NEW FLYER DE40LFR
View complaints and recalls by year, or see all recent reports below.
NEW FLYER DE40LFR Summary
5
Model Years
0
Total Complaints
13
Total Recalls
2006 - 2010
Year Range
Select Year
Recent Recalls
2007 NEW FLYER DE40LFR
2357 vehicles affected
SUSPENSION:FRONT
New Flyer Industries Ltd (New Flyer) is recalling certain 2006 L40LFand DE60LF transit buses, 2006-2007 C35LF, C40LFR, D35LF, D40LFR, D60LFR, DE40LF and DE40LFR transit buses, and 2005-2007 C40LF, D40LF, D60LF, DE60LFA, GE40LF, 2007 D35LFR, and DE60LFR transit buses. These vehicles are equipped with MAN V8-65L axle beams that may have cracks on the upper and/or lower surface, which, over time can cause the axle beam to fail.
Risk: Failure of the front axle beam can cause a loss of vehicle control, increasing the risk of a crash.
2006 NEW FLYER DE40LFR
2048 vehicles affected
STRUCTURE
New Flyer is recalling certain model year 2004-2011 transit buses, models: C35LF, C40LFR, D35LFR, D40LF, D40LFR, D60LF, D60LFA, D60LFR, DE35LFA, DE40LF, DE40LFA, DE40LFR, DE60LF, DE60LFA, DE60LFR, and XDE40. The drive shaft access panel may have insufficient strength or be not properly secured to the floor. If the drive shaft fails, debris from the driveshaft failure may enter the passenger compartment through the panel.
Risk: If debris resulting from drive shaft failure enters the passenger compartment, it may result in injury to the bus occupants.
2010 NEW FLYER DE40LFR
78 vehicles affected
ENGINE AND ENGINE COOLING
NEW FLYER IS RECALLING CERTAIN MODEL YEAR 2010 HEAVY DUTY TRANSIT BUSES, MODELS D35LFR, D40LFR, D60LFR, DE40LFR, DE60LFR, XD35, XDE35, AND XDE40, MANUFACTURED FROM SEPTEMBER 30, 2010, THROUGH JUNE 3, 2011, EQUIPPED WITH A CUMMINS ISB, ISL, ISC, or ISX DIESEL ENGINE. THE V-BAND CLAMP ASSEMBLY, PART NUMBERS Q187684, Q187685, AND Q187686, USED TO CONNECT THE INLET AND OUTLET CONE SECTIONS TO THE DIESEL OXIDATION CATALYST (DOC)/DIESEL PARTICULATE FILTER (DPF) INCLUDE A T-BOLT WHICH CAN FRACTURE AND FAIL WHEN SUBJECTED TO STRESS OR LOAD. A FRACTURE OR FAILURE OF THE T-BOLT MAY CAUSE THE CLAMP TO LOOSEN AND THE INLET OR OUTLET SECTIONS ATTACHED TO THE DOC/DPF HOUSING TO DISCONNECT.
Risk: IF THE INLET OR OUTLET SECTIONS DISCONNECT, HOT EXHAUST GASES CAN VENT PRIOR TO EXITING THE TAILPIPE, CREATING THE RISK OF COMBUSTION AND A FIRE. IF BOTH CLAMPS FAIL, THERE IS A RISK IN SOME APPLICATIONS THAT THE DOC/DPF HOUSING MAY DETACH COMPLETELY, CREATING A ROAD HAZARD.
2010 NEW FLYER DE40LFR
1123 vehicles affected
LATCHES/LOCKS/LINKAGES:DOORS:LATCH
NEW FLYER IS RECALLING CERTAIN MODEL YEAR 2007-2011 LOW FLOOR TRANSIT BUSES PRODUCED FROM MAY 24, 2007, THROUGH MARCH 1, 2011 AND EQUIPPED WITH TEETER LEVER ASSEMBLIES. THERE IS INSUFFICIENT ENGAGEMENT BETWEEN THE TEETER LEVER BASE AND THE CAM PLATE.
Risk: FAILURE OF THE TEETER LEVER ASSEMBLY WILL CAUSE THE REAR SIDE EXIT DOOR TO OPERATE IMPROPERLY. A PASSENGER LEANING ON OR FORCED AGAINST THE DOOR COULD FALL THROUGH THE DOOR AND SUSTAIN INJURIES.
2006 NEW FLYER DE40LFR
1845 vehicles affected
POWER TRAIN:DRIVELINE:DRIVESHAFT
NEW FLYER IS RECALLING CERTAIN MODEL YEAR 2004-2009 TRANSIT BUSES. THESE MODELS HAVE AN INSPECTION PANEL LOCATED ABOVE THE DRIVE SHAFT IN THE PASSENGER COMPARTMENT FLOORING FOR EASY INSPECTION AND REMOVAL OF THE DRIVE SHAFT. THIS PANEL MAY NOT BE OF SUFFICIENT STRENGTH TO PREVENT FOREIGN MATTER FROM ENTERING THE PASSENGER COMPARTMENT IN THE EVENT OF A DRIVE SHAFT FAILURE.
Risk: FAILURE OF THE DRIVE SHAFT ACCESS PANEL TO MAINTAIN PASSENGER COMPARTMENT INTEGRITY COULD RESULT IN INJURY OR DEATH.
Recent Complaints
No recent complaints found.