2023 KIA SORENTO

BACK OVER PREVENTION: SENSING SYSTEM: CAMERA

Kia America, Inc. (Kia) is recalling certain 2022-2023 Sorento, Sorento Hybrid, and Sorento Plug-in Hybrid (PHEV) vehicles. The mounting clips for the rearview camera may break, which can cause the rearview camera image not to appear properly on the display. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."

Risk: A rearview camera that does not properly display an image can reduce the driver's rear view, increasing the risk of a crash.

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:ROTOR

The contact owns a 2023 Kia Sorento. The contact stated that while driving 55 MPH or higher, the vehicle was vibrating abnormally. The contact stated that while depressing the brake pedal, the brakes seized with an abnormal sound coming from the brakes. The vehicle was taken to the dealer, and the contact was informed that the vehicle was included in an undisclosed recall related to rotors, and the rotors were replaced under the recall. However, approximately 2 months after the repair, the failure reoccurred. The vehicle was returned to the dealer, and the contact was informed that the rotors had failed again and needed to be resurfaced. The dealer started to resurface the rotors, but the contact decided to stop the process. The contact researched and determined that rotors needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure. The failure mileage was approximately 12,000.

UNKNOWN OR OTHER

I was driving down the highway when the sunroof randomly exploded, there was no debris that hit the roof or damages to the roof prior.

POWER TRAIN

on [XXX], the check engine light came on solid. My car is just 2 years old, only has 22K miles, and is currently under warranty, as it is a leased vehicle. According to Auto Zone, it was a "speed sensor". On 7/25/25, I was able to get an appointment with Garvey Kia of Queensbury, NY and the fault code is the "input turbine shaft speed sensor B circuit range for performance". The service technician told me that it is not able to be accessed, as it is internal, and it is not serviceable. My safety and the safety of others were at risk because the car would go "limp" when accelerating, there was harsh and delayed shifting, erratic RPM readings, and no power when accelerating. This inability to accelerate causes problems in traffic and when trying to get through intersections or out of side streets when acceleration is imperative. Yes, the car has been inspected by the Kia dealership. This same exact thing happened on [XXX], in which Destination Kia of Albany had by car for over 4 weeks to replace the transmission. At that time, the car had under 10K miles and was not even a year old. At that time, they put a refurbished transmission into the car. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

VISIBILITY:SUN/MOON ROOF ASSEMBLY

Front panel of panoramic sunroof shattered while driving on Interstate 90 at approx 65mpg. Sunroof was fully closed. Exploded on its own with no outside influence. Conditions were clear and dry. Sounded like a gun shot and glass was flying everywhere. Fortunately shade was closed with no glass entering passenger compartment. Could have resulted in injuries or accident if glass entered the driving inside area.

STRUCTURE:BODY

Front panel of panoramic sunroof shattered while driving on Interstate 90 at approx 65mpg. Sunroof was fully closed. Exploded on its own with no outside influence. Conditions were clear and dry. Sounded like a gun shot and glass was flying everywhere. Fortunately shade was closed with no glass entering passenger compartment. Could have resulted in injuries or accident if glass entered the driving inside area.

FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL

6/22/24-Initial start of dashboard light "miscommunication"-Codes could not be duplicated at Evans Kia dealership 7/11/24-Miscommunication occurs again-Codes pulled for diagnostics 7/22/24-Car brought in for scheduled appointment to dealership to "fix" communication errors: I was told "There was an issue with the system not updating but I should be good to go now" 2/17/25-Communication errors reappear on dash-Car taken back to dealership; Tech line case opened; Dashboard Cluster Replaced; Car given back to customer 3/20/25-Lemon Law Case filed: Determined past mileage window-Given $3000 settlement for my trouble 6/23/25-Miscommunication reappears on dash: Car taken back to dealership; Tech line case opened; Replaced Steering Column Assembly-Car given back to customer Customer files complaint with Kia Customer Affairs 6/30/25-Miscommunication reappears on dash: Car taken back to dealership; Numerous codes read from diagnostic-Tech line case opened-Front windshield camera is ready "overheating"-Tech line advises for the the camera to be replaced; Car not given back to customer and tech authorized to test drive 7/07/25-Customer informed miscommunication reappeared on dash; Tech line contacted and additional repairs pending their advice 7/15/25-Field Tech scheduled to come to Evans Kia dealership 7/24/25 "The safety of both myself and my children has been repeatedly compromised. No representative within Kia's organization has been able to provide assurance that, when all dashboard warning lights illuminate, the vehicle will not experience a complete malfunction. As a result, I no longer feel safe operating the vehicle. In July 2025, I formally requested that Kia Corporate initiate a buyback of the vehicle, rather than returning it to me following another attempted repair."

LANE DEPARTURE: ASSIST

6/22/24-Initial start of dashboard light "miscommunication"-Codes could not be duplicated at Evans Kia dealership 7/11/24-Miscommunication occurs again-Codes pulled for diagnostics 7/22/24-Car brought in for scheduled appointment to dealership to "fix" communication errors: I was told "There was an issue with the system not updating but I should be good to go now" 2/17/25-Communication errors reappear on dash-Car taken back to dealership; Tech line case opened; Dashboard Cluster Replaced; Car given back to customer 3/20/25-Lemon Law Case filed: Determined past mileage window-Given $3000 settlement for my trouble 6/23/25-Miscommunication reappears on dash: Car taken back to dealership; Tech line case opened; Replaced Steering Column Assembly-Car given back to customer Customer files complaint with Kia Customer Affairs 6/30/25-Miscommunication reappears on dash: Car taken back to dealership; Numerous codes read from diagnostic-Tech line case opened-Front windshield camera is ready "overheating"-Tech line advises for the the camera to be replaced; Car not given back to customer and tech authorized to test drive 7/07/25-Customer informed miscommunication reappeared on dash; Tech line contacted and additional repairs pending their advice 7/15/25-Field Tech scheduled to come to Evans Kia dealership 7/24/25 "The safety of both myself and my children has been repeatedly compromised. No representative within Kia's organization has been able to provide assurance that, when all dashboard warning lights illuminate, the vehicle will not experience a complete malfunction. As a result, I no longer feel safe operating the vehicle. In July 2025, I formally requested that Kia Corporate initiate a buyback of the vehicle, rather than returning it to me following another attempted repair."

FORWARD COLLISION AVOIDANCE: WARNINGS

6/22/24-Initial start of dashboard light "miscommunication"-Codes could not be duplicated at Evans Kia dealership 7/11/24-Miscommunication occurs again-Codes pulled for diagnostics 7/22/24-Car brought in for scheduled appointment to dealership to "fix" communication errors: I was told "There was an issue with the system not updating but I should be good to go now" 2/17/25-Communication errors reappear on dash-Car taken back to dealership; Tech line case opened; Dashboard Cluster Replaced; Car given back to customer 3/20/25-Lemon Law Case filed: Determined past mileage window-Given $3000 settlement for my trouble 6/23/25-Miscommunication reappears on dash: Car taken back to dealership; Tech line case opened; Replaced Steering Column Assembly-Car given back to customer Customer files complaint with Kia Customer Affairs 6/30/25-Miscommunication reappears on dash: Car taken back to dealership; Numerous codes read from diagnostic-Tech line case opened-Front windshield camera is ready "overheating"-Tech line advises for the the camera to be replaced; Car not given back to customer and tech authorized to test drive 7/07/25-Customer informed miscommunication reappeared on dash; Tech line contacted and additional repairs pending their advice 7/15/25-Field Tech scheduled to come to Evans Kia dealership 7/24/25 "The safety of both myself and my children has been repeatedly compromised. No representative within Kia's organization has been able to provide assurance that, when all dashboard warning lights illuminate, the vehicle will not experience a complete malfunction. As a result, I no longer feel safe operating the vehicle. In July 2025, I formally requested that Kia Corporate initiate a buyback of the vehicle, rather than returning it to me following another attempted repair."

UNKNOWN OR OTHER

Safety concern. Vehicle suddenly could not maintain highway speed; vehicle unexpectedly decelerated. We were forced to pull over on the shoulder of the freeway. We called 911 and officers came. Officer confirmed being stopped on the shoulder of a major freeway was a very dangerous situation. We had 3 adults and two sleeping children in the car. No warning signals in the vehicle prior to the incident.

UNKNOWN OR OTHER

The car is accelerating without anyone pressing down on the gas, not accelerating when our foot is on the gas, jerking unexplainably and the emergency brake warning is coming on when it has not been employed.

SERVICE BRAKES

The car is accelerating without anyone pressing down on the gas, not accelerating when our foot is on the gas, jerking unexplainably and the emergency brake warning is coming on when it has not been employed.

ELECTRICAL SYSTEM

The car is accelerating without anyone pressing down on the gas, not accelerating when our foot is on the gas, jerking unexplainably and the emergency brake warning is coming on when it has not been employed.

UNKNOWN OR OTHER

The car overheated while driving and my wife and daughter had to pull over to side of road. Engine Coolant was spilling everywhere. Car was towed to Raceway Kia in Freehold NJ. The dealer advised my wife that the radiator needs to be replaced and it was NOT covered under warranty. They claim that debris from the road must have damaged the radiator and therefore it was "third party damage". I searched the web for incidents and found that this ios a design problem in the Kia Sorrento. Their design causes the vulnerability to get damage to readaitor due to leaks. This should be recalled and redesigned before someone gets seriously injured as a result.

VISIBILITY/WIPER

Even though the dealership reports that safety recall 23V610 / SC280 for the mounting clip replacement was completed on 2/16/24, my rearview camera has just fell out of its housing, hanging by its wires, with the mounting clips laying broken in my driveway. My rearview camera is currently unusable; its taped up so that it is not just swinging by the wires. When I contacted my dealership, they are pretty sure they can get this work covered under the warranty, but they are not sure. And my VIN# is currently not pulling up any "Active Recalls". Either the clips they used to replace the previous clips were also bad, or the dealership didnt actually complete the work as reported.

ELECTRICAL SYSTEM

Even though the dealership reports that safety recall 23V610 / SC280 for the mounting clip replacement was completed on 2/16/24, my rearview camera has just fell out of its housing, hanging by its wires, with the mounting clips laying broken in my driveway. My rearview camera is currently unusable; its taped up so that it is not just swinging by the wires. When I contacted my dealership, they are pretty sure they can get this work covered under the warranty, but they are not sure. And my VIN# is currently not pulling up any "Active Recalls". Either the clips they used to replace the previous clips were also bad, or the dealership didnt actually complete the work as reported.

BACK OVER PREVENTION: REARVIEW SYSTEM BRAKING

Even though the dealership reports that safety recall 23V610 / SC280 for the mounting clip replacement was completed on 2/16/24, my rearview camera has just fell out of its housing, hanging by its wires, with the mounting clips laying broken in my driveway. My rearview camera is currently unusable; its taped up so that it is not just swinging by the wires. When I contacted my dealership, they are pretty sure they can get this work covered under the warranty, but they are not sure. And my VIN# is currently not pulling up any "Active Recalls". Either the clips they used to replace the previous clips were also bad, or the dealership didnt actually complete the work as reported.

ENGINE

Vehicle suddenly loses power while driving. Engine does not turn on, vehicle will run on battery until battery is dead, then putting the vehicle in park once stopped. Vehicle will not accelerate normally since the engine does not turn on. Only goes 10-20 mph. Lights on the dash come on, prompting to keep car on to charge the battery. No code is found when the vehicle is scanned. Dealerships can't seem to diagnose the issue. This is a safety concern when driving on busy roads or state highways at higher speeds.

POWER TRAIN

Vehicle suddenly loses power while driving. Engine does not turn on, vehicle will run on battery until battery is dead, then putting the vehicle in park once stopped. Vehicle will not accelerate normally since the engine does not turn on. Only goes 10-20 mph. Lights on the dash come on, prompting to keep car on to charge the battery. No code is found when the vehicle is scanned. Dealerships can't seem to diagnose the issue. This is a safety concern when driving on busy roads or state highways at higher speeds.

FUEL/PROPULSION SYSTEM

Vehicle suddenly loses power while driving. Engine does not turn on, vehicle will run on battery until battery is dead, then putting the vehicle in park once stopped. Vehicle will not accelerate normally since the engine does not turn on. Only goes 10-20 mph. Lights on the dash come on, prompting to keep car on to charge the battery. No code is found when the vehicle is scanned. Dealerships can't seem to diagnose the issue. This is a safety concern when driving on busy roads or state highways at higher speeds.

POWER TRAIN

Critical Issue: Gasoline leaks into engine. That causes increasing engine oil level significantly and mixed with engine oil. I dropped off me car (mileage: 11731) at Kia Pro in Glendale, CA on 5/1/2025 as soon as I confirmed that engine oil level exceeds the maximum (twice of max) and smelled Gasoline from the dipstick. The service advisor and a tech confirmed that the excessive engine oil level and gasoline smell. However, they refused to repair it under warranty because they don't see any physical leaks and error codes. In addition to that, they told me that the car is not good to drive as is because Gasoline is mixed with engine oil. In my opinion, this can cause critical powertrain failures or possible life-threatening damages if that initiates fire from engine. Car maintenance history: at 6312miles, 1 oil change change at Kia in Alhambra, CA I have attached the service receipt on 5/1 for your reference. That shows that the dealership confirmed the issue but they didn't try to resolve the issue.

FUEL/PROPULSION SYSTEM

Critical Issue: Gasoline leaks into engine. That causes increasing engine oil level significantly and mixed with engine oil. I dropped off me car (mileage: 11731) at Kia Pro in Glendale, CA on 5/1/2025 as soon as I confirmed that engine oil level exceeds the maximum (twice of max) and smelled Gasoline from the dipstick. The service advisor and a tech confirmed that the excessive engine oil level and gasoline smell. However, they refused to repair it under warranty because they don't see any physical leaks and error codes. In addition to that, they told me that the car is not good to drive as is because Gasoline is mixed with engine oil. In my opinion, this can cause critical powertrain failures or possible life-threatening damages if that initiates fire from engine. Car maintenance history: at 6312miles, 1 oil change change at Kia in Alhambra, CA I have attached the service receipt on 5/1 for your reference. That shows that the dealership confirmed the issue but they didn't try to resolve the issue.

ENGINE

Critical Issue: Gasoline leaks into engine. That causes increasing engine oil level significantly and mixed with engine oil. I dropped off me car (mileage: 11731) at Kia Pro in Glendale, CA on 5/1/2025 as soon as I confirmed that engine oil level exceeds the maximum (twice of max) and smelled Gasoline from the dipstick. The service advisor and a tech confirmed that the excessive engine oil level and gasoline smell. However, they refused to repair it under warranty because they don't see any physical leaks and error codes. In addition to that, they told me that the car is not good to drive as is because Gasoline is mixed with engine oil. In my opinion, this can cause critical powertrain failures or possible life-threatening damages if that initiates fire from engine. Car maintenance history: at 6312miles, 1 oil change change at Kia in Alhambra, CA I have attached the service receipt on 5/1 for your reference. That shows that the dealership confirmed the issue but they didn't try to resolve the issue.

SEAT BELTS

We were involved in a T-bone type accident at highway speeds. I am filing a complaint because I feel Kia Of America did not pursue potential safety issues with the seatbelts. I called them to inform them of the issue to see if there was any other similar trending reports. they stated that they would send an inspector out which they never did. I believe that the seatbelt failed due to the nature of my injuries and discussion with medical experts. I was sitting behind driver. The accident resulted in a fractured sternum and rib injuries, injuries to both of my shins and injury to my coccyx. Most significant is that there was no seatbelt bruising on my chest. All suggestive of hitting back of front seat.I have pix. Also, upon attempting to exit the vehicle post impact, the seatbelt was fully extended, as I got tangled up in it trying to exit. Also to note the driver’s seatbelt was fully extended also however they were protected by airbag deployment. The front and rear passenger seatbelts were not extended and those passengers had only minor injuries. My wife’s, the driver, injuries were much more serious and has resulted in permanent damage. I contacted Kia of America to report the concern and they assured me they would send an engineer out to provide an inspection. They had multiple months to do this, and I followed up multiple times as to the status of this inspection. During that time the car switched insurance carriers hands however there was ample time to perform the inspection. After a couple months, I followed up again and they informed me that the car was destroyed. I informed them that was not satisfactory and please escalate this. They did and a gentleman called me and left a voicemail. I returned his call 4 times and left voicemails but again no follow up. I feel that this attention to a potentially significant safety issue has been neglected and I ask you to further investigate. I have emails and timelines of conversations documented. Thank you.

FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL

All safety features disabled, srs light turns on, vehicle shuts off when driving, guage cluster is inop doesn’t show speed.

ENGINE

All safety features disabled, srs light turns on, vehicle shuts off when driving, guage cluster is inop doesn’t show speed.

ELECTRICAL SYSTEM

All safety features disabled, srs light turns on, vehicle shuts off when driving, guage cluster is inop doesn’t show speed.

VEHICLE SPEED CONTROL

Vehicles instrument cluster goes black at times ( speedometer, tach and all exterior lights and turn signals are inoperative during this time) I took it to the dealership and they said they couldn’t duplicate the problem

EXTERIOR LIGHTING

Vehicles instrument cluster goes black at times ( speedometer, tach and all exterior lights and turn signals are inoperative during this time) I took it to the dealership and they said they couldn’t duplicate the problem

ELECTRICAL SYSTEM

Vehicles instrument cluster goes black at times ( speedometer, tach and all exterior lights and turn signals are inoperative during this time) I took it to the dealership and they said they couldn’t duplicate the problem

UNKNOWN OR OTHER

The USB ports disconnect intermittently cause maps and phone calls to disconnect temporarily. Sometimes not connecting again until I turn off and on the car.

ELECTRICAL SYSTEM

The USB ports disconnect intermittently cause maps and phone calls to disconnect temporarily. Sometimes not connecting again until I turn off and on the car.

UNKNOWN OR OTHER

Vehicle gear slipping acceleration loss with difficulty in proper control of the vehicle. Vehicle has a consistent noise that comes from the accelerator as if something was loose and vibrating. The wheels don’t seem to be moving at the same time and feels like the cars slightly moves side to side as if something in the structure of the vehicle has como off loose with sounds/ rattle coming from the passenger side and back. The vehicle has have wheels aligned and checked more than 6 times with continuous problems and no real solution from the dealers. The dealer has stated everything is fine and to go back if a light sensor turns on. They have said every excuse possible, from telling me that I don’t know to drive the vehicle to having the cops called on me to be removed from the premises . To the dealership telling me they will not check the vehicle. I have gone to 5 different dealership and they refuse to acknowledge my concern with the vehicle. I went ahead and place the vehicle on a lemon law and settled with Kia stating they would validate the warranty. The problem is the dealership have told me that they have to do lots of paperwork and they have to replicate the problem, but have me drive the vehicle instead of them . They stated they only drive the vehicle for about five minutes. The service advisor at time have requested authorization from me inorder for them to drive the car. When asked for a mechanic to do the testing, Ive been told they are may no be available and are working on other vehicles.I have stated the vehicle starts presenting the problem after it has been driven for a while. Again the dealership dismisses all of my claims. The vehicle doesn’t feel safe to drive and I fear a collision may happen putting my life and others at risk.

LANE DEPARTURE: BLIND SPOT DETECTION

Vehicle gear slipping acceleration loss with difficulty in proper control of the vehicle. Vehicle has a consistent noise that comes from the accelerator as if something was loose and vibrating. The wheels don’t seem to be moving at the same time and feels like the cars slightly moves side to side as if something in the structure of the vehicle has como off loose with sounds/ rattle coming from the passenger side and back. The vehicle has have wheels aligned and checked more than 6 times with continuous problems and no real solution from the dealers. The dealer has stated everything is fine and to go back if a light sensor turns on. They have said every excuse possible, from telling me that I don’t know to drive the vehicle to having the cops called on me to be removed from the premises . To the dealership telling me they will not check the vehicle. I have gone to 5 different dealership and they refuse to acknowledge my concern with the vehicle. I went ahead and place the vehicle on a lemon law and settled with Kia stating they would validate the warranty. The problem is the dealership have told me that they have to do lots of paperwork and they have to replicate the problem, but have me drive the vehicle instead of them . They stated they only drive the vehicle for about five minutes. The service advisor at time have requested authorization from me inorder for them to drive the car. When asked for a mechanic to do the testing, Ive been told they are may no be available and are working on other vehicles.I have stated the vehicle starts presenting the problem after it has been driven for a while. Again the dealership dismisses all of my claims. The vehicle doesn’t feel safe to drive and I fear a collision may happen putting my life and others at risk.

FORWARD COLLISION AVOIDANCE: WARNINGS

Vehicle gear slipping acceleration loss with difficulty in proper control of the vehicle. Vehicle has a consistent noise that comes from the accelerator as if something was loose and vibrating. The wheels don’t seem to be moving at the same time and feels like the cars slightly moves side to side as if something in the structure of the vehicle has como off loose with sounds/ rattle coming from the passenger side and back. The vehicle has have wheels aligned and checked more than 6 times with continuous problems and no real solution from the dealers. The dealer has stated everything is fine and to go back if a light sensor turns on. They have said every excuse possible, from telling me that I don’t know to drive the vehicle to having the cops called on me to be removed from the premises . To the dealership telling me they will not check the vehicle. I have gone to 5 different dealership and they refuse to acknowledge my concern with the vehicle. I went ahead and place the vehicle on a lemon law and settled with Kia stating they would validate the warranty. The problem is the dealership have told me that they have to do lots of paperwork and they have to replicate the problem, but have me drive the vehicle instead of them . They stated they only drive the vehicle for about five minutes. The service advisor at time have requested authorization from me inorder for them to drive the car. When asked for a mechanic to do the testing, Ive been told they are may no be available and are working on other vehicles.I have stated the vehicle starts presenting the problem after it has been driven for a while. Again the dealership dismisses all of my claims. The vehicle doesn’t feel safe to drive and I fear a collision may happen putting my life and others at risk.

VEHICLE SPEED CONTROL

Was driving up a hill when the 'Auto-Off' light started flashing on the driver display. Car would not accelerate above 20mph. At the top of the hill, I switched gears to neutral and the car began operating as expected; however, the same behavior occurred again at the next hill. Pulled over and restarted the car. Car worked as expected after restart. This is dangerous. I was taking my daughter to school in morning rush hour traffic. We live in a very hilly area and I'm terrified to drive the car. I dropped it off at the dealership almost 2 weeks ago and they have yet to identify the issue. I do see similar complaints on this site so I'm hoping that you are investigating.

ELECTRICAL SYSTEM

Was driving up a hill when the 'Auto-Off' light started flashing on the driver display. Car would not accelerate above 20mph. At the top of the hill, I switched gears to neutral and the car began operating as expected; however, the same behavior occurred again at the next hill. Pulled over and restarted the car. Car worked as expected after restart. This is dangerous. I was taking my daughter to school in morning rush hour traffic. We live in a very hilly area and I'm terrified to drive the car. I dropped it off at the dealership almost 2 weeks ago and they have yet to identify the issue. I do see similar complaints on this site so I'm hoping that you are investigating.