2009 STARTRANS MFSAB

EQUIPMENT ADAPTIVE/MOBILITY

Supreme Corporation (Supreme) is recalling certain model year 2008-2014 Startrans Activity Bus, Azure Hybrid, Candidate, Senator, Senator HD, Senator II, President, President S2, Sentinel Van, and Trolley shuttle buses manufactured May 9, 2008, to August 9, 2014, equipped with certain model S2005, S2010, S5005, S5010, S5505, and S5510 wheelchair lifts by Ricon. The platform side plate of the affected wheelchair lifts may crack. Additionally, the lifts are equipped with folding link arms that may have pivot holes that are too big, allowing the bearings to move out of position.

Risk: If the bearings move out of position, the stowed platform may have excessive movement resulting in failure of the platform mounting. This failure could cause the wheel chair lift platform to fall out of the vehicle when the doors are opened, increasing the risk of injury for the lift operator.

EQUIPMENT ADAPTIVE/MOBILITY

Supreme Corporation (Supreme) is recalling certain model year 2009-2010 Startrans MFSAB school buses equipped with Ricon manufactured wheelchair lifts which have an optional armored pendant cable. The armored cable may be positioned such that it does not clear the wheelchair lift.

Risk: If the cable does not clear the wheel chair lift it may contact the power lug and if it does not have a nonconductive cover, or it has an improperly installed non-conductive cover, then a short circuit may occur that could result in a fire.

EQUIPMENT ADAPTIVE/MOBILITY

STARTRANS IS RECALLING CERTAIN 2009 AND 2010 MFSAB SCHOOL BUSES, EQUIPPED WITH BRAUN WHEELCHAIR LIFTS. OVER TIME AND WITH FREQUENT USE, THE ROLL STOP LATCHES ON THE OUTER BARRIER MAY BECOME BENT OR MISALIGNED.

Risk: A WHEELCHAIR OCCUPANT MAY DEFEAT OR RIDE OVER THE INSUFFICIENTLY LATCHED ROLL STOP. IF THIS OCCURS WHEN THE LIFT PLATFORM IS IN AN ELEVATED POSITION, THE WHEELCHAIR’S OCCUPANT COULD FALL AND SUSTAIN INJURY.

VISIBILITY:REARVIEW MIRRORS/DEVICES:INTERIOR

CERTAIN MODEL YEAR 2007 THROUGH 2011 STARTRANS MFSAB SCHOOL ACTIVITY BUSES WERE PRODUCED WITHOUT THE REQUIRED DECAL ON THE REAR VIEW MIRROR WHICH WARNS THE BUS OPERATOR TO USE THE CROSS VIEW MIRRORS WHILE THE BUS IS STOPPED AND NOT TO USE THE CROSS VIEW MIRRORS WHILE THE BUS IS MOVING. ACCORDINGLY, THE BUSES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 111, "REARVIEW MIRRORS."

Risk: IMAGES IN CROSS VIEW MIRRORS DO NOT ACCURATELY SHOW ANOTHER VEHICLE'S LOCATION, IMPROPER USE OF MIRRORS MAY REDUCE THE CLEAR AND REASONABLY UNOBSTRUCTED VIEW TO THE REAR, INCREASING THE RISK OF A CRASH.

STRUCTURE:BODY:DOOR

STARTRANS IS RECALLING CERTAIN MODEL YEAR 2007 THROUGH 2011 MODEL MFSAB SCHOOL ACTIVITY BUSES. THE REAR DOOR EMERGENCY EXIT IS PARTIALLY BLOCKED BY THE BUS SEATS. ACCORDINGLY, THESE BUSES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 217, "BUS EMERGENCY EXITS AND WINDOW RETENTION AND RELEASE."

Risk: EGRESS FROM THE BUS MAY BE HINDERED IN THE EVENT OF AN EMERGENCY, INCREASING THE RISK OF INJURY TO THE BUS OCCUPANTS.

EQUIPMENT:APPLIANCE:AIR CONDITIONER

STARTRANS IS RECALLING CERTAIN MODEL YEAR 2006 THROUGH 2010 MFSAB SCHOOL BUSES EQUIPPED WITH CARRIER GENV EM-1 EVAPORATOR UNITS. DUE TO TIME, TEMPERATURE, AND/OR VIBRATION, THE FUSE MAY LOOSEN IN THE FUSE HOLDER RESULTING IN HIGH RESISTANCE AND ARCING.

Risk: IF SUFFICIENT ARCING OCCURS, THE FUSE HOLDER MAY MELT, AND A VEHICLE FIRE MAY OCCUR.