2013 KIA OPTIMA

SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP:CONTROL UNIT/MODULE

Kia America, Inc. (Kia) is recalling certain 2010-2019 Borrego, 2014-2016 Cadenza, 2010-2013 Forte, Forte Koup, Sportage, 2015-2018 K900, 2011-2015 Optima, 2011-2013 Optima Hybrid, Soul, 2012-2017 Rio, 2011-2014 Sorento, and 2010-2011 Rondo vehicles. The Hydraulic Electronic Control Unit (HECU) may experience an electrical short, which can result in an engine compartment fire while parked or driving.

Risk: An engine compartment fire while parked or driving can increase the risk of injury.

FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS

Kia Motors America (Kia) is recalling certain 2013-2014 Optima vehicles that were previously repaired under NHTSA recall number 20V-100. The low pressure fuel hose may be damaged, or missing heat-protective tape, which can result in a fuel leak.

Risk: A fuel leak can increase the risk of a fire.

SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP:CONTROL UNIT/MODULE

Kia Motors America (Kia) is recalling certain 2013-2015 Optima and 2014-2015 Sorento vehicles previously recalled under recall 20V-519. Brake fluid may leak inside the Hydraulic Electronic Control Unit (HECU), possibly resulting in an electrical short.

Risk: An electrical short in the HECU increases the risk of a fire while parked or driving.

SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP:CONTROL UNIT/MODULE

Kia Motors America (Kia) is recalling certain 2013-2015 Optima and 2014-2015 Sorento vehicles. Brake fluid may leak inside the Hydraulic Electronic Control Unit (HECU), possibly resulting in an electrical short.

Risk: If the HECU short circuits, there is an increased risk of an engine compartment fire.

FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS

Kia Motors America (Kia) is recalling certain 2013-2014 Optima vehicles equipped with 2.4L Gasoline Direct Injection (GDI) or 2.0L GDI Turbo engines. The low pressure fuel hose may deteriorate and crack over time due to heat generated within the engine compartment.

Risk: If the fuel hose cracks, a fuel leak can occur, increasing the risk of a fire.

FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS

Kia Motors America (Kia) is recalling certain 2011-2017 Optima, 2012-2017 Sorento and 2011-2018 Sportage vehicles that previously received an engine replacement under recall number 17V-224, warranty, or the Knock Sensor Detection System (KSDS) Product Improvement Campaign. The high pressure fuel pipe that connects to the fuel pump outlet may have been damaged, misaligned or improperly torqued during the engine replacement procedure, possibly causing a fuel leak.

Risk: A fuel leak in the presence of an ignition source can increase the risk of a fire.

AIR BAGS: AIR BAG/RESTRAINT CONTROL MODULE

Kia Motors America (Kia) is recalling certain 2010-2013 Kia Forte, Forte Koup, 2011-2013 Kia Optima and 2011-2012 Kia Optima Hybrid and Sedona vehicles. In the event of a crash, the air bag control unit (ACU) may short circuit, preventing the frontal air bags and seat belt pretensioners from deploying.

Risk: If the frontal air bags and seat belt pretensioners are disabled, there is an increased risk of injury to the vehicle occupants in the event of a vehicle crash that necessitates deployment of these safety systems.

STEERING

I had the car inspected by an independent service center because of extreme shaking from the steering wheel and steering wheel being unstable when going over bumps and making clanking noises all while driving. The steering wheel began to feel very loose and dangerous to drive so I took it in and they had to replace the steering coupling Assembly.

ENGINE AND ENGINE COOLING

The contact owns a 2013 Kia Optima. The contact stated while driving approximately 70-75 MPH, the contact accelerated to 80 MPH to pass another vehicle; however, after releasing the accelerator pedal, the vehicle stalled. The contact was able to pull over to the side of the road. The battery and the low oil pressure warning lights and two other unknown warning lights were illuminated. The vehicle failed to restart and was towed to an independent mechanic, where it was diagnosed and determined that the engine had seized and needed to be replaced. The vehicle was not repaired. The contact related the failure to NHTSA Campaign Number: 17V224000 (Engine and Engine Cooling); however, the VIN was not included in the recall. The manufacturer was not notified of the failure. The failure mileage was approximately 123,000.

ENGINE

The contact owned a 2013 Kia Optima. The contact's son was driving at 35 MPH when smoke was emitting from under the hood. The contact's son pulled over to the side of the road and immediately exited the vehicle. The contact's son opened the hood, and smoke was emitting from the engine. No warning lights were illuminated. The contact's son did not sustain any injuries. The police or fire department was not called. The vehicle was towed to an independent mechanic, who diagnosed that an electrical fire had started in the engine and damaged the engine. The vehicle was not repaired. The manufacturer was not notified of the fire. The contact stated that the engine was replaced in 2018 or 2019 due to an unknown recall. The contact did not notify her insurance company. The failure mileage was approximately 190,000.

ENGINE

After picking up my 2013 Kia Optima from a Kia dealership for an engine recall repair, I was told that no issues were found with the vehicle. The following morning, while driving on the freeway, the vehicle suddenly stalled without warning and lost power in the middle of traffic. This created a dangerous situation, as the driver was left stranded in an active lane with vehicles traveling at high speeds. Prior to dropping off the car, multiple independent mechanics and a body shop had advised that the vehicle was unsafe to drive due to engine concerns. The dealer stated they could not reproduce the issue and cleared the car for use. However, within hours of getting the car back, the stall occurred. The vehicle is currently available for inspection. The problem has not yet been confirmed by the dealer, but the symptoms are consistent with known Kia engine failures related to connecting-rod bearing wear. Before the stall, the check engine light had intermittently illuminated, but the dealer reported “no issues found.” This failure put the driver and surrounding motorists at serious risk of a collision and highlights that the recall remedy may not have addressed the underlying safety defect.

STRUCTURE:BODY

3 years ago the paint on my car started peeling. I drove my car from rideshare and was unable to continue due to the visual condition of my car. After further research, it's a nationwide problem. I dont have the money to afford a full paint job and put a bad taste in my mouth when thinking about referring people buying a Kia or my next car purchase. I have lost thousands of dollars due to kid's negligence on their paint.

STEERING

The steering wheel has a noise when turn, actually the noise is so loud now that it shakes while I'm driving. I have a video of it. I also brought to the mechanic and he told me that this is from the manufacturer problem. The videos are not support to download here. Let me know if I can send it through another way. Thank you, I'm going to kia dealer on Sep. 2nd to fix another recall, if please, send me a recall for the steering wheel as well. Thank you, appreciate it.

SERVICE BRAKES, HYDRAULIC

The contact owns a 2013 Kia Optima. The contact stated that while driving approximately 65 MPH, there was a burning odor inside the vehicle before the vehicle stalled. The vehicle was later towed to the local dealer who diagnosed the vehicle with engine seizure. The contact was informed that the engine needed to be replaced. The vehicle was not yet repaired. The contact was informed of the NHTSA Campaign Number: 23V652000 (SERVICE BRAKES, HYDRAULIC), but due to the vehicle having a branded title, the recall repair was not performed. The failure mileage was 119,000.

ENGINE AND ENGINE COOLING

The contact owns a 2013 Kia Optima. The contact stated that while driving approximately 65 MPH, there was a burning odor inside the vehicle before the vehicle stalled. The vehicle was later towed to the local dealer who diagnosed the vehicle with engine seizure. The contact was informed that the engine needed to be replaced. The vehicle was not yet repaired. The contact was informed of the NHTSA Campaign Number: 23V652000 (SERVICE BRAKES, HYDRAULIC), but due to the vehicle having a branded title, the recall repair was not performed. The failure mileage was 119,000.

ENGINE

My car lost power on [xxx]..Called a tow truck to come and pick it up. cone to found out my engine was blown. Taking it to a kia dealership on 09/12/2025 to get a diagnostic test done on it. I have all my paperwork. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

UNKNOWN OR OTHER

White paint coming off

ENGINE

Hello, I have been a KIA owner for a very long time. I am dissatisfied with the corporation regarding my current experience. My vehicle qualified for the engine recall. Over several months I have been bringing my car into KIA Valley regarding concerns of the performance of my car which is connected with the recall. Every time I have brought in my car , the code has not popped up yet. I followed up with a phone call to KIA customer service. Over the phone I was told that the code needs to be popped up. In order for that to happen, that would require my car to seize or the engine catch on fire. The FACT THAT THIS COMPANY IS WILLING TO PUT LIVES AT RISK, is alarming. A few weeks ago at 10:00PM at night my car seized on the on ramp of freeway. Took car to dealer. I was informed the code did not pop up and the KIA dealer filled my car with more oil.A week later, my engine completely seized and oil was everywhere. I WAS IN FEAR OF MY ENGINE CATCHING ON FIRE. I got out of my car and called a tow truck. I was informed by the service dealership that the code popped up. Meaning I now qualify for a new engine. The following day I received a phone call that CORPORATE IS KICKING IT BACK AND DEMANDING AN ABUNDANCE of receipts. Receipts dating back even several years, to try to prove its neglect on my end, for the company to avoid cost. When clearly this is due to the recall per the service dealer. I recently went to the dealer to bring several receipts showing the care for my KIA. IT IS STILL NOT GOOD ENOUGH FOR CORPORATE. Receipts even included documentation from other mechanic businesses that did not want to work on my car because their finding with my engine appeared to be linked to the recall. They told me it was unsafe to drive and take it to the dealer. Over the past 8 months because KIA CORPORATE has made it difficult. I am seeking help.

VEHICLE SPEED CONTROL:ACCELERATOR PEDAL

The contact owns a 2013 Kia Optima. The contact stated that after having the vehicle for a month, while driving approximately 30-40 MPH on a residential street, there was an abnormal knocking sound coming from the vehicle and the vehicle went into LIMP Mode. The vehicle failed to accelerate above 35 MPH and stalled. There were no warning lights illuminated. The contact stated that the vehicle had a Salvaged Title but should still be covered under NHTSA Campaign Number: 23V652000 (Service Brakes, Hydraulic). The vehicle was towed to the local dealer, where it was diagnosed with engine rod bearing failure. The vehicle was not repaired. The manufacturer was contacted regarding the failure. The approximate failure mileage was 137,000.

ENGINE

The contact owns a 2013 Kia Optima. The contact stated that after having the vehicle for a month, while driving approximately 30-40 MPH on a residential street, there was an abnormal knocking sound coming from the vehicle and the vehicle went into LIMP Mode. The vehicle failed to accelerate above 35 MPH and stalled. There were no warning lights illuminated. The contact stated that the vehicle had a Salvaged Title but should still be covered under NHTSA Campaign Number: 23V652000 (Service Brakes, Hydraulic). The vehicle was towed to the local dealer, where it was diagnosed with engine rod bearing failure. The vehicle was not repaired. The manufacturer was contacted regarding the failure. The approximate failure mileage was 137,000.

SERVICE BRAKES, HYDRAULIC

The contact owns a 2013 Kia Optima. The contact stated that after having the vehicle for a month, while driving approximately 30-40 MPH on a residential street, there was an abnormal knocking sound coming from the vehicle and the vehicle went into LIMP Mode. The vehicle failed to accelerate above 35 MPH and stalled. There were no warning lights illuminated. The contact stated that the vehicle had a Salvaged Title but should still be covered under NHTSA Campaign Number: 23V652000 (Service Brakes, Hydraulic). The vehicle was towed to the local dealer, where it was diagnosed with engine rod bearing failure. The vehicle was not repaired. The manufacturer was contacted regarding the failure. The approximate failure mileage was 137,000.

UNKNOWN OR OTHER

The paint on my car slowly began to peel away on the hood and side panels, eventually exposing almost the entire hood to be bare (Kia was notified and I was denied any sort of help). I had the hood and panels painted out of pocket, shortly after the side rear passenger door has begun with the exact same issue Eventually, my car is going to be missing all paint and just primer. This needs to be addressed in a class action settlement! Otherwise my car is immaculate condition.

STRUCTURE:BODY

The paint on my car slowly began to peel away on the hood and side panels, eventually exposing almost the entire hood to be bare (Kia was notified and I was denied any sort of help). I had the hood and panels painted out of pocket, shortly after the side rear passenger door has begun with the exact same issue Eventually, my car is going to be missing all paint and just primer. This needs to be addressed in a class action settlement! Otherwise my car is immaculate condition.

ENGINE AND ENGINE COOLING

The contact owns a 2013 Kia Optima. The contact stated while driving 45 MPH, the vehicle stalled. The low oil pressure warning light flashed on the instrument panel. The contact called Roadside Assistance and was informed that the oil level was low. The vehicle was towed to an independent mechanic, where an oil change was performed; however, the failure persisted. The vehicle was then towed to a dealer, where it was diagnosed with engine failure. The manufacturer was notified of the failure and informed the contact that the repair could not be covered under warranty because the knock sensor detection system software was not previously updated under warranty. The vehicle was not repaired and remained at the dealer. The failure mileage was approximately 119,000.

ENGINE

The contact owns a 2013 Kia Optima. The contact stated while driving 25 MPH, the engine seized. There was no warning light illuminated. The vehicle was towed to the residence. The dealer was contacted; however, the vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 140,000.

STRUCTURE:BODY

PAINT ON MY KIA OPTIMA HAS BEEN PEAL LIKE THE PAINT JOB WAS BAD IT WAS NEVER PAINT IT HAS ORGINAL PAINT FROM WHEN IT WAS FIRST OPERATED.

STEERING

I called Kia Consumer Assistance in reference the MDPS flexible coupling. I spoke with a Kia representative named Gina. I specifically asked if this item is covered under my vehicles warranty (i gave the vin number of the vehicle to her. She stated if it was diagnosed as the MDPS flexible coupling, it would be covered. I made an appointment (it took two weeks) with Spitzer Kia at 3414 Brookpark Rd, Cleveland, Ohio 44134. The service advisor, Belinda Frost, stated, yes the MDPS flexible coupling needs to be replaced. I gave the case number from Kia, #[XXX]. She looked and said it is not covered. I told her Gina from Kia consumer assistance stated it is covered. She called Kia, spoke with "Brad" who stated I would need to pay a $93.00 diagnostic charge (car was already diagnosed with the issue) and leave the car for 24 to 48 hours. During that time, they would make a determination if it is warrantied - I believe that other person's name was Robert - the regional manager. He would need to approve coverage for the MDPS flexible coupling. The diagnosis is to turn the steering wheel while the engine is off for play and a clunking sound, which takes 30 seconds and was already done. Also note this is a hazard as the car wanders due to additional play in the steering, sometimes has a notch, taking more effort to turn the wheel slightly plus makes a metal on metal sound when going over bumps. This $10.00 part, should be mandated to replace without a time limit. I was also told it was covered by warranty by Kia consumer after giving the serial number, and that was NOT honored by the dealership nor Kia consumer when the dealer ship called in my presents. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

ENGINE

The contact owns a 2013 Kia Optima. The contact stated that while driving approximately 60 MPH, the vehicle suddenly lost motive power. There were no warning lights illuminated. The contact was able to restart the vehicle and continued driving. The contact stated that during the second failure, the vehicle was unable to be restarted. The vehicle was towed to the person who the contact purchased the vehicle from who was a certified mechanic and was diagnosed with engine failure. The vehicle was not repaired. The manufacturer was informed of the failure, and confirmed that the VIN was not under recall or warranty. The failure mileage was unknown.

ENGINE

I own a Kia optima LX 4.0 engine when I called I was told that this car has an open recall for engine rod bearing defect my engine locked up on me 2 mts ago and has not ran since I just finalized my payments on this car and received the title...I took very good care of this car and it was well maintained...it only has 104,000 miles on it.i called and was told this open recall could be fixed with no problem however when I took it to Kia dealership here in gso NC they refused to repair it..I've spent almost 200.00 in towing fees for nothiing..I'm so unhappy with the response I've gotten with this company since I have had such a wonderful experience with my car I hope maybe I can get a response from your company for its the only car I have and my daily living activities have been altered by lack of transportation..thank you..I was told to call attorney general to see what could come about however Im hoping I can get a response from your office

UNKNOWN OR OTHER

This is a general inquiry on Kia white paint. My paint is chipping off all over my car. They told me it's inherent to white paint. Is this true or are the trying to get away without addressing the problem.

STEERING

Steering clunks left & right, feels like steering coupler or clock spring is broken or out of wack, steering column rattles on bumpy r thoughtoads

ENGINE

In December 2024 I experienced a major engine issue where while we were driving the car went from 75mph to losing all power and not allowing us to drive more than 20mph we took it to a shop in mt Juliet Tennessee where they proceeded to tell us that an error code of P0325 and that our engine had seized. They suggested I get it towed to Kia which I did. We towed it to Kia of Murfreesboro tn and they took about a month to tell us that the engine had seized and that due to car fax and sludge we couldnt get the engine replaced under the extended warranty however, when speaking with customer service at Kia over the phone, they promised me that my car and its engine are still covered under that warranty due to the class action lawsuit, and that my engine would be replaced at no cost to me. It is now been six months and I still have no answers, and everybody keeps telling me that due to lack of maintenance even though we are the only owners of the car and have kept up on the maintenance they are not honoring the extended warranty. My car currently is 120,000 miles extended warranty goes to 150,000 miles. I would like my car engine replaced. I don’t know what to do this point anymore.

STRUCTURE:BODY

While driving 55 mph down the road the window trim flew off of the rear driver side window and a week later the other side flew off hitting the car behind us. Not a very safe thing to be happening while driving.

ENGINE

My Kia has the part number that was recalled for the ABS module. But Kia said it’s not included in the recall because of my vin. Appeared 2 months ago. All lights on & potential risk of fire according to the brake fluid leaking. So I have to park outside. Kia inspected & said it was ABS module that needed replacement. For $2,600. Which I can’t afford. I Have already spent $500 for the other problems they said it was at first. But it didn’t fix the problem. Now I am having to borrow cars to get to work.

ELECTRICAL SYSTEM

My Kia has the part number that was recalled for the ABS module. But Kia said it’s not included in the recall because of my vin. Appeared 2 months ago. All lights on & potential risk of fire according to the brake fluid leaking. So I have to park outside. Kia inspected & said it was ABS module that needed replacement. For $2,600. Which I can’t afford. I Have already spent $500 for the other problems they said it was at first. But it didn’t fix the problem. Now I am having to borrow cars to get to work.

SERVICE BRAKES

My Kia has the part number that was recalled for the ABS module. But Kia said it’s not included in the recall because of my vin. Appeared 2 months ago. All lights on & potential risk of fire according to the brake fluid leaking. So I have to park outside. Kia inspected & said it was ABS module that needed replacement. For $2,600. Which I can’t afford. I Have already spent $500 for the other problems they said it was at first. But it didn’t fix the problem. Now I am having to borrow cars to get to work.

ENGINE

My ABS module is failing with no open recall, even though Kia has issued multiple safety recalls (SC197, SC212, SC284) for this exact issue. My car is showing brake system errors (ABS, EPB, traction control, auto hold) and has stored codes like [insert your codes]. I’m concerned this is a serious safety hazard. If brake fluid has leaked into the module, there’s a known risk of electrical fire, even while parked. Kia has not included my VIN, but I believe it should be. Please investigate expanding the recall to include additional VINs. I’m requesting NHTSA to take this report seriously and hold Kia accountable for known safety defects in affected vehicles that are being ignored due to VIN limitations.

ELECTRICAL SYSTEM

My ABS module is failing with no open recall, even though Kia has issued multiple safety recalls (SC197, SC212, SC284) for this exact issue. My car is showing brake system errors (ABS, EPB, traction control, auto hold) and has stored codes like [insert your codes]. I’m concerned this is a serious safety hazard. If brake fluid has leaked into the module, there’s a known risk of electrical fire, even while parked. Kia has not included my VIN, but I believe it should be. Please investigate expanding the recall to include additional VINs. I’m requesting NHTSA to take this report seriously and hold Kia accountable for known safety defects in affected vehicles that are being ignored due to VIN limitations.

UNKNOWN OR OTHER

The white paint on the car is peeling off in many areas of the car.

ENGINE

The contact owns a 2013 Kia Optima. The contact stated that the engine was replaced four years ago. The contact stated that the engine had not been running correctly since the engine was replaced. The contact stated that the engine was overheating, and there were several unknown warning lights illuminated. The contact stated that most recently the head gasket failed. The contact had taken the vehicle to a local dealer; however, the dealer was unable to diagnose the vehicle. The vehicle was not repaired. The contact stated that the vehicle had been taken to the same dealer several times. The contact stated that the dealer had the vehicle towed back to the residence and declined perform any further repairs. The manufacturer was informed of the failure. The failure mileage was 133,997.

ENGINE AND ENGINE COOLING

The contact owns a 2013 Kia Optima. The contact stated that the engine was replaced four years ago. The contact stated that the engine had not been running correctly since the engine was replaced. The contact stated that the engine was overheating, and there were several unknown warning lights illuminated. The contact stated that most recently the head gasket failed. The contact had taken the vehicle to a local dealer; however, the dealer was unable to diagnose the vehicle. The vehicle was not repaired. The contact stated that the vehicle had been taken to the same dealer several times. The contact stated that the dealer had the vehicle towed back to the residence and declined perform any further repairs. The manufacturer was informed of the failure. The failure mileage was 133,997.

FUEL/PROPULSION SYSTEM

Bought car 2020, engine failed and was consuming oil like it was fuel after 50-60K miles in 2022, Serra Kia Misdiagnosed and charged me $900 for ignition coil and combustion chamber cleaning that was not needed nor refunded when I was denied replacement due to me NOT letting engine lock up(Service manager basically told me to do so to be approved) or a P1326 code, charged +\-$8,000 for engine to be replaced. Horrible experience, engine was fine at first, then shortly after the SHORT mileage warranty they give, the engine started having minor non catastrophic issues here and there. Finally, around the same amount of time(last October 2024) and almost the SAME AMOUNT OF MILES on the engine, its doing EXACTLY what it was when i took it to KIA for the engine. One random day, on my way to work, i got to a red light and when i went to go at green the engine hesitated and i noticed a MASSIVE smoke cloud behind me and coming from my engine. It was consuming oil yet again the same way. Reached out to KCC(Kia Customer Care) and provided them a 4 page personally written letter by myself explaining the full story and my experience. However they merely closed my case without any explanation or reason for doing so. So as i stated to them i would do if i needed to, I've reached out to the BBB and now you. I'm hoping to get justice, whats right, and what should have happened in the first place. My money back and or my engine repaired and no more charges to me. 2022 first engine failure(Denied and paid for engine) Oct 2024 Engine failure AGAIN. (added copy of letter sent plus proof of service manager influencing me to lock the motor up to get covered the first time)

POWER TRAIN

Bought car 2020, engine failed and was consuming oil like it was fuel after 50-60K miles in 2022, Serra Kia Misdiagnosed and charged me $900 for ignition coil and combustion chamber cleaning that was not needed nor refunded when I was denied replacement due to me NOT letting engine lock up(Service manager basically told me to do so to be approved) or a P1326 code, charged +\-$8,000 for engine to be replaced. Horrible experience, engine was fine at first, then shortly after the SHORT mileage warranty they give, the engine started having minor non catastrophic issues here and there. Finally, around the same amount of time(last October 2024) and almost the SAME AMOUNT OF MILES on the engine, its doing EXACTLY what it was when i took it to KIA for the engine. One random day, on my way to work, i got to a red light and when i went to go at green the engine hesitated and i noticed a MASSIVE smoke cloud behind me and coming from my engine. It was consuming oil yet again the same way. Reached out to KCC(Kia Customer Care) and provided them a 4 page personally written letter by myself explaining the full story and my experience. However they merely closed my case without any explanation or reason for doing so. So as i stated to them i would do if i needed to, I've reached out to the BBB and now you. I'm hoping to get justice, whats right, and what should have happened in the first place. My money back and or my engine repaired and no more charges to me. 2022 first engine failure(Denied and paid for engine) Oct 2024 Engine failure AGAIN. (added copy of letter sent plus proof of service manager influencing me to lock the motor up to get covered the first time)

ENGINE

Bought car 2020, engine failed and was consuming oil like it was fuel after 50-60K miles in 2022, Serra Kia Misdiagnosed and charged me $900 for ignition coil and combustion chamber cleaning that was not needed nor refunded when I was denied replacement due to me NOT letting engine lock up(Service manager basically told me to do so to be approved) or a P1326 code, charged +\-$8,000 for engine to be replaced. Horrible experience, engine was fine at first, then shortly after the SHORT mileage warranty they give, the engine started having minor non catastrophic issues here and there. Finally, around the same amount of time(last October 2024) and almost the SAME AMOUNT OF MILES on the engine, its doing EXACTLY what it was when i took it to KIA for the engine. One random day, on my way to work, i got to a red light and when i went to go at green the engine hesitated and i noticed a MASSIVE smoke cloud behind me and coming from my engine. It was consuming oil yet again the same way. Reached out to KCC(Kia Customer Care) and provided them a 4 page personally written letter by myself explaining the full story and my experience. However they merely closed my case without any explanation or reason for doing so. So as i stated to them i would do if i needed to, I've reached out to the BBB and now you. I'm hoping to get justice, whats right, and what should have happened in the first place. My money back and or my engine repaired and no more charges to me. 2022 first engine failure(Denied and paid for engine) Oct 2024 Engine failure AGAIN. (added copy of letter sent plus proof of service manager influencing me to lock the motor up to get covered the first time)

ELECTRICAL SYSTEM

My engine locked ,

FUEL/PROPULSION SYSTEM

My engine locked ,

ENGINE

My engine locked ,

ENGINE AND ENGINE COOLING

The contact owns a 2013 Kia Optima. The contact stated while driving at an undisclosed speed, the vehicle inadvertently lost motive power. The contact was able to pull over to the shoulder of the roadway, where the vehicle failed to restart. No warning lights were illuminated. The vehicle was towed to the dealer, who diagnosed a failure with the oil control valve, resulting in damages to the engine. The vehicle was repaired, but the failure reoccurred. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 17V224000 (Engine and Engine Cooling), but the VIN was not included. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was unknown.

STEERING

I believe the steering wheel coupler is bad on my 2013 Kia Optima. It is a known issue for this year/make/model. The steering wheel is slipping and makes a clicking noise occasionally when turning.

UNKNOWN OR OTHER

The paint on my car is flaking off. We had a very bad storm and after it passed there was lots of paint gone from my car. I filed a claim with state farm and was denied as they state Kia was responsible of the paint because it's a know fact that the snow white pearl paint us defective and kua knows this. I file with Kia care and they say the paint warranty is gone. But they know that the paint is defective and they need to repaint my car. This issue started in 2011 through 2020. My car is a 2013 Kia optima and Kia is responsible for fixing this issue.

SERVICE BRAKES

Car cuts off while driving almost causing a accident. The brakes randomly stop working while driving also. The code says P1777 relating to the transmission/ hybrid system. Kia dealerships are charging customers to diagnosis their vehicles. Eventhough they already know this is a common problem with the hybrid cars. Also the 12v battery and hybrid battery needs to be replaced every 2 years, which is costly. The tech also advised that Hybrids are the worst cars and I should sale my car. This is unfair to customers and a waste of money. Please make this a recall and extend all warranties past 150k. This is a huge safety problem and could cause deaths in the future.

ELECTRICAL SYSTEM

Car cuts off while driving almost causing a accident. The brakes randomly stop working while driving also. The code says P1777 relating to the transmission/ hybrid system. Kia dealerships are charging customers to diagnosis their vehicles. Eventhough they already know this is a common problem with the hybrid cars. Also the 12v battery and hybrid battery needs to be replaced every 2 years, which is costly. The tech also advised that Hybrids are the worst cars and I should sale my car. This is unfair to customers and a waste of money. Please make this a recall and extend all warranties past 150k. This is a huge safety problem and could cause deaths in the future.

ENGINE

The contact owns a 2013 Kia Optima. The contact stated that while a friend was attempting to start the vehicle, the vehicle failed to start. There was no warning light illuminated. The vehicle was towed to a local dealer, where the vehicle was diagnosed, and the contact was informed that the engine had failed and needed to be replaced. The vehicle was not repaired. The contact referenced NHTSA Campaign Number: 23V652000 (SERVICE BRAKES, HYDRAULIC); as the probable cause for the failure. The manufacturer was notified of the failure. The approximate failure mileage was 67,999.

SERVICE BRAKES, HYDRAULIC

The contact owns a 2013 Kia Optima. The contact stated that while a friend was attempting to start the vehicle, the vehicle failed to start. There was no warning light illuminated. The vehicle was towed to a local dealer, where the vehicle was diagnosed, and the contact was informed that the engine had failed and needed to be replaced. The vehicle was not repaired. The contact referenced NHTSA Campaign Number: 23V652000 (SERVICE BRAKES, HYDRAULIC); as the probable cause for the failure. The manufacturer was notified of the failure. The approximate failure mileage was 67,999.

SERVICE BRAKES, HYDRAULIC

The contact owned a 2013 Kia Optima. The contact stated that after parking her vehicle in her driveway when the vehicle had caught on fire 2 hours later. The vehicle was unoccupied during the fire. The origin of the fire was unknown. The location of the fire was underneath the front driver's side tire, shortly after the vehicle was engulfed in flames, and due to the proximity of the vehicle to the contact's residence, this caused siding on the side of her house to also catch on fire. The fire department arrived and extinguished the fire. A fire department report was filed. A police department report was filed. The vehicle was destroyed. No injuries were reported. The local dealer was not contacted. The contact referenced NHTSA Campaign Number: 21V331000 (SERVICE BRAKES, HYDRAULIC) as probable cause for the failure. The manufacturer was notified of the failure. The approximate failure mileage was 116,000.

SERVICE BRAKES

Yesterday [XXX] as I was driving with my wife present, suddenly warning popped up: Stop the car, hybrid break system safety, not safe to drive, or something close to that, I don't recall exact words. The car started to sputter , the brake pedal lost power meaning no brake, I quickly looked at the rear view mirror, luckily there was no car coming up close to me, the car lost speed and I slowly drove into an almost vacant parking lot across Lowe's, turned the engine off. Waited 30 minutes and start the car and the issue was gone. The same thing happened almost a month ago but that time the car was parked and hybrid brake system safety popped up as I tried to start the car and went away after 45 minutes of the engine being off. Had yesterday's episode happened while I was driving on the highway two weeks ago to visit my grandsons in Fontana, I would have surly killed in an horrific accident. My vehicle is Optima Hybrid. Thank you. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

STRUCTURE:BODY

The white paint on my car (Snow White Pearl) has been chipping and peeling off near the windshield and rails on the side as well the hood. This is a known problem for KIA's with this particular white colored paint and KIA should really address is. Touching up just the locations it's happening in is not a fix ... The car needs to be properly repainted to fix the issue. KIA has not addressed this for customers and really need to as this happens for spanning several years and different models.

ELECTRICAL SYSTEM

I am leasing the 2013 Kia Optima LX through a 3rd party dealership that apparently stated in their terms and conditions that they are not responsible for doing maintenance on the car before being sold. I was on the road after getting gas when all of the sudden, the car started to slow down and my emergency check oil, engine, battery lights all came on. I was able to safely pull into a parking lot but after that, the car wouldn’t turn on. After trying to jump start the battery with another car, the engine started to smoke. We thought the alternator died. The third party dealership has their own maintenance shop and said it was alternator one day, then said it was engine the next and it manually can’t be turned over. That’s when they said because I didn’t get a software update, I didn’t have a warranty and I need to pay for the engine myself. Kia won’t help and the dealership won’t lend a loaner car for this inconvenience. I was never made aware that there were recalls on the car or a software update that needed to happen.

ENGINE

I am leasing the 2013 Kia Optima LX through a 3rd party dealership that apparently stated in their terms and conditions that they are not responsible for doing maintenance on the car before being sold. I was on the road after getting gas when all of the sudden, the car started to slow down and my emergency check oil, engine, battery lights all came on. I was able to safely pull into a parking lot but after that, the car wouldn’t turn on. After trying to jump start the battery with another car, the engine started to smoke. We thought the alternator died. The third party dealership has their own maintenance shop and said it was alternator one day, then said it was engine the next and it manually can’t be turned over. That’s when they said because I didn’t get a software update, I didn’t have a warranty and I need to pay for the engine myself. Kia won’t help and the dealership won’t lend a loaner car for this inconvenience. I was never made aware that there were recalls on the car or a software update that needed to happen.

ENGINE

I came in to Oil Changers in Fremont California on 4088 Thornton Avenue on 1/8/25 to come in and get an oil change prior to my road trip to Virginia with my dad on [XXX]. I talked to the worker about getting my oil changed and was even asked whether or not I wanted a regular or synthetic oil change in which I said synthetic because it was the best option for my car's long term health. During my service of the car I was also told my car needed a coolant refill soon and oil air filter and was asked if I would like to get that as well which i said yes. When my service was done I was given my receipt of the things done as well as given my oil service sticker that I put on my windshield. After my service I continued with my life as usual the next two days before taking my trip. While on my trip I got to approximately 150 miles from Fremont California before I started to feel an unusual feeling in the gas pedal which went away for a little before eventually turning into a clicking noise around 150 miles after which immediately turned to a complete stoppage on [XXX] about 10 miles Keene. We were in the middle of nowhere in pitch black darkness waiting for my AAA insurance tow truck to come pick us up. My car engine seized up and now it need a completely new engine. I was already paying a monthly car note of 247.69 every 10th and still have a remaining balance of $5,000 left. I now couldn't drive to Virginia with my car because of an error that was not of my doing i've always tried my best to mainta0in the car to the best of my ability. The car's error forced me and my dad to get last second plane tickets to Virginia the day after [XXX] for 611.94 so I could make it to my college on time. This has caused me so much hassle and now i cant even have a vehicle for school because of something out of my control. l still have the receipt from Oil Changers that states i paid for an Synthetic oil change as well all of this information can and will be sent over to you. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION A

UNKNOWN OR OTHER

The paint on my Kia optima is coming off.

ENGINE

I bought this car for 6000$ in the month of November. I checked everything while buying the car. I did checked the oil level the engine sound its condition and transmission. I did the oil change myself after buying and once in the middle. Suddenly on Feb 16th it got stopped on the middle of the highway. After lot research I see there are thousands of complaints for the kia optima’s and Hyundai Sonata’s for their failure GDI Engines. I towed to dealership whether they could help replacing engine. They haven’t. I see there are no recalls on this car. I would like to complain regarding this incident and justice should be provided to me

ENGINE

The contact owns a 2013 Kia Optima. The contact stated that while driving approximately 40 MPH when they suddenly heard a loud boom noise and the front end of the vehicle caught on fire. The contact pulled into a nearby parking lot and all passengers exited the vehicle. The vehicle was consumed by the fire which was put out by the fire department. The vehicle was towed and totaled. There were no injuries or need for medical assistance. The fire department filed a report. There were no injuries or need for medical assistance. The dealer was contacted and informed of the failure. The vehicle was not taken to the dealer. The vehicle was not diagnosed or repaired. The manufacturer was not informed of the failure. The failure mileage was 187,000.

ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:CONTROL MODULE

The contact owns a 2013 Kia Optima. The contact stated that while the vehicle was parked, the vehicle was stolen. The vehicle had been repaired by the dealer for an unknown recall for the anti-theft system. The vehicle was stolen, and the anti-theft feature failed to function as designed. A Police report was filed; however, the police report was not available. The dealer was not made aware of the failure. The manufacturer was not made aware of the failure. The failure mileage was approximately 90,000.

ENGINE

When I turned the ignition on the car wouldn't start. But the ABS light and all other lights flickering when trying to start the car. The alarm kept going off. Passenger side front and rear windows won't function. Smell like something was burning. This is the second incident ([XXX]). Fuses had to be removed to silence the alarms on the first incident on [XXX] because the lights were still flickering on and off when car wasn't on. I had my car serviced at the West Broad Kia Dealership in Richmond, Va. Thank you! INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

EXTERIOR LIGHTING

When I turned the ignition on the car wouldn't start. But the ABS light and all other lights flickering when trying to start the car. The alarm kept going off. Passenger side front and rear windows won't function. Smell like something was burning. This is the second incident ([XXX]). Fuses had to be removed to silence the alarms on the first incident on [XXX] because the lights were still flickering on and off when car wasn't on. I had my car serviced at the West Broad Kia Dealership in Richmond, Va. Thank you! INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

ELECTRICAL SYSTEM

When I turned the ignition on the car wouldn't start. But the ABS light and all other lights flickering when trying to start the car. The alarm kept going off. Passenger side front and rear windows won't function. Smell like something was burning. This is the second incident ([XXX]). Fuses had to be removed to silence the alarms on the first incident on [XXX] because the lights were still flickering on and off when car wasn't on. I had my car serviced at the West Broad Kia Dealership in Richmond, Va. Thank you! INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

ENGINE AND ENGINE COOLING

The contact owns a 2013 Kia Optima. The contact stated while driving at approximately 35 MPH, the vehicle stalled. The contact stated that the power steering assist and brakes failed when the vehicle stalled. The contact stated no warning light was illuminated. The contact had the vehicle towed to a local dealer, where it was diagnosed and determined that the engine had seized and needed to be replaced. The vehicle was not repaired. The contact had been advised by the dealer that the VIN was not included in NHTSA Campaign Number: 17V224000 (Engine and Engine Cooling). The manufacturer was informed of the failure. The failure mileage was approximately 147,000.

ENGINE

driving down highway on March 1, 2025 a knocking sound started, the oil light came on, making weird loud tapping, knocking sounds. I just bought vehicle about 4 months ago, it was in mint condition and I NEED my car is my lively hood

FUEL/PROPULSION SYSTEM

I have notice an ongoing issues with motor oil consumption. Over the past six months, I have added oil every 2,000 miles The Technicians at Oil Changers recently inspected my vehicle and recommended having it evaluated as the issue seems to be occurring more frequently. There are no warning lights displayed on my dashboard, I have not noticed any oil leaks where I park. While my car has been running fine,I want to insure there are no underlying issues. But most important me and my family’s safety and everyone’s when operating the vehicle. Please let me know the next steps for further inspection.

ENGINE

I have notice an ongoing issues with motor oil consumption. Over the past six months, I have added oil every 2,000 miles The Technicians at Oil Changers recently inspected my vehicle and recommended having it evaluated as the issue seems to be occurring more frequently. There are no warning lights displayed on my dashboard, I have not noticed any oil leaks where I park. While my car has been running fine,I want to insure there are no underlying issues. But most important me and my family’s safety and everyone’s when operating the vehicle. Please let me know the next steps for further inspection.

SERVICE BRAKES, HYDRAULIC

I am a owner of the Kia Optima 2013 and wish to fill a complaint with the dealership Luther Kia of Inver Grove for refusing to complete/resolve the safety recall of NHTSA #23V652. I attempted several times but was told by the staff, the remote start on my vehicle need to be removed and replaced in order for them to complete the safety recall. It would cost 200.00 to take it off and then, another 200.00 to reinstall it at the cost of myself. This seems like an unreasonable high cost to make sure my car is safe. I don't think is fair or right. This is a inconvenience for me! Please help!

SERVICE BRAKES, HYDRAULIC

The contact owns a 2013 Kia Optima. The contact received notification of NHTSA Campaign Number: 23V652000 (SERVICE BRAKES, HYDRAULIC); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

SERVICE BRAKES, HYDRAULIC

The contact owns a 2013 Kia Optima. The contact received notification of NHTSA Campaign Number: 23V652000 (SERVICE BRAKES, HYDRAULIC). The contact stated while driving 15 MPH, the brake pedal was depressed; however, the vehicle failed to respond as needed. There were no warning lights illuminated. The contact then tried to merge into the Wal-Mart parking lot with the assistance of a police officer. An independent mechanic arrived at Wal-Mart where the vehicle was parked to diagnose the vehicle. The vehicle was diagnosed with starter failure. The vehicle was then towed to the dealer where it was diagnosed with engine failure. The vehicle was not repaired because the manufacturer informed the contact that the vehicle had not been repaired under the other 7 recalls associated with the VIN. The manufacturer was made aware of the failure. The failure mileage was approximately 120,000. Parts distribution disconnect.

ENGINE

Vehicle starts to shake above 2000 rpm and shuts down. Went to a mechanic and they said the engine was bad and that there were recalls by Kia for this particular engine. When we asked a Kia Dealer they said they would not warranty due to this being our first visit for a recall.

UNKNOWN OR OTHER

My driver's side door lock actuator is stuck in the closed position, and will not allow me to close the door. I searched for a video on what to do, as I need the door to close to drive safely, and found hundreds of videos of people with the same car having this same issue. The fix that a video provided explained to hold the door handle open (the inside or outside handle work just the same) and to take a key or screwdriver and flip the actuator into the correct position, allowing the door to latch properly. I searched the internet to see how difficult it is to replace, and found more people with my car's make/model having issues with their door being stuck in the lock position, while the door is closed. This would be a nightmare in the case of an emergency retrieval. A faulty lock could literally be life or death.

STEERING

steering coupler failing, making loud noise

ENGINE

After engine replacement from previous recall, engine is making loud revving sound. Since recall repair/replacement the engine has an increasingly high rev with a loud engine noise while idling.

ENGINE

I have been experiencing my engine consuming oil with my dealerships knowledge Since back in 2023. In my records it is stated that my engine has been consuming oil. I was advised to continue to put oil in it myself until the engine goes out and then it will be covered. My engine light continues to go on and off. I went to the dealership today and was told that because my engine light is not on at the moment that I should come back so they can do a proper diagnosis. I was covered under the warranty to have the engine fixed but now that is over the 10 year warranty, I have no idea how to fix this issue after the diagnosis. I really need some help because I have been putting oil in it and I’m afraid that the engine will go out with it no longer being replaced. Especially when I had the warranty to use when it was initially discovered.

STRUCTURE:BODY

The paint is chipping heavily and apparently this is an issue with older Kia vehicles due to a primer issue.

ENGINE AND ENGINE COOLING

The contact's son owns a 2013 Kia Optima. The contact stated while his son was driving 50-60 MPH, the engine started overheating. The driver pulled to the side of the road and added coolant to the vehicle. The driver then drove to the residence. The contact stated that the vehicle was difficult to start the following day. The contact's son was able to restart the vehicle and drove to a nearby independent mechanic, where the engine started to overheat. The mechanic provided an unknown diagnosis and referred the contact to the dealer for an Extended Warranty repair. The vehicle was towed to the dealer, where it was diagnosed with a blown head gasket and damaged water pump. The dealer informed the contact the vehicle could not be covered under the Extended Warranty. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 128,000.

ELECTRICAL SYSTEM

I purchased a 2013 Kia Optima EX from an on-line auction [XXX] in Memphis, Tn. After the car was delivered I noticed the vehicle engine had a slight engine knock. When I attempted to test drive the vehicle the engine knock grew louder, and the vehicle shut down in the middle of the road. I was fortunate enough to get the vehicle back to my residence where I was able inspect the engine, and noticed "Metal Dust" on the oil dipstick. Service records showed the vehicle had been serviced at the correct intervals, and the oil had been professionally been changed at correct intervals, and the vehicle appear to be in excellent condition. After doing some research I notice Kia had a recall for the "Theta Engine 2" for a rod bearing recall that was causing engine failure prematurely. I contacted Kia customer services on 11-20-24. I was told the vehicle was in fact under the "rod bearing" recall and it had a lifetime warranty on it. I was instructed to contact a Kia dealership to have the vehicle serviced for possible engine replacement due to rod bearing failure. I contacted Serra Kia of Jackson, TN, and inform them of my conversation with Kia's customer services, and I was told they were pretty sure the engine would have to be replaced, and to have the vehicle towed to their dealership to perform the services. I had the vehicle towed to Serra Kia on 12-2-24. I sent an email to the service department on 1-16-25 for an update on my vehicle. On 1-16-25 I received an email from the dealership's service department stating a case was opened with Kia Tech, and they declined approval of an engine because I bought it from an auction. The dealership did offer to replace the engine for $6003.71 for parts and labor. I contacted Kia customer services on 1-18-25 and they said they wouldn't approve replacing the engine even though it's under recall because I bought the vehicle at an auction. I'm filing this complaint because Kia is refusing to do an active safety recall for my vehicle. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF

UNKNOWN OR OTHER

I purchased a 2013 Kia Optima EX from an on-line auction [XXX] in Memphis, Tn. After the car was delivered I noticed the vehicle engine had a slight engine knock. When I attempted to test drive the vehicle the engine knock grew louder, and the vehicle shut down in the middle of the road. I was fortunate enough to get the vehicle back to my residence where I was able inspect the engine, and noticed "Metal Dust" on the oil dipstick. Service records showed the vehicle had been serviced at the correct intervals, and the oil had been professionally been changed at correct intervals, and the vehicle appear to be in excellent condition. After doing some research I notice Kia had a recall for the "Theta Engine 2" for a rod bearing recall that was causing engine failure prematurely. I contacted Kia customer services on 11-20-24. I was told the vehicle was in fact under the "rod bearing" recall and it had a lifetime warranty on it. I was instructed to contact a Kia dealership to have the vehicle serviced for possible engine replacement due to rod bearing failure. I contacted Serra Kia of Jackson, TN, and inform them of my conversation with Kia's customer services, and I was told they were pretty sure the engine would have to be replaced, and to have the vehicle towed to their dealership to perform the services. I had the vehicle towed to Serra Kia on 12-2-24. I sent an email to the service department on 1-16-25 for an update on my vehicle. On 1-16-25 I received an email from the dealership's service department stating a case was opened with Kia Tech, and they declined approval of an engine because I bought it from an auction. The dealership did offer to replace the engine for $6003.71 for parts and labor. I contacted Kia customer services on 1-18-25 and they said they wouldn't approve replacing the engine even though it's under recall because I bought the vehicle at an auction. I'm filing this complaint because Kia is refusing to do an active safety recall for my vehicle. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF

ENGINE

I purchased a 2013 Kia Optima EX from an on-line auction [XXX] in Memphis, Tn. After the car was delivered I noticed the vehicle engine had a slight engine knock. When I attempted to test drive the vehicle the engine knock grew louder, and the vehicle shut down in the middle of the road. I was fortunate enough to get the vehicle back to my residence where I was able inspect the engine, and noticed "Metal Dust" on the oil dipstick. Service records showed the vehicle had been serviced at the correct intervals, and the oil had been professionally been changed at correct intervals, and the vehicle appear to be in excellent condition. After doing some research I notice Kia had a recall for the "Theta Engine 2" for a rod bearing recall that was causing engine failure prematurely. I contacted Kia customer services on 11-20-24. I was told the vehicle was in fact under the "rod bearing" recall and it had a lifetime warranty on it. I was instructed to contact a Kia dealership to have the vehicle serviced for possible engine replacement due to rod bearing failure. I contacted Serra Kia of Jackson, TN, and inform them of my conversation with Kia's customer services, and I was told they were pretty sure the engine would have to be replaced, and to have the vehicle towed to their dealership to perform the services. I had the vehicle towed to Serra Kia on 12-2-24. I sent an email to the service department on 1-16-25 for an update on my vehicle. On 1-16-25 I received an email from the dealership's service department stating a case was opened with Kia Tech, and they declined approval of an engine because I bought it from an auction. The dealership did offer to replace the engine for $6003.71 for parts and labor. I contacted Kia customer services on 1-18-25 and they said they wouldn't approve replacing the engine even though it's under recall because I bought the vehicle at an auction. I'm filing this complaint because Kia is refusing to do an active safety recall for my vehicle. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF

SERVICE BRAKES

Was driving home and the brake light came on and dash said to pull over brakes started to grind as I pressed on them took it in and couldn’t find the problem looked online and a lot of people with my car are having the same problem read that there was a recall for the brake module 21V331000.

STEERING

I took my 2013 into the Kia dealer on 1/19/21 to checkout an issue with the steering wheel it felt as though when you went to turn the wheel the steering of the tires took a while to catch up. The service advisor wrote it up to replace the power steering coupler and it was repaired. The mileage at that time was 28,300. It is now April of 2022 I went back to the dealer for other work and told the service advisor that the same issue was happening again with steering. She informed me the the dealership only had to repair it once. The issue that I am having is this has been a problem 2011 to at least 2022 they sold the car with a faulty part and have been doing the repair with the same faulty. My mileage now on the car is 38,800. When this issue represented again in 2022 the mileage was approximately 34,500 That’s just over 6,000 miles. The repair is around $500.00. So if I repair now at that cost of $500.00 and the repair only last 6,000 miles I will be repairing it at 44,000 miles. I feel that they should repair the faulty part because it is no less a safety issue now as it was originally. Thank you [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

FUEL/PROPULSION SYSTEM

My vehicle received a new engine due to a component failure, which there was a recall specifically describing the failure, recall 17v224 (SC147). After the new engine replacement, April 2024, while driving my car I began to notice a faint smell of gas with inside my car. As time passed the smell grew heavier. Drove the car to the Pueblo Colorado Dealership and had the service department take a look to confirm the leak. It was confirmed and one of the service personnel tried to torque the bolt tighter and that did not stop the leak. I was told by one of the service personnel that it was not covered under warranty and the cost would be mine out of pocket to fix. I found out this fuel leak is a recall (SC172), vehicles that received an engine replacement under previous recall 17v224 (SC147). ("Kia Motors America, Inc., pursuant to the National Traffic and Motor Vehicle Safety Act, is conducting a Safety Recall Campaign to inspect and, if necessary, replace the High Pressure Fuel Pipe on certain 2011–2014 MY Kia Optima, 2012-2014 MY Kia Sorento, and 2011-2013 MY Kia Sportage vehicles that received an engine replacement under Recall No. 17v224 (SC147). The remedy for the previous recall may not have been properly performed, and in some cases, the high pressure fuel pipe may have been damaged, misaligned or improperly torqued during the engine replacement procedure, allowing fuel to leak. Leaking fuel increases the risk of fire."). I have spoken to the Dealership and they do not recognize this recall as it is not showing up in their data system. I have spoken to the Kia Corporation and I have gotten nowhere. This was issued by your department and is recognized by KIA corporation but the Pueblo Colorado KIA dealership states it is not in their system as a recall. My car has been parked after notifying both parties of this issue since December 19, 2024. Your NHTSA: Part 573 Safety Recall Report 18V-907 Manufacturer Recall No. : SC172

ENGINE

My vehicle received a new engine due to a component failure, which there was a recall specifically describing the failure, recall 17v224 (SC147). After the new engine replacement, April 2024, while driving my car I began to notice a faint smell of gas with inside my car. As time passed the smell grew heavier. Drove the car to the Pueblo Colorado Dealership and had the service department take a look to confirm the leak. It was confirmed and one of the service personnel tried to torque the bolt tighter and that did not stop the leak. I was told by one of the service personnel that it was not covered under warranty and the cost would be mine out of pocket to fix. I found out this fuel leak is a recall (SC172), vehicles that received an engine replacement under previous recall 17v224 (SC147). ("Kia Motors America, Inc., pursuant to the National Traffic and Motor Vehicle Safety Act, is conducting a Safety Recall Campaign to inspect and, if necessary, replace the High Pressure Fuel Pipe on certain 2011–2014 MY Kia Optima, 2012-2014 MY Kia Sorento, and 2011-2013 MY Kia Sportage vehicles that received an engine replacement under Recall No. 17v224 (SC147). The remedy for the previous recall may not have been properly performed, and in some cases, the high pressure fuel pipe may have been damaged, misaligned or improperly torqued during the engine replacement procedure, allowing fuel to leak. Leaking fuel increases the risk of fire."). I have spoken to the Dealership and they do not recognize this recall as it is not showing up in their data system. I have spoken to the Kia Corporation and I have gotten nowhere. This was issued by your department and is recognized by KIA corporation but the Pueblo Colorado KIA dealership states it is not in their system as a recall. My car has been parked after notifying both parties of this issue since December 19, 2024. Your NHTSA: Part 573 Safety Recall Report 18V-907 Manufacturer Recall No. : SC172

UNKNOWN OR OTHER

We were driving and then suddenly stopped, thank goodness nothing bad happened to us. and the car never turned on again! I Was told by a mechanic it was the engine. We were told there were several recalls and alot regarding the engine for this year. Why should I have to pay for something we're still paying on and that has been sitting in our driveway for over 2 years! Fix our car!

ENGINE

We were driving and then suddenly stopped, thank goodness nothing bad happened to us. and the car never turned on again! I Was told by a mechanic it was the engine. We were told there were several recalls and alot regarding the engine for this year. Why should I have to pay for something we're still paying on and that has been sitting in our driveway for over 2 years! Fix our car!

ENGINE AND ENGINE COOLING

The contact owns a 2013 Kia Optima. The contact stated that the vehicle was consuming an excessive amount of oil. There was no indication of an oil leak. There were no warning lights illuminated. There was an abnormal burning odor coming from the vehicle. The contact stated that the failure was related to NHTSA Campaign Number: 17V224000 (Engine and Engine Cooling). The vehicle was taken to the local dealer, where three oil consumption tests were performed. The mechanic added oil. The vehicle was repaired, but the failure recurred. The contact had to continuously add oil. The vehicle was taken back to the same local dealer, where it was diagnosed that the oil gasket was cracked. The oil gasket was replaced, but the failure persisted. The vehicle was taken to an independent mechanic for routine maintenance who determined that the engine was 2-quarts low on engine oil. The manufacturer was not contacted. The failure mileage was approximately 87,095.