KIA OPTIMA

SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP:CONTROL UNIT/MODULE

Kia America, Inc. (Kia) is recalling certain 2010-2019 Borrego, 2014-2016 Cadenza, 2010-2013 Forte, Forte Koup, Sportage, 2015-2018 K900, 2011-2015 Optima, 2011-2013 Optima Hybrid, Soul, 2012-2017 Rio, 2011-2014 Sorento, and 2010-2011 Rondo vehicles. The Hydraulic Electronic Control Unit (HECU) may experience an electrical short, which can result in an engine compartment fire while parked or driving.

Risk: An engine compartment fire while parked or driving can increase the risk of injury.

LATCHES/LOCKS/LINKAGES:TRUNK LID:LATCH

Kia America, Inc. (Kia) is recalling certain 2016-2017 Rio, 2016-2018 Optima, 2017-2018 Optima Hybrid and Optima Plug-in Hybrid vehicles. The trunk latch base may crack, preventing the opening of the trunk from the inside. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 401, "Internal Trunk Release."

Risk: A person inside the trunk compartment may become trapped, increasing their risk of injury.

FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS

Kia Motors America (Kia) is recalling certain 2013-2014 Optima vehicles that were previously repaired under NHTSA recall number 20V-100. The low pressure fuel hose may be damaged, or missing heat-protective tape, which can result in a fuel leak.

Risk: A fuel leak can increase the risk of a fire.

SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP:CONTROL UNIT/MODULE

Kia Motors America (Kia) is recalling certain 2013-2015 Optima and 2014-2015 Sorento vehicles previously recalled under recall 20V-519. Brake fluid may leak inside the Hydraulic Electronic Control Unit (HECU), possibly resulting in an electrical short.

Risk: An electrical short in the HECU increases the risk of a fire while parked or driving.

SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP:CONTROL UNIT/MODULE

Kia Motors America (Kia) is recalling certain 2013-2015 Optima and 2014-2015 Sorento vehicles. Brake fluid may leak inside the Hydraulic Electronic Control Unit (HECU), possibly resulting in an electrical short.

Risk: If the HECU short circuits, there is an increased risk of an engine compartment fire.

FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS

Kia Motors America (Kia) is recalling certain 2013-2014 Optima vehicles equipped with 2.4L Gasoline Direct Injection (GDI) or 2.0L GDI Turbo engines. The low pressure fuel hose may deteriorate and crack over time due to heat generated within the engine compartment.

Risk: If the fuel hose cracks, a fuel leak can occur, increasing the risk of a fire.

FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING

Kia Motors America (Kia) is recalling certain 2019 Optima vehicles equipped with Gamma 1.6L Turbo-GDI or Theta II 2.0L Turbo-GDI engines. A software error in the Forward Collision-Avoidance Assist (FCA) system may cause the braking assist function to not engage when a stationary vehicle is detected.

Risk: Improper intervention of the Forward Collision-Avoidance Assist can increase the risk of a crash.

FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS

Kia Motors America (Kia) is recalling certain 2011-2017 Optima, 2012-2017 Sorento and 2011-2018 Sportage vehicles that previously received an engine replacement under recall number 17V-224, warranty, or the Knock Sensor Detection System (KSDS) Product Improvement Campaign. The high pressure fuel pipe that connects to the fuel pump outlet may have been damaged, misaligned or improperly torqued during the engine replacement procedure, possibly causing a fuel leak.

Risk: A fuel leak in the presence of an ignition source can increase the risk of a fire.

HYBRID PROPULSION SYSTEM

Kia Motors America (Kia) is recalling certain 2017-2018 Kia Optima hybrid vehicles. These vehicles are equipped with a Voltage Protection Device (VPD), designed to protect the high voltage battery module, that may activate inadvertently.

Risk: If the VPD activates while the vehicle is being operated in Electric Vehicle (EV) mode, there may be a loss of power, increasing the risk of a crash.

ENGINE

Engine completely shut down when driving it. Had it replaced among many other things then found out it was part of a class action lawsuit. I have spent two years trying to recoup the money I lost in repairs and the cash I paid for the car.

ELECTRICAL SYSTEM:INSTRUMENT PANEL:SPEEDOMETER/ODOMETER

Odometer Fraud. The contact purchased a 2019 Kia Optima. The contact stated that it was discovered that there was a mileage discrepancy after the purchase. The vehicle was a dealer sale. At the time of purchase, the vehicle mileage was 51,000. It was later discovered that the mileage was 82,000.

AIR BAGS

Driving on [XXX] to Eureka, Ca. Just outside of Laytonville, CA. the vehicle in front of me swerved into oncoming traffic lane (no vehicle in his way) to go around rock, then rock was there, I swerved to the right, but hit the rock, went up on embankment, flipped over and slid to a stop. There is an upcoming California Highway Patrol report from Mendocino County, with support witness (PG&E employee) statement given to California Highway Patrol. No airbags deployed throughout the car. Pictures attached of inside and outside vehicle. No deployment of airbags was written into the report from auto wreak retriever. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

STEERING

I had the car inspected by an independent service center because of extreme shaking from the steering wheel and steering wheel being unstable when going over bumps and making clanking noises all while driving. The steering wheel began to feel very loose and dangerous to drive so I took it in and they had to replace the steering coupling Assembly.

ENGINE AND ENGINE COOLING

The contact owns a 2013 Kia Optima. The contact stated while driving approximately 70-75 MPH, the contact accelerated to 80 MPH to pass another vehicle; however, after releasing the accelerator pedal, the vehicle stalled. The contact was able to pull over to the side of the road. The battery and the low oil pressure warning lights and two other unknown warning lights were illuminated. The vehicle failed to restart and was towed to an independent mechanic, where it was diagnosed and determined that the engine had seized and needed to be replaced. The vehicle was not repaired. The contact related the failure to NHTSA Campaign Number: 17V224000 (Engine and Engine Cooling); however, the VIN was not included in the recall. The manufacturer was not notified of the failure. The failure mileage was approximately 123,000.

ENGINE

The contact owned a 2013 Kia Optima. The contact's son was driving at 35 MPH when smoke was emitting from under the hood. The contact's son pulled over to the side of the road and immediately exited the vehicle. The contact's son opened the hood, and smoke was emitting from the engine. No warning lights were illuminated. The contact's son did not sustain any injuries. The police or fire department was not called. The vehicle was towed to an independent mechanic, who diagnosed that an electrical fire had started in the engine and damaged the engine. The vehicle was not repaired. The manufacturer was not notified of the fire. The contact stated that the engine was replaced in 2018 or 2019 due to an unknown recall. The contact did not notify her insurance company. The failure mileage was approximately 190,000.

ENGINE

My 2018 Kia Optima has a cracked oil pan, which caused an excessive oil leak —up to 5 quarts in a matter of hours. This eventually led to my engine going out.

ENGINE

The contact owned a 2014 Kia Optima. The contact stated that after her daughter had parked the vehicle and shut off the engine, a fire had started under the hood as she exited. No warning lights illuminated. There was no odor or strange sound during the failure. The local fire department had arrived on scene to extinguish the fire. The local fire department deemed that the cause of the fire was started with the HECU. It was unknown if a Police report was filed. The vehicle was left at the contact's relative's residence, where it remains for further investigation. The vehicle was deemed a total loss since it was consumed by the fire. No injuries were sustained. No medical attention was sought. The local dealer was not contacted. The vehicle was not diagnosed. The manufacturer was not made aware of the failure. The failure mileage was approximately 185,000.

STRUCTURE:BODY

Pearl white paint peeling prematurely