2015 HYUNDAI VELOSTER Complaints and Recall Information
The 2015 HYUNDAI VELOSTER has 11 complaints and 5 recalls filed with NHTSA. Owners most frequently report engine issues such as spontaneous rod knocking and premature connecting rod bearing wear. Several complaints describe stalls and loss of power while driving, with some drivers unable to shift gears after stalling. Reports also include climate control switch melting and dashboard warning lights indicating ABS and EPS malfunctions.
Common Issues- Rod knocking. Complaints describe spontaneous rod knocking leading to poor acceleration and motor vehicle safety risks, especially on highways.
- Engine failure. Owners report premature connecting rod bearing wear with debris in the crankshaft causing engine damage and breakdowns.
- Stalling. Multiple complaints involve sudden vehicle stalls at speeds of 30-40 MPH with failure to shift into gear afterward.
- Oil leaks near spark plugs. Reports include oil accumulating around spark plugs, requiring gasket replacements and costly repairs.
- ABS and EPS malfunctions. Dashboard warning lights for ABS, EPS, and check engine illuminate, followed by steering stiffening and power loss.
- Burnt smells and fumes. Some vehicles emit burnt odors and fumes from under the hood after driving 10-20 minutes, creating safety concerns.
- Climate control switch melting. One owner reported the climate control switch melted producing plastic fumes but no dashboard warning lights were triggered.
- Dealer repair refusal. At least one complaint mentions dealer refusal to inspect or repair safety-related issues without customers paying $2,500 for other unrelated repairs.
There are 5 recalls for the 2015 Hyundai Veloster affecting systems related to brakes, engine, and safety control modules. These recalls address risks including fire hazards, engine damage, and stalling.
Recalls- ABS module. Recall 23V651000 affects 1,649,478 vehicles, including the 2015 Veloster. The ABS control unit may leak brake fluid causing an electrical short that can start an engine compartment fire while parked or driving. Owners should park outside until repaired. Dealers will replace the ABS fuse free of charge.
- Engine connecting rod bearings. Recall 20V746000 affects 128,948 vehicles including the 2015 Veloster. Premature wear of the connecting rod bearings can damage the engine and increase risks of fire or stalling which could cause a crash. Dealers will inspect engines and replace if damaged, plus install software updates at no cost.
Owners with repeated engine failures, safety system malfunctions, or unresolved recall repairs may have rights under their state’s lemon law. Consulting with a consumer protection attorney about these ongoing issues might be beneficial.
2015 HYUNDAI VELOSTER Summary
2015
Model Year
11
Total Complaints
2
Total Recalls
1778426
Vehicles Affected
Recalls
2015 HYUNDAI VELOSTER
1649478 vehicles affected
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP:CONTROL UNIT/MODULE
Hyundai Motor America (Hyundai) is recalling certain 2011-2015 Elantra, Genesis Coupe, Sonata Hybrid, 2012-2015 Accent, Azera, Veloster, 2013-2015 Elantra Coupe, Santa Fe, 2014-2015 Equus, 2010-2012 Veracruz, 2010-2013 Tucson, 2015 Tucson Fuel Cell, and 2013 Santa Fe Sport vehicles. The Anti-Lock Brake System (ABS) module may leak brake fluid internally and cause an electrical short, which can result in an engine compartment fire while parked or driving.
Risk: An engine compartment fire while parked or driving can increase the risk of injury.
2015 HYUNDAI VELOSTER
128948 vehicles affected
ENGINE
Hyundai Motor America (Hyundai) is recalling certain 2015-2016 Veloster, 2012 Santa Fe, 2011-2013 Sonata Hybrid, and 2016 Sonata Hybrid vehicles. The connecting rod bearings inside the engine may wear prematurely, which over time can result in engine damage.
Risk: A damaged engine can increase the risk of a fire or it can cause an engine stall, increasing the risk of a crash.
Complaints
2015 HYUNDAI VELOSTER
ID: 2116518POWER TRAIN
The contact owns a 2015 Hyundai Veloster. The contact stated that the vehicle was taken to a local dealer for a recall repair; however, after leaving the dealer, while driving approximately 30-40 MPH, the vehicle stalled. The vehicle failed to shift into gear. The vehicle sat for two hours before being restarted and slowly driven to the place of employment, and was then driven to the residence. The contact was unable to determine if there were any warning lights illuminated. The contact called the dealer and was provided with information for towing services and a diagnostic test. The vehicle was not repaired. The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 176,000.
2015 HYUNDAI VELOSTER
ID: 2116517ENGINE
The contact owns a 2015 Hyundai Veloster. The contact stated that the vehicle was taken to a local dealer for a recall repair; however, after leaving the dealer, while driving approximately 30-40 MPH, the vehicle stalled. The vehicle failed to shift into gear. The vehicle sat for two hours before being restarted and slowly driven to the place of employment, and was then driven to the residence. The contact was unable to determine if there were any warning lights illuminated. The contact called the dealer and was provided with information for towing services and a diagnostic test. The vehicle was not repaired. The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 176,000.
2015 HYUNDAI VELOSTER
ID: 2104185ENGINE
ABS, EPS, check engine light appeared on dashboard then car’s steering wheel stiffed and car lost power. Vehicle’s hood smells burnt and has fumes come out after driving for 10-20minutes. My safety and my family’s was endangered as this happened while driving on the road. Not at a stop sign or a red traffic light but while driving. The dealer has refused to inspect/address the issue without having me paid close to $2,500.00 for other repairs.
2015 HYUNDAI VELOSTER
ID: 2104184ELECTRICAL SYSTEM
ABS, EPS, check engine light appeared on dashboard then car’s steering wheel stiffed and car lost power. Vehicle’s hood smells burnt and has fumes come out after driving for 10-20minutes. My safety and my family’s was endangered as this happened while driving on the road. Not at a stop sign or a red traffic light but while driving. The dealer has refused to inspect/address the issue without having me paid close to $2,500.00 for other repairs.
2015 HYUNDAI VELOSTER
ID: 2104183SERVICE BRAKES
ABS, EPS, check engine light appeared on dashboard then car’s steering wheel stiffed and car lost power. Vehicle’s hood smells burnt and has fumes come out after driving for 10-20minutes. My safety and my family’s was endangered as this happened while driving on the road. Not at a stop sign or a red traffic light but while driving. The dealer has refused to inspect/address the issue without having me paid close to $2,500.00 for other repairs.
2015 HYUNDAI VELOSTER
ID: 2100288ELECTRICAL SYSTEM
The climate control switch melted. Available for inspection I was getting smoked out by plastic fumes. Researched this issues with all data No No lights.
2015 HYUNDAI VELOSTER
ID: 2081043ENGINE
Motor started knocking yesterday 4/8/25 which was immediately followed by multiple dash sensors for oil and battery. As I pulled over to get assistance at a Jiffy Lube, the car stalled and wasn’t drivable but they also confirmed that the car should not be driven for risk of blowing the engine. Will be taking my vehicle in for an evaluation as soon as I am able to get it towed for further inspection and diagnostics.
2015 HYUNDAI VELOSTER
ID: 2066616ENGINE
Spun rod bearings. Noticed that was the issue with play in piston doing a screwdriver test and noticing thru under the oil pan before tear down. Had to pry the bearing off with pliers and hit with a screwdriver to remove. I have plenty of photos and videos
2015 HYUNDAI VELOSTER
ID: 2060797POWER TRAIN
I HAVE A RECALL ON THE HYUNDAI 2015 VELOSTER FOR FOUR YEARS SINCE THE LAWSUIT THAT YOU TOLD HYUNDAI CORP TO PUT LIFETIME WARRANTY ON DEFECTIVE CARS THGEY HAVE DONE NOTHING TO RESOLVE THE PROBLEM. MY CAR AGAIN IS BROKE DOWN TO OIL AROUND SPARKPLUGS I WENT THROUGH THE SAME PROBLEM IN OCT 2023 WHICH THEY PUT A GASKET ON IT AND CHARGE ME 505.00 DOLLARS. NOW THEY ARE MAKING IT HARD TO FIND A ENGINE TO REPLACED THE MANUFACTURED DEFECT ENGINE IN IT. DEBRIS IN CRANKSHAFT AND THEN SOLD WHICH CAUSE THE CONNECTING ROD PROBLEM PREMATURE. I NEED MY CAR AND CAN'T AFFORD ANOTHER PLEASE HELP ME GET THIS RESOLVE
2015 HYUNDAI VELOSTER
ID: 2060796ENGINE
I HAVE A RECALL ON THE HYUNDAI 2015 VELOSTER FOR FOUR YEARS SINCE THE LAWSUIT THAT YOU TOLD HYUNDAI CORP TO PUT LIFETIME WARRANTY ON DEFECTIVE CARS THGEY HAVE DONE NOTHING TO RESOLVE THE PROBLEM. MY CAR AGAIN IS BROKE DOWN TO OIL AROUND SPARKPLUGS I WENT THROUGH THE SAME PROBLEM IN OCT 2023 WHICH THEY PUT A GASKET ON IT AND CHARGE ME 505.00 DOLLARS. NOW THEY ARE MAKING IT HARD TO FIND A ENGINE TO REPLACED THE MANUFACTURED DEFECT ENGINE IN IT. DEBRIS IN CRANKSHAFT AND THEN SOLD WHICH CAUSE THE CONNECTING ROD PROBLEM PREMATURE. I NEED MY CAR AND CAN'T AFFORD ANOTHER PLEASE HELP ME GET THIS RESOLVE
2015 HYUNDAI VELOSTER
ID: 2053659ENGINE
Spontaneous rod knocking, hindered performance which in tern poor acceleration, which could become a safety risk especially when commuting on a freeway. High risk of motor vehicle accidents or could lead to a fatal incident if left stranded on major roadways and railroad crossings.