KIA CARNIVAL

STRUCTURE:BODY:ROOF AND PILLARS

Kia America, Inc. (Kia) is recalling certain 2023-2024 Sportage and 2022-2024 Carnival vehicles. The roof molding may loosen and detach.

Risk: A detached roof molding can create a road hazard for other vehicles, increasing the risk of a crash.

TRAILER HITCHES

Kia America, Inc. (Kia) is recalling certain 2022-2023 Carnival vehicles equipped with a tow hitch harness installed as original equipment, or purchased as an accessory through a Kia dealership. Water accumulation on the tow hitch harness module printed circuit board (PCB) may cause an electrical short, which can result in a fire.

Risk: A fire while parked or driving can increase the risk of injury.

STRUCTURE:BODY:DOOR

Kia America, Inc. (Kia) is recalling all 2022 and certain 2023 Carnival vehicles. The auto-reverse feature for the power sliding doors (PSD) may not activate in all situations.

Risk: A power sliding door that does not auto-reverse can close on an occupant, increasing the risk of injury.

STRUCTURE:BODY:DOOR

Kia Motors America (Kia) is recalling certain 2022 Carnival vehicles. The remote controller assembly for the passenger-side power sliding door may malfunction, preventing the passenger-side sliding door from securely latching.

Risk: A power sliding door that fails to latch may open while moving, increasing the risk of injury.

ELECTRICAL SYSTEM:12V/24V/48V BATTERY

The contact owns a 2025 Kia Carnival. The contact stated that on several occasions the vehicle failed to start due to the 24-Volt battery failure. The vehicle was jump-started and operated normally, but the failure reoccurred. Additionally, the contact indicated that the emergency key failed to open the doors of the vehicle after the battery malfunction. A locksmith was called to the scene to open the doors. The cause of the failures was not yet determined. The local dealer and manufacturer were notified of the failures. The failure mileage was 600.

UNKNOWN OR OTHER

On August 23, 2025, I purchased a certified pre-owned Kia Carnival. Within hours, the vehicle had a severe fuel leak that produced a strong gasoline odor. Driving it made me sick, and I feared for the safety of my three children in the vehicle. A Kia technician later confirmed a crossover fuel line leak so severe that he became ill while inspecting it and feared the vehicle could explode. Even after repair, the gas odor persisted. This vehicle was sold to me in unsafe condition, and I believe this may represent a larger safety issue that needs investigation.

FUEL/PROPULSION SYSTEM

On August 23, 2025, I purchased a certified pre-owned Kia Carnival. Within hours, the vehicle had a severe fuel leak that produced a strong gasoline odor. Driving it made me sick, and I feared for the safety of my three children in the vehicle. A Kia technician later confirmed a crossover fuel line leak so severe that he became ill while inspecting it and feared the vehicle could explode. Even after repair, the gas odor persisted. This vehicle was sold to me in unsafe condition, and I believe this may represent a larger safety issue that needs investigation.

FORWARD COLLISION AVOIDANCE: WARNINGS

The 2025 Kia Carnivals have a safety systems that prompts the driver to, "Take and coffee break". The system cannot be turned off and is extremely distracting. The system prompts the driver even if the adaptive cruise control is turned off. I called Kia and they told me to take the vehicle to the dealer. The dealer was not able to turn the computer nag off either. The car makes a noise and the prompt flashes at the driver every few miles. This happens when traveling at highway speeds and in traffic. The driver has to look down from the road to see what the noise is and is greeted with the infuriating "Take a coffee break" message. It is extremely distracting and annoying to the point it induces road rage. The NTSB needs to investigate this system and require manufacturers to either allow owners to turn it off or do not include this feature in their vehicles. The next question is irrelevant because this happens on almost every highway drive. It is not a one time occurrence.

FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL

The 2025 Kia Carnivals have a safety systems that prompts the driver to, "Take and coffee break". The system cannot be turned off and is extremely distracting. The system prompts the driver even if the adaptive cruise control is turned off. I called Kia and they told me to take the vehicle to the dealer. The dealer was not able to turn the computer nag off either. The car makes a noise and the prompt flashes at the driver every few miles. This happens when traveling at highway speeds and in traffic. The driver has to look down from the road to see what the noise is and is greeted with the infuriating "Take a coffee break" message. It is extremely distracting and annoying to the point it induces road rage. The NTSB needs to investigate this system and require manufacturers to either allow owners to turn it off or do not include this feature in their vehicles. The next question is irrelevant because this happens on almost every highway drive. It is not a one time occurrence.

UNKNOWN OR OTHER

The 2025 Kia Carnivals have a safety systems that prompts the driver to, "Take and coffee break". The system cannot be turned off and is extremely distracting. The system prompts the driver even if the adaptive cruise control is turned off. I called Kia and they told me to take the vehicle to the dealer. The dealer was not able to turn the computer nag off either. The car makes a noise and the prompt flashes at the driver every few miles. This happens when traveling at highway speeds and in traffic. The driver has to look down from the road to see what the noise is and is greeted with the infuriating "Take a coffee break" message. It is extremely distracting and annoying to the point it induces road rage. The NTSB needs to investigate this system and require manufacturers to either allow owners to turn it off or do not include this feature in their vehicles. The next question is irrelevant because this happens on almost every highway drive. It is not a one time occurrence.

POWER TRAIN

Vehicle Malfunction Report What component or system failed or malfunctioned, and is it available for inspection upon request? The vehicle's transmission and/or gear shifter system has failed to function as intended. When the gear shifter is set to "Reverse," the transmission has repeatedly shifted into "Drive" or "Neutral" instead. Concurrently, the vehicle's electronic backup camera system and audible sensor beep activate, indicating that the vehicle believes it is in reverse. The van is available for inspection upon request. How was your safety or the safety of others put at risk? My safety and the safety of others were put at risk on multiple occasions due to the vehicle shifting into the wrong gear. This has caused the van to unexpectedly lurch forward when I intended to back up. I have nearly collided with other parked vehicles and my garage door between 10 to 20 times. Has the problem been reproduced or confirmed by a dealer or independent service center? The problem has not yet been reproduced or confirmed by a dealer or service center, but it has occurred on numerous occasions and is a confirmed issue by the driver. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? To date, the vehicle and its components have not been inspected by the manufacturer, police, or insurance representatives. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? There were no warning lamps or messages displayed prior to the problem occurring. The primary symptoms of the malfunction are the vehicle shifting into "Drive" or "Neutral" instead of "Reverse," while the backup camera and an audible beep are active. These symptoms began almost immediately after the vehicle was purchased.

ELECTRICAL SYSTEM

Vehicle Malfunction Report What component or system failed or malfunctioned, and is it available for inspection upon request? The vehicle's transmission and/or gear shifter system has failed to function as intended. When the gear shifter is set to "Reverse," the transmission has repeatedly shifted into "Drive" or "Neutral" instead. Concurrently, the vehicle's electronic backup camera system and audible sensor beep activate, indicating that the vehicle believes it is in reverse. The van is available for inspection upon request. How was your safety or the safety of others put at risk? My safety and the safety of others were put at risk on multiple occasions due to the vehicle shifting into the wrong gear. This has caused the van to unexpectedly lurch forward when I intended to back up. I have nearly collided with other parked vehicles and my garage door between 10 to 20 times. Has the problem been reproduced or confirmed by a dealer or independent service center? The problem has not yet been reproduced or confirmed by a dealer or service center, but it has occurred on numerous occasions and is a confirmed issue by the driver. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? To date, the vehicle and its components have not been inspected by the manufacturer, police, or insurance representatives. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? There were no warning lamps or messages displayed prior to the problem occurring. The primary symptoms of the malfunction are the vehicle shifting into "Drive" or "Neutral" instead of "Reverse," while the backup camera and an audible beep are active. These symptoms began almost immediately after the vehicle was purchased.

UNKNOWN OR OTHER

Vehicle Malfunction Report What component or system failed or malfunctioned, and is it available for inspection upon request? The vehicle's transmission and/or gear shifter system has failed to function as intended. When the gear shifter is set to "Reverse," the transmission has repeatedly shifted into "Drive" or "Neutral" instead. Concurrently, the vehicle's electronic backup camera system and audible sensor beep activate, indicating that the vehicle believes it is in reverse. The van is available for inspection upon request. How was your safety or the safety of others put at risk? My safety and the safety of others were put at risk on multiple occasions due to the vehicle shifting into the wrong gear. This has caused the van to unexpectedly lurch forward when I intended to back up. I have nearly collided with other parked vehicles and my garage door between 10 to 20 times. Has the problem been reproduced or confirmed by a dealer or independent service center? The problem has not yet been reproduced or confirmed by a dealer or service center, but it has occurred on numerous occasions and is a confirmed issue by the driver. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? To date, the vehicle and its components have not been inspected by the manufacturer, police, or insurance representatives. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? There were no warning lamps or messages displayed prior to the problem occurring. The primary symptoms of the malfunction are the vehicle shifting into "Drive" or "Neutral" instead of "Reverse," while the backup camera and an audible beep are active. These symptoms began almost immediately after the vehicle was purchased.