2012 KIA SORENTO

SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP:CONTROL UNIT/MODULE

Kia America, Inc. (Kia) is recalling certain 2010-2019 Borrego, 2014-2016 Cadenza, 2010-2013 Forte, Forte Koup, Sportage, 2015-2018 K900, 2011-2015 Optima, 2011-2013 Optima Hybrid, Soul, 2012-2017 Rio, 2011-2014 Sorento, and 2010-2011 Rondo vehicles. The Hydraulic Electronic Control Unit (HECU) may experience an electrical short, which can result in an engine compartment fire while parked or driving.

Risk: An engine compartment fire while parked or driving can increase the risk of injury.

ENGINE

Kia Motors America (Kia) is recalling certain 2012-2013 Sorento, 2012-2015 Forte and Forte Koup, 2011-2013 Optima Hybrid, 2014-2015 Soul, and 2012 Sportage vehicles. An engine compartment fire can occur while driving.

Risk: An engine compartment fire increases the risk of injury.

FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS

Kia Motors America (Kia) is recalling certain 2011-2017 Optima, 2012-2017 Sorento and 2011-2018 Sportage vehicles that previously received an engine replacement under recall number 17V-224, warranty, or the Knock Sensor Detection System (KSDS) Product Improvement Campaign. The high pressure fuel pipe that connects to the fuel pump outlet may have been damaged, misaligned or improperly torqued during the engine replacement procedure, possibly causing a fuel leak.

Risk: A fuel leak in the presence of an ignition source can increase the risk of a fire.

ENGINE AND ENGINE COOLING:ENGINE

Kia Motor Company (Kia) is recalling certain 2011-2014 Optima, 2012-2014 Sorento and 2011-2013 Sportage vehicles. Machining errors during the engine manufacturing process may cause premature bearing wear within the engine.

Risk: Bearing wear may result in the engine seizing, increasing the risk of a crash.

UNKNOWN OR OTHER

My pearl white paint is chipping and peeling off my car

ENGINE

The contact owns a 2012 Kia Sorento. The contact received notification of NHTSA Campaign Number: 23V652000 (SERVICE BRAKES, HYDRAULIC). The contact stated that while driving at 60 MPH, the vehicle jerked with an abnormal rattling coming from the engine. The check engine warning light was illuminated. The contact pulled over to the side of the road, and the vehicle was towed to the residence. The vehicle was then towed to a dealer, where it was diagnosed, and determined that there were metal shavings found inside the engine. The dealer requested that the contact provide the history of maintenance on the vehicle. The contact provided documents; however, the dealer refused to perform the recall repair due to a lack of maintenance on the vehicle. The vehicle was not repaired. The vehicle was towed back to the residence. The failure persisted, and the vehicle remained at the residence unrepaired. The manufacturer was not notified of the failure. The failure mileage was approximately 11,877.

SERVICE BRAKES, HYDRAULIC

The contact owns a 2012 Kia Sorento. The contact received notification of NHTSA Campaign Number: 23V652000 (SERVICE BRAKES, HYDRAULIC). The contact stated that while driving at 60 MPH, the vehicle jerked with an abnormal rattling coming from the engine. The check engine warning light was illuminated. The contact pulled over to the side of the road, and the vehicle was towed to the residence. The vehicle was then towed to a dealer, where it was diagnosed, and determined that there were metal shavings found inside the engine. The dealer requested that the contact provide the history of maintenance on the vehicle. The contact provided documents; however, the dealer refused to perform the recall repair due to a lack of maintenance on the vehicle. The vehicle was not repaired. The vehicle was towed back to the residence. The failure persisted, and the vehicle remained at the residence unrepaired. The manufacturer was not notified of the failure. The failure mileage was approximately 11,877.

FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL

Parking lights stay on, change brake light switch but the hole that the switch goes in is not aligned with the brake stopper to turn off the stop brakes, therefore it remains on. Battery needs to be unplugged to keep from draining. The mechanism to stop the lights from remaining on is somehow shifted to no longer turn off the brake lights.

SERVICE BRAKES

Parking lights stay on, change brake light switch but the hole that the switch goes in is not aligned with the brake stopper to turn off the stop brakes, therefore it remains on. Battery needs to be unplugged to keep from draining. The mechanism to stop the lights from remaining on is somehow shifted to no longer turn off the brake lights.

FUEL/PROPULSION SYSTEM

I smelled fuel in & around vehicle. Did some checking discovered cracked fuel rail , causing significant fuel leak when engine is on. Did some more research online discovered 2012 KIA Sedona recall SC188 “fuel rail leak” Identical issue my 2012 Sorento has but my VIN does not come up with fuel leak recall. There is however recall 23V652 HECU replacement- engine fire possible

ENGINE

The contact owns a 2012 Kia Sorento. The contact received notifications of NHTSA Campaign Numbers: 23V652000 (SERVICE BRAKES, HYDRAULIC) and 18V907000 (FUEL SYSTEM, GASOLINE, ENGINE). The contact stated that while driving 10 MPH, the vehicle failed to accelerate as intended while depressing the accelerator pedal before the vehicle stalled. The check engine warning light was illuminated. In addition, the contact stated there was an abnormal sound coming from the engine. The contact stated that the vehicle was pushed to a nearby parking lot. The vehicle was then towed to a Collison enter. However, no cause for the failure was found. The vehicle was then towed to the dealer where it was determined that the engine needed to be replaced. The contact was informed that the recall repair of NHTSA Campaign Number: 18V907000 (FUEL SYSTEM, GASOLINE, ENGINE) could not be performed if the engine was not replaced first. The vehicle was not repaired. The contact had received a recall letter regarding a defect in the engine and the vehicle had been repaired in 2017. The manufacturer was made aware of the failure. The failure mileage was 274,479.

ENGINE

[XXX] brought car in to dealer with engine problem, I was told it needed a new engine and would be replaced under warranty. April 27th 2025 I picked up my car, two weeks later on [XXX], driving home from work the engine caught on fire, I was able to pull over, got out and called 911. In 5 minutes the whole front end was engulfed in flames. Coconut Creek Police arrived first, then the fire department. The fire department extinguished the fire. I didn't notice any warning lamps, car was driving fine, I filed a claim with my insurance, AAA, I also spoke with the KIA service manager about it, He said it could have been an old brittle fuel line, they only replaced the engine. My AAA insurance company has the vehicle and is inspecting it. The Coconut Creek Police in FL has a report # [XXX]. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

ENGINE

The engine was replace May 1, 2025 and on May 11, 2025 the car caught on fire. It was a total loss.

SUSPENSION

Left rear sub frame cracked in half while driving car . 2017 they did work to the under belly in reference to corrosion of the car . Has therr been any other complaints about this vehicle type ?

ENGINE

The contact owns a 2012 Kia Sorento. The contact stated while driving 35 MPH, the vehicle experienced a loss of automotive power. The check engine warning light was illuminated. The vehicle was towed to the local dealer, where it was diagnosed with a bearing failure and the failure was linked to NHTSA Campaign Number: 20V750000 (Engine); however, the VIN was not included. The manufacturer was made aware of the failure. The failure mileage was approximately 140,000.

ELECTRICAL SYSTEM

The downhill break control (DBC) and the traction control system is is engaged and eliminated in the dash. It causes smoke or steam to come from under the hood after it is driven. This is the second time this issue has happened. I spent over $3,000 and six months getting this fixed last time. If there is not a recall on these things it should be recalled and fixed without me having to pay for it again. I believe it should have been covered the first time it happened.

SERVICE BRAKES

The downhill break control (DBC) and the traction control system is is engaged and eliminated in the dash. It causes smoke or steam to come from under the hood after it is driven. This is the second time this issue has happened. I spent over $3,000 and six months getting this fixed last time. If there is not a recall on these things it should be recalled and fixed without me having to pay for it again. I believe it should have been covered the first time it happened.

UNKNOWN OR OTHER

I had my mechanic come to my house to diagnose what has been going on and it is a recall on the motor. Along with my car throwing codes as well. I purchased the car from car max told them almost a year ago something was wrong with my car and they told me it was nothing it was a transmission issue. My father raised me to learn how to fix vehicles so o knew something was wrong. Now due to their negligence I am stranded with two small children.

ENGINE

I had my mechanic come to my house to diagnose what has been going on and it is a recall on the motor. Along with my car throwing codes as well. I purchased the car from car max told them almost a year ago something was wrong with my car and they told me it was nothing it was a transmission issue. My father raised me to learn how to fix vehicles so o knew something was wrong. Now due to their negligence I am stranded with two small children.

SERVICE BRAKES, HYDRAULIC

The contact owns a 2012 Kia Sorento. The contact stated that upon parking the vehicle at his home, an abnormal burning odor began to emit from the vehicle's vents. Upon inspection of the vehicle, the contact discovered that the engine had caught fire and did not engulf beyond the vehicle's firewall. The contact used his home's water hose and sprayed the engine for approximately 25-30 minutes until the fire was fully extinguished. The police and fire departments were not notified of the failure and no injuries were reported. Upon investigation, the contact discovered NHTSA Campaign Number: 23V652000 (Service Brakes, Hydraulics) which was linked to the failure. The dealer nor the manufacturer had yet to be notified of the failure. The vehicle was not repaired. The failure mileage was approximately 100,000.

SERVICE BRAKES, HYDRAULIC

The contact owned a 2012 Kia Sorento. The contact stated that while the vehicle was parked and unoccupied, she was informed by an individual if she was the owner of the vehicle since it was smoking and caught on fire. Prior to the fire, unknown warning lights would illuminate and un-illuminated intermittently. The Fire Department was on the scene and extinguished the fire. The vehicle was towed to an impound lot and then towed by the insurance company. The vehicle was deemed a total loss by the insurance company. The local dealer was contacted; however, the vehicle was not repaired due to the VIN not being included in a recall at the time the failure occurred. The contact received NHTSA Campaign Number: 23V652000 (SERVICE BRAKES, HYDRAULIC) after the vehicle caught fire and was destroyed. The manufacturer was not made aware of the failure. The failure mileage was approximately 142,739.