2012 KIA FORTE

SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP:CONTROL UNIT/MODULE

Kia America, Inc. (Kia) is recalling certain 2010-2019 Borrego, 2014-2016 Cadenza, 2010-2013 Forte, Forte Koup, Sportage, 2015-2018 K900, 2011-2015 Optima, 2011-2013 Optima Hybrid, Soul, 2012-2017 Rio, 2011-2014 Sorento, and 2010-2011 Rondo vehicles. The Hydraulic Electronic Control Unit (HECU) may experience an electrical short, which can result in an engine compartment fire while parked or driving.

Risk: An engine compartment fire while parked or driving can increase the risk of injury.

ENGINE

Kia Motors America (Kia) is recalling certain 2012-2013 Sorento, 2012-2015 Forte and Forte Koup, 2011-2013 Optima Hybrid, 2014-2015 Soul, and 2012 Sportage vehicles. An engine compartment fire can occur while driving.

Risk: An engine compartment fire increases the risk of injury.

AIR BAGS: AIR BAG/RESTRAINT CONTROL MODULE

Kia Motors America (Kia) is recalling certain 2010-2013 Kia Forte, Forte Koup, 2011-2013 Kia Optima and 2011-2012 Kia Optima Hybrid and Sedona vehicles. In the event of a crash, the air bag control unit (ACU) may short circuit, preventing the frontal air bags and seat belt pretensioners from deploying.

Risk: If the frontal air bags and seat belt pretensioners are disabled, there is an increased risk of injury to the vehicle occupants in the event of a vehicle crash that necessitates deployment of these safety systems.

ELECTRICAL SYSTEM

In forte koups installed with a factory wing allows for water to collect in taillights causeing a no start issue for my vehicle

AIR BAGS

My wife got an accident in June 2022 but air bag did not work so I contacted Kia 6/22/2022 sent proof photo but just no good excuse why air bag did not work. It should be recalled for this matter. Defective airbag or sender.

ELECTRICAL SYSTEM

Kia denied repair and replacement of components damaged by a known safety recall (Hydraulic Electronic Control Unit) on my 2012 Kia Forte Coupe, VIN# [XXX] . There was also a recall on the “Knock Sensor”, but I was unaware of the recall and paid for the repair out of pocket. Specifically, I was seeking repair or replacement of the starter and battery, as well as any other component that I wasn’t aware of, which was compromised as a direct result of the defective HECU system covered under the recall. They denied the repair because they said that the warranty was voided because the car had a salvage title, but the request to repair was not a warranty issue. The recall involves the HECU potentially causing electrical shorts and engine compartment fires, which can damage surrounding electrical components — including the battery and starter. These are not wear-and-tear items in this case, but parts affected by the consequences of a manufacturer-recognized safety defect. The internal electrical short circuit condition of the HECU fuse caused an overcurrent, which resulted in the wire from the solenoid cable of the starter burning and damaging the starter. As well as the wire of the negative battery terminal, which also resulted in the battery being damaged. I even left the battery and the starter on the floor of the car to show proof that these occurrences happened due to the defect of the HECU fused because when I purchased a new battery and starter the overcurrent of the HECU caused white smoke to appear and was about to catch fire and burn out the replacement parts as well. Kia has declined to perform these recall-related repairs, citing that the vehicle holds a salvage title, which was issued due to hail damage only. I respectfully contended that the cosmetic damage had no connection to the mechanical or electrical condition of the vehicle and in no way contributed to the failure of the battery or starter. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

ENGINE

Kia denied repair and replacement of components damaged by a known safety recall (Hydraulic Electronic Control Unit) on my 2012 Kia Forte Coupe, VIN# [XXX] . There was also a recall on the “Knock Sensor”, but I was unaware of the recall and paid for the repair out of pocket. Specifically, I was seeking repair or replacement of the starter and battery, as well as any other component that I wasn’t aware of, which was compromised as a direct result of the defective HECU system covered under the recall. They denied the repair because they said that the warranty was voided because the car had a salvage title, but the request to repair was not a warranty issue. The recall involves the HECU potentially causing electrical shorts and engine compartment fires, which can damage surrounding electrical components — including the battery and starter. These are not wear-and-tear items in this case, but parts affected by the consequences of a manufacturer-recognized safety defect. The internal electrical short circuit condition of the HECU fuse caused an overcurrent, which resulted in the wire from the solenoid cable of the starter burning and damaging the starter. As well as the wire of the negative battery terminal, which also resulted in the battery being damaged. I even left the battery and the starter on the floor of the car to show proof that these occurrences happened due to the defect of the HECU fused because when I purchased a new battery and starter the overcurrent of the HECU caused white smoke to appear and was about to catch fire and burn out the replacement parts as well. Kia has declined to perform these recall-related repairs, citing that the vehicle holds a salvage title, which was issued due to hail damage only. I respectfully contended that the cosmetic damage had no connection to the mechanical or electrical condition of the vehicle and in no way contributed to the failure of the battery or starter. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

VEHICLE SPEED CONTROL

the VCM motor has a "coupler" that operates intake manifold runner, this coupler brakes apart , causing vehicle to loose engine power, engine light comes on, code P200. kia dealer recommends to replace the intake manifold that comes with new VCM motor, if you replace it you're self then you need to take vehicle to kia dealer to have them update software for the new VCM.

ENGINE

My vehicle is affected by NHTSA Recall Number 23V652000, I have taken my vehicle to Jim Ellis Kia of Kennesaw on several occasions, I believe 3 separate occasions to try and get this recall resolved. Each time I am told that the fix, a replacement fuse, is not being accepted by my vehicle. Each time they attempt to replace the fuse, the vehicle goes into anti-theft mode where the alarm goes off consistently. The dealership is unable to tell me why and states they can not complete the recall because of this. Initially, they tried to state the issue was that engine oil was seeping through into my engine harness and that I would need a new engine harness, sending me home with a quote for $3,000 to fix the issue. That same night I took my vehicle to an actual professional, who told me the dealership had no clue what they were talking about and that there was no oil in my engine harness. I returned to the dealership requesting that my vehicle only be looked at by the master technician, after the master tech reviewed the vehicle he agreed there was no oil in the engine harness and that that was a misdiagnosis. Absolutely absurd to think they can send a customer home with a $3k quote with no oversight before doing so. The master tech stated he could not figure out the incompatibility of my vehicle and the recall remedy, and stated I would have to pay $300 for them to do a full electrical review as a first step of troubleshooting. I can not believe that a massive corporation like Kia is sticking a customer with a MASSIVE fire hazard of a vehicle that is a result of their negligence and telling me that 'although we have a fix, for some reason the fix doesn't work for your car and you're going to have to pay us to figure out why.' This is absolutely unacceptable, I am a college student and while driving my only form of transportation, I constantly have to hope that I am not a victim of fatality at the hands of Kia.

ELECTRICAL SYSTEM

My vehicle is affected by NHTSA Recall Number 23V652000, I have taken my vehicle to Jim Ellis Kia of Kennesaw on several occasions, I believe 3 separate occasions to try and get this recall resolved. Each time I am told that the fix, a replacement fuse, is not being accepted by my vehicle. Each time they attempt to replace the fuse, the vehicle goes into anti-theft mode where the alarm goes off consistently. The dealership is unable to tell me why and states they can not complete the recall because of this. Initially, they tried to state the issue was that engine oil was seeping through into my engine harness and that I would need a new engine harness, sending me home with a quote for $3,000 to fix the issue. That same night I took my vehicle to an actual professional, who told me the dealership had no clue what they were talking about and that there was no oil in my engine harness. I returned to the dealership requesting that my vehicle only be looked at by the master technician, after the master tech reviewed the vehicle he agreed there was no oil in the engine harness and that that was a misdiagnosis. Absolutely absurd to think they can send a customer home with a $3k quote with no oversight before doing so. The master tech stated he could not figure out the incompatibility of my vehicle and the recall remedy, and stated I would have to pay $300 for them to do a full electrical review as a first step of troubleshooting. I can not believe that a massive corporation like Kia is sticking a customer with a MASSIVE fire hazard of a vehicle that is a result of their negligence and telling me that 'although we have a fix, for some reason the fix doesn't work for your car and you're going to have to pay us to figure out why.' This is absolutely unacceptable, I am a college student and while driving my only form of transportation, I constantly have to hope that I am not a victim of fatality at the hands of Kia.

ENGINE

Called the kia dealer in Springfield Missouri to find out if my engine was under the class action engine lawsuit and was redirected to the service department the lady said someone would text me they ignored all my texts about seeing if my engine was under kia class action lawsuit warranty no one ever messaged me back. My engine is still making a loud knocking noise and I can not drive it like this so it is sitting on the street parked and no longer can drive it because of the engine noise which i am sure is rod knock. 156,636 miles as it sits right now. My name [XXX] owned this kia since 82,300 miles. Vin is [XXX] 2012 kia Forte 5 hatchback Ex 2.0 L INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

ENGINE

The contact owns a 2012 Kia Forte. The contact stated that while driving at an undisclosed speed, she observed smoke emanating from the engine compartment, after which the vehicle lost motive power. The contact was able to coast to the shoulder of the roadway, where the vehicle was able to be restarted. The following day, upon starting the vehicle, the contact heard an abnormal rattling sound emanating from the engine compartment, prompting the contact to discontinue driving the vehicle. The check engine warning light was illuminated. The vehicle was towed to the dealer, who diagnosed a failure with the engine. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 20V750000 (Engine); the VIN was included, and parts were available. However, the dealer declined to perform the recall repair, stating that the vehicle needed to be brought in before the failure for the cost of the repair to be covered by the manufacturer. The manufacturer was not notified of the failure. The failure mileage was 100,000.