2023 RIVIAN R1T

SEAT BELTS:FRONT:ANCHORAGE

Rivian Automotive, LLC (Rivian) is recalling certain 2022-2025 R1T and R1S vehicles. The D-ring bolts for one or both front seat belt anchorage assemblies may not have been properly installed.

Risk: An improperly secured seat belt may not restrain an occupant as intended, increasing the risk of injury during a crash.

EXTERIOR LIGHTING:HEADLIGHTS

Rivian Automotive, LLC. (Rivian) is recalling certain 2023-2024 EDV, R1S, and R1T vehicles. The headlights may be improperly aimed. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamp, Reflective Devices and Associated Equipment."

Risk: Improperly aimed headlights can result in insufficient illumination of the road, decreasing the driver's visibility and increasing the risk of a crash.

EQUIPMENT:OTHER:LABELS

Rivian Automotive, LLC. (Rivian) is recalling certain 2022-2023 R1S and R1T vehicles. The maximum vehicle capacity weight value on the tire placard label is incorrect. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 110, "Tire Selection and Rims."

Risk: A vehicle with an incorrect maximum capacity weight value may be overloaded, which can increase the risk of a crash.

AIR BAGS:SIDE/WINDOW:CURTAIN

Rivian Automotive, LLC (Rivian) is recalling certain 2022-2024 R1T and R1S vehicles. The attachment clips on the upper B-pillar and/or C-pillar trim panels may have been damaged during a service procedure.

Risk: Damaged pillar trim panel clips can result in improper side curtain air bag deployment, increasing the risk of injury during a crash.

UNKNOWN OR OTHER

I was shifting my truck from park to reverse when the shift handle snapped off. There was no warning and I had just driven the vehicle a couple hours earlier. The truck only has 13k miles on it.

POWER TRAIN

Rivian R1T was brought to independent tire center for tire rotation on same day before 1,000 mile trip. Technician documented: "Drivers side front CV axle bolt almost completely backed out". Bolt took less than one rotation by hand to come off. Documented by tire shop technician. - Possible safety impact by possible failure of half-shaft and loss of steering control and/or wheel loss - The vehicle is scheduled for an inspection by manufacturer July 14, 2025 - There were no warnings or symptoms prior to discovery

FUEL/PROPULSION SYSTEM

The vehicle caught fire and was completely destroyed. The fire was due to an electrical or battery system defect.

ELECTRICAL SYSTEM

The vehicle caught fire and was completely destroyed. The fire was due to an electrical or battery system defect.

ELECTRICAL SYSTEM

I Was driving down highway and receive a fe messages in quick order -front sensors off, front camera off, collision detection off, regenerative braking off - started moving toward right shoulder prior to pulling off - car lost speed at high rate putting me in jeopardy of being rear ended. 2025.06.012 code was loaded into truck the day before - this was first real drive after new code loaded into truck - early in the morning the warning for front sensors off, collision detection off, regenerative braking off did come and I pulled off and rebooted system. Everything seemed to be fine - made into office and again on return the loss of speed at high rate was a safety issue.

SERVICE BRAKES

I Was driving down highway and receive a fe messages in quick order -front sensors off, front camera off, collision detection off, regenerative braking off - started moving toward right shoulder prior to pulling off - car lost speed at high rate putting me in jeopardy of being rear ended. 2025.06.012 code was loaded into truck the day before - this was first real drive after new code loaded into truck - early in the morning the warning for front sensors off, collision detection off, regenerative braking off did come and I pulled off and rebooted system. Everything seemed to be fine - made into office and again on return the loss of speed at high rate was a safety issue.

VEHICLE SPEED CONTROL

I Was driving down highway and receive a fe messages in quick order -front sensors off, front camera off, collision detection off, regenerative braking off - started moving toward right shoulder prior to pulling off - car lost speed at high rate putting me in jeopardy of being rear ended. 2025.06.012 code was loaded into truck the day before - this was first real drive after new code loaded into truck - early in the morning the warning for front sensors off, collision detection off, regenerative braking off did come and I pulled off and rebooted system. Everything seemed to be fine - made into office and again on return the loss of speed at high rate was a safety issue.

POWER TRAIN

1. The powertrain, acceleration system, and defrost system failed. The vehicle unexpectedly entered Limited Performance Mode, but instead of allowing reduced acceleration as expected, it resulted in a complete loss of power and left us stranded in traffic. Additionally, a defrost system failure warning appeared, causing a loss of visibility. The vehicle is currently at a Rivian service center, and it should be available for inspection upon request. 2.The vehicle became completely unresponsive while on a single-lane on-ramp overpass, leaving us stranded in moving traffic. Other vehicles were traveling at 50-60 mph, and drivers had to swerve abruptly to avoid a collision. This failure created an imminent risk of a rear-end or multi-car accident, putting my wife and me—and other drivers—at serious risk of injury or death. Additionally, the defrost failure further compromised visibility, making it even more dangerous to remain in the vehicle while waiting for assistance. 3.The vehicle is currently at the Rivian service center, but Rivian has not yet provided a definitive diagnosis or explanation for the failure. We are awaiting their response and further inspection. 4. The vehicle is at Rivian’s service center, where it is undergoing inspection by the manufacturer. However, it has not yet been inspected by police or insurance representatives. 5. Yes, the “Limited Performance Mode” message appeared, but according to Rivian’s own system, the vehicle should have still allowed for reduced acceleration. Instead, it lost all power completely, leaving us stranded. Additionally, a defrost system failure warning appeared at the same time, preventing us from defrosting the windshield.

ELECTRICAL SYSTEM

1. The powertrain, acceleration system, and defrost system failed. The vehicle unexpectedly entered Limited Performance Mode, but instead of allowing reduced acceleration as expected, it resulted in a complete loss of power and left us stranded in traffic. Additionally, a defrost system failure warning appeared, causing a loss of visibility. The vehicle is currently at a Rivian service center, and it should be available for inspection upon request. 2.The vehicle became completely unresponsive while on a single-lane on-ramp overpass, leaving us stranded in moving traffic. Other vehicles were traveling at 50-60 mph, and drivers had to swerve abruptly to avoid a collision. This failure created an imminent risk of a rear-end or multi-car accident, putting my wife and me—and other drivers—at serious risk of injury or death. Additionally, the defrost failure further compromised visibility, making it even more dangerous to remain in the vehicle while waiting for assistance. 3.The vehicle is currently at the Rivian service center, but Rivian has not yet provided a definitive diagnosis or explanation for the failure. We are awaiting their response and further inspection. 4. The vehicle is at Rivian’s service center, where it is undergoing inspection by the manufacturer. However, it has not yet been inspected by police or insurance representatives. 5. Yes, the “Limited Performance Mode” message appeared, but according to Rivian’s own system, the vehicle should have still allowed for reduced acceleration. Instead, it lost all power completely, leaving us stranded. Additionally, a defrost system failure warning appeared at the same time, preventing us from defrosting the windshield.

VISIBILITY/WIPER

1. The powertrain, acceleration system, and defrost system failed. The vehicle unexpectedly entered Limited Performance Mode, but instead of allowing reduced acceleration as expected, it resulted in a complete loss of power and left us stranded in traffic. Additionally, a defrost system failure warning appeared, causing a loss of visibility. The vehicle is currently at a Rivian service center, and it should be available for inspection upon request. 2.The vehicle became completely unresponsive while on a single-lane on-ramp overpass, leaving us stranded in moving traffic. Other vehicles were traveling at 50-60 mph, and drivers had to swerve abruptly to avoid a collision. This failure created an imminent risk of a rear-end or multi-car accident, putting my wife and me—and other drivers—at serious risk of injury or death. Additionally, the defrost failure further compromised visibility, making it even more dangerous to remain in the vehicle while waiting for assistance. 3.The vehicle is currently at the Rivian service center, but Rivian has not yet provided a definitive diagnosis or explanation for the failure. We are awaiting their response and further inspection. 4. The vehicle is at Rivian’s service center, where it is undergoing inspection by the manufacturer. However, it has not yet been inspected by police or insurance representatives. 5. Yes, the “Limited Performance Mode” message appeared, but according to Rivian’s own system, the vehicle should have still allowed for reduced acceleration. Instead, it lost all power completely, leaving us stranded. Additionally, a defrost system failure warning appeared at the same time, preventing us from defrosting the windshield.

STRUCTURE:BODY

My driver side door intermittently does not close. There is something wrong with the latch. I called service center over 3 times and still haven’t been given any immediate appointment as the issue of safety is paramount, as I can’t drive with an open door. I still haven’t had this issue resolved.