2024 INTERNATIONAL MV

SERVICE BRAKES, HYDRAULIC:FLUID

International Motors, LLC (International) is recalling certain 2018 International 4000 Series 4300, 2017-2025 MV, 2018-2024 1300 FBC, 2018-2025 IC Bus TC, and 2024-2025 IC Bus CECB vehicles. The brake pressure switch assembly may leak brake fluid into the brake pressure switch's electrical components and cause an electrical short-circuit.

Risk: An electrical short in the brake pressure switch can overheat the circuit and increase the risk of a fire while driving or parked.

SERVICE BRAKES, AIR:DISC:CALIPER

International Motors, LLC (International) is recalling certain 2024 HV, 2020-2025 MV, and 2019 Workstar 7400 trucks. The caliper may contact a suspension spring or axle U-bolt and prevent the outer brake pad from functioning.

Risk: A loss of outer brake pad function can extend the vehicle's stopping distance, increasing the risk of a crash.

SERVICE BRAKES, AIR:ANTILOCK:CONTROL UNIT/MODULE

International Motors, LLC (International) is recalling certain 2021-2024 Lonestar, 2021-2025 RH, HV, MV, LT, HX, and 2022 PROSTAR vehicles, equipped with Bendix EC80 Advanced Electronic Control Units (ECU). Electrical noise and low signal to the power line carrier may cause the ECU to incorrectly process commands or stop working.

Risk: Safety systems that depend on the ECU (Automatic Traction Control, ABS, Electronic Stability Control, Active Cruise Control, and Collison Mitigation System) may have diminished or lost functionality, increasing the risk of a crash.

STEERING

Navistar, Inc. (Navistar) is recalling certain 2024 International HX, LT, RH and 2024-2025 International HV, MV trucks and 2024 IC Bus CE commercial buses. The steering gear assemblies may have been assembled incorrectly with fewer recirculating balls than are required, which may result in a loss of steering control.

Risk: A loss of steering control increases the risk of a crash.

SEAT BELTS:CRITICAL FASTENERS

Navistar, Inc. (Navistar) is recalling certain 2024 International HV and International MV trucks. The driver's seat belt tether bolt may not be properly seated in the anchor, causing a bind at the anchor point.

Risk: An improperly anchored seat belt tether may not restrain an occupant as intended, increasing their risk of injury during a crash.

POWER TRAIN:DRIVELINE:DRIVESHAFT

Navistar, Inc. (Navistar) is recalling certain 2023 International HV and 2023-2024 International MV vehicles. The rear axle spring wedge shim may have been incorrectly installed, which can cause U-joint failure and result in driveshaft separation.

Risk: Driveshaft separation can cause a loss of drive power and increase the risk of a crash.

ENGINE AND ENGINE COOLING:ENGINE:ENGINE CONTROL MODULE (ECU/ECM):SOFTWARE

Navistar, Inc. (Navistar) is recalling certain 2022-2024 International HV, International MV trucks, and 2022-2023 IC Bus TC commercial buses. When the parking brake is applied, the automatic transmission is still in drive or reverse position, and the stationary power take-off (PTO) switch is engaged by the operator, the engine may rev and overcome the parking brake's ability to keep the vehicle from moving.

Risk: Unexpected vehicle movement can increase the risk of a crash or injury.

EXTERIOR LIGHTING:BACK UP LIGHTS

Navistar, Inc. (Navistar) is recalling certain 2000-2003 International 8100, 2001-2003 International 9100i, 2001-2007 International 9400i, 2001-2010 International 9200i, 2002-2007, 2009 International 8500, 2003-2007, 2013 International 9900i, 2003-2018 International 8600, 2004, 2007 International 9900iX, 2008-2018 International ProStar, 2010-2011, 2013, 2016 International LoneStar, 2011-2012, 2016 International 4400, 2017-2024 International LT, 2018-2024 International RH, 2019-2021 International LS, 2019-2024 International MV vehicles. The back-up lights offer low visibility when the vehicle is in reverse and bobtail mode. Also, the vehicles have not been equipped with additional unobstructed back-up lights. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."

Risk: Low visibility or obstructed back up lights may not alert other drivers that the vehicle is backing up, increasing the risk of a crash.

ELECTRICAL SYSTEM:12V/24V/48V BATTERY

Navistar, Inc. (Navistar) is recalling certain 2023 International HV and 2023-2024 International MV vehicles. The assembly bolts used to attach the battery box to the mounting bracket may be loose or missing.

Risk: Loose or missing bolts can allow the battery box to detach from the vehicle and become a road hazard, increasing the risk of a crash.

SERVICE BRAKES, HYDRAULIC:FLUID

Navistar, Inc. (Navistar) is recalling certain 2016 International DuraStar, 2018-2020 and 2023-2024 International 1300FBC Stripped chassis, 2019-2022 IC Bus CE Commercial bus, 2019-2024 IC Bus TC Commercial bus, and 2019-2024 International MV vehicles. The brake pressure switch assembly may leak brake fluid into the brake pressure switch's electrical components and cause an electrical short-circuit.

Risk: An electrical short in the brake pressure switch can overheat the circuit and increase the risk of a fire while driving or parked.