning system that fails to alert occupants of an unbelted seat belt can increase the risk of injury during a crash.

TIRES:PRESSURE MONITORING AND REGULATING SYSTEMS

Tesla, Inc. (Tesla) is recalling certain 2024 Cybertruck, 2017-2025 Model 3, and 2020-2025 Model Y vehicles. The tire pressure monitoring system (TPMS) warning light may not remain illuminated between drive cycles, failing to warn the driver of low tire pressure. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 138, "Tire Pressure Monitoring Systems."

Risk: Driving with improperly inflated tires increases the risk of a crash.

STEERING:AUTOMATED/ADAPTIVE STEERING

Tesla, Inc. (Tesla) is recalling certain 2016-2023 Model S, Model X, 2017-2023 Model 3, and 2020-2023 Model Y vehicles equipped with Full Self-Driving Beta (FSD Beta) software or pending installation.  The FSD Beta system may allow the vehicle to act unsafe around intersections, such as traveling straight through an intersection while in a turn-only lane, entering a stop sign-controlled intersection without coming to a complete stop, or proceeding into an intersection during a steady yellow traffic signal without due caution. In addition, the system may respond insufficiently to changes in posted speed limits or not adequately account for the driver's adjustment of the vehicle's speed to exceed posted speed limits.

Risk: FSD Beta software that allows a vehicle to exceed speed limits or travel through intersections in an unlawful or unpredictable manner increases the risk of a crash.

ELECTRICAL SYSTEM:PROPULSION SYSTEM:TRACTION BATTERY

Tesla, Inc. (Tesla) is recalling certain 2023 Model 3 and Model Y vehicles. The pyrotechnic battery disconnect may be defective.

Risk: A defective battery disconnect may not isolate the vehicle's high voltage battery after a crash or fault detection, increasing the risk of electrical shock and injury.

ELECTRICAL SYSTEM:ADAS:AUTONOMOUS/SELF DRIVING:SOFTWARE

Tesla, Inc. (Tesla) is recalling 2012-2023 Model S, 2016-2023 Model X, 2017-2023 Model 3, and 2020-2023 Model Y vehicles equipped with all versions of Autosteer leading up to the version(s) that contains the recall remedy. In certain circumstances when Autosteer is engaged, the prominence and scope of the feature's controls may not be sufficient to prevent driver misuse of the SAE Level 2 advanced driver-assistance feature.

Risk: In certain circumstances when Autosteer is engaged, and the driver does not maintain responsibility for vehicle operation and is unprepared to intervene as necessary or fails to recognize when Autosteer is canceled or not engaged, there may be an increased risk of a crash.

EXTERIOR LIGHTING:TAIL LIGHTS

Tesla, Inc. (Tesla) is recalling certain 2023 Model 3 and 2020-2023 Model Y vehicles. One or both taillights may intermittently fail to illuminate.

Risk: A taillight that fails to illuminate may reduce the visibility of the vehicle, increasing the risk of a crash.

BACK OVER PREVENTION:WARNINGS:EXTERNAL/PEDESTRIAN ALERT

The contact owns a 2023 Tesla Model 3. The contact stated that upon starting the vehicle and shifting to drive(D), the front trunk opened inadvertently, blocking the visibility of the roadway. The contact stated that the failure had recurred several times upon shifting to drive(D), which required the contact to exit the vehicle and manually close the trunk. The vehicle was taken to a Tesla service center and to Tesla Service Sunnyvale(680 E El Camino Real, Sunnyvale, CA 94087), where unknown repairs were performed several times; however, the failure persisted. Additionally, the contact stated that while attempting to reverse out of the garage, the contact was unaware that the garage door was closed, and the vehicle hit the garage door. The contact did not recall whether the rearview camera activated; however, the contact stated that the rearview camera pedestrian warning alert failed to engage prior to the incident. The contact stated that the garage door and the rear end of the vehicle were damaged. The manufacturer was contacted through the Tesla mobile app and advised the contact to take the vehicle to a Tesla service center for service. The vehicle was not diagnosed or repaired. The failure mileage was approximately 10.

LATCHES/LOCKS/LINKAGES:HOOD:LATCH

The contact owns a 2023 Tesla Model 3. The contact stated that upon starting the vehicle and shifting to drive(D), the front trunk opened inadvertently, blocking the visibility of the roadway. The contact stated that the failure had recurred several times upon shifting to drive(D), which required the contact to exit the vehicle and manually close the trunk. The vehicle was taken to a Tesla service center and to Tesla Service Sunnyvale(680 E El Camino Real, Sunnyvale, CA 94087), where unknown repairs were performed several times; however, the failure persisted. Additionally, the contact stated that while attempting to reverse out of the garage, the contact was unaware that the garage door was closed, and the vehicle hit the garage door. The contact did not recall whether the rearview camera activated; however, the contact stated that the rearview camera pedestrian warning alert failed to engage prior to the incident. The contact stated that the garage door and the rear end of the vehicle were damaged. The manufacturer was contacted through the Tesla mobile app and advised the contact to take the vehicle to a Tesla service center for service. The vehicle was not diagnosed or repaired. The failure mileage was approximately 10.

ELECTRICAL SYSTEM

The contact owns a 2023 Tesla Model 3. The contact stated that upon starting the vehicle and shifting to drive(D), the front trunk opened inadvertently, blocking the visibility of the roadway. The contact stated that the failure had recurred several times upon shifting to drive(D), which required the contact to exit the vehicle and manually close the trunk. The vehicle was taken to a Tesla service center and to Tesla Service Sunnyvale(680 E El Camino Real, Sunnyvale, CA 94087), where unknown repairs were performed several times; however, the failure persisted. Additionally, the contact stated that while attempting to reverse out of the garage, the contact was unaware that the garage door was closed, and the vehicle hit the garage door. The contact did not recall whether the rearview camera activated; however, the contact stated that the rearview camera pedestrian warning alert failed to engage prior to the incident. The contact stated that the garage door and the rear end of the vehicle were damaged. The manufacturer was contacted through the Tesla mobile app and advised the contact to take the vehicle to a Tesla service center for service. The vehicle was not diagnosed or repaired. The failure mileage was approximately 10.

SERVICE BRAKES, HYDRAULIC; AUTOHOLD BRAKE SYSTEM/BRAKE HOLD:SOFTWARE

The contact owns a 2023 Tesla Model 3. The contact stated that while driving 70 MPH, the vehicle jerked hard with several alerts for the "Traction Control, ABS, Lane Departure feature displayed. Additionally, the Stability Control System was disabled, and the message “Brake Hold Unavailable” was displayed. The contact stated that the “Automatic Emergency Braking Unavailable" and an orange triangle with an exclamation light were illuminated. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was 48,380.

ELECTRONIC STABILITY CONTROL (ESC)

The contact owns a 2023 Tesla Model 3. The contact stated that while driving 70 MPH, the vehicle jerked hard with several alerts for the "Traction Control, ABS, Lane Departure feature displayed. Additionally, the Stability Control System was disabled, and the message “Brake Hold Unavailable” was displayed. The contact stated that the “Automatic Emergency Braking Unavailable" and an orange triangle with an exclamation light were illuminated. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was 48,380.

SERVICE BRAKES, HYDRAULIC

The contact owns a 2023 Tesla Model 3. The contact stated that while driving 70 MPH, the vehicle jerked hard with several alerts for the "Traction Control, ABS, Lane Departure feature displayed. Additionally, the Stability Control System was disabled, and the message “Brake Hold Unavailable” was displayed. The contact stated that the “Automatic Emergency Braking Unavailable" and an orange triangle with an exclamation light were illuminated. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was 48,380.

STRUCTURE:BODY

While exiting the front passenger cut her leg on the door. It appears she contacted the inside bottom, rear edge of the door when closing. This cut her leg requiring immediate medical attention. It took several stitches to close the wound.

SERVICE BRAKES

Three times while driving at low speed and attempting to reduce speed—even while pressing the brake pedal—my 2023 Tesla Model 3 unexpectedly accelerated. During the first incident, the Dynamics screen did not allow me to change the Deceleration Mode. After rebooting the touchscreen, the options reappeared briefly, but later that same day they became unavailable again. Incident Times: 2nd incident: September 3, 2025, at approximately 4:15 PM EST 3rd incident: September 4, 2025, at approximately 4:50 PM EST

ELECTRICAL SYSTEM

The contact's daughter owned a 2023 Tesla Model 3. The contact stated that while driving during rain at 60 MPH, the contact lost control of the vehicle as the vehicle spun in a circle at hit a highway wall barrier. The barrier wall was damaged as a result of the accident, and the contact was given a bill for $3,222.15. The air bags deployed upon impact. The contact did not seek medical attention but suffered from both back and head pains. A police report was filed. Due to the accident, the vehicle was towed to an independent mechanic, where the vehicle remained in their possession. The contact wrote a letter to the manufacturer about the failure, but had yet to receive a response. The vehicle was deemed a total loss as a result of the accident. The failure mileage was approximately 50,000.

VEHICLE SPEED CONTROL

Vehicle Information: 2023 Tesla Model 3 VIN: [XXX] Incident Date: [XXX] Location: [XXX] Summary of the Problem: On [XXX], while Autopilot was active, my 2023 Tesla Model 3 suddenly accelerated without driver input. I was pressing the brake pedal, but the vehicle surged forward uncontrollably, struck a fence and a tree, and caused major property damage. Both I and my wife (passenger) required urgent care treatment after the crash. Details / Safety Defect Evidence: •Tesla’s own raw logs show the accelerator spiked to 100% immediately before impact. •Brake pressure was recorded prior to impact, proving the brake pedal was applied. •Despite this, Tesla’s official Vehicle Data Report falsely states “manual brake not applied.” •Autopilot did not disengage when the brake was pressed, contrary to Tesla’s design claims. •The vehicle logged a “Near-Deploy Collision” at ~27 mph, yet the airbags did not deploy. Why This Is a Safety Defect: This incident reflects multiple critical failures: 1.Sudden unintended acceleration. 2.Failure of brake-override safety design. 3.Airbag non-deployment in a crash severe enough to trigger “Near-Deploy.” 4.Inaccurate Tesla reporting that conceals braking input. This defect created an extremely dangerous situation that could easily have resulted in fatalities. I am requesting NHTSA investigate Tesla vehicles for unintended acceleration, brake override failure, and airbag non-deployment. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

AIR BAGS

Vehicle Information: 2023 Tesla Model 3 VIN: [XXX] Incident Date: [XXX] Location: [XXX] Summary of the Problem: On [XXX], while Autopilot was active, my 2023 Tesla Model 3 suddenly accelerated without driver input. I was pressing the brake pedal, but the vehicle surged forward uncontrollably, struck a fence and a tree, and caused major property damage. Both I and my wife (passenger) required urgent care treatment after the crash. Details / Safety Defect Evidence: •Tesla’s own raw logs show the accelerator spiked to 100% immediately before impact. •Brake pressure was recorded prior to impact, proving the brake pedal was applied. •Despite this, Tesla’s official Vehicle Data Report falsely states “manual brake not applied.” •Autopilot did not disengage when the brake was pressed, contrary to Tesla’s design claims. •The vehicle logged a “Near-Deploy Collision” at ~27 mph, yet the airbags did not deploy. Why This Is a Safety Defect: This incident reflects multiple critical failures: 1.Sudden unintended acceleration. 2.Failure of brake-override safety design. 3.Airbag non-deployment in a crash severe enough to trigger “Near-Deploy.” 4.Inaccurate Tesla reporting that conceals braking input. This defect created an extremely dangerous situation that could easily have resulted in fatalities. I am requesting NHTSA investigate Tesla vehicles for unintended acceleration, brake override failure, and airbag non-deployment. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

SEATS

Rear seat safety restraint system fault

ELECTRICAL SYSTEM

Rear seat safety restraint system fault

SERVICE BRAKES

While driving to work on a local road, I approached a red light where there were no vehicles immediately ahead. However, my vehicle unexpectedly steered off the road in front of a construction sign, entering a ditch. Despite my attempts to regain control of the steering and braking systems, I was unsuccessful. The vehicle subsequently stopped automatically on an incline. Fortunately, I avoided a collision with a gas station and intersecting roadway, but sustained damage to my car’s front bumper. Law enforcement and a towing service were contacted to remove the vehicle. I tried calling the dealership almost half day without an answer, then I went to the dealership where they told me that the hardware is fine but they can’t do anything about the possible software issues which leaves me in a situation where I’m nervous to drive the car. I reached out to the company about the accident and didn’t hear back yet from them. I request a thorough investigation into this incident to determine the cause of the unexpected, highly dangerous, autopilot behavior. I am disturbed mentally and emotionally due to the accident. I also require confirmation of the vehicle's roadworthiness and assurance that it is safe to operate before resuming driving.

STEERING

While driving to work on a local road, I approached a red light where there were no vehicles immediately ahead. However, my vehicle unexpectedly steered off the road in front of a construction sign, entering a ditch. Despite my attempts to regain control of the steering and braking systems, I was unsuccessful. The vehicle subsequently stopped automatically on an incline. Fortunately, I avoided a collision with a gas station and intersecting roadway, but sustained damage to my car’s front bumper. Law enforcement and a towing service were contacted to remove the vehicle. I tried calling the dealership almost half day without an answer, then I went to the dealership where they told me that the hardware is fine but they can’t do anything about the possible software issues which leaves me in a situation where I’m nervous to drive the car. I reached out to the company about the accident and didn’t hear back yet from them. I request a thorough investigation into this incident to determine the cause of the unexpected, highly dangerous, autopilot behavior. I am disturbed mentally and emotionally due to the accident. I also require confirmation of the vehicle's roadworthiness and assurance that it is safe to operate before resuming driving.

VEHICLE SPEED CONTROL

While driving to work on a local road, I approached a red light where there were no vehicles immediately ahead. However, my vehicle unexpectedly steered off the road in front of a construction sign, entering a ditch. Despite my attempts to regain control of the steering and braking systems, I was unsuccessful. The vehicle subsequently stopped automatically on an incline. Fortunately, I avoided a collision with a gas station and intersecting roadway, but sustained damage to my car’s front bumper. Law enforcement and a towing service were contacted to remove the vehicle. I tried calling the dealership almost half day without an answer, then I went to the dealership where they told me that the hardware is fine but they can’t do anything about the possible software issues which leaves me in a situation where I’m nervous to drive the car. I reached out to the company about the accident and didn’t hear back yet from them. I request a thorough investigation into this incident to determine the cause of the unexpected, highly dangerous, autopilot behavior. I am disturbed mentally and emotionally due to the accident. I also require confirmation of the vehicle's roadworthiness and assurance that it is safe to operate before resuming driving.

FORWARD COLLISION AVOIDANCE: WARNINGS

Autopilot (adaptive cruise control) will freak out and slam on the brakes when a motorcycle passes by splitting lanes. This is a serious safety issue as cars and motorcycles behind me may not be able to react in time and cause a rear end collision or into the wall or vehicles next to them. It is impossible to override the braking with the accelerator as it will be too late by the time the car accelerates. Flooring the accelerator is also not a safe option.

FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING

Autopilot (adaptive cruise control) will freak out and slam on the brakes when a motorcycle passes by splitting lanes. This is a serious safety issue as cars and motorcycles behind me may not be able to react in time and cause a rear end collision or into the wall or vehicles next to them. It is impossible to override the braking with the accelerator as it will be too late by the time the car accelerates. Flooring the accelerator is also not a safe option.

FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL

Autopilot (adaptive cruise control) will freak out and slam on the brakes when a motorcycle passes by splitting lanes. This is a serious safety issue as cars and motorcycles behind me may not be able to react in time and cause a rear end collision or into the wall or vehicles next to them. It is impossible to override the braking with the accelerator as it will be too late by the time the car accelerates. Flooring the accelerator is also not a safe option.

FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING

My Tesla Model 3 disengaged cruise control while going 68 mph and braked hard for no apparent reason. I was driving northbound on I-405 at 3:45 a.m. going to LAX airport in the number 3 or 4 of six or seven lanes. Cruise control had been activated for at least 10 minutes before the incident at a speed of 68 mph. There was no traffic within half a mile before or after me due to the time of day. Neither my left or right foot were near either the brake or acceleration pedal, nor were they in motion. Both hands were on the steering wheel and no control was being activated. The only noticeable environmental condition is that the road surface had just changed from a dark gray asphalt to a bright white new concrete roadway. No emergency braking alert was seen or heard, so I do not think it was a false collision detection, and there was no car within a half mile. However, I do believe the severity of braking could have caused an accident if there had been someone behind me. Tesla Model 3 Software Version was v12 (2025.20.6 046c4575d120).

FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL

My Tesla Model 3 disengaged cruise control while going 68 mph and braked hard for no apparent reason. I was driving northbound on I-405 at 3:45 a.m. going to LAX airport in the number 3 or 4 of six or seven lanes. Cruise control had been activated for at least 10 minutes before the incident at a speed of 68 mph. There was no traffic within half a mile before or after me due to the time of day. Neither my left or right foot were near either the brake or acceleration pedal, nor were they in motion. Both hands were on the steering wheel and no control was being activated. The only noticeable environmental condition is that the road surface had just changed from a dark gray asphalt to a bright white new concrete roadway. No emergency braking alert was seen or heard, so I do not think it was a false collision detection, and there was no car within a half mile. However, I do believe the severity of braking could have caused an accident if there had been someone behind me. Tesla Model 3 Software Version was v12 (2025.20.6 046c4575d120).

VEHICLE SPEED CONTROL

My Tesla Model 3 disengaged cruise control while going 68 mph and braked hard for no apparent reason. I was driving northbound on I-405 at 3:45 a.m. going to LAX airport in the number 3 or 4 of six or seven lanes. Cruise control had been activated for at least 10 minutes before the incident at a speed of 68 mph. There was no traffic within half a mile before or after me due to the time of day. Neither my left or right foot were near either the brake or acceleration pedal, nor were they in motion. Both hands were on the steering wheel and no control was being activated. The only noticeable environmental condition is that the road surface had just changed from a dark gray asphalt to a bright white new concrete roadway. No emergency braking alert was seen or heard, so I do not think it was a false collision detection, and there was no car within a half mile. However, I do believe the severity of braking could have caused an accident if there had been someone behind me. Tesla Model 3 Software Version was v12 (2025.20.6 046c4575d120).

FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING

The contact rented a 2023 Tesla Model 3. The contact stated that while driving at 55 MPH in the rain, a vehicle in front of him abruptly slowed down. The contact depressed the brake pedal, but the vehicle jerked to the side. The contact stated that the emergency braking system unexpectedly activated ("slams on") while he was driving due to the Automatic Emergency Braking (AEB) system falsely detecting a potential collision. There were large rocks in the roadway, and there was no traction, causing him to crash into an embankment. The driver's side airbag did not deploy. The other airbags in the vehicle had deployed. The contact sustained a fractured rib, and medical attention was provided at the hospital. The vehicle was towed to a towing company. There were no reported fires. A police report was filed. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The vehicle was taken to an independent mechanic, where an unknown diagnosis was completed. The vehicle was not repaired. The manufacturer was contacted, but no assistance was provided. The failure mileage was unknown.

SERVICE BRAKES

The contact rented a 2023 Tesla Model 3. The contact stated that while driving at 55 MPH in the rain, a vehicle in front of him abruptly slowed down. The contact depressed the brake pedal, but the vehicle jerked to the side. The contact stated that the emergency braking system unexpectedly activated ("slams on") while he was driving due to the Automatic Emergency Braking (AEB) system falsely detecting a potential collision. There were large rocks in the roadway, and there was no traction, causing him to crash into an embankment. The driver's side airbag did not deploy. The other airbags in the vehicle had deployed. The contact sustained a fractured rib, and medical attention was provided at the hospital. The vehicle was towed to a towing company. There were no reported fires. A police report was filed. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The vehicle was taken to an independent mechanic, where an unknown diagnosis was completed. The vehicle was not repaired. The manufacturer was contacted, but no assistance was provided. The failure mileage was unknown.

AIR BAGS

The contact rented a 2023 Tesla Model 3. The contact stated that while driving at 55 MPH in the rain, a vehicle in front of him abruptly slowed down. The contact depressed the brake pedal, but the vehicle jerked to the side. The contact stated that the emergency braking system unexpectedly activated ("slams on") while he was driving due to the Automatic Emergency Braking (AEB) system falsely detecting a potential collision. There were large rocks in the roadway, and there was no traction, causing him to crash into an embankment. The driver's side airbag did not deploy. The other airbags in the vehicle had deployed. The contact sustained a fractured rib, and medical attention was provided at the hospital. The vehicle was towed to a towing company. There were no reported fires. A police report was filed. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The vehicle was taken to an independent mechanic, where an unknown diagnosis was completed. The vehicle was not repaired. The manufacturer was contacted, but no assistance was provided. The failure mileage was unknown.

LATCHES/LOCKS/LINKAGES:TRUNK LID:LATCH

The contact owns a 2023 Tesla Model 3. The contact stated that while the vehicle was parked, the contact attempted to open the trunk and the trunk inadvertently closed on the contact's finger. The contact was taken to a medical specialist and sustained an injury to a finger that required stitching, causing medical leave. The dealer was contacted. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 19,500.

FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING

Description of Problem: While driving under normal highway conditions on July 2, 2025, my Tesla suddenly and violently phantom braked — meaning it rapidly and without cause applied the brakes forcefully. There were no obstacles, vehicles, or hazards present. The sudden deceleration caused a severe flare-up of a recent cervical disc replacement surgery I had undergone. I experienced extreme neck and spinal pain and had to seek emergency medical attention. I am now under medical supervision, on pain medication, and unable to work. I contacted Tesla requesting the logs from the incident and have received no response. I’m deeply concerned about the safety of this vehicle and the lack of accountability for this known and previously investigated issue. I am in the process of retaining legal counsel and intend to pursue this further as a product liability and injury case.

FORWARD COLLISION AVOIDANCE: WARNINGS

Description of Problem: While driving under normal highway conditions on July 2, 2025, my Tesla suddenly and violently phantom braked — meaning it rapidly and without cause applied the brakes forcefully. There were no obstacles, vehicles, or hazards present. The sudden deceleration caused a severe flare-up of a recent cervical disc replacement surgery I had undergone. I experienced extreme neck and spinal pain and had to seek emergency medical attention. I am now under medical supervision, on pain medication, and unable to work. I contacted Tesla requesting the logs from the incident and have received no response. I’m deeply concerned about the safety of this vehicle and the lack of accountability for this known and previously investigated issue. I am in the process of retaining legal counsel and intend to pursue this further as a product liability and injury case.

FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL

Description of Problem: While driving under normal highway conditions on July 2, 2025, my Tesla suddenly and violently phantom braked — meaning it rapidly and without cause applied the brakes forcefully. There were no obstacles, vehicles, or hazards present. The sudden deceleration caused a severe flare-up of a recent cervical disc replacement surgery I had undergone. I experienced extreme neck and spinal pain and had to seek emergency medical attention. I am now under medical supervision, on pain medication, and unable to work. I contacted Tesla requesting the logs from the incident and have received no response. I’m deeply concerned about the safety of this vehicle and the lack of accountability for this known and previously investigated issue. I am in the process of retaining legal counsel and intend to pursue this further as a product liability and injury case.

FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING

While driving with the Adaptive Cruise Control enabled, on California highway 5 on Aug 28, 2023, the vehicle applied the brakes very aggressively and suddenly, shy of making a complete stop, without any object or shadow requiring it to do so - known as the "Phantom Breaking". It was so dangerous that if it was a weekend with many cars behind me, I would've been violently rear-ended and perhaps not lived to report this incident. This happened twice in two hours, to the point that I have never engaged the cruise system again. The Adaptive Cruise Control (ACC) system (which is part of the Auto Pilot system) on this vehicle is dangerous and should be avoided. I wish the vehicle had the [old fashioned] non-adaptive cruise control but it doesn't. Answering the questions: Nothing failed but the ACC clearly malfunctioned since there was no object, shadow, road animal, change in asphalt color, etc. to cause it to abruptly break. It was a clear sunny day. Any accident at such highway speed could've been deadly to multiple drivers on the road. When I informed the dealer, they "verbally" acknowledged and informed me of the term "Phantom Breaking" that they had heard of the problem being reported by others but nothing to worry about and they didn't inspect the vehicle. There we no warning lamps, messages or symptoms prior to the problem. Again, this issue happened twice within a two hour period and I have not used the ACC system again. My spouse was with me in the car in both cases and witnessed the scary situation.

FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL

While driving with the Adaptive Cruise Control enabled, on California highway 5 on Aug 28, 2023, the vehicle applied the brakes very aggressively and suddenly, shy of making a complete stop, without any object or shadow requiring it to do so - known as the "Phantom Breaking". It was so dangerous that if it was a weekend with many cars behind me, I would've been violently rear-ended and perhaps not lived to report this incident. This happened twice in two hours, to the point that I have never engaged the cruise system again. The Adaptive Cruise Control (ACC) system (which is part of the Auto Pilot system) on this vehicle is dangerous and should be avoided. I wish the vehicle had the [old fashioned] non-adaptive cruise control but it doesn't. Answering the questions: Nothing failed but the ACC clearly malfunctioned since there was no object, shadow, road animal, change in asphalt color, etc. to cause it to abruptly break. It was a clear sunny day. Any accident at such highway speed could've been deadly to multiple drivers on the road. When I informed the dealer, they "verbally" acknowledged and informed me of the term "Phantom Breaking" that they had heard of the problem being reported by others but nothing to worry about and they didn't inspect the vehicle. There we no warning lamps, messages or symptoms prior to the problem. Again, this issue happened twice within a two hour period and I have not used the ACC system again. My spouse was with me in the car in both cases and witnessed the scary situation.

SUSPENSION

Car is disengaging Full Self Driving because of steering becoming difficult at slow speeds in a turn. FSD disengages and the car drive straight instead of staying in the turn, crash could be likely.

STEERING

Car is disengaging Full Self Driving because of steering becoming difficult at slow speeds in a turn. FSD disengages and the car drive straight instead of staying in the turn, crash could be likely.

UNKNOWN OR OTHER

On June 4th I was in a hurry to get to work, pushed open my car door and started to slide in at which point the door unexpectedly to me swung back shut, clamping my head behind my ear pressing it against the top of the door frame. Everything stuck for about 1 second and then the door released my head. I am concerned that the door shouldn’t close so forcefully and should not bounce back closed when pushed open; that perhaps this contributed to the dangerous situation? There were other factors such as my car parking pad is slightly sloped. It seems this is an issue with the design of the car as opposed to a defect as there are no warning lights or recalls. I am still trying to figure out the effects of this injury. I have been to two doctors- not immediately because at first there were no immediate effects except for the discomfort of the pressure at the time. But less than 24 hours following the incident I developed a puffed up patch behind the ear where the door clamped, and now have developed a very swollen painless lymph node behind my other ear as well as headaches and some soreness that comes and goes. I have not contacted Tesla about the problem yet but am extremely cautious when I use the door and I don’t drive people in the car. I have included some photos but also just took some videos illustrating how the door swings back shut pretty forcefully when pushed open.

STRUCTURE:BODY

On June 4th I was in a hurry to get to work, pushed open my car door and started to slide in at which point the door unexpectedly to me swung back shut, clamping my head behind my ear pressing it against the top of the door frame. Everything stuck for about 1 second and then the door released my head. I am concerned that the door shouldn’t close so forcefully and should not bounce back closed when pushed open; that perhaps this contributed to the dangerous situation? There were other factors such as my car parking pad is slightly sloped. It seems this is an issue with the design of the car as opposed to a defect as there are no warning lights or recalls. I am still trying to figure out the effects of this injury. I have been to two doctors- not immediately because at first there were no immediate effects except for the discomfort of the pressure at the time. But less than 24 hours following the incident I developed a puffed up patch behind the ear where the door clamped, and now have developed a very swollen painless lymph node behind my other ear as well as headaches and some soreness that comes and goes. I have not contacted Tesla about the problem yet but am extremely cautious when I use the door and I don’t drive people in the car. I have included some photos but also just took some videos illustrating how the door swings back shut pretty forcefully when pushed open.

FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING

I was traveling at highway speeds on a highway with no vehicles or other obstacles in front of me. I had adaptive cruise control on. Then, the emergency brakes deployed for no reason (so called “phantom braking”), decelerating the car quickly. I turned off adaptive cruise control as fast as I could and nothing bad happened. But the situation was dangerous, as if a car was close behind me it could have rear ended my vehicle.

FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL

I was traveling at highway speeds on a highway with no vehicles or other obstacles in front of me. I had adaptive cruise control on. Then, the emergency brakes deployed for no reason (so called “phantom braking”), decelerating the car quickly. I turned off adaptive cruise control as fast as I could and nothing bad happened. But the situation was dangerous, as if a car was close behind me it could have rear ended my vehicle.

VEHICLE SPEED CONTROL

I was traveling at highway speeds on a highway with no vehicles or other obstacles in front of me. I had adaptive cruise control on. Then, the emergency brakes deployed for no reason (so called “phantom braking”), decelerating the car quickly. I turned off adaptive cruise control as fast as I could and nothing bad happened. But the situation was dangerous, as if a car was close behind me it could have rear ended my vehicle.

LANE DEPARTURE: ASSIST

Curvature Assist feature agressively brakes while driving at highway speeds. This is supposed to slow down for curves, but frequently intervenes for straight, clearly marked lanes. Feature cannot be turned off. Drivers behind me have gotten agitated several times for the sudden, harsh braking, and I do not feel comfortable driving this car.

FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING

Curvature Assist feature agressively brakes while driving at highway speeds. This is supposed to slow down for curves, but frequently intervenes for straight, clearly marked lanes. Feature cannot be turned off. Drivers behind me have gotten agitated several times for the sudden, harsh braking, and I do not feel comfortable driving this car.

FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL

Curvature Assist feature agressively brakes while driving at highway speeds. This is supposed to slow down for curves, but frequently intervenes for straight, clearly marked lanes. Feature cannot be turned off. Drivers behind me have gotten agitated several times for the sudden, harsh braking, and I do not feel comfortable driving this car.

SUSPENSION

Incident Summary: On [XXX], I was in an accident and dropped my Tesla Model 3 at Tesla’s North Phoenix Collision Center in Nov 2024. I received the car back in Dec/Jan. Immediately, I noticed dangerous swaying, bouncing, and veering when hitting dips—especially on the freeway. The car was unstable and unsafe to drive at high speeds. In Feb/Mar, Tanner (assistant manager at the collision center) drove the vehicle with me in the passenger seat. After hitting a dip on the freeway, he panicked, exited, and agreed something was wrong. I was later told they did a wheel alignment, but the issue remained. This was the second time they returned the vehicle in an unsafe condition. I nearly crashed due to how unstable it felt. In May 2025, I brought the car back again. Tanner suspected the steering column but said no diagnosis was done. He gave me a loaner vehicle, which had a flat tire. I had to drive my own unsafe car for nearly a month while waiting for another loaner and parts—no resolution during that time. On 6/13/2025, I contacted the Tesla Glendale Service Center. The advisor expressed frustration, saying this collision center often offloads unresolved issues. I also contacted Tesla Support (877-798-3752), who advised me to file this NHTSA complaint. As of June 2025, the issue is still unresolved. My car continues to sway and veer dangerously on the freeway, and Tesla North Phoenix Collision has failed to properly diagnose or fix it despite multiple returns. This vehicle is unsafe to drive, and I’ve been given excuses for over 7 months. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

WHEELS

Incident Summary: On [XXX], I was in an accident and dropped my Tesla Model 3 at Tesla’s North Phoenix Collision Center in Nov 2024. I received the car back in Dec/Jan. Immediately, I noticed dangerous swaying, bouncing, and veering when hitting dips—especially on the freeway. The car was unstable and unsafe to drive at high speeds. In Feb/Mar, Tanner (assistant manager at the collision center) drove the vehicle with me in the passenger seat. After hitting a dip on the freeway, he panicked, exited, and agreed something was wrong. I was later told they did a wheel alignment, but the issue remained. This was the second time they returned the vehicle in an unsafe condition. I nearly crashed due to how unstable it felt. In May 2025, I brought the car back again. Tanner suspected the steering column but said no diagnosis was done. He gave me a loaner vehicle, which had a flat tire. I had to drive my own unsafe car for nearly a month while waiting for another loaner and parts—no resolution during that time. On 6/13/2025, I contacted the Tesla Glendale Service Center. The advisor expressed frustration, saying this collision center often offloads unresolved issues. I also contacted Tesla Support (877-798-3752), who advised me to file this NHTSA complaint. As of June 2025, the issue is still unresolved. My car continues to sway and veer dangerously on the freeway, and Tesla North Phoenix Collision has failed to properly diagnose or fix it despite multiple returns. This vehicle is unsafe to drive, and I’ve been given excuses for over 7 months. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

STEERING

Incident Summary: On [XXX], I was in an accident and dropped my Tesla Model 3 at Tesla’s North Phoenix Collision Center in Nov 2024. I received the car back in Dec/Jan. Immediately, I noticed dangerous swaying, bouncing, and veering when hitting dips—especially on the freeway. The car was unstable and unsafe to drive at high speeds. In Feb/Mar, Tanner (assistant manager at the collision center) drove the vehicle with me in the passenger seat. After hitting a dip on the freeway, he panicked, exited, and agreed something was wrong. I was later told they did a wheel alignment, but the issue remained. This was the second time they returned the vehicle in an unsafe condition. I nearly crashed due to how unstable it felt. In May 2025, I brought the car back again. Tanner suspected the steering column but said no diagnosis was done. He gave me a loaner vehicle, which had a flat tire. I had to drive my own unsafe car for nearly a month while waiting for another loaner and parts—no resolution during that time. On 6/13/2025, I contacted the Tesla Glendale Service Center. The advisor expressed frustration, saying this collision center often offloads unresolved issues. I also contacted Tesla Support (877-798-3752), who advised me to file this NHTSA complaint. As of June 2025, the issue is still unresolved. My car continues to sway and veer dangerously on the freeway, and Tesla North Phoenix Collision has failed to properly diagnose or fix it despite multiple returns. This vehicle is unsafe to drive, and I’ve been given excuses for over 7 months. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

ELECTRICAL SYSTEM

Documenting a sudden unintended acceleration experience. Today while driving and trying to stop for a red light, I lightly applied pressure on my brake pedal to brake for the red light. Midway through the braking, my car lunged forward for about half a second. Went through the dash cam footage, and I noticed that the footage skipped half a second as well. Seems like something electrical that caused the car to lunge. This is a huge safety issue.

ENGINE

Documenting a sudden unintended acceleration experience. Today while driving and trying to stop for a red light, I lightly applied pressure on my brake pedal to brake for the red light. Midway through the braking, my car lunged forward for about half a second. Went through the dash cam footage, and I noticed that the footage skipped half a second as well. Seems like something electrical that caused the car to lunge. This is a huge safety issue.

SEAT BELTS

Front driver seatbelt will not latch or lock. Car less than 3 years old.

UNKNOWN OR OTHER

My pant leg got caught on the plastic seat trim under the seat. Kept my leg trapped so I fell out of the car on the ground in the parking lot. Happened again the same day, but I caught myself before I fell. The incident caused a hole and rip in my clothing, but the rest of my body went to the ground leaving my knee and other leg caught until the end. Had a different outfit on today and it caught again! I did not fall this time either. The time I did fall I hyperextended my wrist and landed on my hip and leg, creating bruising and a sore pelvis, knee and back. Went to massage therapist soon after. Currently, following up with doctor

SEATS

My pant leg got caught on the plastic seat trim under the seat. Kept my leg trapped so I fell out of the car on the ground in the parking lot. Happened again the same day, but I caught myself before I fell. The incident caused a hole and rip in my clothing, but the rest of my body went to the ground leaving my knee and other leg caught until the end. Had a different outfit on today and it caught again! I did not fall this time either. The time I did fall I hyperextended my wrist and landed on my hip and leg, creating bruising and a sore pelvis, knee and back. Went to massage therapist soon after. Currently, following up with doctor

SUSPENSION

Front upper control arms replaced. Vehicle Only has 24,000 miles.

STEERING

The volume control buttons and vehicle setting buttons on my car’s steering wheel are made of metal. In high atmospheric temperatures the interior of the car heats up. The buttons also heat up and can cause burns if touching the button for an extended (more than 30 seconds) amount of time. This is very distracting while driving while also causing a mild burn.

UNKNOWN OR OTHER

RCM2_a636 Front passenger safety restraint system fault (service is required) This causes an issue where the airbags won’t deploy due to it not thinking there is someone sitting there or not

STRUCTURE:BODY:HATCHBACK/LIFTGATE:SUPPORT DEVICE/STRUT

Trunk struts snap/come off. Causing trunk to slam shut. Damaging body. Tesla states vehicle is safe to operate, however vehicle trunk does not latch down anymore and opens every time I hit a bump. The trunk allignment is also well off. The vibration of the trunk causes several electrical issues including Automatic Emergency Braking. Original problem occured september 15th 2023. Issue was fixed and persists. Current issue has been going on since february 18th 2025. Issue is not yet resolved or fixed. Tesla is not taking any action to repair issue at all. Vehicle is unsafe to operate.

STRUCTURE:BODY:TRUNK LID

Trunk struts snap/come off. Causing trunk to slam shut. Damaging body. Tesla states vehicle is safe to operate, however vehicle trunk does not latch down anymore and opens every time I hit a bump. The trunk allignment is also well off. The vibration of the trunk causes several electrical issues including Automatic Emergency Braking. Original problem occured september 15th 2023. Issue was fixed and persists. Current issue has been going on since february 18th 2025. Issue is not yet resolved or fixed. Tesla is not taking any action to repair issue at all. Vehicle is unsafe to operate.

STEERING

What component or system failed or malfunctioned, and is it available for inspection upon request? Steering Wheel. How was your safety or the safety of others put at risk? Single vehicle accident. Driver suffered injury. No other person or vehicle was involved. Has the problem been reproduced or confirmed by a dealer or independent service center? Don't Know. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? In progress. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? No indications were visible.

SERVICE BRAKES

My dad was driving to work in the morning in the Tesla in the left lane of the freeway. Then the car started swerving on its own. He tried to regain control with the steering wheel but he couldn’t control it. The car wouldn’t turn when using the steering wheel and he was not using autopilot or lane assistance. He said it felt like the steering wheel and the car were not talking to each other. And the brakes weren’t stopping the car at all and because he couldn’t control the car it turned left into the divider and hit the divider and the car turn again to the right and automatically stopped in the middle of the second lane. The airbags deployed for the driver side. Thankfully there weren’t any other cars on the road at the time so there aren’t any injuries. But this crash could’ve caused serious injuries to him or other people. There were no warning signs, alerts, or noises before this happened. He has filed a claim with the insurance company. And a crash report was filed by the police.

STEERING

My dad was driving to work in the morning in the Tesla in the left lane of the freeway. Then the car started swerving on its own. He tried to regain control with the steering wheel but he couldn’t control it. The car wouldn’t turn when using the steering wheel and he was not using autopilot or lane assistance. He said it felt like the steering wheel and the car were not talking to each other. And the brakes weren’t stopping the car at all and because he couldn’t control the car it turned left into the divider and hit the divider and the car turn again to the right and automatically stopped in the middle of the second lane. The airbags deployed for the driver side. Thankfully there weren’t any other cars on the road at the time so there aren’t any injuries. But this crash could’ve caused serious injuries to him or other people. There were no warning signs, alerts, or noises before this happened. He has filed a claim with the insurance company. And a crash report was filed by the police.

SEAT BELTS

Seatbelt of drivers side won’t latch into compartment, putting myself and others at risk

AIR BAGS

I was involved in an accident due to what I believe was a malfunction in my Tesla’s steering system. While driving, the car unexpectedly turned the wheel to the left on its own and collided with a parked car. Despite my efforts to regain control by turning the wheel to the right and applying the brakes, the vehicle did not respond, and I was unable to prevent the crash. Given the lack of control and failure of the braking system, I strongly believe there was a serious issue with the car that led to the accident.

SERVICE BRAKES

I was involved in an accident due to what I believe was a malfunction in my Tesla’s steering system. While driving, the car unexpectedly turned the wheel to the left on its own and collided with a parked car. Despite my efforts to regain control by turning the wheel to the right and applying the brakes, the vehicle did not respond, and I was unable to prevent the crash. Given the lack of control and failure of the braking system, I strongly believe there was a serious issue with the car that led to the accident.

STEERING

I was involved in an accident due to what I believe was a malfunction in my Tesla’s steering system. While driving, the car unexpectedly turned the wheel to the left on its own and collided with a parked car. Despite my efforts to regain control by turning the wheel to the right and applying the brakes, the vehicle did not respond, and I was unable to prevent the crash. Given the lack of control and failure of the braking system, I strongly believe there was a serious issue with the car that led to the accident.

AIR BAGS

FRONT LEFTSAFTEY RESTRAINT SYSTEM FAULT/SERVICE IS REQUIRED TESLA WANT TO CHARGE $351 TO START FOR THE SERVICE

SEAT BELTS

FRONT LEFTSAFTEY RESTRAINT SYSTEM FAULT/SERVICE IS REQUIRED TESLA WANT TO CHARGE $351 TO START FOR THE SERVICE

AIR BAGS

UNKNOWN Moving collision resulted in insurance company describing damage as a total loss. It was inspected by an auto collision expert; his description, photos and estimate were forwarded to a claims specialist at the insurance company. The side of my head hit the window on the driver's side, but no airbags inflated. I feel this was a risk to my overall safety. There were no warning messages.

LANE DEPARTURE: WARNING

The full self driving is very dangerous. I had several events that put me in danger. Like, going to the wrong lane. Going to the wrong way. Changing lanes that almost hit a car good thing I took over right away. It made the other car upset and honk at me.

FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL

The full self driving is very dangerous. I had several events that put me in danger. Like, going to the wrong lane. Going to the wrong way. Changing lanes that almost hit a car good thing I took over right away. It made the other car upset and honk at me.

VEHICLE SPEED CONTROL

The full self driving is very dangerous. I had several events that put me in danger. Like, going to the wrong lane. Going to the wrong way. Changing lanes that almost hit a car good thing I took over right away. It made the other car upset and honk at me.

ELECTRICAL SYSTEM

I charged a 2021 Apple Macbook Pro with factory charging cable from the front USB-C charging port in a 2023 Tesla Model 3. The laptop charged up to around 70% but ended prematurely due to a melted charging cable and usb-c port (the connections from the usb-c port that the cable plugs into, and the part of the cable itself (male end) was melted and so hot that it burned my finger. I brought it to Tesla Service and they said it's not covered under warranty and are charging $377 + tax to replace it. The manual does not state any limitations as to what can/cannot be connected to the usb-c port. This issue has also been reported on Reddit: [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

STEERING

during a hydroplaning incident on a ramp, the tesla refused to budge or give any steer. Major issue was no air bags deployed during collision.

SERVICE BRAKES

during a hydroplaning incident on a ramp, the tesla refused to budge or give any steer. Major issue was no air bags deployed during collision.

AIR BAGS

during a hydroplaning incident on a ramp, the tesla refused to budge or give any steer. Major issue was no air bags deployed during collision.

UNKNOWN OR OTHER

Any time I get into the car and immediately start driving before the car has time to catch up with what I am doing, the NHTSA mandated safety sounds played when the car is in reverse or drive does not play until the cars computer can catch up and begin playing the sounds. Most times this can take 3 seconds or so but today I had an incident where it took over 30 seconds before it would start playing. The same issue can be detected when restarting the infotainment screen by holding down both scroll wheels on the steering wheel. When doing this the car will cease playing the sound for around 5 seconds while the computer reboots.

ELECTRICAL SYSTEM

Any time I get into the car and immediately start driving before the car has time to catch up with what I am doing, the NHTSA mandated safety sounds played when the car is in reverse or drive does not play until the cars computer can catch up and begin playing the sounds. Most times this can take 3 seconds or so but today I had an incident where it took over 30 seconds before it would start playing. The same issue can be detected when restarting the infotainment screen by holding down both scroll wheels on the steering wheel. When doing this the car will cease playing the sound for around 5 seconds while the computer reboots.

STRUCTURE:BODY

Any time I get into the car and immediately start driving before the car has time to catch up with what I am doing, the NHTSA mandated safety sounds played when the car is in reverse or drive does not play until the cars computer can catch up and begin playing the sounds. Most times this can take 3 seconds or so but today I had an incident where it took over 30 seconds before it would start playing. The same issue can be detected when restarting the infotainment screen by holding down both scroll wheels on the steering wheel. When doing this the car will cease playing the sound for around 5 seconds while the computer reboots.

WHEELS

Rims cracked with normal usage. Current mileage under 17,000. This should not occur, and poses a safety risk with loss of tire pressure.