2022 MAZDA CX-5

ELECTRICAL SYSTEM:INSTRUMENT PANEL:SPEEDOMETER/ODOMETER

Odometer Fraud. The contact purchased a 2022 Mazda CX-5. The contact discovered a mileage discrepancy after purchasing the vehicle. The vehicle was a dealer sale. At the time of purchase, the vehicle mileage was 26,400. The contact stated that the dealer harassed her to buy the extended warranty. The contact stopped by the dealer and requested that they stop with the harassment. The contact stated that at the time of purchase, the dealer connected the service to the infotainment system. The contact noticed that the vehicle was being tracked and the gauges on the instrument panel were tampered with. The manufacturer was notified of the failure. The contact stated that two days later, it was discovered that the mileage was approximately 46,000. The contact suspected that the vehicle was hacked.

POWER TRAIN

Transmission failure, currently reproducible but car is at dealer to be evaluated/repaired. I was safe as I was still in my driveway, however if I was in traffic I would be at risk of an accident, by the time you realize you are not moving you have already let off the brake and could be rolling, fear is that if it happens at a traffic light other drivers woudl assume I am going to accelerate but I'm not. First time this happened dealer reproduced issue, contacted Mazda, and a replacement valve body was installed. Now that it has happened again within the first 33K miles it creates a trust issue. There were no warning sign either time the transmission failed. I also do not drive aggressively, wife says I drive like a grandpa. about 10-15 seconds after failure the alarms and warning lights go off.

UNKNOWN OR OTHER

Several times and most recently today 8/18/2025 at 5:30 PM my 2022 Mazda CX-5 accelerated while I had my foot on the brake and only the brake. Hard pressure on the brake kept the SUV from lurching forward. This has happened before but I did not think it would occur again. But it has and I find that this could easily cause an accident. The SUV in question has only 23,000 miles on it. An investigation and recall to fix the problem should be initiated.

EXTERIOR LIGHTING

A grating/moaning noise started coming from the passenger-side headlight. After googling, it seems that it is a common issue that others have had which requires replacement of the headlight assembly. I took this to the dealership, and the tech told me this is common. They didn’t even have to take it back into the shop to make a diagnosis. He said that dirt gets into the bearings on the fan meant to cool the lamp DURING MANUFACTURING. This causes the fan to fail and the light to overheat if the headlight assembly is not replaced. This problem seems to be so common that the dealership already had the part in stock that they would need.

POWER TRAIN

The timing chain cover gasket failed and is leaking oil at 66,000 miles. It is currently being addressed at Borgman Mazda in Grand Rapids. No crash or safety risk. There were no warning lamps, it was found by an separate inspection not from the dealership.

ENGINE

The timing chain cover gasket failed and is leaking oil at 66,000 miles. It is currently being addressed at Borgman Mazda in Grand Rapids. No crash or safety risk. There were no warning lamps, it was found by an separate inspection not from the dealership.

ENGINE

While driving down highway the car suddenly will stop accelerating. Once this occurs the check engine light will turn on and shortly after the battery light will turn on. The car will not move and the AC will then stop working. The first time the car was brought to dealership (under warranty). They had to replace battery, fuel pump and fuel level indicator. They stated the fuel pump was broken as was the fuel level indicator. They were able to reproduce the problem prior to fixing it the first time. Less than a month after the car was repaired the exact same issue happened. This is a significant safety concern as I was driving on the highway with a [XXX] child in the back seat when the car stopped driving the second time. I was barely able to get over a lane and off the road before the car stopped driving. The AC then stopped working on a day where the feels like temperature was over 100. I had to lay wet cloths over my infant to prevent her from overheating while we waited for AAA and a family member to reach us. The inability to accelerate/sudden stopping of the car while driving on a highway with a speed limit of 70mph posed a significant safety risk to my life, my child’s life and potentially other cars if they weren’t able to stop. I had to wave frantically at the car in the lane next to me so that they wouldn’t hit me. No warning lights came on until after the issue (stopped accelerating) occurred. The dealership (Mazda) now has the car again and will be inspecting it. I have files from the first incident however they are in the car. Once I get my car back I can send over the reports of what they replaced/work completed. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

FUEL/PROPULSION SYSTEM

While driving down highway the car suddenly will stop accelerating. Once this occurs the check engine light will turn on and shortly after the battery light will turn on. The car will not move and the AC will then stop working. The first time the car was brought to dealership (under warranty). They had to replace battery, fuel pump and fuel level indicator. They stated the fuel pump was broken as was the fuel level indicator. They were able to reproduce the problem prior to fixing it the first time. Less than a month after the car was repaired the exact same issue happened. This is a significant safety concern as I was driving on the highway with a [XXX] child in the back seat when the car stopped driving the second time. I was barely able to get over a lane and off the road before the car stopped driving. The AC then stopped working on a day where the feels like temperature was over 100. I had to lay wet cloths over my infant to prevent her from overheating while we waited for AAA and a family member to reach us. The inability to accelerate/sudden stopping of the car while driving on a highway with a speed limit of 70mph posed a significant safety risk to my life, my child’s life and potentially other cars if they weren’t able to stop. I had to wave frantically at the car in the lane next to me so that they wouldn’t hit me. No warning lights came on until after the issue (stopped accelerating) occurred. The dealership (Mazda) now has the car again and will be inspecting it. I have files from the first incident however they are in the car. Once I get my car back I can send over the reports of what they replaced/work completed. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

ELECTRICAL SYSTEM

While driving down highway the car suddenly will stop accelerating. Once this occurs the check engine light will turn on and shortly after the battery light will turn on. The car will not move and the AC will then stop working. The first time the car was brought to dealership (under warranty). They had to replace battery, fuel pump and fuel level indicator. They stated the fuel pump was broken as was the fuel level indicator. They were able to reproduce the problem prior to fixing it the first time. Less than a month after the car was repaired the exact same issue happened. This is a significant safety concern as I was driving on the highway with a [XXX] child in the back seat when the car stopped driving the second time. I was barely able to get over a lane and off the road before the car stopped driving. The AC then stopped working on a day where the feels like temperature was over 100. I had to lay wet cloths over my infant to prevent her from overheating while we waited for AAA and a family member to reach us. The inability to accelerate/sudden stopping of the car while driving on a highway with a speed limit of 70mph posed a significant safety risk to my life, my child’s life and potentially other cars if they weren’t able to stop. I had to wave frantically at the car in the lane next to me so that they wouldn’t hit me. No warning lights came on until after the issue (stopped accelerating) occurred. The dealership (Mazda) now has the car again and will be inspecting it. I have files from the first incident however they are in the car. Once I get my car back I can send over the reports of what they replaced/work completed. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

EXTERIOR LIGHTING

I own a 2022 Mazda CX-5 Carbon Edition and have recently noticed a persistent noise coming from the left headlight. The noise resembles a fan or vibrating sound. The issue appears to be caused by a malfunctioning auto-leveling or adaptive headlight motor. The component is still installed in the vehicle and can be inspected upon request by a dealer or manufacturer. Safety Risks: While this issue has not yet caused immediate driving hazards, a malfunctioning headlight system could pose a safety risk if the auto-leveling function fails, leading to improper headlight beam alignment. This could impact nighttime visibility or cause glare for other drivers, increasing the risk of accidents.

ENGINE

I am submitting this report to document a persistent ticking noise in my 2022 Mazda CX-5, which appears to be the same issue outlined in Mazda Service Bulletin 01-002/21 for previous model years. This issue is commonly associated with Hydraulic Lash Adjusters (HLAs), which maintain proper valve clearance. The noise occurs most prominently during cold starts and resembles the previously reported HLA ticking sound. Owners of earlier CX-5 models have attributed this issue to air bubbles or insufficient oil supply within the HLAs, with cold weather exacerbating the problem due to restricted oil circulation. Despite Mazda's claim that revisions to the engine components have resolved this issue in newer models, my experience suggests it remains unresolved in the 2022 model year. I am concerned about the long-term reliability of these engine components and the potential repair costs if the issue leads to premature wear or failure. While Mazda has not issued a Technical Service Bulletin (TSB) for the 2022 CX-5, multiple owners have reported similar ticking noises online, indicating that the problem may persist. I have a video recording of the noise but am unable to attach it to this submission. If further investigation is warranted, I would be happy to provide the footage upon request. Additionally, similar reports and video evidence from other owners can be found on online forums, including the CX-5 subreddit, where searching for “clicking” will yield multiple examples. I urge the NHTSA to review this issue, as it may indicate an unresolved mechanical defect affecting the reliability of the 2022 Mazda CX-5’s engine. Please advise on any potential investigations or next steps regarding this matter.

EXTERIOR LIGHTING

I own a 2022 Mazda CX-5 Carbon Edition and have recently noticed a persistent noise coming from the left headlight. The noise resembles a fan or vibrating sound. Coincidentally, this issue started only a month after I bought out the vehicle following the lease expiration. Component/System Failure and Inspection: The issue appears to be caused by a malfunctioning auto-leveling or adaptive headlight motor. The component is still installed in the vehicle and can be inspected upon request by a dealer or manufacturer. Safety Risks: While this issue has not yet caused immediate driving hazards, a malfunctioning headlight system could pose a safety risk if the auto-leveling function fails, leading to improper headlight beam alignment. This could impact nighttime visibility or cause glare for other drivers, increasing the risk of accidents. Reproduction and Confirmation: The problem has not yet been confirmed by a dealer or independent service center in my case, but many other customers have reported similar issues, some of whom have had the component replaced under warranty. Inspection Status: As of now, the vehicle has not yet been inspected by the manufacturer, police, insurance representatives, or other parties. Warning Signs or Symptoms Prior to Failure: No warning lamps, messages, or dashboard alerts appeared before the noise started. The issue began suddenly and has been persistent ever since. I have a video, but it cannot be uploaded in this report.

EXTERIOR LIGHTING

Headlights on these vehicles go out around 40,000 miles due to issues during their manufacturing. The repair costs $2,500+. The issue is known by Mazda and is widespread but they refuse to recall.