KIA SORENTO PHEV

ELECTRICAL SYSTEM:BODY CONTROL MODULE:SOFTWARE

Kia America, Inc. (Kia) is recalling certain 2024-2025 Sorento, 2025 Sorento Hybrid, and 2025 Sorento Plug-In Hybrid vehicles. A software error in the Body Domain Control Unit (BDC) may cause a loss of low beam headlights and taillights. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) 108, "Lamps, Reflective Devices, and Associated Equipment."

Risk: A loss of headlights and taillights can reduce visibility, increasing the risk of a crash.

FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS

Kia America, Inc. (Kia) is recalling certain 2025 Sorento Plug-In Hybrid vehicles. During a crash, the steering rack may damage the fuel line, which can result in a fuel leak.

Risk: A fuel leak in the presence of an ignition source can increase the risk of a fire.

BACK OVER PREVENTION: SENSING SYSTEM: CAMERA

Kia America, Inc. (Kia) is recalling certain 2022-2023 Sorento, Sorento Hybrid, and Sorento Plug-in Hybrid (PHEV) vehicles. The mounting clips for the rearview camera may break, which can cause the rearview camera image not to appear properly on the display. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."

Risk: A rearview camera that does not properly display an image can reduce the driver's rear view, increasing the risk of a crash.

FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY

Kia America, Inc. (Kia) is recalling certain 2022 Sorento Plug-In Hybrid (PHEV) vehicles. The fuel tank may have been improperly molded, which can result in a fuel leak.

Risk: A fuel leak in the presence of an ignition source can increase the risk of a fire.

SEAT BELTS:FRONT

Kia Motors America (Kia) is recalling certain 2021-2022 Sorento Hybrid and 2022 Sorento Plug-in Hybrid vehicles. In the event of a crash, the front driver-side and/or passenger-side seat belt pretensioner(s) may explode upon deployment.

Risk: An exploding seat belt pretensioner can project metal fragments into the vehicle, striking vehicle occupants and resulting in injury.

TRAILER HITCHES

Kia America, Inc. (Kia) is recalling certain 2016-2022 Sorento, 2021-2022 Sorento Hybrid (HEV), 2022-2023 Sorento Plug-In Hybrid (PHEV), and 2017-2022 Sportage vehicles equipped with a tow hitch harness installed as original equipment, or purchased as an accessory through a Kia dealership. Debris and moisture accumulation on the tow hitch harness module printed circuit board (PCB) may cause an electrical short, which can result in a fire.

Risk: A fire while parked or driving can increase the risk of injury.

SERVICE BRAKES

My Sorento PHEV popped a P0c4e code and now the car is gutless on electric power. Kia cleared the code in an attempt to fix it but now the code is gone and it’s still weak. When I let off the brake it rolls when it used to have the power to hold it. I used to be able to get on the freeway and now I can’t get up to speed in town (35mph). It’s running in some sort of limp mode and Kia can’t see any codes. It’s loud, too. Each gear whines. It whines when I hit the brake and it regenerates electricity. It regens so little now that it doesn’t hardly slow me down anymore until I stand on them and use the brake pads. Kia said that it might be a sensor in the electric motor but it’s not replaceable and you have to replace the whole motor. Even though it’s under warranty, it’s 15 hours labor to replace it. I have family with the same car and theirs has done the same thing in the past and had to be replaced. My dealer said that they have seen a bunch of these throw that same code and have to have the motor replaced. She said she is expecting Kia to start replacing them for free or possibly recall them because of how many she has seen all doing the same thing.

POWER TRAIN

My Sorento PHEV popped a P0c4e code and now the car is gutless on electric power. Kia cleared the code in an attempt to fix it but now the code is gone and it’s still weak. When I let off the brake it rolls when it used to have the power to hold it. I used to be able to get on the freeway and now I can’t get up to speed in town (35mph). It’s running in some sort of limp mode and Kia can’t see any codes. It’s loud, too. Each gear whines. It whines when I hit the brake and it regenerates electricity. It regens so little now that it doesn’t hardly slow me down anymore until I stand on them and use the brake pads. Kia said that it might be a sensor in the electric motor but it’s not replaceable and you have to replace the whole motor. Even though it’s under warranty, it’s 15 hours labor to replace it. I have family with the same car and theirs has done the same thing in the past and had to be replaced. My dealer said that they have seen a bunch of these throw that same code and have to have the motor replaced. She said she is expecting Kia to start replacing them for free or possibly recall them because of how many she has seen all doing the same thing.

ELECTRICAL SYSTEM

My Sorento PHEV popped a P0c4e code and now the car is gutless on electric power. Kia cleared the code in an attempt to fix it but now the code is gone and it’s still weak. When I let off the brake it rolls when it used to have the power to hold it. I used to be able to get on the freeway and now I can’t get up to speed in town (35mph). It’s running in some sort of limp mode and Kia can’t see any codes. It’s loud, too. Each gear whines. It whines when I hit the brake and it regenerates electricity. It regens so little now that it doesn’t hardly slow me down anymore until I stand on them and use the brake pads. Kia said that it might be a sensor in the electric motor but it’s not replaceable and you have to replace the whole motor. Even though it’s under warranty, it’s 15 hours labor to replace it. I have family with the same car and theirs has done the same thing in the past and had to be replaced. My dealer said that they have seen a bunch of these throw that same code and have to have the motor replaced. She said she is expecting Kia to start replacing them for free or possibly recall them because of how many she has seen all doing the same thing.

POWER TRAIN

I have gotten the notice Refill Inverter Coolant and Hybrid System Failure and lost acceleration and the all power. The first time this happened was in Dec 2024 with about 60,000 miles on the car. Dealer flushed system and it worked fine until April 2025 at about 71000 miles Hybrid system failure alert again, barely able to accelerate from stop light, made to a parking space just as I lost power steering. After about 2 hours to cool off car started and could be driven home. Got Refill inverter coolant alert.

BACK OVER PREVENTION

The contact owns a 2022 Kia Sorento PHEV. The contact stated that while reversing the vehicle, the rearview camera failed to display a clear image, and the grid lines were not properly aligned. The contact crashed the vehicle into his mailbox. There were no injuries sustained and no police report was filed. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The contact related the failure to NHTSA Campaign Number: 23V610000 (Back Over Prevention); however, the VIN was not included in the recall. The manufacturer was not made aware of the failure. The failure mileage was approximately 22,500.

FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING

Several times over the past 12 months, the car has applied emergency braking when a car approaches me from behind in the lane to my left. The dealer was not able to replicate the problem but I have captured it twice on my dash cam. I was only able to intentionally replicate the problem once on my own but it has happened 15-20 times. If I do not press the accelerator, the car will come to a stop without me pushing the brake. When the emergency brake is applied, the warning sound is heard in the car and the dash lights up with the emergency braking icon and emphasizes the left rear of the vehicle. I have been to the dealer twice for this issue. The first time they told me it was due to a faulty camera mount under recall. It was replaced but the issue continued. The second time they told me they decreased the sensitivity of some sensor. The issue continued.

SERVICE BRAKES

Several times over the past 12 months, the car has applied emergency braking when a car approaches me from behind in the lane to my left. The dealer was not able to replicate the problem but I have captured it twice on my dash cam. I was only able to intentionally replicate the problem once on my own but it has happened 15-20 times. If I do not press the accelerator, the car will come to a stop without me pushing the brake. When the emergency brake is applied, the warning sound is heard in the car and the dash lights up with the emergency braking icon and emphasizes the left rear of the vehicle. I have been to the dealer twice for this issue. The first time they told me it was due to a faulty camera mount under recall. It was replaced but the issue continued. The second time they told me they decreased the sensitivity of some sensor. The issue continued.