2017 KIA SORENTO

TRAILER HITCHES

Kia America, Inc. (Kia) is recalling certain 2016-2022 Sorento, 2021-2022 Sorento Hybrid (HEV), 2022-2023 Sorento Plug-In Hybrid (PHEV), and 2017-2022 Sportage vehicles equipped with a tow hitch harness installed as original equipment, or purchased as an accessory through a Kia dealership. Debris and moisture accumulation on the tow hitch harness module printed circuit board (PCB) may cause an electrical short, which can result in a fire.

Risk: A fire while parked or driving can increase the risk of injury.

FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS

Kia Motors America (Kia) is recalling certain 2011-2017 Optima, 2012-2017 Sorento and 2011-2018 Sportage vehicles that previously received an engine replacement under recall number 17V-224, warranty, or the Knock Sensor Detection System (KSDS) Product Improvement Campaign. The high pressure fuel pipe that connects to the fuel pump outlet may have been damaged, misaligned or improperly torqued during the engine replacement procedure, possibly causing a fuel leak.

Risk: A fuel leak in the presence of an ignition source can increase the risk of a fire.

ENGINE AND ENGINE COOLING:ENGINE

Kia Motors America (Kia) is recalling certain 2017 Sorento vehicles equipped with 3.3L engines. The engine crankshaft may have been improperly heat treated and may fail.

Risk: If the crankshaft fails, the engine will stall, increasing the risk of a crash. A failed crankshaft also increases the risk of a fire.

STEERING

The contact owns a 2017 Kia Sorento. The contact stated that while turning the steering wheel in either direction, the steering wheel was sticking and notchy while attempting to return the steering wheel to center. The vehicle was taken to the local dealer, who diagnosed that the power steering motor was faulty and needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure, but no assistance was offered. The failure mileage was 21,083.

ENGINE AND ENGINE COOLING

The contact owns a 2017 Kia Sorento. The contact stated that while driving 25-29 MPH uphill and approaching a stop sign, the vehicle began sputtering and struggling to accelerate. While at the stop sign, the vehicle started idling roughly with the check engine warning light illuminated. The vehicle was towed to the dealer and was diagnosed and determined that the cylinders were filling with oil due to a gasket failure. The contact was informed that the engine needed to be replaced. The failure caused the catalytic converter to be corrupted and needed to be replaced. The dealer informed the contact that there was a Class Action Lawsuit for the issue, and there was an Extended Warranty coverage for the failure; however, because a specific fault code was not retrieved, the vehicle would not qualify for the repair, unless the engine seized. The contact was advised not to add oil to the engine to prevent the engine from seizing and to get the repair covered. The vehicle was not repaired. The manufacturer was informed of the failure and referred the contact to the dealer for assistance. The failure mileage was approximately 95,500.

ENGINE

Engine seized with zero warning lights, cautions, check engine lights, or low/high indicators. It started knocking and was driven 3 miles to our mechanic who said it was a failed engine. I called the Kia dealer who recommended I tow or drive it to the dealer. ~3 miles from our house, less than a mile from the dealer the car lost all power. We had it towed. The service manager chastised me for not towing but also told me irregardless of how it arrived that the engine was no longer functional. It is out of warranty w/ 143,000 miles but without any indication of a problem how was I supposed to mitigate any risk. From the start of the knocking until the engine failed it was less than 6 miles. The mechanic had to put 3 quarts of oil in the car and it still failed on the way to the dealer. I get regular oil changes and have never been told it’s running low on oil. I’m asking that somebody please look into this issue. Thank you. R/ Aaron

ENGINE

This 2017 Kia Sorento with the 3.3L V6 Lambda II engine appears to have had possible rod bearing failure or connecting rod failure. This vehicle has 107,987 miles on it when the incident happened. 2 hours into a drive on the highway, the car began to sound like it had a possible exhaust leak, however this was followed shorty by knocking which prompted us to pull over and just as we made the shoulder as the engine quit and began to smoke heavily. Went to quickly open the hood and the smoke died down in about a minute. Most likely due to the oil hitting the exhaust from the hole the rod left in the block. There were no oil lights or other indications that anything was going to happen prior to this. The vehicle has been maintained meticulously with all maintenance items. This vehicle is available for inspection. Let me know if this needs to happen prior to KIA getting ahold of it. Our entire family was in the car (5 people including our dog) and we were at highway speeds when this happened. Fortunately we were able to get over just before the engine blew. Also fortunate enough to open the hood fast enough to get it cool before it started a fire. We are going to take it to the dealer for inspection, however both the dealership and Kia Customer Care said this is not currently under any warranty for engine failure. I have yet to inspect myself to take pictures from under the car, so no inspection has been thoroughly performed. As previously stated, there was no warning lights, the car did sound like it started to have an exhaust leak no more than a minute or two before the knocking started.

ENGINE

On 8/16/2025 my 2017 Kia Sorento experienced major engine failure which resulted in loss of power and severe engine misfiring. I submitted a warranty claim with full maintenance documentation to Kia cooperation but was denied coverage on 8/27/2025. This denial is improper because 1.The engine type is covered under recalls and/or the Kia Engine Class Action Settlement, which extends coverage to 15 years / 150,000 miles and my vehicle currently has 94423. 2.I complied with all maintenance requirements and have already provided numerous records. 3.Engine failure presents a serious safety hazard and has been widely reported.

ENGINE

Valves are knocking and rattling. Engine sometimes stalls out. The knocking and rattling will not go away. It is getting worse everyday to the point that I am scared to drive it because it will stall out on me somewhere and leave me stuck on the side of the road. Been doing this for a couple of months now.

ENGINE

The contact owns a 2017 Kia Sorento. The contact stated that while driving at 20 MPH, the contact heard a clicking and banging sound coming from the engine. The contact mentioned that while looking through the front driver's side mirror, she noticed smoke coming from the engine. Several unknown warning lights illuminated. The contact pulled over to the right side of the road, turned the vehicle off and then exited the vehicle and opened the hood of the vehicle and noticed flames coming from the engine. No injuries were sustained. No medical attention. The contact dialed 911, but there was no police report filed. The fire chief showed up at the scene and extinguished the fire. The vehicle was not destroyed. The vehicle was towed to a collision center. The manufacturer was notified of the failure and opened a case. The approximate failure mileage was 105,000.

ENGINE

Engine seized Kia denied warranty extension b/c of maintenance records changed oil myself had 3 years of receipts for oil and filters

ENGINE

I was driving and out of no where the battery light pop up and than car turns off on in the middle of traffic.. surprisingly there was no accident it was scary I had my two babies in the car with me. There’s no recall it’s a safety hazard ..

ENGINE

I don’t understand how my 2017 Kia sorento doesn’t have a recall on its engine. I bought the car in cash and 1 month the car doesn’t want to start.. I don’t understand I wasted money… I need engine replaced and don’t have $10000

ELECTRICAL SYSTEM

Headlights turn off at night when set in the auto position and turn on when the car is off

EXTERIOR LIGHTING

Headlights turn off at night when set in the auto position and turn on when the car is off

ENGINE AND ENGINE COOLING

The contact owns a 2017 Kia Sorento. The contact stated that on several occasions, while checking the engine oil level, after driving 600 miles, the dipstick indicated that the engine oil level was extremely low. The vehicle was taken to a dealer, and the contact was informed to monitor the oil level to determine if the engine was consuming an excessive amount of engine oil. The contact stated that the engine was flushed twice. The contact stated that the symptoms of oil consumption were mild, but the failure persisted. The vehicle was taken back to the same dealer where it was diagnosed, and determined that the engine needed to be replaced. The vehicle was not repaired. The failure mileage was approximately 60,000.

ENGINE

The engine locked up. The engine only had 80,000 miles. The car stopped in the middle of traffic. The dealership refused to take responsibility. KIA also declined warning coverage. I had to pay to replace the engine.

ENGINE

My 2017 Kia Sorento has developed intermittent safety-related engine issues that have resulted in loss of acceleration and stalling. December 2024: After a two-hour drive, the vehicle stalled and would not restart. Roadside assistance confirmed the engine oil level was low, despite no external leaks. After approximately two hours, the vehicle restarted. [XXX]: After driving about 30 minutes and parking for 10–20 minutes, the engine started with loud rumbling/knocking noises, and the accelerator was unresponsive. The problem resolved only after shutting the car off and restarting. Video is available. The Kia dealer performed a rod bearing test which passed, but the symptoms match early failure stages of the known Theta II engine defect covered under Kia’s lifetime warranty (PI1802 settlement). Kia attributes the issue to “low oil” as a maintenance problem, but the oil consumption appears to be internal and abnormal. This defect creates a serious safety risk because it causes sudden loss of power, which could lead to an accident if it occurs while driving in traffic. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

ENGINE

Motor uses 6 guarts of oil in 3000 miles. No leaks. The dealer has done the oil consumption test. And it failed every time. Kia denied claim to replace engine. They stated that it passed the bearing test. This is crap.

ENGINE

Bought the car last month had it put on a diagnostic machine 2 times took a trip lasted one week now it's in the shop days bad motor engine light came on @ parked it right then they told me that it ended a engine it run perfect then it wasn't it is a 2017 Kia Sorento it's only 8 yrs old is there any manufacturer warranty or coverage of any kind for that yr it ran really good for a minute then it wasn't it's still in shop being looked @ I have exstended warranty. They want me to pay 2.700 for tear down @ they can't say if they fix it then after I'm outa pocket I had to leave it in another state I seen online recalls on that make yr @ model can you give advice thanks

ENGINE

We purchased a 2017 Kia Sorrento AWD 3.3L V6 153,000 on May 9 2025. We made our 2nd payment on July 11th & on July 17th @5am we went and filled it up and got on the highway to head to work. We didn't even drive ¬Ω a mile when all of a sudden it lost all power at 73mph. No warning lights nothing. Dash said "key fob not in vehicle". We had it towed to Kia which cost almost $350 for them to call & tell us we need a new engine. No codes nothing. Also almost $200 for them to diagnose that. And that it will cost over 10k to fix. We paid under 10k to begin with. They are saying it isn't covered under any warranty. It's our only vehicle that we can drive in winter. We literally had the Kia just over 2 months.

ENGINE

Unknown Engine stopped in the middle of driving. The engine has a bad bearing. Caused the starter wire to be burned so can’t start vehicle what so ever. Chunks of metal in the oil.

ENGINE

Oil consumption

UNKNOWN OR OTHER

Oil consumption

ENGINE

Oil consumption

ENGINE

While driving, the engine warning light suddenly turned on and the vehicle began shaking violently. I was forced to pull over, and the car had to be towed. The dealership diagnosed engine failure caused by excessive oil consumption. Despite routine maintenance, the manufacturer refuses to cover repairs under warranty. This creates a serious safety hazard, as engine components like spark plugs can fail without warning, potentially leaving drivers stranded or causing accidents.

FUEL SYSTEM, GASOLINE

The contact owns a 2017 Kia Sorento. The contact stated that upon starting the vehicle, the vehicle stalled and failed to respond as intended. The check engine warning light was illuminated. Additionally, the contact stated that the vehicle had failed to respond as needed while depressing the accelerator pedal. The local dealer was contacted. The vehicle was taken to an inspection station, where it was diagnosed that the fuel pump had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure but no assistance was provided. The failure mileage was 150,000.

ENGINE

I have a 2017 Kia Sorento. On Sunday [XXX], I was driving on [XXX] in Oklahoma when I started hearing a weird knocking noise and was having difficulties accelerating. I was in the car with my mother and [XXX] son just between Guthrie and Edmond OK which is a very heavily trafficked area. My car suddenly shut off, I coasted to the side and put my hazards on. After 2 hours waiting for a tow truck to tow my vehicle back to my home town a mechanic informed us the engine was blown and could be apart of their lawsuit against engines. After reading many many other peoples encounter with Kia, Kia acknowledges issues with the engines and were placed in a lawsuit however they find every way out of responsibility for replacing the engines that are faulty. Not only did this put others in danger while I was driving UNDER the 75mph speed limit but it is July in Oklahoma and in the upper 90’s but feels like the hundreds placing myself, my mother and child at risk of heat exposure due to this faulty engine and having to wait 2 hours for a tow truck. I purchased the vehicle in 2020 during Covid when many business’ were shut down and more difficult to receive oil changes properly, and many people reported that since the engine was faulty it was eating away at the oil faster meaning oil did not go as far as it should. This company should replace ALL faulty engines REGARDLESS of their oil change reports and software updates as this is a massive safety feature and puts lives at risk on the road. No warning lights went off until the engine already shut down. They need to accept responsibility on these models as this is a major cost in a time many people cannot afford repairs for something that should be safe to drive. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

ENGINE AND ENGINE COOLING

The contact owns a 2017 Kia Sorento. The contact stated while driving 55 MPH, the vehicle inadvertently lost motive power. No warning lights were illuminated. The vehicle was towed to the residence. The vehicle was then towed to the dealer where it was diagnosed that there was oil intrusion that caused the engine to fail. The contact was told that the engine needed to be replaced. The vehicle was not repaired due to the cost. The contact was informed that documents of past maintenance records were incomplete, and the warranty had expired. The contact stated that in the past, the vehicle consumed an excessive amount of oil. The manufacturer was notified of the failure. The failure mileage was approximately 90,000.

ENGINE AND ENGINE COOLING

The contact owns a 2017 Kia Sorento. The contact stated that while her husband was driving 65 MPH, the contact heard a thumping sound coming from the engine. No warning light was illuminated. A dealer was contacted. The vehicle was taken to the dealer where it was diagnosed and determined that the engine needed to be replaced. The vehicle was not repaired; however, the engine had been replaced one time before. The contact related the failure NHTSA Campaign Number: 25V099000( ENGINE AND ENGINE COOLING ); however, the VIN was not included in the recall. The manufacturer was notified of the failure by the AG Office. The manufacturer denied the claim and refused to repair the vehicle. The failure mileage was 243,000.

ENGINE

My 2017 Kia Sorento is not included in the engine safety recall regarding the crankshaft failure in the engine. But I am experiencing the exact same problem so I do not see how it is not included in the recall. I am requesting the recall be expanded to include more vehicles because it is not safe to drive and is currently being held hostage by the dealer who wants $10,500 to repair my engine. I refuse to pay for negligence on the part of the manufacturer. Kia corporate has been very dismissive and not helpful. Please advise

FUEL/PROPULSION SYSTEM

For several months, there has been a noticeable smell of gas fumes coming from my 2017 Kia Sorrento EX. Recently, smell has been getting much stronger and cause for concern. I have discovered a visible gas leak dripping from the gas tank area. This could likely or possibly be related to a recall engine replacement last year. The website mentions issues with the fuel pump, which is a The website mentions issues with the fuel pump, which is very concerning. I am attaching photos and video. Please advise.

FUEL/PROPULSION SYSTEM

To whom this may concern, I'm having to replace an upper module fuel pump that goes into the top of the tank. This part is being recalled on several other Kia vehicles but not mine. The car was stalling and had a heavy smell of gasoline. I was told by my repair shop not to drive this car until repaired due to gasoline fumes having the potential to be ignited and cause a fire. I was told by Kia customer care (Sandra) on 6-30-25 @ 655am MST that my Vin number was not a part of this recall. I explained my car was experiencing the same issue and required the same repair as other recalls for Kia and I was directed to file a formal complaint with nhtsa for assistance. Can you please assist with a formal recall. This is a very dangerous situation with flammable fumes escaping. Sincerely, [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

ENGINE

The contact owns a 2017 Kia Sorento. The contact stated that the check engine and low oil pressure warning lights were illuminated. The vehicle was taken to an independent mechanic, where an oil change was performed; however, the check engine warning light remained illuminated. The vehicle was taken to the nearest dealer for an unknown recall repair, and the contact was informed that the vehicle needed to be diagnosed. The dealer diagnosed the vehicle and determined that the engine needed to be replaced. The dealer informed the contact that the maintenance records needed to be reviewed to repair the vehicle under recall. The contact provided the maintenance records that the dealer sent to the manufacturer. The manufacturer later informed the dealer that the vehicle was not eligible for an engine replacement based on the maintenance records. The vehicle was not repaired. The contact called the manufacturer and was informed that the engineers had determined that the vehicle was not eligible for engine replacement and no further assistance was provided. The failure mileage was approximately 133,000.

ENGINE AND ENGINE COOLING

The contact owns a 2017 Kia Sorento. The contact stated that the check engine and low oil pressure warning lights were illuminated. The vehicle was taken to an independent mechanic, where an oil change was performed; however, the check engine warning light remained illuminated. The vehicle was taken to the nearest dealer for an unknown recall repair, and the contact was informed that the vehicle needed to be diagnosed. The dealer diagnosed the vehicle and determined that the engine needed to be replaced. The dealer informed the contact that the maintenance records needed to be reviewed to repair the vehicle under recall. The contact provided the maintenance records that the dealer sent to the manufacturer. The manufacturer later informed the dealer that the vehicle was not eligible for an engine replacement based on the maintenance records. The vehicle was not repaired. The contact called the manufacturer and was informed that the engineers had determined that the vehicle was not eligible for engine replacement and no further assistance was provided. The failure mileage was approximately 133,000.

UNKNOWN OR OTHER

Paint peeling on hood and roof

SERVICE BRAKES

while traveling about 30 miles per hour a car in front stopped. When I applied the brakes the abs locked up and caused my car to skid in to car in front. I had plenty of room to stop but as the policy report shows there was kid marks and car did not stop .

ENGINE

Engine failure. Hyundai and Kia Theta Engine Class Action Settlement 2017 Kia sorento 2.0 vin [XXX] . vehicle has the Knock Sensor Detection System (KSDS) Update which extends engine coverage to 10 years/150k miles for rod bearing failure. the vehicle has 118k miles and is at a kia dealership. They denied coverage due to no present codes related to the knock sensor and being that it has low compression on one cylinder. My 2017 Kia Sorento experienced a serious engine failure related to rod bearing wear, a known issue in the Theta II 2.4L GDI engine. The engine began making a loud knocking noise, which is a classic sign of rod bearing failure. They just so happened to left that out of their diagnosis that it has rod bearing noise and are using only the fact that low compression and no code related to the bearings to deny the coverage. When rod bearings wear out, they allow excessive play in the connecting rods, leading to unstable piston movement. In interference engines like this one, that instability can cause the piston to travel too far upward and strike open valves during operation. This can result in bent valves, valve seat damage, low cylinder compression, and repeated misfires. In my case, the engine was diagnosed with low compression and misfires consistent with this kind of internal damage. This isn’t just a wear-and-tear issue. it’s a known design flaw that leads to catastrophic engine failure and a serious safety risk. Kia denied coverage, despite this exact failure being covered under a class action settlement and extended warranty program, and despite my vehicle showing textbook symptoms of the defect. I am requesting a full investigation into Kia's handling of these claims and the lack of proper recall enforcement. My name is [XXX] with 1A auto mart inc. I am handling this case for my customer who is the registered owner of the vehicle [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

FUEL/PROPULSION SYSTEM

Upper fuel pump module is defected and will malfunction. This leads to a fuel leak inside the vehicle. You will be able to see the leak if you remove the back seat and you will be able to smell the fumes of the fuel inside and outside the vehicle. This has occurred twice to our vehicle. First time, the vehicle had 72000 miles and the 2nd time is 130 000. The kia dealership repaired it the first time and has acknowledged the leak both times. This is dangerous as the vehicle can burst into flames by a spark or flame. We did not receive any warning lights regarding the fuel leak. The leak was determined by the smell and the reduced miles per gallon.

FUEL SYSTEM, GASOLINE

The contact owns a 2017 Kia Sorento. The contact stated while driving at an undisclosed speed, there was a strong gasoline odor inside the vehicle. The contact stated that the gasoline odor had become stronger. The contact stated that upon removing the rear seats, the contact became aware there was gasoline continuously leaking into the vehicle while the vehicle was started. The vehicle was taken to the dealer, where an unknown repair was performed; however, the failure recurred. The vehicle was taken back to the dealer, where it was diagnosed that the upper fuel pump module needed to be replaced. The vehicle was not repaired. The contact related the failure to TSB Number: WTY033. The manufacturer was notified of the failure and informed the contact that the repair could not be covered because the vehicle was out warranty. The failure mileage was approximately 70,000.

ENGINE

The contact owns a 2017 Kia Sorento. The contact stated the check engine warning light was illuminated. The vehicle was taken to a certified mechanic who diagnosed the vehicle with engine failure. The mechanic replaced the air filter, brake fluid, serpentine belt, accessory belt, performed tire rotation, replaced the power steering fluid, and performed an oil change. The check engine warning light illuminated again. The vehicle was returned to the mechanic who replaced the ignition coil and spark plugs. The check engine warning light was illuminated. The vehicle was taken to the dealer who confirmed the diagnosis. The dealer replaced the valve cover gasket, fuel pump gasket, and coolant, performed a 3-point GGI induction service, refilled the brake fluid, and replaced a carbon air filter. The failure persisted and the vehicle was returned to the dealer who diagnosed the vehicle and determined that piston #3 had failed, and a spark plug was burned and needed to be replaced. The vehicle was repaired. While the contact’s husband was driving approximately 65 - 70 MPH, the vehicle began to shake aggressively, and the engine had seized. There was no warning light during the failure. The vehicle was towed to the dealer to be diagnosed and the contact was informed that the engine needed to be replaced. The vehicle was not repaired. The driver had coasted to the side of the road where the vehicle was towed home with open fuel injectors and piston failure. The manufacturer was informed of the failure and a case was opened. The manufacturer informed the contact that the spark plugs needed to be replaced again. The failure mileage was approximately 92,000.

ENGINE AND ENGINE COOLING

The contact owns a 2017 Kia Sorento. The contact stated the check engine warning light was illuminated. The vehicle was taken to a certified mechanic who diagnosed the vehicle with engine failure. The mechanic replaced the air filter, brake fluid, serpentine belt, accessory belt, performed tire rotation, replaced the power steering fluid, and performed an oil change. The check engine warning light illuminated again. The vehicle was returned to the mechanic who replaced the ignition coil and spark plugs. The check engine warning light was illuminated. The vehicle was taken to the dealer who confirmed the diagnosis. The dealer replaced the valve cover gasket, fuel pump gasket, and coolant, performed a 3-point GGI induction service, refilled the brake fluid, and replaced a carbon air filter. The failure persisted and the vehicle was returned to the dealer who diagnosed the vehicle and determined that piston #3 had failed, and a spark plug was burned and needed to be replaced. The vehicle was repaired. While the contact’s husband was driving approximately 65 - 70 MPH, the vehicle began to shake aggressively, and the engine had seized. There was no warning light during the failure. The vehicle was towed to the dealer to be diagnosed and the contact was informed that the engine needed to be replaced. The vehicle was not repaired. The driver had coasted to the side of the road where the vehicle was towed home with open fuel injectors and piston failure. The manufacturer was informed of the failure and a case was opened. The manufacturer informed the contact that the spark plugs needed to be replaced again. The failure mileage was approximately 92,000.

EXTERIOR LIGHTING

When I drive at night with the headlights on, sometimes the headlights will all go off until I click the button a couple of times then they will come back on, and this scares me because it can cause a wreck when I can’t see

FUEL/PROPULSION SYSTEM

Strong smell of gas while driving and under the hood of car with no visible leaks.

UNKNOWN OR OTHER

The car is a 2017 Kia Sorento with approximately 73,000 miles. We have always had the oil changed at the Kia dealership. A month after the last time I had it changed (1/2025) we were going on a trip so my dad checked the oil. There was no oil in it. Since then we have been having to put oil in it about once a month or so because it runs out. It is not leaking anywhere and no oil light comes on when it does run out. The oil is disappearing. The oil is burning internally. I am having difficulties with the dealership in addressing the oil consumption issue, even when it's a known problem. This last time I spoke with Robert at Kia Ramada in Shelby NC. They want me to pay for them to look at it and then said they would write up a report to see if corporate would cover it. I feel like since this is a known issue I shouldn’t have to pay for them to look at or diagnose it. He said it would not be covered unless the engine locked up. Well if I keep driving it and don’t keep putting oil in it, it will lock up. I’d rather you fix the issue than have to put in a whole new motor. Please get in touch with me asap so I know what further actions that I will need to take to resolve this matter.

ENGINE

The car is a 2017 Kia Sorento with approximately 73,000 miles. We have always had the oil changed at the Kia dealership. A month after the last time I had it changed (1/2025) we were going on a trip so my dad checked the oil. There was no oil in it. Since then we have been having to put oil in it about once a month or so because it runs out. It is not leaking anywhere and no oil light comes on when it does run out. The oil is disappearing. The oil is burning internally. I am having difficulties with the dealership in addressing the oil consumption issue, even when it's a known problem. This last time I spoke with Robert at Kia Ramada in Shelby NC. They want me to pay for them to look at it and then said they would write up a report to see if corporate would cover it. I feel like since this is a known issue I shouldn’t have to pay for them to look at or diagnose it. He said it would not be covered unless the engine locked up. Well if I keep driving it and don’t keep putting oil in it, it will lock up. I’d rather you fix the issue than have to put in a whole new motor. Please get in touch with me asap so I know what further actions that I will need to take to resolve this matter.

UNKNOWN OR OTHER

I am unsure what component system failed or malfunctioned. The car is in the toe place. It's a total loss burned from front to back my safety was put at risk by no indication of any lights coming on my dashboard. By the time I stopped the whole front into my car was on fire. It burned from from 2 back within 8 minutes. It has not been inspected by insurance. The police were there when the fire was put out along with the fire department. There were no warning lights or lamps of any indication of a problem. I was driving down the road and I seemed small but I had no lights on my dashboard. Indicating anything was wrong? So I drove as soon as I started to slow down at the stoplight. Flames started coming out of the driver's side of the hook. But I turned the corner and stopped the car and the whole front end.By the time I stopped was on fire.I contacted the fire department and within 8 minutes.The car was a total loss

ELECTRICAL SYSTEM

I am unsure what component system failed or malfunctioned. The car is in the toe place. It's a total loss burned from front to back my safety was put at risk by no indication of any lights coming on my dashboard. By the time I stopped the whole front into my car was on fire. It burned from from 2 back within 8 minutes. It has not been inspected by insurance. The police were there when the fire was put out along with the fire department. There were no warning lights or lamps of any indication of a problem. I was driving down the road and I seemed small but I had no lights on my dashboard. Indicating anything was wrong? So I drove as soon as I started to slow down at the stoplight. Flames started coming out of the driver's side of the hook. But I turned the corner and stopped the car and the whole front end.By the time I stopped was on fire.I contacted the fire department and within 8 minutes.The car was a total loss

ENGINE

In April 2025 the check engine light came on. The engine had been replaced in February 2025 so I immediately took the vehicle to Safford Kia Dealership in Fredericksburg, VA. (NOTE: The engine was replaced at Jacksonville Kia, Jacksonville, NC as the issue with the engine happened while I was away working at that location.) A few days after dropping the vehicle off I was notified by the service writer there that the catalytic converter had gone bad which was a common issue after problems with the engine. Specifically, I was told the engine dumps oil into the catalytic converter therefore ruining it. The new engine has been driven about a 1000 miles (give or take) as the vehicle was picked up from the dealership in Jacksonville, NC and driven to Fredericksburg, VA on 1 March 2025 with minimal normal driving before the check engine light came on.

STEERING

Sticking steering wheel at speeds around 60 mph on slight turns been happening over a year took it to dealer said they couldn’t get it to do it.

STEERING

The steering is sticky. When on the highway you have to keep correcting the steering because the wheel seems to be sticking then moving. As a result you can not just go straight down the road but have to keep putting in steering corrections!!!!! This needs to be addressed! This is an ongoing problem , not just on one date.

STRUCTURE:BODY

Above the windshield on the driver's side, paint is progressively peeling away with regular operation of my pearl-white 2017 Kia Sorento. What began as a very small and barely noticeable chip in the paint has progressed to a large paint-less spot. On the hood and surrounding areas, paint chips are appearing as well. According to the auto body repair shop I received an estimate from, this is referred to as "delamination" and is a result of poor quality paint or craftsmanship in the manufacturing process. The auto body shop said this is a recurring issue in WHITE Kia Sorentos specifically. Many other owners of white Kia Sorentos have reported this same issue.

ENGINE

Engine blew at 175000. It is not one of the vehicles that is covered under the class action lawsuit but the vehicle itself just blew an engine after an oil change. One of the Pistons let go.

UNKNOWN OR OTHER

I am writing to bring to your attention a concerning issue regarding the instrument panel of the 2016-2020 Kia Sorento. My car - 2017 Kia Sorento. In approx. 2021, I noticed a small 2 cm crack resembling a razor blade cut on my instrument panel (Part Number: 84710-C5000WK, also 84710-C6000WK and 84710-C6001WK). At the time, I did not find this defect alarming as it was minor and located far from the airbag area. However, over time, the situation has deteriorated significantly. The small crack has now developed into three substantial cracks measuring between 6 to 8 inches, with some of them encroaching upon the airbag area. I am increasingly concerned that these cracks may impact the airbag deployment mechanism and potentially result in fragments from the panel flying out during a collision, an issue that has been documented in other vehicle brands in the past. After conducting some research, I found that this problem appears to be common among the Kia Sorento models manufactured between 2016 and 2020. Numerous sources online indicate that these dashboard cracks pose a safety hazard. I have made attempts to address this issue directly with Kia. However, I was informed that the initial inspection fee is $150, and the estimated cost for part replacement and installation is approximately $3,959. This amount is quite significant. I urge your organization to investigate this matter further and consider providing a remedy for affected customers. Thank you for your attention to this important matter.

STRUCTURE:BODY

I am writing to bring to your attention a concerning issue regarding the instrument panel of the 2016-2020 Kia Sorento. My car - 2017 Kia Sorento. In approx. 2021, I noticed a small 2 cm crack resembling a razor blade cut on my instrument panel (Part Number: 84710-C5000WK, also 84710-C6000WK and 84710-C6001WK). At the time, I did not find this defect alarming as it was minor and located far from the airbag area. However, over time, the situation has deteriorated significantly. The small crack has now developed into three substantial cracks measuring between 6 to 8 inches, with some of them encroaching upon the airbag area. I am increasingly concerned that these cracks may impact the airbag deployment mechanism and potentially result in fragments from the panel flying out during a collision, an issue that has been documented in other vehicle brands in the past. After conducting some research, I found that this problem appears to be common among the Kia Sorento models manufactured between 2016 and 2020. Numerous sources online indicate that these dashboard cracks pose a safety hazard. I have made attempts to address this issue directly with Kia. However, I was informed that the initial inspection fee is $150, and the estimated cost for part replacement and installation is approximately $3,959. This amount is quite significant. I urge your organization to investigate this matter further and consider providing a remedy for affected customers. Thank you for your attention to this important matter.

AIR BAGS

I am writing to bring to your attention a concerning issue regarding the instrument panel of the 2016-2020 Kia Sorento. My car - 2017 Kia Sorento. In approx. 2021, I noticed a small 2 cm crack resembling a razor blade cut on my instrument panel (Part Number: 84710-C5000WK, also 84710-C6000WK and 84710-C6001WK). At the time, I did not find this defect alarming as it was minor and located far from the airbag area. However, over time, the situation has deteriorated significantly. The small crack has now developed into three substantial cracks measuring between 6 to 8 inches, with some of them encroaching upon the airbag area. I am increasingly concerned that these cracks may impact the airbag deployment mechanism and potentially result in fragments from the panel flying out during a collision, an issue that has been documented in other vehicle brands in the past. After conducting some research, I found that this problem appears to be common among the Kia Sorento models manufactured between 2016 and 2020. Numerous sources online indicate that these dashboard cracks pose a safety hazard. I have made attempts to address this issue directly with Kia. However, I was informed that the initial inspection fee is $150, and the estimated cost for part replacement and installation is approximately $3,959. This amount is quite significant. I urge your organization to investigate this matter further and consider providing a remedy for affected customers. Thank you for your attention to this important matter.

EXTERIOR LIGHTING

When my head lights are on automatic, they will cut on and off on their own while driving at night! Completely off! My break lights also come and go. I have had the bulbs replaced and still have the same issue

ENGINE

Engine failed, leaving me stranded at a stop light. I was finally able to get it started, but it ran terribly and didn't have the power to go uphill, almost rolled back into the vehicles behind me. Had to have it towed. No warning whatsoever, engine stalled and engine light on. I got it fixed at dealership I purchased from, then it did the same thing a week later. I will NEVER purchase a KIA again. Almost every shop I inquire about service won't even service KIA engines anymore because of the problems. I'm left with a car payment and no vehicle.

VEHICLE SPEED CONTROL

This is the third time I’m having to take my SUV to the Kia dealership because my check engine light begins flashing and then my car has a hard time accelerating when it gets to certain speeds. It shakes but will not go over 68 mph although it is covered under a warranty, it is very frustrating. Having to keep take my car to get fixed. There should be a more permanent solution.

ENGINE

This is the third time I’m having to take my SUV to the Kia dealership because my check engine light begins flashing and then my car has a hard time accelerating when it gets to certain speeds. It shakes but will not go over 68 mph although it is covered under a warranty, it is very frustrating. Having to keep take my car to get fixed. There should be a more permanent solution.

ELECTRICAL SYSTEM

This is the third time I’m having to take my SUV to the Kia dealership because my check engine light begins flashing and then my car has a hard time accelerating when it gets to certain speeds. It shakes but will not go over 68 mph although it is covered under a warranty, it is very frustrating. Having to keep take my car to get fixed. There should be a more permanent solution.

ENGINE

Severe oil spill from engine and is spilling out into the car tires and the side doors and comes through the muffler and my back window and it’s stalling my car and I have been left stranded on the side of the road and I had it diagnosed at the dealership I bought it and I need my car fixed due to faulty issues of the vehicle not my fault please and thank you

POWER TRAIN

The contact owns a 2017 Kia Sorento. The contact stated that the gear shifter was stuck in park(P). The contact stated that once the vehicle was parked, the gear shifter remained stuck in park(P). The contact manually depressed the button under the gear shifter to move the gear shifter. No warning lights were illuminated. The contact stated that after the first failure, the vehicle was taken to the dealer, where it was diagnosed that an unknown part in the gear shifter had failed. The vehicle was not repaired. The manufacturer was contacted. The contact stated that the failure persisted. The failure mileage was approximately 94,000.

ENGINE

1.Component/System Failure: The issue involves a recurring failure of the oil pressure switch, which is part of the engine’s lubrication monitoring system. This malfunction has resulted in an oil leak that subsequently damaged a major wiring control harness and the associated control module. The affected components are available for inspection by an authorized service center. 2.Safety Risk: The oil leak poses a safety risk by potentially compromising the vehicle’s engine performance and electrical system integrity. While there has been no direct incident of injury, the malfunction increases the risk of unexpected vehicle failure, which could endanger the driver and others on the road. 3.Confirmation of the Problem: The recurring issue was initially diagnosed by an authorized dealer. After the first repair under warranty, the same problem reappeared, and an independent service center later confirmed that the oil pressure switch was leaking excessively. This repeated diagnosis supports the conclusion that the component is defective. 4.Inspections Conducted: The vehicle has been inspected by both the authorized dealer and an independent service center. Additionally, the previous repair under warranty was conducted with oversight from manufacturer representatives. There has been no involvement of the police or insurance representatives regarding this incident. 5.Warning Lamps or Symptoms: There were no specific warning lamps or error messages that appeared before the failure. The primary symptoms noted were poor acceleration and unusual engine noise, which first appeared shortly before the issue was identified as an oil leak.

ELECTRICAL SYSTEM

1.Component/System Failure: The issue involves a recurring failure of the oil pressure switch, which is part of the engine’s lubrication monitoring system. This malfunction has resulted in an oil leak that subsequently damaged a major wiring control harness and the associated control module. The affected components are available for inspection by an authorized service center. 2.Safety Risk: The oil leak poses a safety risk by potentially compromising the vehicle’s engine performance and electrical system integrity. While there has been no direct incident of injury, the malfunction increases the risk of unexpected vehicle failure, which could endanger the driver and others on the road. 3.Confirmation of the Problem: The recurring issue was initially diagnosed by an authorized dealer. After the first repair under warranty, the same problem reappeared, and an independent service center later confirmed that the oil pressure switch was leaking excessively. This repeated diagnosis supports the conclusion that the component is defective. 4.Inspections Conducted: The vehicle has been inspected by both the authorized dealer and an independent service center. Additionally, the previous repair under warranty was conducted with oversight from manufacturer representatives. There has been no involvement of the police or insurance representatives regarding this incident. 5.Warning Lamps or Symptoms: There were no specific warning lamps or error messages that appeared before the failure. The primary symptoms noted were poor acceleration and unusual engine noise, which first appeared shortly before the issue was identified as an oil leak.

STEERING

Car shut off and the radio kept going on and off red light on dash board and steering was hard

ELECTRICAL SYSTEM

Car shut off and the radio kept going on and off red light on dash board and steering was hard

STEERING

Steering sticks and makes it difficult to stay straight. Have to use extreme effort to keep it in the lane. Complained to Kia in 2022 and dealer saw problem with the rack mounted motor driven power assembly but that it was within their specs. They did a software update on the eps and said system now operating as designed. The miles were 35,774 at that time. Started having same issues in february of 2025. Dealer is saying it needs a new steering column, but now out of warranty. Miles were 59,436.

ENGINE

[XXX] the engine on my 2017 Kia Sorento seized up due to severe oil leak. There was a recall earlier in the year for oil pressure gauge which I had replaced. This seems to be a common problem in Kias as there is the class action law suit for this very problem however my car does not qualify but after reading many forums this is still a common problem in Kias that are not covered in this class action. I am now left with an inoperable car and nothing to show for it. I have been in touch with Kia Corporate with no help, lawyer, Office of Attorney General and MyCarVoice.com. Hoping you all can add some advice or answers. Thank you. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

STEERING

Steering is sticky when making SLIGHT correction. Happens every time I drive. The speed does not matter. Happens at all speeds.

ENGINE

Car went into limp mode and check engine light began blinking. We do not have a Kia dealer in our town so we had it towed to local mechanic. He did not save the code but said it indicated one of two options: change the oil or replace engine. He changed the oil and cleared the code. The car had been using oil for some time so we called Kia to report it. We were told to let it run out of oil until it goes into limp mode again and then tow it to the dealer. We can’t do that! We live on a mountain. If the engine locked up, we could die. So, we add a quart to a quart and a half every couple of weeks. The car smells hot so we know the engine is bad. It is one of the GDI engines. There was a class action suit for this problem in CA. We believe Kia should be held responsible for the Over Consumption of Oil issue before more accidents occur. Our case number with Kia is [XXX]. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

ENGINE

Engine failure, loss of power on multilane highway, engine valves failed. unable to move to safe location Dealer checked valves failed No warning lamps, messages prior to failure

ENGINE

Urgent Assistance Needed: Engine Issue and Warranty Dispute Since September last year, the engine warning light has been consistently on. Whenever I took the car to the Kia dealership, they merely mentioned that the system was “too rich” and assured me it was not a concern. Instead of addressing the engine issue, they recommended replacing unrelated parts such as the air filter. When I took the vehicle to a local mechanic, I was informed that the engine was not in good condition, causing the oil to burn quickly, which indicated an engine problem. However, the Kia dealership did not acknowledge this issue. On February 7th, while driving, the vehicle began shaking violently and making unusual noises. I immediately brought it to the local mechanic, who diagnosed that the #4 cylinder valve was burnt. The following day, on February 8th, I brought the car to the dealership. They mentioned that the engine might need to be replaced and promised to contact the warranty company for approval. They initially seemed optimistic, suggesting that the replacement could be covered under the warranty. However, two weeks later, I received a response stating that the warranty would not cover the repair. Despite multiple attempts to contact Kia headquarters via email, I have not received any response. Upon further investigation, I discovered that my vehicle is part of the Theta II engine recall. Kia had publicly announced a lifetime engine warranty for vehicles with this issue. However, now that my engine has failed and requires replacement, they are refusing to honor this promise. The estimated cost for the engine replacement is $8,000, and I have been told that I am responsible for the full amount. I kindly request your immediate assistance in resolving this issue. I believe Kia should honor its commitment to the lifetime engine warranty for the Theta II engine vehicles. Thank you for your prompt attention to this matter. I look forward to your response.

STEERING

We Reported in February of 2022 To Kia of Port Charlotte in Florida that our steering wheel was sticking so bad we had to use extraordinary effort to keep the car going straight. They told us they were unable to replicate what we experienced. Starting in February of 2025 we started to experience the same thing. We brought it [XXX] to Kia of Sebring Florida. They diagnosed that there is a sticking of the steering wheel but it is not covered because the car is 7 years old and has 59000 miles under warranty. When I checked on line there are tons of customers complaining of this same problem. Please look into this issue as it could cause accidents eventually. Thank you INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

UNKNOWN OR OTHER

Engine problem. I've had to replace spark plugs and have to add oil almost every week. This was done about 3 months ago. Today check engine light came back on and it's the same problem stalling and shaking as if it's going to dye in me .. I bought my car brand new I've been the only owner..it's only got 80,000 miles .. I know that you guys have life time warranty on your engines .what do I need to do to have it repaired under warranty?

FUEL/PROPULSION SYSTEM

Engine problem. I've had to replace spark plugs and have to add oil almost every week. This was done about 3 months ago. Today check engine light came back on and it's the same problem stalling and shaking as if it's going to dye in me .. I bought my car brand new I've been the only owner..it's only got 80,000 miles .. I know that you guys have life time warranty on your engines .what do I need to do to have it repaired under warranty?

ENGINE

Engine problem. I've had to replace spark plugs and have to add oil almost every week. This was done about 3 months ago. Today check engine light came back on and it's the same problem stalling and shaking as if it's going to dye in me .. I bought my car brand new I've been the only owner..it's only got 80,000 miles .. I know that you guys have life time warranty on your engines .what do I need to do to have it repaired under warranty?

STEERING

Steering MDPS Unit malfunction causing loss of power assisted steering. Visible steering light on dash. Vehicle was inspected at a Kia dealer confirming issue with MDPS unit. Kia shop stated that this was an issue with the 2016-2020 Kia Sorento models and most fell under the recall umbrella but this specific 2017 Kia Sorento is not on the VIN checked list for a steering recall for the MDPS Unit failure. Kia stated that the repair would cost out of pocket at $3500 for the same issue others with the same problem Kia is replacing under recall warranty. The MDPS Unit failed while driving causing issues with being able to steer.

ENGINE AND ENGINE COOLING

The contact owns a 2017 Kia Sorento. The contact stated that while operating the vehicle, the front and rear exterior lights shut off unexpectedly. The contact turned off the light switch and then back on and the failure was fixed. Additionally, the vehicle had experienced excessive oil consumption, and engine oil was added shortly after having an oil change performed. The vehicle also experienced harsh driving due to the oil consumption failure. The cause of the failure was not yet determined. The local dealer was notified of the failure, but no assistance was offered. The manufacturer was not contacted. The failure mileage was 65,000.

EXTERIOR LIGHTING

The contact owns a 2017 Kia Sorento. The contact stated that while operating the vehicle, the front and rear exterior lights shut off unexpectedly. The contact turned off the light switch and then back on and the failure was fixed. Additionally, the vehicle had experienced excessive oil consumption, and engine oil was added shortly after having an oil change performed. The vehicle also experienced harsh driving due to the oil consumption failure. The cause of the failure was not yet determined. The local dealer was notified of the failure, but no assistance was offered. The manufacturer was not contacted. The failure mileage was 65,000.

STEERING

The steering seems to stick, hard to explain but when you are driving on the highway feels like the steering wheel is going to stop working.

UNKNOWN OR OTHER

None of the above. The paint is continuously chipping on the hood and top of the car. When I’m driving, sometimes I see others with the same car as me and their paint is also chipping really bad. It’s only on the Kia Sorento from what I can tell. It makes the car look horrible and it’s very expensive to repaint a car. There has to be some kind of warranty they need to issue. I have a 2017 Kia Sorento. It started maybe a year or so ago, and it’s getting continuously worse at a very fast pace. It looks horrible. You can already see where the next chunks want to come off. Even when washing the car the paint comes off. When you pay $30,000 for a car, the last thing you want is for all the paint to come off and there is nothing you can do about it. THIS IS NOT NORMAL!

ENGINE

While on vacation the oil light came on (just had it in for maintenance, told them it was using oil but no sign of leak, they told me it was fine to go on vacation, that there was no problem) we put oil in but then engine light came on. It was Saturday night and warranty co. had no emergency phone number. Got to Hotel, Monday was towed to Repair Shop was told after they inspected the car that we had to replace the engine. Warranty Co. replaced the engine a MONTH later with a used engine. My car was not on the recall and should of been. KIA did not answer any calls or emails. Also I am still paying for it. I had a lo of problems with the warranty co, luckily I kept up with the maintenance on it, because if I did not they would never replaced the engine, but now I have to worry about it happening again. Also my car is in Arkansas and we live in Wisconsin.

ENGINE

The contact owns a 2017 Kia Sorento. The contact stated that while driving at an undisclosed speed, the vehicle inadvertently lost motive power. The contact was able to pull over to the shoulder of the roadway, where the vehicle failed to restart. The check engine warning light was illuminated. The vehicle was towed to the dealer, who diagnosed a failure. The contact stated that engine oil was covering the engine compartment. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 110,000. The VIN was not available.

ENGINE

My vehicle started leaking oil from the engine from an unknown location. I took it to the dealership for them to diagnose the cause of the leak which is under warranty. The dealer refused and did not honor the warranty. Now my car is immobile

ENGINE

While driving the check engine light came on. I could feel the vehicle losing power despite giving it gas & seeing the rpm's rise. While looking at the dash board to see if there any other indicators the check engine light started flashing followed up by the oil light and another light (can't remember what it was). I pulled off the highway and the vehicle was shaking while running before cutting out. It would not restart and I had it towed to the dealership. The dealership attempted to diagnos however all they can tell me is cylinders 1 & 3 will not hold compression, the engine needs to be replaced & despite only having 82K miles it's not covered by Kia. The vehicle has been meticulously maintained at the dealership.

ENGINE

Vehicle up to date on oil changes. Driving down interstate and vehicle just stopped without warning. Message to contact a dealer popped up. When diagnostic put on vehicle shows camshaft and crankshaft bad. No oil on dipstick AT ALL. Oil light never came on showing low. Never seen oil in garage so no leaks. Sensors showing misfire were changed along with spark plugs and coil packs. Codes never cleared. Car is not drivable but has been well maintained and up to date on everything. After researching I have seen multiple pages and pages of the same exact complaint on same exact vehicle. There is a recall for certain 2017 kia Sorento 3.3L V6 engines but shows mine is not affected although my vehicle is the exact same as the recall and having exact same issue as the recall. I would like this looked into and a explanation for the engine issue with help on fixing it through Kia. This is a good vehicle never gave ANY issues at all, nor gave any warnings on the issue that caused it to stop running.

FUEL/PROPULSION SYSTEM

like many other kia owners I have a Kia Sorrento and after 6700 miles started running into problems with oil consumption. I have Toyota extended warranty because I am second owner and wanted some type of coverage. Kia knows there are problems and giving customers run around plus higher insurance premiums. second time over 5 days my car is being evaluated I have done 3 oil changes since March 2024 I did get engine oil switch fixed did own oil consumption test which Toyota did not except because it was not Toyota or kia dealer that did it. I would sue them on my own or geta new car if i could afford it. I love the car for size and smoothness of ride but they are failing their customers.

ENGINE

like many other kia owners I have a Kia Sorrento and after 6700 miles started running into problems with oil consumption. I have Toyota extended warranty because I am second owner and wanted some type of coverage. Kia knows there are problems and giving customers run around plus higher insurance premiums. second time over 5 days my car is being evaluated I have done 3 oil changes since March 2024 I did get engine oil switch fixed did own oil consumption test which Toyota did not except because it was not Toyota or kia dealer that did it. I would sue them on my own or geta new car if i could afford it. I love the car for size and smoothness of ride but they are failing their customers.