MERCEDES-BENZ GLE 450

ELECTRICAL SYSTEM:WIRING

Mercedes-Benz USA, LLC (MBUSA) is recalling certain 2021-2022 GLE 350 and 2021-2022 GLE 450 vehicles. The front acceleration sensor's wiring harness may be routed incorrectly, which can prevent the front air bags from deploying properly. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard 208, "Occupant Crash Protection."

Risk: An air bag that does not deploy properly can increase the risk of injury in the event of a crash.

VEHICLE SPEED CONTROL:ACCELERATOR PEDAL

Mercedes-Benz USA, LLC (MBUSA) is recalling certain 2024 GLE350, GLE450, AMG GLE53, and AMG GLE53 Coupe vehicles. The accelerator pedal module bracket may have been improperly welded, which can result in the bracket breaking or detaching.

Risk: A broken or detached accelerator pedal can increase the risk of a crash or injury.

ELECTRICAL SYSTEM:WIRING

Mercedes-Benz USA, LLC (MBUSA) is recalling certain 2023-2024 GLE 350, 2020-2024 GLE 450, 2020-2023 GLS 580, GLE 580, 2019-2023 GLS 450, 2021-2023 Maybach GLS 600, AMG GLS 63, 2021-2024 AMG GLE 53, AMG GLE 53 Coupe, and AMG GLE 63 S vehicles. A 48-Volt ground connection under the passenger seat may not be secured properly, resulting in the ground connection overheating.

Risk: An overheated ground connection can increase the risk of a fire.

POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE:SOFTWARE

Mercedes-Benz USA, LLC (MBUSA) is recalling certain 2020-2023 GLE 450 and GLS 450 vehicles. The transmission may not fully downshift in certain conditions, causing the engine to stall.

Risk: An engine stall increases the risk of a crash.

FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP

Mercedes-Benz USA, LLC (MBUSA) is recalling certain 2021-2024 GLE, GLS, C-Class, E-Class, S-Class, SL, GLC, CLS, AMG GT, and G-Class vehicles. Please refer to MBUSA's recall report for specific vehicle details. The fuel pump may shutdown, causing a loss of drive power.

Risk: A loss of drive power can increase the risk of a crash.

ELECTRICAL SYSTEM:12V/24V/48V BATTERY

Mercedes-Benz USA, LLC (MBUSA) is recalling certain 2021-2022 GLE350 and GLE450 vehicles. A 12-Volt ground connection under the driver seat may not be secured properly, resulting in the ground connection overheating.

Risk: An overheated ground connection can increase the risk of a fire.

STRUCTURE:BODY

Mercedes-Benz USA, LLC (MBUSA) is recalling certain 2022-2023 GLE350, GLE450, GLE580, GLS450, GLS580, Maybach GLS600, AMG GLE53, AMG GLE63 S, and AMG GLS63 vehicles. The rear door window trim bars may detach from the vehicle while driving.

Risk: Detached trim bars may cause a road hazard and increase the risk of a crash or injury.

VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM

Mercedes-Benz USA, LLC (MBUSA) is recalling certain 2020-2021 GLE350, GLE450, GLS450, GLS580, 2021 AMG GLE53, AMG GLE63, Maybach GLS600, AMG GLS63, and 2020 GLE580 vehicles. The air conditioner drain hoses may have been incorrectly installed, causing water to drain into the passenger compartment.

Risk: Water intrusion into the foot wells may cause corrosion and/or short circuits to electrical components, increasing the risk of fire. In addition, the emergency call (eCall) feature may be disabled and the doors may not unlock, increasing the risk of injury. Also, the engine may not start or may enter a limp-home mode, increasing the risk of a crash.

FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP

Mercedes-Benz USA, LLC (MBUSA) is recalling certain 2021-2023 C-Class, E-Class, S-Class, CLS, SL, GT, GLC, GLE, GLS, and G-Class vehicles. Please refer to MBUSA's recall report for specific vehicle details. The fuel pump may shutdown, which can result in a loss of drive power.

Risk: A loss of drive power can increase the risk of a crash.

FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING

The Mercedes GLE450 was stopped at a red light. When the light turned green, the driver entered the intersection. The automatic braking system engaged without reason (there was open road ahead), bringing the car to a sudden standstill. The driver accelerated again, but this time the car went backwards into the car behind him. The driver had not shifted into reverse. So the car both slammed on the brakes, and switched the transmission into reverse, without driver input. Mercedes-Benz USA conducted an investigation and produced data showing that the car shifted into reverse while it was driving forward; they claimed this was driver error. However, the dealer (and our own experience) says it is impossible to shift the car into reverse when it is driving forward; the car must be stopped before it can shift into reverse. We have asked them to explain this seeming incoherence in their explanation, but they have not responded. Our conclusion is that the car malfunctioned. We still have the dashcam footage recorded during the incident, if that is needed.

POWER TRAIN

The Mercedes GLE450 was stopped at a red light. When the light turned green, the driver entered the intersection. The automatic braking system engaged without reason (there was open road ahead), bringing the car to a sudden standstill. The driver accelerated again, but this time the car went backwards into the car behind him. The driver had not shifted into reverse. So the car both slammed on the brakes, and switched the transmission into reverse, without driver input. Mercedes-Benz USA conducted an investigation and produced data showing that the car shifted into reverse while it was driving forward; they claimed this was driver error. However, the dealer (and our own experience) says it is impossible to shift the car into reverse when it is driving forward; the car must be stopped before it can shift into reverse. We have asked them to explain this seeming incoherence in their explanation, but they have not responded. Our conclusion is that the car malfunctioned. We still have the dashcam footage recorded during the incident, if that is needed.

SERVICE BRAKES

The Mercedes GLE450 was stopped at a red light. When the light turned green, the driver entered the intersection. The automatic braking system engaged without reason (there was open road ahead), bringing the car to a sudden standstill. The driver accelerated again, but this time the car went backwards into the car behind him. The driver had not shifted into reverse. So the car both slammed on the brakes, and switched the transmission into reverse, without driver input. Mercedes-Benz USA conducted an investigation and produced data showing that the car shifted into reverse while it was driving forward; they claimed this was driver error. However, the dealer (and our own experience) says it is impossible to shift the car into reverse when it is driving forward; the car must be stopped before it can shift into reverse. We have asked them to explain this seeming incoherence in their explanation, but they have not responded. Our conclusion is that the car malfunctioned. We still have the dashcam footage recorded during the incident, if that is needed.

EXTERIOR LIGHTING

Both left and right headlamp/turn signal/marker light assemblies and control modules have been replaced. One under warranty in 2023, the second in 2025. Infotainment system displays error messages Messages may increase as assembly/control module becomes increasingly dysfunctional.

SUSPENSION

The rear shock absorbers have failed on my vehicle. The vehicle makes sounds when going over bumps in the road. There is an active recall on other GLE 2020 450 models but not my specific VIN. The vehicle has less then 30,000 miles on it before the shock absorbers went out.

ELECTRICAL SYSTEM

On [XXX] the power lock system in my Mercedes auto locked itself with my key and phone inside the vehicle on a hot day with a baby secured in a rear car seat. I did not lock the vehicle or touch the door handle lock. This vehicle is designed to never lock with a key inside. Obviously, this was a life threatening situation as our area was experiencing record heat. Since my phone was also locked inside, I couldn't call for help & had to find a stranger to lend me a phone. Immediately after I took care of the baby & had help, I reported the incident immediately to the Mercedes Emergency Customer Care center via the SOS button in the vehicle. They told me I would hear from someone within 72 hours - it's now been 10+ days since the incident & no communication from Mercedes. The vehicle locked itself again without warning a few days ago but fortunately, there was an adult in the vehicle who was able to unlock it (and the driver had the key on hand outside the vehicle). We have owned 6 Mercedes vehicles - we are familiar with the auto lock system & this is not normal. Srvice is scheduled with the local dealer in Fredericksburg VA the week of July 16, 2025. There was no warning & no warning lights. Normally, the vehicle verbally alerts us when the key is left in the vehicle. In this case, the key was in my purse on the front passenger seat. All doors were unlocked when I placed the baby in her seat and closed the right passenger doors. I walked around to open the drivers side door when I discovered all doors were locked. The vehicle is designed to not be able to lock with a key inside. We have been unable to manually reproduce the incident which leads us to believe the problem is in the electronic coding and needs attention and service from the manufacturing level. This could have easily ended in a fatality. I do not want this to happen to anyone else. I submitted another complaint to Mercedes - this time via letter on their website. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(

VEHICLE SPEED CONTROL:CRUISE CONTROL

The contact owns a 2024 Mercedes-Benz GLE450. The contact stated while driving 70 MPH with the cruise control activated, the vehicle suddenly decelerated to 15 MPH. The contact became aware that the cruise control system had changed the set speed independently. The vehicle returned to normal functionality, but the failure became a regular occurrence, with the vehicle accelerating or decelerating independently. No warning lights were illuminated. The vehicle was taken to the dealer, who was unable to diagnose the failure. The contact was advised that the cruise control should not be activated. The vehicle was not repaired. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was 1,500.

ELECTRICAL SYSTEM

48V battery issue cause the car not able to drive.

ENGINE

My wife was driving on [XXX] going ~70mph. Without warning the engine shut down and the vehicle decelerated. A message popped up saying “48 volt malfunction”. A google search indicated the car should not be driven as it could result in a fire. Note the Mercedes dealer in Centerville Ohio completed recall campaign: 2024040002 in May, 2024. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)