2017 NISSAN TITAN

ELECTRICAL SYSTEM:ALTERNATOR/GENERATOR/REGULATOR

Nissan North America, Inc. (Nissan) is recalling certain 2017-2019 gasoline, light duty, Titan vehicles. The alternator harness may have been damaged during the engine installation process, possibly resulting in an electrical short.

Risk: An electrical short may cause an engine stall, increasing the risk of a crash. In addition, it increases the risk of a fire.

EQUIPMENT:OTHER:LABELS

Nissan North America, Inc. (Nissan) is recalling certain 2016-2018 Nissan Titan, 2016 and 2018 Nissan Titan XD vehicles. Accessories installed on these vehicles reduced the load carrying capacity, however, a Load Carrying Capacity modification label was not installed, possibly allowing the vehicle to be overloaded. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 110, "Tire Selection and Rims."

Risk: An overloaded vehicle can increase the risk of a crash.

ENGINE

V8 endurance engine has a known defect with scaring of cylinder 7 causing knocking in the engines and engines replacements. I purchased this Titan brand new in 2017. It required a brand new engine at 18,000 miles that was covered by the warranty. That engine developed another knock that required another engine replacement at 89,000 miles. Initially Nissan refused to cover as the truck was more than 5 years old even though the miles were well below 100,000 manufacturer warranty. I have found that these are bad engines that dealership is continue to install in these trucks even knowing that it could develop another knock. Other engine manufacturers refused to work on these engines due to this known defect. Nissan has thus far refused to recall this engine. The replacement cost is $18,000 without warranty.

ENGINE

I was droving down the road with the cruise control set at 70MPH, when all of the sudden the engine lost power and stopped. It did not have a check engine light or anything on the dash to indicate that there was a problem. I coasted to the edge of the road where i attempted to restart the vehicle, but it would not even turn over. I had the vehicle towed to a repair shop where I was informed that they engine was locked solid. The mechanic suspects that they crankshaft is broken, but the entire engine will need to be replaced.

ENGINE

Broken crankshaft

ENGINE

Spun rod bearing/broken crank shaft - major vibration, loss off power, dangerous

POWER TRAIN

Purchased a used 2017 Nissan Titan XD Pro-4X 5.0L diesel on 3/8/25. Left the dealership and only made it ~10 miles down the road before the check engine light came on and there was a loud knocking noise. Immediately turned around and went back to the dealership. After diagnosing it I was told it was a fuel injector and that they were replacing it. Received the truck back ~3/20/25. This truck is not my daily driver but the few times I have attempted to drive it the check engine light keeps coming on and I'm getting a message about the REGEN. On 5/28/25 I had the truck towed to my local Nissan dealership. They diagnosed it and although there is still a code for the same injector coming up they said the issue is the wiring harness and quoted me $7000 to repair and it's not covered under my powertrain warranty. After research it seems like this is a common issue in 2017-2019 Nissan Titan 5.0L diesel trucks which will cause the crankshaft to break if not fixed. I am super frustrated that after less than 3 months of ownership I have an undrivable truck requiring thousands of dollars in repairs.

FUEL/PROPULSION SYSTEM

Purchased a used 2017 Nissan Titan XD Pro-4X 5.0L diesel on 3/8/25. Left the dealership and only made it ~10 miles down the road before the check engine light came on and there was a loud knocking noise. Immediately turned around and went back to the dealership. After diagnosing it I was told it was a fuel injector and that they were replacing it. Received the truck back ~3/20/25. This truck is not my daily driver but the few times I have attempted to drive it the check engine light keeps coming on and I'm getting a message about the REGEN. On 5/28/25 I had the truck towed to my local Nissan dealership. They diagnosed it and although there is still a code for the same injector coming up they said the issue is the wiring harness and quoted me $7000 to repair and it's not covered under my powertrain warranty. After research it seems like this is a common issue in 2017-2019 Nissan Titan 5.0L diesel trucks which will cause the crankshaft to break if not fixed. I am super frustrated that after less than 3 months of ownership I have an undrivable truck requiring thousands of dollars in repairs.

ELECTRICAL SYSTEM

Purchased a used 2017 Nissan Titan XD Pro-4X 5.0L diesel on 3/8/25. Left the dealership and only made it ~10 miles down the road before the check engine light came on and there was a loud knocking noise. Immediately turned around and went back to the dealership. After diagnosing it I was told it was a fuel injector and that they were replacing it. Received the truck back ~3/20/25. This truck is not my daily driver but the few times I have attempted to drive it the check engine light keeps coming on and I'm getting a message about the REGEN. On 5/28/25 I had the truck towed to my local Nissan dealership. They diagnosed it and although there is still a code for the same injector coming up they said the issue is the wiring harness and quoted me $7000 to repair and it's not covered under my powertrain warranty. After research it seems like this is a common issue in 2017-2019 Nissan Titan 5.0L diesel trucks which will cause the crankshaft to break if not fixed. I am super frustrated that after less than 3 months of ownership I have an undrivable truck requiring thousands of dollars in repairs.

UNKNOWN OR OTHER

Took my nissan titan xd into the tim dahle nissan to get my recall done and also my ac fixed since it was broken, let them know that i had a light turn on and then turn back off, they said that they would look at it. when messaging with the service advisor he had told me that the part that was issued for the recall could not be done because there was something already wrong with my truck. i had not had any problems previously when i took it in just weeks prior and it was never brought up when they looked at it before. they then told me i shouldn’t drive it very far because it is not safe, i just wanted to take it in for the recall part but they refused to do it for me even though it would help. i was very unhappy with how i was treated and how they denied me a part that should be put in regardless. but they had just told me it would be pointless to put it in.

POWER TRAIN

Truck was fine and then went to pull out in traffic and it would not shift past 3rd gear, was dangerous because traffic was moving quickly and no lights appeared on the dash but the transmission just stopped shifting past 3rd. Had to limp it back off the road which was scary because people were traveling at higher speeds than we were able to even though just 2 minutes prior we had come from that same road and we were traveling just fine. Was told by dealer that the valve body went out and is costing $3400 to replace, no metal shavings found inside the transmission but this incident almost caused a wreck and is costing a serious fortune. Seems to be a serious and common issue from the research I’ve done, unfortunately it’s something that’s just becoming known because I would have never bought it expecting danger and expenses like these.

ENGINE

Highway driving and lost power, started hearing engine rattle. 5.0L Cummins Diesel engine crankshaft is broken. Dealer verified it to be crankshaft. Insurance company denied a claim stating the crankshaft was manufacturer defect. Turns out that defective crankshaft was a known issue with the 2016 and 2017 Titan 5.0L engines that Cummins changed it for subsequent years. This should be a recall. I see daily the same issue on forums and groups in the USA. Thousands of us have a dead truck we are paying for in our yards.

ENGINE

Driving down the road, motor locked up due to crankshaft. Unable to control or restart vehicle.

ELECTRICAL SYSTEM

Received a recall for my vehicle. Recall was pd128. Took vehicle to dealer to have recall serviced on vehicle which was for a pm sensor and reprogram the emissions control module. After recall, DEF system error code and reduce speed to 5mph showed up on truck. Went back to dealer to explain issue after the recall. They ran codes and thought it could be the DPF filter or EGR without thinking the recall could be to blame. Went to another mechanic and did a DEF system check and found no issue with system but a miscommunication with the NOx sensor. Had NOx sensor replaced and a week later had same DEF system error come on but was more intermittent and would clear on its own. Checked codes and found said miscommunication with the same NOx sensor that was replaced. Went back to the original dealer to explain the issue and believe it was due to the recall reprogram. They did a diagnostic and spoke with their own techs and said their campaign recall repair revealed a concern that was present before but did not have detection sensor or the logic to determine the issue and recommends DOC/DOF to to replaced. Contacted Nissan about the issue and if replacement would be covered due to it being tied to the recall and was told no that it is just a coincidence even though their campaign revealed there was an issue with the recall.

FUEL/PROPULSION SYSTEM

Received a recall for my vehicle. Recall was pd128. Took vehicle to dealer to have recall serviced on vehicle which was for a pm sensor and reprogram the emissions control module. After recall, DEF system error code and reduce speed to 5mph showed up on truck. Went back to dealer to explain issue after the recall. They ran codes and thought it could be the DPF filter or EGR without thinking the recall could be to blame. Went to another mechanic and did a DEF system check and found no issue with system but a miscommunication with the NOx sensor. Had NOx sensor replaced and a week later had same DEF system error come on but was more intermittent and would clear on its own. Checked codes and found said miscommunication with the same NOx sensor that was replaced. Went back to the original dealer to explain the issue and believe it was due to the recall reprogram. They did a diagnostic and spoke with their own techs and said their campaign recall repair revealed a concern that was present before but did not have detection sensor or the logic to determine the issue and recommends DOC/DOF to to replaced. Contacted Nissan about the issue and if replacement would be covered due to it being tied to the recall and was told no that it is just a coincidence even though their campaign revealed there was an issue with the recall.

ENGINE

Received a recall for my vehicle. Recall was pd128. Took vehicle to dealer to have recall serviced on vehicle which was for a pm sensor and reprogram the emissions control module. After recall, DEF system error code and reduce speed to 5mph showed up on truck. Went back to dealer to explain issue after the recall. They ran codes and thought it could be the DPF filter or EGR without thinking the recall could be to blame. Went to another mechanic and did a DEF system check and found no issue with system but a miscommunication with the NOx sensor. Had NOx sensor replaced and a week later had same DEF system error come on but was more intermittent and would clear on its own. Checked codes and found said miscommunication with the same NOx sensor that was replaced. Went back to the original dealer to explain the issue and believe it was due to the recall reprogram. They did a diagnostic and spoke with their own techs and said their campaign recall repair revealed a concern that was present before but did not have detection sensor or the logic to determine the issue and recommends DOC/DOF to to replaced. Contacted Nissan about the issue and if replacement would be covered due to it being tied to the recall and was told no that it is just a coincidence even though their campaign revealed there was an issue with the recall.

POWER TRAIN

Car went into limp mode on the highway and would not exceed 40 mph where the speeds were around 70 putting me at risk with a code of P0720 which usually points to a valve body or transmission.

ENGINE

The truck has a broken crankshaft with only 80,000 miles on it an Nissan is aware of the defect in the engines an will not cover any repairs

ENGINE

Driving down the interstate at 65 mph out of the Blue Crankshaft broke. Massive steering wheel vibration hard to keep under control

STEERING

Original Problem: 2017 Nissan Tital Truck - Miles: 82706 Issue 1) Purchased the vehicle and owner of the Nissan dealership stated it had a "bumper-to-bumper" 100,000 miles warranty on this model truck. He never mentioned the warranty expired after 5 years in December 2022. Issue 2) Power Steering pump started making a "growling" noise Went to the local Nissan dealership and they determined a seal in the pump needed to be replaced. Found out that the seal has been back ordered from Nissan Japan due to the "high demand and part failure". Local dealership wanted to replace the entire rack & pinion system at a cost of several thousands of dollars. Contacted the Nissan Corporation to help with the warranty issue and replace only the defective seal. Local dealership will not call me now that I took the issues to Nissan Corporation. Nissan is stating that there are 67 seals on back order due to the high volume of requests and I'm now with a truck I haven't been able to drive for 3 weeks. Please look into this seal failure for a recall because I cannot afford to replace the entire rack & pinion system with 9 hours of labor cost at $200 per hour plus the cost of the entire rack & pinion assembly when I only need the seal replaced!! please help

ENGINE

Recently took the truck to get serviced a month ago. Two weeks ago I was coming back home and the motor let out and had a loud banging noise which I assumed to be a bearing or crank shaft failure. Upon getting it to a dealership they inspected it and pulled the oil pan to find metal shavings all in the turbos and oil.