2018 KIA SORENTO

TRAILER HITCHES

Kia America, Inc. (Kia) is recalling certain 2016-2022 Sorento, 2021-2022 Sorento Hybrid (HEV), 2022-2023 Sorento Plug-In Hybrid (PHEV), and 2017-2022 Sportage vehicles equipped with a tow hitch harness installed as original equipment, or purchased as an accessory through a Kia dealership. Debris and moisture accumulation on the tow hitch harness module printed circuit board (PCB) may cause an electrical short, which can result in a fire.

Risk: A fire while parked or driving can increase the risk of injury.

STEERING:COLUMN

Kia Motors America (Kia) is recalling certain 2018 Kia Sorento vehicles. The cowl crossbar that connects to the Motor Driven Power Steering (MDPS) steering column may be improperly welded, allowing the steering column to separate.

Risk: If the steering column separates, it can cause a loss of steering ability, increasing the risk of a crash.

ENGINE

KIA Sorento 2018 The vehicle experienced engine failure due to piston ring damage at approximately 111,500 miles. A Kia dealer diagnosed the issue with codes P0301 and P0304 and confirmed the engine requires full replacement. This creates serious safety concerns, including engine misfires, loss of power, and risk of stalling while driving.

UNKNOWN OR OTHER

The Vehicle emits a strong fuel odor: seems to be around the rear of vehicle & front engine compartment of vehicle. Seems the fuel system, both low & high pressure fuel pumps and their pipes channels are leaking to emit a strong fuel odor. Extreme high volatile combustion & fire risk! Remedy: the fuel system including both low & high pressure fuel pumps & their pipes channels need replaced with strong, better engineered components! A newer vehicle like this should not be having fuel system failures.

ENGINE

The Vehicle emits a strong fuel odor: seems to be around the rear of vehicle & front engine compartment of vehicle. Seems the fuel system, both low & high pressure fuel pumps and their pipes channels are leaking to emit a strong fuel odor. Extreme high volatile combustion & fire risk! Remedy: the fuel system including both low & high pressure fuel pumps & their pipes channels need replaced with strong, better engineered components! A newer vehicle like this should not be having fuel system failures.

FUEL/PROPULSION SYSTEM

The Vehicle emits a strong fuel odor: seems to be around the rear of vehicle & front engine compartment of vehicle. Seems the fuel system, both low & high pressure fuel pumps and their pipes channels are leaking to emit a strong fuel odor. Extreme high volatile combustion & fire risk! Remedy: the fuel system including both low & high pressure fuel pumps & their pipes channels need replaced with strong, better engineered components! A newer vehicle like this should not be having fuel system failures.

EXTERIOR LIGHTING:HEADLIGHTS:BULBS

The contact owns a 2018 Kia Sorento. The contact stated that while driving at an undisclosed speed, the headlights failed to function as intended. The contact, who was a retired certified mechanic, inspected the headlights and determined that the passenger's side headlight bulbs were blown. The contact then noticed a burning odor in the circuit board inside the headlight. The contact stated that the front passenger's side headlight bulbs were replaced twice within three months due to failure. In addition, the contact stated that an unknown manufacturer's recall was performed approximately two years prior, and the multi-function switch knob was replaced. The contact stated that the headlights were not replaced at the time. The manufacturer was not made aware of the failure. The failure mileage was unknown.

UNKNOWN OR OTHER

1. What component or system failed or malfunctioned, and is it available for inspection upon request? The engine misfired due to a broken valve in one of the cylinders. This failure occurred approximately two months after completing the scheduled 100,000-mile service at a Kia dealership. The affected parts (valve, cylinder components) should still be available for inspection by Kia or a third party. 2. How was your safety or the safety of others put at risk? The vehicle suddenly lost power and stalled in the middle of the highway while driving at normal speed. This created a dangerous situation where I could have been struck by oncoming traffic while trying to safely exit the roadway. 3. Has the problem been reproduced or confirmed by a dealer or independent service center? The issue was confirmed by a repair shop, which diagnosed the cause as a misfire due to a broken valve. I have service documentation of the diagnosis available. 4. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives, or others? The vehicle has not yet been inspected by the manufacturer or insurance representatives, but it was inspected by the servicing dealership and/or an independent mechanic who confirmed the valve failure. 5. Were there any warning lamps, messages, or other symptoms of the problem prior to the failure, and when did they first appear? Prior to the complete failure, the check engine light illuminated and the vehicle began running roughly (misfiring). These symptoms appeared very shortly before the breakdown, giving me no meaningful time to react before the engine stalled.

ENGINE

1. What component or system failed or malfunctioned, and is it available for inspection upon request? The engine misfired due to a broken valve in one of the cylinders. This failure occurred approximately two months after completing the scheduled 100,000-mile service at a Kia dealership. The affected parts (valve, cylinder components) should still be available for inspection by Kia or a third party. 2. How was your safety or the safety of others put at risk? The vehicle suddenly lost power and stalled in the middle of the highway while driving at normal speed. This created a dangerous situation where I could have been struck by oncoming traffic while trying to safely exit the roadway. 3. Has the problem been reproduced or confirmed by a dealer or independent service center? The issue was confirmed by a repair shop, which diagnosed the cause as a misfire due to a broken valve. I have service documentation of the diagnosis available. 4. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives, or others? The vehicle has not yet been inspected by the manufacturer or insurance representatives, but it was inspected by the servicing dealership and/or an independent mechanic who confirmed the valve failure. 5. Were there any warning lamps, messages, or other symptoms of the problem prior to the failure, and when did they first appear? Prior to the complete failure, the check engine light illuminated and the vehicle began running roughly (misfiring). These symptoms appeared very shortly before the breakdown, giving me no meaningful time to react before the engine stalled.

ELECTRICAL SYSTEM

My vehicle started with oil issues took to dealer and the attempted to perform an oil consumption test however the vehicle would not pass the test as the oil would not last long enough for next test. Was advised I needed an engine, Kia refused to replace since it wouldn’t pass consumption test. I paid for engine replacement 1month later engine light comes on, again I return to Kia dealer they say engine needs replacement they replace supposedly through warranty. Drive for about 30 days and engine light comes on again takes to dealer and they say it’s the knock sensors code which is the same code that came up prior to engine replacement. The knock sensor was a recalled part that they replaced by them but now are refusing to replace even though they replaced it less then 12 months ago.

ENGINE

My vehicle started with oil issues took to dealer and the attempted to perform an oil consumption test however the vehicle would not pass the test as the oil would not last long enough for next test. Was advised I needed an engine, Kia refused to replace since it wouldn’t pass consumption test. I paid for engine replacement 1month later engine light comes on, again I return to Kia dealer they say engine needs replacement they replace supposedly through warranty. Drive for about 30 days and engine light comes on again takes to dealer and they say it’s the knock sensors code which is the same code that came up prior to engine replacement. The knock sensor was a recalled part that they replaced by them but now are refusing to replace even though they replaced it less then 12 months ago.

ENGINE

The contact owns a 2018 Kia Sorento. The contact stated that upon starting the vehicle, the vehicle made an abnormal knocking sound. Additionally, the contact stated that while driving and depressing the accelerator pedal all the way to the floorboard, the vehicle failed to exceed 18 MPH. The check engine warning light was illuminated. The vehicle was taken to an independent mechanic, where it was diagnosed, and the failure was linked to the knock sensor detection system(KSDS). The vehicle was not repaired. The local dealer was unreachable. The manufacturer was not notified of the failure. The failure mileage was 85,798.

ENGINE

I was driving and the vehicle shut off. All electric still on lights, radio, dash, etc. No issues or noises indicating that the engine was having faliure. Did not overheat, had oil and gas. Just bought car used 6 months ago with 140k miles. Had it towed to Mechanic and was told the engine was locked. Engine repair is my only option that is going to cost 5-8k. Vehicle has been maintained regularly with only one previous owner and no major repairs ever needed to be done.

SEAT BELTS

The contact owns a 2018 Kia Sorento. The contact stated that the rear driver's side seat lap belt harness anchor pin had detached while the contact's son was attempting to wear the seat belt, rendering the seat belt inoperable. The vehicle was taken to the dealer, where an unknown diagnosis was made, and the contact was informed that there was a fee for the repair. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the dealer for assistance. The failure mileage was approximately 76,000.

EXTERIOR LIGHTING

My lights are set to auto but when driving they randomly switch off. The dash shows the switch from auto to off but the control is still set to auto. I have to manually switch the control off and then back on for the lights to come back on. I’ve also noticed a few times in the morning my lights are on. My switch is set to auto and my car is completely off but the lights are on. This is very unsafe as it happens at night and I can’t see the road.

FUEL/PROPULSION SYSTEM

* High pressure fuel pump quick disconnect fuel line fitting leaking fuel. * Raw fuel leaking poses a risk of fire and danger to the vehicle occupants. Raw fuel leaking in a closed in area as it did in my garage could have lead to an explosion due ignition of the fuel vapors. * My vehicle was repaired by a KIA dealership. The dealership noted that they've seen this issue several times in the past few months including one instance where the fuel line fitting actually fell off. The dealership acknowledged this failure hasn't yet become a recall issue which is why I'm filing a complaint with the NHSTA to establish a record of the issue. * The component was probably discarded by the dealership. The dealership didn't mention sending the part out for inspection or reporting the issue to the manufacturer. Galeana KIA did provide 2 pictures of the fuel leak area. I've attached these to this form. * There were no warning lamps or messages for this type of leak. The vehicle drove as normal. It wasn't until I parked the vehicle in my garage that I noticed a strong smell of raw fuel.

ENGINE

I am writing to express my concern regarding a serious issue with my 2018 Kia Sorento equipped with the 2.4-liter engine. The vehicle has been experiencing excessive oil consumption—approximately one quart every 400 miles—which I believe may be indicative of a manufacturing defect. Based on similar issues reported with more recent Kia models, including those involving potentially defective piston oil rings, I am concerned that my vehicle may be affected by a similar issue. As you are aware, defective piston rings can lead to long-term engine damage, sudden loss of power, and even an increased risk of engine fire. Given the severity of the symptoms and potential safety implications, I respectfully request that this matter be formally investigated and that Kia consider extending the recall or offering a resolution for affected 2018 Sorento models. I look forward to your prompt response regarding this issue.

EXTERIOR LIGHTING

The headlights will randomly turn off while driving, mostly when turning on the right blinker. This has been happening a few times a month since I got the vehicle in 2017. More recently, the bottom brake lights and running lights have been shorting out.

ENGINE

Excessive oil consumption, 4 quarts in 2000 miles

ENGINE

Engine oil is always law. Engine eats lots of oil.

LANE DEPARTURE: WARNING

An intermittent error occurs where these services stop working. It was last for a day or two and then the error will clear. I am not able to be alerted to passing cars or cars in my blind spot when changing lanes. And if there is a situation to suddenly stop the emergency automatic braking system will not be engaged.

FORWARD COLLISION AVOIDANCE: WARNINGS

An intermittent error occurs where these services stop working. It was last for a day or two and then the error will clear. I am not able to be alerted to passing cars or cars in my blind spot when changing lanes. And if there is a situation to suddenly stop the emergency automatic braking system will not be engaged.

FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING

An intermittent error occurs where these services stop working. It was last for a day or two and then the error will clear. I am not able to be alerted to passing cars or cars in my blind spot when changing lanes. And if there is a situation to suddenly stop the emergency automatic braking system will not be engaged.

UNKNOWN OR OTHER

The car is not able to shift out of park unless the shift interlock release button is depressed. This issue has occurred intermittently in the last year but has been consistent in the past few weeks of the submission of the complaint.

POWER TRAIN

GDI engine carbon buildup causing very high gas consumption and damage . Should carbon buildup break free it will cause engine falure resulting in engine seizure while at speed. Loss if property and life imment. Only soulition is disassembly to remove buildup. Another failure is corrosion on shift cable causing gear falure.

ENGINE

GDI engine carbon buildup causing very high gas consumption and damage . Should carbon buildup break free it will cause engine falure resulting in engine seizure while at speed. Loss if property and life imment. Only soulition is disassembly to remove buildup. Another failure is corrosion on shift cable causing gear falure.

STEERING

The steering started to fail and would be hard to steer while driving.I then looked further online and found that a recall was issued for the steering column and how dangerous it was to continue driving the vehicle for the cross as stated in the recall could seperate and one could lose steering and cause a crash so we; my wife and I managed to get the car safely to the dealer for further diagnostic only to find out that although a recall was issued for the steering problem. Our vin was not included and we had to pay for the repair.

STEERING

Sometimes this condition hardly noticable and other times very stiff then move steering wheel slightly and full assist. Seems more prevalent after driving 1/2 hour or more on expressway steering becomes stiff and ratchety. This causes steering to stick whenever driving at highway then driver is putting more effort to overcome stuck wheel. When breaks loose vehicle goes to far in that direction then sticks again causing to stick again and over corrects other direction. This goes from annoying and uncomfortable to just plain dangerous depending on conditions speed weather and proximity to other vehicles or obstacles.

ENGINE

Engine burns and eats up lots of engine oil. Engine oil is always low.

STRUCTURE:BODY

2018 Kia Sorento. Snow White Pearl paint started delaminating at about 45,000 miles. Now it has 51,000 miles and I have multiple spots where it is delaminating on the hood, front bumper, and fender. Also, where the paint is delaminating I am also starting to see small chips on the paint below since the clear coat is gone. I cant believe my car paint is having issues and it only has 51,000 miles on it. It has been stored in a garage for the life of the car.

ENGINE

The contact owns a 2018 Kia Sorento. The contact stated while driving at an undisclosed speed, the vehicle lost motive power. The check engine warning light was illuminated. The vehicle failed to restart and was towed to an unknown dealer. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure and a case was filed. The failure mileage was approximately 89,000.

STEERING

In January 2024 I started getting power steering issues and multiple warning lights related to the electrical systems. I took my vehicle to Car Pros Kia for inspection and repair on 2/1/2024. They took it for a test drive at which time it caught fire.

ENGINE

In January 2024 I started getting power steering issues and multiple warning lights related to the electrical systems. I took my vehicle to Car Pros Kia for inspection and repair on 2/1/2024. They took it for a test drive at which time it caught fire.

ELECTRICAL SYSTEM

In January 2024 I started getting power steering issues and multiple warning lights related to the electrical systems. I took my vehicle to Car Pros Kia for inspection and repair on 2/1/2024. They took it for a test drive at which time it caught fire.

UNKNOWN OR OTHER

I was driving my daughter to school and heard 2 popping noises under the car. The car started smoking as I was driving. I pulled into the parking lot and the car wouldn’t stop. I pressed the break multiple times before it eventually stopped. The car was completely smoking from the hood and then caught fire as I got me and my children out of it. The fire department came and successfully put the fire out after about 30 minutes of continuous flames. It was a total loss

ENGINE

The contact owns a 2018 Kia Sorento. The contact stated while driving 20 MPH, the vehicle lost automotive power. The contact stated that the failure had occurred on several occasions. The check engine warning light was illuminated. The vehicle remained at the residence. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was unknown.

ENGINE

Was driving car it lost power, pulled over and had tow truck bring car to dealership. Dealership states a new engine is needed due to a malfunction in the engine block, however warranty is out on car just by 9,000 miles and car is still financed! Maintenance has been kept up on car. Kia wants $10,000 to replace engine.

ENGINE

The contact owns a 2018 Kia Sorento. The contact stated while driving at an undisclosed speed, the contact heard an abnormal knocking sound coming from the engine before the vehicle lost motive power, with the check engine and oil warning lights illuminated. The vehicle was towed to the dealer but was not diagnosed or repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 115,000.

UNKNOWN OR OTHER

Trunk latch won’t latch, Looked into it and other 2018 Kia sorentos gave the same problem. I called to check for a recall as I bought the car less then a year ago and was told nothing. This is a problem I barely used it and it won’t close now. Just pops back open and will start alerting me that it’s open and won’t latch. Meaning the car will keep beeping that it’s open and then will eventually drain the battery due to the alert going off the whole time (it won’t relatch) it took 8 hours for it to latch to close. This is the Manuel trunk.

ENGINE

I bought a used Kia sorento from a Kia Dealership. This engine makes oil evaporate completely. This engine must be a bad engine. I heard there was some recalls on Kia engines not sure if this one fits it. The dealership did a five hundred dollar job on it and it did not fix. I put oil in this car every month. No way to upgrade because of these issues.