LINCOLN AVIATOR

BACK OVER PREVENTION:SOFTWARE

Ford Motor Company (Ford) is recalling certain 2018-2022 Transit Connect, 2019-2020 MKZ, Edge, Continental, F-150, Nautilus, Fusion, 2019-2023 Ranger, Mustang, 2020-2021 EcoSport, Expedition, Navigator, 2020-2022 Escape, F-250 SD, Corsair, 2020-2023 Aviator, Transit, 2020-2024 Explorer, 2021-2024 Bronco Sport, and 2022-2024 Maverick vehicles. A software error may cause the rearview camera to display a blank image, or the image may remain on the display after the backing event has ended.

Risk: A rearview camera that displays a blank image can reduce the driver's view behind the vehicle. A rearview image that continues to be displayed after the vehicle is shifted out of reverse may distract the driver. Both of these situations can increase the risk of a crash.

SEATS:MID/REAR ASSEMBLY

Ford Motor Company (Ford) is recalling certain 2020-2025 Aviator, and Explorer vehicles. The switch for the easy-entry second-row outer seats may bind or stick, resulting in the seats unlatching, folding, or sliding unexpectedly while driving.

Risk: A seat that moves unexpectedly may not properly restrain an occupant during a crash, increasing their risk of injury.

SEAT BELTS:FRONT:WARNING LIGHT/DEVICES

Ford Motor Company (Ford) is recalling certain 2020-2023 Lincoln Aviator and Lincoln Corsair vehicles equipped with a Revel Audio System that were repaired incorrectly under recall 22V-953. When the driver's seat belt is not buckled and the vehicle is started, the seat belt warning system may activate the audible warning chime for an insufficient amount of time of less than 4 seconds. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."

Risk: An audible warning chime that does not properly alert of an unbelted seat belt can increase the risk of injury during a crash.

EXTERIOR LIGHTING:TAIL LIGHTS

Ford Motor Company (Ford) is recalling certain 2025 Explorer and Aviator vehicles. When towing a trailer, the tail lights on the trailer may fail to illuminate due to an improperly manufactured body control module. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, " Lamps, Reflective Devices, and Associated Equipment."

Risk: Trailer tail lights that do not illuminate as intended can reduce visibility to other drivers, increasing the risk of a crash.

FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP

Ford Motor Company (Ford) is recalling certain 2021-2023 Bronco, Explorer, Lincoln Aviator, F-250 SD, F-350 SD, F-450 SD, F-550 SD, 2021-2022 Lincoln Navigator, Mustang, F-150, and 2022 Expedition vehicles. The low-pressure fuel pump may fail, which can result in an engine stall while driving.

Risk: An engine stall increases the risk of a crash.

STRUCTURE:FRAME AND MEMBERS

Ford Motor Company (Ford) is recalling certain 2025 Ford Explorer and Lincoln Aviator vehicles. The transmission may be improperly secured due to loose cross member bolts.

Risk: An improperly secured transmission can result in a loss of drive power, increasing the risk of a crash.

STRUCTURE:BODY

Ford Motor Company (Ford) is recalling certain 2020-2025 Aviator vehicles. The rear door window bars and C-pillar trim may have insufficient adhesive bonding, which can allow the trim to detach from the vehicle.

Risk: Detached trim may cause a road hazard and increase the risk of a crash.

VISIBILITY:POWER WINDOW DEVICES AND CONTROLS

Ford Motor Company (Ford) is recalling certain 2025 Lincoln Aviator vehicles. When closing the windows with the global closing feature, the side rear windows may exert excessive force when encountering an object, before they automatically reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 118, "Power-Operated Window Systems."

Risk: A closing window that does not reverse direction as expected can pinch a passenger before retracting, increasing the risk of injury.

ELECTRICAL SYSTEM:PROPULSION SYSTEM:TRACTION BATTERY

Ford Motor Company (Ford) is recalling certain 2020-2021 Lincoln Aviator vehicles equipped with 3.0L PHEV engines that were repaired incorrectly under recall 23V626. A manufacturing defect in one or more of the high voltage battery cells may result in an internal short circuit and battery failure.

Risk: Battery failure can cause a loss of drive power, increasing the risk of a crash. Battery failure can also increase the risk of a fire.

POWER TRAIN

Axle shaft Seal no warning besides loud grinding noise. Electrical issues- causing speakers to not work and the lights coming on and going off. Then it causing the crash detection to not have sound.

ELECTRICAL SYSTEM

Axle shaft Seal no warning besides loud grinding noise. Electrical issues- causing speakers to not work and the lights coming on and going off. Then it causing the crash detection to not have sound.

VISIBILITY

See attached document for complaint.

ELECTRICAL SYSTEM

See attached document for complaint.

BACK OVER PREVENTION

See attached document for complaint.

STRUCTURE:BODY

No one was in the back seat when this happened. The back passenger door flung open while driving down the road. Immediately pulled off the road and it would not latch! Drove immediately to the dealership and got a loaner. Dealership stated it was the latch and repaired in a day or two.

STRUCTURE:BODY

My 2021 Lincoln Aviator PHEV lift gate safety stop does not function properly. It will come closing down extremely hard. This will happen when the button is pressed on the lift gate or the hands free feature is triggered. The lift gate will not safety stop and pop back open as it should unless a significant amount of force is used; this is usually 2 or more people trying with all their strength to stop it from closing on them. I have been hurt by this and so has my child. This is a serious safety issue. I have included screenshots from the video (the system won’t let me send the video) I took replicating the issue with it completely crushing a box at the height of my head.

ELECTRICAL SYSTEM

My 2021 Lincoln Aviator PHEV lift gate safety stop does not function properly. It will come closing down extremely hard. This will happen when the button is pressed on the lift gate or the hands free feature is triggered. The lift gate will not safety stop and pop back open as it should unless a significant amount of force is used; this is usually 2 or more people trying with all their strength to stop it from closing on them. I have been hurt by this and so has my child. This is a serious safety issue. I have included screenshots from the video (the system won’t let me send the video) I took replicating the issue with it completely crushing a box at the height of my head.

SERVICE BRAKES

My 2021 Lincoln Aviator grand touring PHEV has on 3 separate occasions randomly gone into “brick” mode where power is to some components like the Sync screen, and some lights, but main dash won’t boot, the lock/unlock doesn’t work but lock icon flashes on door panel, the vehicle won’t start. This is after short trips out with my family for the evening. Not a fob issue. All 3 times the same. First occurrence at just over 11,000 miles, again in Sept 2023, and happening again June 2025. Roadside assistance dispatches tow trucks, the vehicle can never be jump started. Electric parking brake is engaged and will not disengage even when manually put in neutral. Always takes dispatching several different tow trucks to get one equipped with skates to drag the vehicle on to a flatbed tow truck, or old school wheel lift truck to be able to tow the vehicle since the electric parking brake will not disengage in this situation. Last time this happened it took 6 separate trucks to come out over 3 days to find one that could tow it in metro Detroit, the heart of the auto industry. This is a defect in the system of my vehicle that poses a safety issue because it prevents a regular tow truck from being able to tow this vehicle. I have had the dealership look at it many times, there is no fix, tech says it is a defect. Each time I have reported it to the Lincoln Customer Experience Center, they don’t care enough to do anything. Not sure how to get help but I’m probably not the only one with this safety defect. There are other safety issues. The safety stop for the lift gate doesn’t always work and will hit you hard without stopping for an obstruction. I also have acceleration hesitation when stopped and turning in traffic, risk for accident. The electrical problems with my Aviator are endless but leaving me stranded with my children and unable to easily get help is a serious problem and unacceptable. Please let me know how you can help. Sincerely a concerned mother of 2 little boys.