2019 MAZDA CX-5

FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP

Mazda North American Operations (Mazda) is recalling certain 2018 Mazda3, Mazda6, 2019 CX-3, 2018-2019 MX-5, CX-5, CX-9, and 2019-2020 Mazda2 vehicles. The impeller inside the low-pressure fuel pump may crack and deform, potentially causing the fuel pump to fail.

Risk: Fuel pump failure may cause an engine stall, increasing the risk of a crash.

ENGINE

Dealership service department found a cracked cylinder head. This issue has been reported to NHTSA by Mazda. The car is being serviced and this issue was found. I’m attaching photos and also report from dealership l.

ENGINE

Cracked Cylinder Head.

ENGINE

Timing cover oil leak. This is the same issue reported in technical bulletin #01-006/23 issued on 04/26/2023. There is oil leaking and the engine is smoking. No engine warning lights or other messages appeared. My car is a 2019 mazda CX-5 and has 31,954 miles. This problem has been confirmed by both an independent mechanic and the dealer service center. On 08/22/2025, I took my vehicle to dealer service for the repair. I also submitted a ticket to Mazda care for review of the case.

UNKNOWN OR OTHER

My vehicle was damaged by an as yet determined electrical fire seemingly having originated in the passenger door speaker components.

ELECTRICAL SYSTEM

My vehicle was damaged by an as yet determined electrical fire seemingly having originated in the passenger door speaker components.

AIR BAGS

My vehicle was damaged by an as yet determined electrical fire seemingly having originated in the passenger door speaker components.

UNKNOWN OR OTHER

While operating the vehicle it will randomly start changing infotainment system settings. The radio station settings change, navigation maps will pop up and unprompted phone calls will be initiated. Each action is followed by a “beep.” Very distracting and requires actions that take focus away from operating the vehicle.

ELECTRICAL SYSTEM

When accelerating, the transmission feels jerky/stutters. The check engine light and traction control light are illuminated and on the instrument cluster the messages: "Forward Smart City Brake Support Malfunction", "Smart Brake System Malfunction" and "Front Radar Sensor System Malfunction" appear. The vehicle acts like it doesn't know which gear it should be in, it'll buck pretty hard and then it refuses to accelerate...it feels like it's in a "limp mode". A previous driver of the vehicle complained and said that it actually stalled in traffic on the highway and was of course difficult to steer due to loss of power. I took it to a dealership and they came up with a laundry list of things to fix...most of which wouldn't have any bearing on this issue. I did have the serpentine belt replaced and the belt tensioner replaced due to wear on the belt and loose tension. On 7/16/25, I scanned the vehicle with a code reader, the codes P0301 and P0506 appeared. P0301 is a generic "Cylinder 1 Misfire Detected" message and P0506 is a generic "IAC system RPM Lower Than Expected. The vehicle was taken to a shop where the spark plugs and the cylinder 1 coil was replaces and the IAC cleaned. On 7/24/25 the same vehicle behaviors were observed and the same warning lights and messages were activated. I scanned the vehicle and got "p0300 Random/Multiple Cylinder Misfire Detected and P0304 Cylinder 4 Misfire detected. There was a recall on this particular vehicle make, model and year and my vehicle was out of the VIN# range. I firmly believe that the recall needs to be expanded to include a larger number of vehicles...you can google about this vehicle and see many others with similar issues. Usually, the cure is a PCM reflashing/software update that seems to take care of the issue. Please expand the recall before someone dies in an accident because of this problem.

FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING

When accelerating, the transmission feels jerky/stutters. The check engine light and traction control light are illuminated and on the instrument cluster the messages: "Forward Smart City Brake Support Malfunction", "Smart Brake System Malfunction" and "Front Radar Sensor System Malfunction" appear. The vehicle acts like it doesn't know which gear it should be in, it'll buck pretty hard and then it refuses to accelerate...it feels like it's in a "limp mode". A previous driver of the vehicle complained and said that it actually stalled in traffic on the highway and was of course difficult to steer due to loss of power. I took it to a dealership and they came up with a laundry list of things to fix...most of which wouldn't have any bearing on this issue. I did have the serpentine belt replaced and the belt tensioner replaced due to wear on the belt and loose tension. On 7/16/25, I scanned the vehicle with a code reader, the codes P0301 and P0506 appeared. P0301 is a generic "Cylinder 1 Misfire Detected" message and P0506 is a generic "IAC system RPM Lower Than Expected. The vehicle was taken to a shop where the spark plugs and the cylinder 1 coil was replaces and the IAC cleaned. On 7/24/25 the same vehicle behaviors were observed and the same warning lights and messages were activated. I scanned the vehicle and got "p0300 Random/Multiple Cylinder Misfire Detected and P0304 Cylinder 4 Misfire detected. There was a recall on this particular vehicle make, model and year and my vehicle was out of the VIN# range. I firmly believe that the recall needs to be expanded to include a larger number of vehicles...you can google about this vehicle and see many others with similar issues. Usually, the cure is a PCM reflashing/software update that seems to take care of the issue. Please expand the recall before someone dies in an accident because of this problem.

FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL

When accelerating, the transmission feels jerky/stutters. The check engine light and traction control light are illuminated and on the instrument cluster the messages: "Forward Smart City Brake Support Malfunction", "Smart Brake System Malfunction" and "Front Radar Sensor System Malfunction" appear. The vehicle acts like it doesn't know which gear it should be in, it'll buck pretty hard and then it refuses to accelerate...it feels like it's in a "limp mode". A previous driver of the vehicle complained and said that it actually stalled in traffic on the highway and was of course difficult to steer due to loss of power. I took it to a dealership and they came up with a laundry list of things to fix...most of which wouldn't have any bearing on this issue. I did have the serpentine belt replaced and the belt tensioner replaced due to wear on the belt and loose tension. On 7/16/25, I scanned the vehicle with a code reader, the codes P0301 and P0506 appeared. P0301 is a generic "Cylinder 1 Misfire Detected" message and P0506 is a generic "IAC system RPM Lower Than Expected. The vehicle was taken to a shop where the spark plugs and the cylinder 1 coil was replaces and the IAC cleaned. On 7/24/25 the same vehicle behaviors were observed and the same warning lights and messages were activated. I scanned the vehicle and got "p0300 Random/Multiple Cylinder Misfire Detected and P0304 Cylinder 4 Misfire detected. There was a recall on this particular vehicle make, model and year and my vehicle was out of the VIN# range. I firmly believe that the recall needs to be expanded to include a larger number of vehicles...you can google about this vehicle and see many others with similar issues. Usually, the cure is a PCM reflashing/software update that seems to take care of the issue. Please expand the recall before someone dies in an accident because of this problem.

UNKNOWN OR OTHER

There is a current lawsuit/settlement stating that there are known issues with the Mazda Connect Infotainment system having technical glitches. I own a 2019 Mazda CX5 and have been having issues with the Mazda Connect pressing random buttons, drastically increasing the volume, the carplay disconnecting while I'm following GPS directions, among other technical issues while I am driving. These are extremely dangerous issues while operating a vehicle and many Mazda owners are experiencing the same issues. With the limited extended warranty, I brought my vehicle into a Mazda service center to get the issue resolved. Although there are issues with the Mazda Connect Infotainment system, they claimed that the issue is not covered under the warranty and I need to purchase a new screen repair kit which would cost $608+tax. I believe they are trying to get out of repairing the issue and the repair kit they are recommending should be covered as well. A recall should be made to cover these issues.

VEHICLE SPEED CONTROL

For the 3rd or 4th time since I have own this car I experienced a loss of acceleration when attempting to make quick acceleration while attempting to merge with traffic. Acceleration is fine around town where quick acceleration is not appropriate. But the first attempt to merge with flowing traffic the car will slowly accelerates to about 30 mph and no more regardless as to position of accelerator pedal. On all occasion this bad behavior has this first drive of the day - going to work in the a.m. There is often a warning message indicating the safety radar is not working due to limited visibility which is a very common warning in the a.m.

FUEL/PROPULSION SYSTEM

For the 3rd or 4th time since I have own this car I experienced a loss of acceleration when attempting to make quick acceleration while attempting to merge with traffic. Acceleration is fine around town where quick acceleration is not appropriate. But the first attempt to merge with flowing traffic the car will slowly accelerates to about 30 mph and no more regardless as to position of accelerator pedal. On all occasion this bad behavior has this first drive of the day - going to work in the a.m. There is often a warning message indicating the safety radar is not working due to limited visibility which is a very common warning in the a.m.

ENGINE

For the 3rd or 4th time since I have own this car I experienced a loss of acceleration when attempting to make quick acceleration while attempting to merge with traffic. Acceleration is fine around town where quick acceleration is not appropriate. But the first attempt to merge with flowing traffic the car will slowly accelerates to about 30 mph and no more regardless as to position of accelerator pedal. On all occasion this bad behavior has this first drive of the day - going to work in the a.m. There is often a warning message indicating the safety radar is not working due to limited visibility which is a very common warning in the a.m.

ENGINE

I am the owner of a 2019 Mazda CX-5 (non-turbo) which experienced a cylinder head leak requiring full replacement. The repair was done by Riley Mazda of Stamford on July 28, 2023, at a personal cost of $4,074.34. Mazda has acknowledged this defect in turbocharged CX-5 models from the same year and issued a reimbursement program. However, Mazda has declined reimbursement for non-turbo models, even though the failure is the same, and the repair used identical part numbers and labor hours as listed in Mazda’s own TSB for the turbo reimbursement. This indicates a broader issue affecting both engine variants. Mazda’s refusal to extend reimbursement to non-turbo owners is unfair and leaves affected customers with no support for a known manufacturing flaw. I urge NHTSA to investigate this recurring engine defect in non-turbo 2019–2020 Mazda CX-5 models and encourage Mazda to offer equal reimbursement.

UNKNOWN OR OTHER

My infotainment system regularly ghost jumps between screens and adjusts the volume of music (both on CarPlay and regular radio) by itself. The car turns off CarPlay regularly, including the navigation, which is dangerous when you are not sure where you are going. The sound is the worst part of it, as it will change the volume to unhealthy levels without warning. Even turning it off does not stop the jumping, as it turns itself back on. While Mazada did provide an extended warranty for this exact problem, they will not cover the display which they allege is the problem in my car and told me it is a $600 replacement fee that I am fully responsible for, even though their screen does not work. This issue is all over the internet with Mazda refusing to fix it but it's an issue that can cause serious safety issues (with navigation failing and especially with unexpected volume changes). There is no rhyme or reason to when it happens and when it doesn't. It will be fine for a few days and then not work at all for a day. This has been ongoing for about a year. My car has about 55,000 miles on it.

UNKNOWN OR OTHER

While driving on a 75 degree and sunny day my Sunroof exploded. There were no cars around that could have thrown debris up. Luckily I had the shade cover closed or I would have been showered with broken glass.

ENGINE

My vehicle has 64k miles and has had regular maintenance - oil changes, etc. it has recently developed an oil leak. I took it to the dealer today & they said the cylinder head and gasket needs to be replaced. My car has not overheating or even run warm. I understand there are 2019 CX-5S that have had a casting issue with cylinder heads. I feel sure that’s what the issue is here yet they want almost $6k to repair my vehicle!

UNKNOWN OR OTHER

I’m reaching out regarding a persistent issue with my Mazda 2019 cx5 infotainment system. The screen is experiencing frequent “ghost touch” or phantom button presses, where functions are activated without any input. This makes the screen erratic and often unusable, creating a distraction and raising safety concerns while driving. I’ve already restarted the system and attempted basic troubleshooting, but the issue continues. I’ve learned that this is a known issue in various Mazda models, and I believe this should be covered for repair, especially since it impacts both functionality and driver focus. I’ve already contacted Mazda customer service and my local dealership; however, they advised that the repair would need to be paid out of pocket. Given the nature of the issue and the potential safety concerns it presents, I strongly believe this is something that should be covered by Mazda. Please let me know how I can escalate this issue for formal documentation and create a new recall. Thank you, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

ENGINE

The contact owns a 2019 Mazda CX-5. The contact stated that while operating the vehicle, the message that the engine oil level was low was displayed. The contact stated that oil was added to the engine; however, the next day the message reoccurred. The contact stated that later while the vehicle was parked, the contact discovered an oil leak underneath the vehicle. The vehicle was driven to the local mechanic who confirmed oil leaking from the engine, but the cause of the oil leak was not yet determined. The local dealer was contacted, and a service appointment was scheduled. The cause of the failure was not yet determined, and the vehicle was not yet repaired. The manufacturer was not contacted about the failure. The failure mileage was 96,600.

POWER TRAIN

One of the cylinder heads on the back portion of the motor cracked, leaking oil down into the engine compartment. I didn't realize this was an issue until I got a warning about low oil. I went and got an oil change and within 2 days I had the low oil warning again. I had no other warnings that this was going on. This creates a potentially dangerous situation with people leaking oil onto roads and highways unknowingly. It was inspected by Mazda and confirmed to be the issue. There is currently a TSB from Mazda about it. But my car wasn't included in it. TSB 01-002/23

POWER TRAIN

Just got diagnosed with cracked cylinder head. After looking on social media, it appears this is a thing for the model years 2018 and 2019. Bad casting? Anyway I believe this should be a voluntary recall to correct such a flawed engine. I bought this new from a Mazda dealership and kept it up to date with service only through the dealer. The 60 month/60,000 mile drive train warranty ran out last July. However I only have 50,000 miles on the car...babied.

ENGINE

Just got diagnosed with cracked cylinder head. After looking on social media, it appears this is a thing for the model years 2018 and 2019. Bad casting? Anyway I believe this should be a voluntary recall to correct such a flawed engine. I bought this new from a Mazda dealership and kept it up to date with service only through the dealer. The 60 month/60,000 mile drive train warranty ran out last July. However I only have 50,000 miles on the car...babied.

ENGINE

At 30,000 miles car began leaking oil severely and was told that the engine block was cracked and needed to be replaced. There are numerous complaints of this same issue online happening just after the warranty has expired. The cost of repair is $6000.

ENGINE

Unknown. Ticking noise on engine.

ENGINE

The engine cylinder head cracked before the vehicle hit 50,000 miles. This caused oil to leak and burn in the engine compartment, leading to a burning smell coming into the cabin. Once enough oil had been lost, I got a low oil pressure light. I immediately pulled over and noticed white smoke was coming out from under my hood, and the smell of burning oil was quite strong. The problem has been confirmed by my mazda dealer. The vehicle has not been inspected by manufacturer, police, insurance. Just the dealer. The vehicle is currently at the dealer, and the cylinder head would need to be removed for inspection if requested. The smell of burning oil was the only early symptom, though I did not recognize it at the time.

ENGINE

The contact owns a 2019 Mazda CX-5. The contact stated that while driving up on incline at 45 MPH, the engine shut off with the check engine warning light flashing on the instrument panel. Despite the failure, the contact was able to pull the vehicle off to the shoulder of the road. Due to the failure, the vehicle was towed to the residence. The following day the vehicle was towed to an independent mechanic; however, the mechanic was unable to duplicate the failure. The mechanic replaced the spark plugs and the ignition coil. The mechanic referred the contact to the dealer for additional assistance. The contact drove the vehicle to the dealer with an abnormal rumbling sound coming from the vehicle. While at the dealer, the dealer was unable to determine the cause of the failure. The contact was provided an estimate for repairs unrelated to the failure. The manufacturer was notified of the failure and provided a case number. The vehicle was not repaired. The failure mileage was a 129,000.

UNKNOWN OR OTHER

The Mazda Connect screen has ghost touch issues. The screen randomly presses buttons while the vehicle is in motion. The most dangerous component is when it changes the lighting to nighttime during the day causing me to be unable to see my screen during the daytime. It also repeatedly skips music, changes the screen while the gps is on, and constantly presses random buttons and disturbs me while I'm driving the vehicle. This is a known issue amongst many Mazda models that they have yet to fix and it is highly distracting.

ENGINE

Valve cover develops crack causing significant loss of oil resulting in seizing of engine with the potential of serious accident and potential loss of life.

ELECTRICAL SYSTEM

This is a complete electrical system failure. My screen continues scroll All Systems fails. At least it is not draining the battery again. I have had to replace the battery 2 times in the last 6 months. Maybe CarMax sold me a "lemon". . I received a recall notice, however when I spoke with the service department at the Bob Mazda dealership in Carlsbad and they told me that the recall on my vehicle is closed. I can come in for repairs, but at my own expense. I have only owned this vehicle for 6 months in which 2 months I was in the hospital recovering from a major surgery. When I get in my car and start it, if it starts the "blue" light is on every time, which is apparently Thermostat. After about 20 minutes or so the light turns off, sometimes 30 minutes. The next part is the scrolling malfunctions. It lists about everything on the car. I am [XXX] and live in Baja. I live in a very safe, gated with a security guard neighborhood, however I am scared of going any due to my car issues and being stranded. I also really need to cross the border to see my doctor but I am afraid. When you have to replace 2 batteries in 6 months and I have only driven under 5,000 since I purchased the car. Mazda needs to make me whole. My car also only has 24,000 and when I bought it had20,000 miles. There is something seriously wrong, actually multiple things are wrong with my 2019 Mazda. A person should never be afraid to get in the vehicle due to safety issues. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

ELECTRICAL SYSTEM

While driving, the infotainment screen went crazy! It randomly changed screens rapidly, and the navigation voice started talking loudly about changing volume level, and repeatedly. Very distracting and dangerous.

ENGINE

I had my vehicle looked at and found a cracked cylinder head on #3 and did some research of people having the same issues. I was driving when the vehicle started smoking it turns out the oil coming out of cylinder #3 flows down the driver and passenger side behind the exhaust manifold which can lead to a fire. My car only has a little over 80,000 miles and this should not happen around that low of a mile vehicle. I believe this is an issue that needs attention.

ENGINE AND ENGINE COOLING

The contact owns a 2019 Mazda CX-5. The contact stated that while the vehicle was parked, the contact discovered an abnormal odor coming from the engine compartment. No warning light was illuminated. The vehicle was taken to a dealer, where it was diagnosed that there was a cracked cylinder head and that the cylinder head needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 26,000.

ENGINE

The contact owns a 2019 Mazda CX-5. The contact stated that while the vehicle was parked, the contact discovered an abnormal odor coming from the engine compartment. No warning light was illuminated. The vehicle was taken to a dealer, where it was diagnosed that there was a cracked cylinder head and that the cylinder head needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 26,000.

ENGINE

Cracked cylinder head. Major oil leak. Oil light came on but then turned off. No other warning light. No engine light came on. The vehicle was taken to the dealer for diagnosis.

ENGINE

The cylinder head in the engine cracked while I was driving. The vehicle was leaking oil profusely and was down a quart after the oil had been changed the week prior. There were no warning lights or indication and I had just had the vehicle in the dealership the week before. I'm a disabled driver that requires hand controls so if I needed to exit the vehicle and move away from it it would not be possible. It's been at the dealership since 2/24/25. I have found numerous other people that have experienced the same issue online.

UNKNOWN OR OTHER

With only 60k miles on my car which I regularly take in for maintenance, my car started to leak a ton of oil. It was determined that the cylinder head is cracked. This should not happen on a car this new and maintained. In doing research, this seems to be a common occurrence with this year.

POWER TRAIN

On [XXX], I was the operator of a 2019 Mazda CX-5 in Los Angeles, California. I parked the vehicle on an incline on or around [XXX] in Los Angeles, California, and then exited the vehicle. The vehicle remained stationary for some time, until it suddenly began rolling backwards at a speed that pushed me to the ground while I was getting my things from the passenger side door, causing me serious injuries. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

ELECTRICAL SYSTEM

On [XXX], I was the operator of a 2019 Mazda CX-5 in Los Angeles, California. I parked the vehicle on an incline on or around [XXX] in Los Angeles, California, and then exited the vehicle. The vehicle remained stationary for some time, until it suddenly began rolling backwards at a speed that pushed me to the ground while I was getting my things from the passenger side door, causing me serious injuries. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

SERVICE BRAKES

On [XXX], I was the operator of a 2019 Mazda CX-5 in Los Angeles, California. I parked the vehicle on an incline on or around [XXX] in Los Angeles, California, and then exited the vehicle. The vehicle remained stationary for some time, until it suddenly began rolling backwards at a speed that pushed me to the ground while I was getting my things from the passenger side door, causing me serious injuries. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

ENGINE

The cylinder head on my 2019 Mazda CX-5 failed prematurely due to a known defect. The vehicle is currently at Fred Beans Mazda in Mechanicsburg, PA, where the issue has been diagnosed and confirmed. The defective component is available for inspection upon request. This failure created a serious safety risk due to an oil leak, which led to smoking from the engine bay and a potential fire hazard. If the oil had ignited, this could have caused severe vehicle damage or injury. Additionally, the failure could lead to a sudden loss of power while driving, increasing the risk of an accident. The problem has been reproduced and confirmed by the dealership, and Mazda has been contacted regarding assistance. They have acknowledged the issue but have not provided full coverage for the repair. Prior to the failure, there were no warning lights or messages. The only symptom was an oil leak, which led to smoke coming from the engine. This issue appears to be a common problem with this model, and Mazda should take responsibility for addressing it properly before it causes serious harm.

ENGINE

This concerns a 2019 Mazda CX5 with approximately 52,000 miles - the engine of this vehicle is the 2.5L naturally aspirated version. Driving the vehicle with the HVAC system on resulted in a burning oil smell coming through to the cabin. Upon owner inspection, engine oil was seen as coating the underside of the vehicle in various areas. The oil pan drain plug and oil filter were both found to be tight and not leaking oil. The vehicle was taken to a nearby Mazda dealership for inspection on 2/26/2025. On 2/27/2025, Mazda technicians state that the cylinder head on the vehicle engine requires replacement. Replacement is quoted to be in excess of $5000. Reviewing the issue online shows numerous similar cases of engine cylinder head failure. This vehicle comes equipped with cylinder deactivation which seems to have a higher rate of failure regarding cylinder heads and a potential design flaw with cylinder heads manufactured in a time frame of 2018-2020. Leaking oil could potentially start a fire as the oil drips onto the exhaust manifold when the car is at operating temperature.

ENGINE

While driving the vehicle, I started smelling a burning smell about 10 days ago (2/17). I also felt a slightly reduced engine performance and could see the car emitting smoke from the engine bay. I had no warning lights on my dash. For all I know, the engine could've blown while I was driving on the road. Upon taking the vehicle to the dealership 2 days ago (2/25), they informed that my car has a cracked cylinder head, and there was no apparent reason why this would happen. The vehicle has only been inspected by the dealership thus far and I was quoted $5,700 to fix the issue. Upon looking up the problem, I see this is a common issue, with many having experienced it before, but no TSBs issued for this. There is a CSP issued for vehicles of the same year, but limited to the Turbo version on the engine. Unfortunately, I do not have any warranty on the car currently.

UNKNOWN OR OTHER

The infotainment system within the Mazda has a variety of issues. 1. Its CarPlay system is extremely slow to connect to the mobile device via a USB. 2. 'Mobile Device Error' message pops-up frequently and disconnects the infotainment system from the mobile device. 3. 'Ghost Touch' occurs when driving under 20 mph. The screen fritz's out, will randomly press buttons, turn settings on and off, and there is no control over it. 4. Screen freezes. System and screen will either lag extremely slowly, or will freeze entirely. In sum, these issues are not only annoying but also a safety concern. It is extremely distracting for this to happen while you are operating the vehicle. Furthermore, it suddenly removes your mapping/navigation directions that you might be using.

ELECTRICAL SYSTEM

The infotainment system within the Mazda has a variety of issues. 1. Its CarPlay system is extremely slow to connect to the mobile device via a USB. 2. 'Mobile Device Error' message pops-up frequently and disconnects the infotainment system from the mobile device. 3. 'Ghost Touch' occurs when driving under 20 mph. The screen fritz's out, will randomly press buttons, turn settings on and off, and there is no control over it. 4. Screen freezes. System and screen will either lag extremely slowly, or will freeze entirely. In sum, these issues are not only annoying but also a safety concern. It is extremely distracting for this to happen while you are operating the vehicle. Furthermore, it suddenly removes your mapping/navigation directions that you might be using.

EQUIPMENT:ELECTRICAL:INFOTAINMENT:VIDEO (TOUCH)SCREEN/MONITOR/UNIT

The contact's daughter owns a 2019 Mazda CX-5. The contact stated that while her daughter was driving at undisclosed speeds, the Mazda Connect Center Display touch screen was operating independently, causing vehicle functions to be engaged unintendedly. The contact was concerned for her daughter's safety because the center display functions included safety lane departure warning, blind spot monitoring, and traffic sign recognition safety functions. The contact related the failure to Mazda Special Service Program (SSP) Number: B6. The dealer and the manufacturer were notified of the failure. The vehicle was not diagnosed or repaired. The failure mileage was approximately 30,000.

UNKNOWN OR OTHER

Center multimedia display malfunctioning by ghost touching. Without using the commander switch, touch panel, or voice recognition, the screen will scroll through settings, apps, change radio stations, etc. Additionally, it will turn off maps in Apple Play when the program is in use. There are several complaints and examples of this issue online: [XXX] This concern needs to be addressed because it is safety issue as it is a major distraction for the driver. Service appointment with Westcott Mazda on 2/10. Originally brought in 1/28 for appointment, but was advised by Mazda service representative to contact Mazda as car is out of warranty. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

UNKNOWN OR OTHER

I hope this message finds you well. My name is [XXX] , and I am the owner of a 2019 Mazda CX-5 purchased as part of the Certified Pre-Owned (CPO) program. I am writing to formally address two concerning issues related to my vehicle’s warranty coverage and its safety. 1. Warranty Coverage for Drive Belt Tensioner: During a recent visit to your dealership, I was informed that the drive belt tensioner on my vehicle is not covered under the warranty. This contradicts the coverage listed on your official Mazda CPO Warranty, which specifies that the Limited Powertrain Warranty includes the engine, timing chain, tensioner, and associated components. The drive belt tensioner is clearly referenced in this section, yet I was told it falls under wear and tear and is not covered. I kindly request a detailed explanation regarding this discrepancy. I believe the information I was given does not align with the warranty’s stated coverage, and I am concerned that the dealership is not honoring the terms of the warranty as outlined on your website. 2. Ongoing Noise Issue: Additionally, my vehicle has been making an unusual noise, which I reported during my visits to two separate Mazda dealerships. Unfortunately, despite multiple attempts to diagnose the issue, neither dealership has been able to identify the source of the noise. This situation has left me feeling unsafe while operating the vehicle, as I am unsure of its origin or potential impact on my vehicle’s performance or safety. I would appreciate it if you could escalate this matter and offer assistance in determining the cause of the noise, as well as ensure that all components of the vehicle are functioning properly. The lack of resolution is not only inconvenient but also concerning from a safety perspective. Request for Resolution: I trust that Mazda values its customers and will make every effort to resolve these issues in a timely manner. I respectfully request that the drive belt tensioner be covered und INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMA

ENGINE

I hope this message finds you well. My name is [XXX] , and I am the owner of a 2019 Mazda CX-5 purchased as part of the Certified Pre-Owned (CPO) program. I am writing to formally address two concerning issues related to my vehicle’s warranty coverage and its safety. 1. Warranty Coverage for Drive Belt Tensioner: During a recent visit to your dealership, I was informed that the drive belt tensioner on my vehicle is not covered under the warranty. This contradicts the coverage listed on your official Mazda CPO Warranty, which specifies that the Limited Powertrain Warranty includes the engine, timing chain, tensioner, and associated components. The drive belt tensioner is clearly referenced in this section, yet I was told it falls under wear and tear and is not covered. I kindly request a detailed explanation regarding this discrepancy. I believe the information I was given does not align with the warranty’s stated coverage, and I am concerned that the dealership is not honoring the terms of the warranty as outlined on your website. 2. Ongoing Noise Issue: Additionally, my vehicle has been making an unusual noise, which I reported during my visits to two separate Mazda dealerships. Unfortunately, despite multiple attempts to diagnose the issue, neither dealership has been able to identify the source of the noise. This situation has left me feeling unsafe while operating the vehicle, as I am unsure of its origin or potential impact on my vehicle’s performance or safety. I would appreciate it if you could escalate this matter and offer assistance in determining the cause of the noise, as well as ensure that all components of the vehicle are functioning properly. The lack of resolution is not only inconvenient but also concerning from a safety perspective. Request for Resolution: I trust that Mazda values its customers and will make every effort to resolve these issues in a timely manner. I respectfully request that the drive belt tensioner be covered und INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMA

ENGINE

Oil started leaking while car was idling causing smoke to enter the cabin as well as all under the hood. Car was undriveable at this point. She was lucky there was no traffic. Car had to be towed and cylinder head was cracked. Mazda has a known faulty cylinder head problem they have refused to fix and this caused a safety issue. Vehicle will not be able to be inspected as we had it towed to get fixed immediately. The service center did confirm this is the issue and there were no prior issues before this.

FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING

Car will slam on brakes even if car is in opposite lane farther away. We have received sooo many chips amd cracks on windshield with 2 weeks. We purchased used and was informed windshield was replaced once already.

VISIBILITY/WIPER

Car will slam on brakes even if car is in opposite lane farther away. We have received sooo many chips amd cracks on windshield with 2 weeks. We purchased used and was informed windshield was replaced once already.

ENGINE

As I was driving, a burning smell emanated from the car. There were no check engine lights on. When I pulled over, I saw a lot of smoke coming from the engine. I checked the oil level and it was above the minimum line bit just barely, even though my husband had just done an oil change on it. I refilled the oil and continued on my trip. The problem repeated for several dqays until I got home and took it to the Mazda dealership. They reported the following: "Cylinder Head Assembly: oil leaking out of back of head, recommend replacing cylinder head and related gaskets. The cylinder head sits above the cylinders on top of the cylinder block. It closes in the top of the cylinder, forming the combustion chamber. This joint is sealed by a head gasket. In most engines, the head also provides space for the passages that feed air and fuel to the cylinder, and that allow the exhaust to escape." This service is $5600! My car only has 80K miles on it. This is a safety issue because there was no warning. No check engine light appeared and there was no warning.

ENGINE

I own a 2019 Mazda cx 5 and it has 78,000 miles. I noticed smoke coming from the engine and a lot of oil leaking on the ground. I brought the car into my independent service center and they confirmed that there was a crack in the engine cylinder head. There is a TSA # SA-031-21 on this problem. I feel that my safety was at risk, since the engine could have seized while driving. This vehicle is available for inspection upon request. No warning lamps or messages were displayed, however there was a strong odor of burning oil. This problem occurred on 1/9/25 and it has been in the service center since.

FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING

Good afternoon. I am reporting an incident that occurred on December 29, 2024. I was driving my 2019 Mazda Cx-5 and I was about to make a left turn. However, as I was making the left turn, I received a notification on my dashboard about a "Forward Smart City Brake Support Malfunction" (a photo of the notification will be included). My car instantly lost control and it did not stop until it collided with the street curb of the road I was attempting to turn on. Fortunately for those around me, my car did not collide with any other vehicles on the road. However, this collision caused damage to the right side of the vehicle, as the right airbag of the vehicle had deployed. I believe that this is a very significant problem that should be looked into as soon as possible. If my car were to hit other drivers on the road, it could have led to a very tragic incident. As far as repairs go, I wanted to wait and see how this complaint would carry out. I do not believe that it would be fair for me to pay repairs for an event that was out of my control. Thank you.

UNKNOWN OR OTHER

Good afternoon. I am reporting an incident that occurred on December 29, 2024. I was driving my 2019 Mazda Cx-5 and I was about to make a left turn. However, as I was making the left turn, I received a notification on my dashboard about a "Forward Smart City Brake Support Malfunction" (a photo of the notification will be included). My car instantly lost control and it did not stop until it collided with the street curb of the road I was attempting to turn on. Fortunately for those around me, my car did not collide with any other vehicles on the road. However, this collision caused damage to the right side of the vehicle, as the right airbag of the vehicle had deployed. I believe that this is a very significant problem that should be looked into as soon as possible. If my car were to hit other drivers on the road, it could have led to a very tragic incident. As far as repairs go, I wanted to wait and see how this complaint would carry out. I do not believe that it would be fair for me to pay repairs for an event that was out of my control. Thank you.

SERVICE BRAKES

Good afternoon. I am reporting an incident that occurred on December 29, 2024. I was driving my 2019 Mazda Cx-5 and I was about to make a left turn. However, as I was making the left turn, I received a notification on my dashboard about a "Forward Smart City Brake Support Malfunction" (a photo of the notification will be included). My car instantly lost control and it did not stop until it collided with the street curb of the road I was attempting to turn on. Fortunately for those around me, my car did not collide with any other vehicles on the road. However, this collision caused damage to the right side of the vehicle, as the right airbag of the vehicle had deployed. I believe that this is a very significant problem that should be looked into as soon as possible. If my car were to hit other drivers on the road, it could have led to a very tragic incident. As far as repairs go, I wanted to wait and see how this complaint would carry out. I do not believe that it would be fair for me to pay repairs for an event that was out of my control. Thank you.

ENGINE

Car was purchased in June 2019. Car started smelling like burning oil and started finding oil pooling under the car around November 2024. At time the incident was discovered, car only had 38k miles. There was no warning lights or indication there was an issue other than the smell and small pool of oil under car. The Mazda service manager immediately knew what the issue was and told me they were going to confirm with a full inspection and diagnosis. I was told that I have a cracked cylinder head and I will need to have it replaced. Warranty ended few months prior so they will not cover. I was told it would cost $4589.76. The Mazda service department told me that this is a common issue and to hold off on repair and contact Mazda corporate since warranty just ended. They topped off my oil and told me to keep an eye on the oil level and to wait to hear back from Mazda corporate.I submitted a case with Mazda and the customer care specialist told me that they cannot guarantee they will cover this. Within a week, the temperatures got colder and issue got worse. Low oil light came on, topped off with oil. Lost 4 quarts in one day. Called Mazda service and they told me to top off oil and come drop car off immediately. Upon researching this issue, the cracking of cylinder heads in Mazda CX-5 vehicles, particularly those with the 2.5-liter (NA) engine were widespread and discussed in online forum. The contributing factors of the issue point to a design flaw of the cylinder head due to the cylinder deactivation technology and a manufacturing defect due to the cylinder head casting process based on reports and discussions within the automotive community. A TSB (SA-013/22) has been released for the affected cylinder head with a modified replacement. This seems to be a significant and widespread issue that can cause entire engine to fail and require full replacement. Oil leaking on to the hot exhaust near other engine parts could ignite and put myself or others at risk.

ENGINE

Engine block cracked, passenger cabin filled with noxious odder. Vehicle was suddenly leaking oil at high rate.