2025 KIA K5

STRUCTURE:BODY:ROOF AND PILLARS

Kia America, Inc. (Kia) is recalling certain 2023-2025 K5 vehicles. The left and right rear window trim pieces may loosen and detach.

Risk: Detached trim pieces can create a road hazard for other vehicles, increasing the risk of a crash.

POWER TRAIN

Transmission has extremely hard shifting if vehicle sits for more than 24 hours. After the vehicle is parked, inside garage, or outside, the first drive of the day has an extremely hard shift of the transmission on the first shifting of the day. The shift it so hard, it jerks the entire car and jolts me in my seat. The remainder of the drive and day, the hard shifting does not occur. Took the vehicle into dealership where purchased at 1000 miles and left it with them for 2 full days. Unsurprisingly, they said they were, "Unable to reproduce". The next day, the vehicle had the exact same problem. I have close to 3000 miles on the vehicle and the transmission continues to do the exact same thing every time I drive it. It is terrible for a brand new car. It doesn't matter which "Drive mode" the vehicle is in. The dealership also tried to reset the ECM. But no luck. My neck and back have been sore from the hard shift events too.

TIRES:SIDEWALL

234/45/R18 - 94V bubble developed on exterior of front, passenger side tire AND the interior of back, passenger side tire within a year of purchasing vehicle new with this tire installed. The tire had to be replaced immediately to avoid a tire blowout.

STRUCTURE

The contact owns a 2025 Kia K5. The contact stated that the vehicle was purchased from the Kia dealer as a brand-new vehicle. The contact stated that while attempting to register the vehicle on the online vehicle rental site Turo the following day, the contact became aware that the VIN was included in a recall. The contact stated that the dealer had sold and delivered a brand-new vehicle that was under recall. The dealer and the manufacturer were not notified of the issue. The contact had not experienced a failure.

UNKNOWN OR OTHER

OEM Pirelli tire blew out going 55mph. The car has 6500 miles on it. The sidewall of the tire blew. There were no punctures in the tire or reasoning for this to happen.

WHEELS

OEM Pirelli tire blew out going 55mph. The car has 6500 miles on it. The sidewall of the tire blew. There were no punctures in the tire or reasoning for this to happen.

ENGINE

Third time that this happened when I step on the gas you're accelerate the transmission wines when I'm trying to merge I have to slow the car down and take my foot off the accelerator and then when I put my foot on the celebrator there's a car really close to me

TIRES

Three of the four tires, rated for 30k miles, have failed. There are 11,400 miles on the tires. Back passenger tire blew out and went immediately and audibly flat. Dealer stated this is a known issue with this brand of tire on the Kia K5. 235/45 R18 94v M+S

STRUCTURE:BODY

I am the owner of a 2025 Kia K5 GT-Line that was recently involved in an accident. In the days prior to the crash, I experienced recurring issues including screen reboots while driving and temporary power loss. I do not remember the moment of the accident, and I am currently under medical care for head trauma. I am reporting this because I believe the vehicle may have malfunctioned in a way that contributed to the accident. Please advise if there are known issues with the 2025 K5 GT-Line, and how I can formally report this case for technical investigation.

AIR BAGS

I am the owner of a 2025 Kia K5 GT-Line that was recently involved in an accident. In the days prior to the crash, I experienced recurring issues including screen reboots while driving and temporary power loss. I do not remember the moment of the accident, and I am currently under medical care for head trauma. I am reporting this because I believe the vehicle may have malfunctioned in a way that contributed to the accident. Please advise if there are known issues with the 2025 K5 GT-Line, and how I can formally report this case for technical investigation.

WHEELS

Tire pressure light did not illuminate. Tire was apparently low, and tire blew out at stop. Inside sidewall of tire had large gash once tire was removed and spare installed. See picture.

EXTERIOR LIGHTING

Tire pressure light did not illuminate. Tire was apparently low, and tire blew out at stop. Inside sidewall of tire had large gash once tire was removed and spare installed. See picture.

UNKNOWN OR OTHER

I am reporting a safety concern with the KIA K5 Advance Driving Assistance Systems. The concern is the Driver Attention Warning (DAW) being a distraction to the driver due to consistent dinging and flashing light of the "taking a break" that according to manual could go off every 4 minutes, however, in my experience it can go off every 3 minutes (see attached documentation), which is excessive. The frequency that the light goes off has led me to be distracted and nearly hitting the car in front of me because I am looking down at the light. I'm at the point; I am afraid to drive the car because I don't know when this light will go off. According to the manual it can go off 4 minutes into a drive. When reviewing the manual, it fails to tell you what exactly is causes the light to go off and how long you are supposed to be taking a break for. I have taken it to the dealership three times, and they tell me it is working property. I have asked if the light can be shut off, but they tell me it cannot be shut off even though it says in the manual it can be. I have also worked with KIA corporate, and they tell me the newer KIAs it cannot be shut off. The older models also had attention level gauge that could show the driver where their attention level is, but this was removed. In conclusion, this "take a break light" is a major distraction to driver that cannot be shut off that could lead the driver taking their eyes off the road multiple times in a driver that can cause an accident.

ELECTRICAL SYSTEM

The contact owns a 2025 Kia K5. The contact stated that occasionally while driving at various speeds, the front headlights, rear brake lights, and interior cabin lights illuminated very bright. No warning light was illuminated. The vehicle was taken to a local dealer where unknown repairs were performed; however, the failure persisted. In addition, the contact stated that the transmission was replaced prior to the recurring failure by the same local dealer. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 24,000.

UNKNOWN OR OTHER

I believe my cars GPS system is having issues where it thinks I’m on the wrong side of the road and proceeds to reducing my speed so I can no longer accelerate. I receive the do not enter traffic sign on my dash.

TIRES:SIDEWALL

tire size 235/45 R18. Both front tires at 7,300 miles suddenly have bulging out of the side wall. One tire bulge the size of a golf ball, the other tire slightly larger in size. No warnings or inflation issues prior to failure. Severe safety risk. Risk of blowout is high. Car not drivable due to risk of blowout. Contacted Pirelli the manufacturer, was told both tires are to be sent to them for inspection by the dealership. Pirelli customer service indicated the issue will likely not be covered under warranty.