2015 JEEP RENEGADE

SUSPENSION:REAR

Daystar Products International, Inc. (Daystar) is recalling certain aftermarket replacement rear control arm brackets included in Daystar's 2015-2016 Jeep Renegade 1.5" spacer kit, part KJ09168BK, shipped from Daystar to distributors between October 27, 2015 and November 5, 2015. The affected spacers may have improper or incomplete welds on the top flange on the rear control arm bracket, that can allow the rear axle to shift while driving.

Risk: If the axle moves there could be an increased risk of a crash.

POWER TRAIN:AUTOMATIC TRANSMISSION

Chrysler (FCA US LLC) is recalling certain model year 2014-2015 Jeep Cherokee and 2015 Chrysler 200, Jeep Renegade, RAM ProMaster, and 2016 Fiat 500X vehicles equipped with 9-speed automatic transmissions. The transmission sensor clusters may have insufficient crimps in the transmission wire harness, and as a result, the transmission may unexpectedly shift to neutral. On August 29, 2016 Chrysler added the 2016 Fiat 500X vehicles to this recall.

Risk: If the vehicle unexpectedly shifts to neutral, there is an increased risk of a crash.

TRAILER HITCHES

Chrysler (FCA US LLC) is recalling certain model year 2015-2016 Jeep Renegade vehicles manufactured August 25, 2014, to June 25, 2016, equipped with a factory-installed optional trailer hitch package. The trailer hitch assembly may have been attached with only a single fastener per side, not three per side as required.

Risk: Without the proper amount of fasteners, the trailer hitch assembly may separate from the vehicle, and any towed vehicle may no longer be properly connected, increasing the risk of a crash.

POWER TRAIN

After I filled up my tank, I drove and turned onto a busy highway. As I was turning, it felt like my car went into neutral. I had to take my foot off of the gas and looked to see if the shifter switched gears, but it was still in drive. After about 10 seconds it shifted into gear. If I did not wait for the road to be clear I could have gotten into a major accident.

TIRES

p 215/65 R16 98H SL BSW. date of Manufacture 0919. Made in Canada. What happened the car four tires became a hazard to drive after 6 years from installing the tire . The problem is the deterioation of the rubber was unknowable only by experts. Furthermore, I did not consider my experience enough so I had to confirm it with local shops belle tire and a small local shop . However, In my experience other than the visual.To get accurate analysis I need to apply multiple tests, like chemical component analysis to be verified as manufacture deficiency .Those expansive lab resting over my budget. I had replaced all tires on 06-14-2025 with Cooper tires.P.S. Many drivers don't check their tires they just trust a brand .

ENGINE

Complaint Summary: I brought my 2015 Jeep Renegade Trailhawk (VIN: [XXX] ) to AutoNation CDJR Roseville on May 17, 2025, for the U90 emissions recall. The catalytic converter was replaced, and the PCM software was updated. However, the U0402 diagnostic trouble code (implausible data received from TCM) remains stored. This code has been persistent and prevents the vehicle from passing California emissions, which is required for my registration as the car was transferred from out-of-state. The service advisor initially stated that the TCM was updated, but later corrected himself and admitted the TCM already had the latest version and was not reprogrammed. I have not been given written confirmation that the TCM software or wiring was verified or addressed. I am concerned the dealership is refusing to properly resolve this under recall and is instead recommending a full transmission replacement without supporting mechanical codes or verifying the emissions system software/communication is compliant. I’m requesting FCA’s assistance, and the BAR in California to enforce the complete and proper execution of the U90 recall and resolution of the U0402 code under recall scope. Please help ensure the vehicle is brought into emissions compliance. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

POWER TRAIN

Complaint Summary: I brought my 2015 Jeep Renegade Trailhawk (VIN: [XXX] ) to AutoNation CDJR Roseville on May 17, 2025, for the U90 emissions recall. The catalytic converter was replaced, and the PCM software was updated. However, the U0402 diagnostic trouble code (implausible data received from TCM) remains stored. This code has been persistent and prevents the vehicle from passing California emissions, which is required for my registration as the car was transferred from out-of-state. The service advisor initially stated that the TCM was updated, but later corrected himself and admitted the TCM already had the latest version and was not reprogrammed. I have not been given written confirmation that the TCM software or wiring was verified or addressed. I am concerned the dealership is refusing to properly resolve this under recall and is instead recommending a full transmission replacement without supporting mechanical codes or verifying the emissions system software/communication is compliant. I’m requesting FCA’s assistance, and the BAR in California to enforce the complete and proper execution of the U90 recall and resolution of the U0402 code under recall scope. Please help ensure the vehicle is brought into emissions compliance. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

FUEL/PROPULSION SYSTEM

When adding fuel at the gas station through vehicle Cap-less fuel fill tube, gas pump nozzle could not be removed without pulling on it which snapped the small thin plastic tabs holding cap-less fuel port in place. According to the manufacturer and repair Shops the entire fuel filler tube system has to be replaced and requires the gas tank to be removed to install the new tube This is a very poor design with poor quality materials and will cause fuel spills and combustion

ENGINE

The 2015 Jeep Renegade has had a vibrating sensation since I purchased it used in 2021 from an auto dealership. The vibrations got stronger as time went on. The issue was finally determined what caused the vibrations in May, 2025 and confirmed by an independent mechanic. The vehicle was inspected by a Jeep dealer previously. The vehicle was not inspected by the police or insurance representatives. The auto needed a new Engine Motor Mount. A new one was installed on the front right side, engine mount. The auto is available for inspection. My safety and the safety of others was put at risk because a failed mount leads to excessive engine movement, which can damage other components, affect handling, and lead to accidents.

VEHICLE SPEED CONTROL

The Evaporative Emissions System (EVAP system), including components such as the charcoal canister, purge valve, and/or fuel tank venting system, appears to be malfunctioning. The vehicle is available for inspection upon request. After refueling the vehicle completely, it will stall or shut off unexpectedly while driving, which could cause a collision, particularly in traffic or at highway speeds. This sudden loss of power places myself, my passengers, and other drivers at significant risk. The vehicle has been inspected by an independent mechanic, but not by the manufacturer, police, or insurance representatives. No warning lights, error messages, or advance symptoms were present prior to the vehicle stalling. The issue first occurred around 2022.

ENGINE

The Evaporative Emissions System (EVAP system), including components such as the charcoal canister, purge valve, and/or fuel tank venting system, appears to be malfunctioning. The vehicle is available for inspection upon request. After refueling the vehicle completely, it will stall or shut off unexpectedly while driving, which could cause a collision, particularly in traffic or at highway speeds. This sudden loss of power places myself, my passengers, and other drivers at significant risk. The vehicle has been inspected by an independent mechanic, but not by the manufacturer, police, or insurance representatives. No warning lights, error messages, or advance symptoms were present prior to the vehicle stalling. The issue first occurred around 2022.

FUEL/PROPULSION SYSTEM

The Evaporative Emissions System (EVAP system), including components such as the charcoal canister, purge valve, and/or fuel tank venting system, appears to be malfunctioning. The vehicle is available for inspection upon request. After refueling the vehicle completely, it will stall or shut off unexpectedly while driving, which could cause a collision, particularly in traffic or at highway speeds. This sudden loss of power places myself, my passengers, and other drivers at significant risk. The vehicle has been inspected by an independent mechanic, but not by the manufacturer, police, or insurance representatives. No warning lights, error messages, or advance symptoms were present prior to the vehicle stalling. The issue first occurred around 2022.

VEHICLE SPEED CONTROL

The contact owns a 2015 Jeep Renegade. The contact stated that after having an oil change, the engine started to misfire. The contact stated while driving 75 MPH, the vehicle decelerated to 15 MPH and failed to accelerate as needed. The check engine warning light was illuminated. The vehicle was taken to the local dealer where it was diagnosed that a multi-air actuator replacement was needed. The part was on backorder. The vehicle was not repaired. The contact stated that DTC: P0304, P106B, and P1064 were retrieved and were related to the failure. The manufacturer was contacted, but no additional assistance was provided. The failure mileage was approximately 145,000.

ENGINE

The contact owns a 2015 Jeep Renegade. The contact stated that after having an oil change, the engine started to misfire. The contact stated while driving 75 MPH, the vehicle decelerated to 15 MPH and failed to accelerate as needed. The check engine warning light was illuminated. The vehicle was taken to the local dealer where it was diagnosed that a multi-air actuator replacement was needed. The part was on backorder. The vehicle was not repaired. The contact stated that DTC: P0304, P106B, and P1064 were retrieved and were related to the failure. The manufacturer was contacted, but no additional assistance was provided. The failure mileage was approximately 145,000.

POWER TRAIN

The contact owns a 2015 Jeep Renegade. The contact stated that while driving at an undisclosed speed, the vehicle suddenly shifted into neutral independently. The contact was able to pull over to the shoulder of the roadway, where the failure persisted. The check engine warning light was illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the shifter assembly tower lever. The vehicle was repaired. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA hotline for assistance. The failure mileage was 86,000.

UNKNOWN OR OTHER

Unknown

ENGINE

I have a U90 recall on my vehicle. I have contacted Jeep dealerships and the Jeep Corp Regarding this issue. I have been told that the parts are on back order and it will be months possibly a year to complete this recall. This is my daily driver and dmv won’t re register the vehicle without the recall being repaired. This is unacceptable. This is my daily driver and has passed smog no issues.