2024 HYUNDAI TUCSON

STEERING:ELECTRIC POWER ASSIST SYSTEM

Hyundai Motor America (Hyundai) is recalling certain 2024 Tucson and Santa Cruz vehicles. The circuit board in the motor-driven power steering assembly may short circuit, resulting in a loss of power steering assist.

Risk: A loss of power steering assist can increase the risk of a crash.

POWER TRAIN:AUTOMATIC TRANSMISSION:FLUID/LUBRICANT:PUMP

Hyundai Motor America (Hyundai) is recalling certain 2023-2024 Palisade Tucson, 2023 Sonata, Elantra, and Kona vehicles. The electronic controller for the Idle Stop & Go oil pump assembly may contain damaged electrical components that can cause the pump controller to overheat.

Risk: An electric oil pump assembly that overheats increases the risk of a vehicle fire.

ELECTRICAL SYSTEM

The contact owns a 2024 Hyundai Tucson. The contact stated that while the vehicle was parked, while attempting to enter the vehicle, the key fob failed to function as intended. The contact was unable to unlock the doors to the vehicle. The contact noticed that the battery was completely drained. The vehicle was taken to the dealer; however, the failure was not duplicated. The contact was informed that the vehicle needed to be started daily to prevent the battery from draining. The contact stated that the failure was persistent. The contact stated that because of the persistent failure, the contact was afraid to drive the vehicle. The vehicle was taken back to the dealer; however, the failure was not duplicated. The manufacturer was made aware of the failure. The failure mileage was approximately 900.

ELECTRICAL SYSTEM

Third time SUV was parked for multiple days without being started and the main battery did not keep the charge. First time was five days and required a battery jump. Then it was 22 days, and as expected, the battery did not keep the charge and required a jump. This week it was eight days and same thing happened. I know the SUV is a hybrid but the main battery should not be run down to not be able to start the engine after a short time not being started. My brother has a 2014 Ford product hybrid and does not have any battery issues when that hybrid vehicle is not started for a period of time.

VEHICLE SPEED CONTROL

The contact owns a 2024 Hyundai Tucson. The contact stated that while stopped at a red light with five vehicles in front of her, the vehicle suddenly accelerated and crashed into several unknown vehicles. The driver swerved and crashed into a cement truck to stop. There were no warning lights illuminated. A woman occupying another unknown vehicle sustained head injuries. The vehicle was towed to a body shop. The air bags deployed. A police report was filed. The driver did not sustain any injuries. There were no reported fires. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not notified. The failure mileage was 2,900.

VISIBILITY/WIPER

The middle panel of the panorama roof exploded spontaneously while I was driving at 50 mph on the highway. The car shook with the explosion. I pulled over to find a gaping hole in my roof and glass shards resting on the shade. This caused the shade to hammock down towards the driver and passenger seats making it unsafe to drive.

UNKNOWN OR OTHER

I am filing a complaint regarding a persistent and disruptive software feature in my leased 2024 Hyundai Tucson Hybrid. The vehicle has an integrated "Red Light Camera Warning" that plays an audible voice alert every time I approach or pass an intersection with a red light camera. Despite numerous attempts through the dealership and Hyundai corporate support, according to Hyundai, the alert is part of their Advanced Driver Assistance System (ADAS) and is considered a safety feature. However, this is not a safety feature, it is a ticket avoidance alert, and the frequent and repetitive alerts create a distraction from safe driving. Key safety concerns: The alert interrupts active phone calls, audio, and music playback at every flagged intersection, regardless of whether I am obeying traffic laws. This forces the driver’s attention away from the road to deal with the disruption or attempt to resume audio. The alert is often triggered in rapid succession when driving through urban areas with multiple camera-monitored intersections, increasing driver stress and reducing focus. Competing manufacturers (Toyota, Honda, Ford, etc.) allow drivers to disable this feature, but Hyundai claims they do not. There is video documentation showing that Hyundai vehicles are capable of disabling this feature via a simple toggle [XXX]. Hyundai’s unwillingness to offer this basic option infringes on the driver’s ability to maintain focus and control over their in-vehicle environment. I respectfully request that NHTSA investigate whether this alert poses a safety hazard due to distraction and urge Hyundai to provide an option for owners to permanently disable or mute it. Thank you for your attention to this matter. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

ENGINE

The contact owned a 2024 Hyundai Tucson. The contact stated that his wife was reversing out of the work parking space, the brake pedal was depressed, and when the gear shift was shifted into drive(D), the vehicle then accelerated independently. The contact stated that the engine revved, hit a parked vehicle, bounced off that vehicle, and continued to accelerate independently, abruptly veered the steering wheel to the left to avoid hitting a tree. The contact's vehicle then hit a second parked vehicle, where it came to a stop. No warning lights were illuminated, and none of the warning alarms sounded. The driver’s and passenger’s side air bags did not deploy. A police report was not filed. There were no injuries sustained. The insurance company was notified and towed the vehicle to a collision center. The vehicle was not diagnosed. The manufacturer was not notified of the failure. The failure mileage was 17,000.

FUEL/PROPULSION SYSTEM

On multiple occasions the vehicle has not transferred from EV to mechanical mode and has stalled out. Shutting the car and restarting it resolved the problem each time. Hyundai has not been able to find the fault after multiple trips to the dealership and no code is recorded or reported. I bought a code reader and the last time this occurred recorded a code. P1120 $07e8Pd I brought the car back into Hyundai and reported the code to- It was not saved in the car's memory. They have had the car for over 3 weeks now and repairs have not been completed.

UNKNOWN OR OTHER

My a/c system has a strong mold/mildew smell. The dealership flushed the system and said a bunch of black mold came out. It has been 3 months and the issue is back. It can’t possibly be safe and healthy to be constantly breathing in mold spores. I have seen a ton of other owners complaining about the same issue. I definitely think the a/c drain design is faulty in some regard.

VEHICLE SPEED CONTROL

The contact owns a 2024 Hyundai Tucson. The contact stated that while operating the vehicle, the manual speed limit assist erroneously activated causing the vehicle to suddenly decelerate, and the vehicle failed to exceed 20 MPH. The cause of the failure was not yet determined, and the vehicle was not repaired. The manufacturer and local dealer were notified of the failure. The failure mileage was 40,000.

FORWARD COLLISION AVOIDANCE: WARNINGS

My wife and I purchased a 2024 Hyundai Tucson in June.  Since February 28, 2025 the SRS indicator lights have come on twice. Hyundai replaced the airbag twice.  In March, the emergency brake system red lights illuminated, and the car came to an abrupt stop.  Luckily, there were  no Cars behind me.  Seconds later, the car resumed, and the lights disappeared. Hyundai dealership took the car in and returned it in two hours noting they could not duplicate. Several days ago, the same thing happened with the emergency brake system. Driving at approximately 40 mph the car slammed on brakes and the dash illuminated again.  No cars behind me. The dealership returned the car once again, noting they could not duplicate.   The car has less than 8000 miles.  I won’t allow my wife to drive more than 10 miles alone.  It’s unsafe. The manual states the car is not to be driven with any of the sys indicators on and to do so would cause serious injury or damage to the car.   I will send attachments of invoices, NHTSA complaints and Hyundai manual info about unsafe condition. 

AIR BAGS

My wife and I purchased a 2024 Hyundai Tucson in June.  Since February 28, 2025 the SRS indicator lights have come on twice. Hyundai replaced the airbag twice.  In March, the emergency brake system red lights illuminated, and the car came to an abrupt stop.  Luckily, there were  no Cars behind me.  Seconds later, the car resumed, and the lights disappeared. Hyundai dealership took the car in and returned it in two hours noting they could not duplicate. Several days ago, the same thing happened with the emergency brake system. Driving at approximately 40 mph the car slammed on brakes and the dash illuminated again.  No cars behind me. The dealership returned the car once again, noting they could not duplicate.   The car has less than 8000 miles.  I won’t allow my wife to drive more than 10 miles alone.  It’s unsafe. The manual states the car is not to be driven with any of the sys indicators on and to do so would cause serious injury or damage to the car.   I will send attachments of invoices, NHTSA complaints and Hyundai manual info about unsafe condition. 

FORWARD COLLISION AVOIDANCE: WARNINGS

Owner [XXX] [XXX] . Driver [XXX] [XXX] ) [XXX] All of a sudden my 2024 Tucson vin: [XXX] gages indicated emergency braking for about 1 to 3 seconds and the front end went down ,(my wife and I went foward ) as though I was stopping (scared me ). It was the forward collision avoidance sys. I was so happy no one was behind me. Avoided a rear end collision. [XXX] we were Traveling west in the left lane of a three lane highway. I released the gas pedal to make a left turn in a left turn lane. The light was red. No one really behind me or to my left. Only one car to the right of me in another lane. This is dangerous! This is my wife’s car. Enough said!!!! Car was at the dealer for a couple of hours. They could not duplicate. Said it could have been my floor mat “that made my emergency lights come on the dash.” “STUPID” This occurred the day after picking up my car from the dealer. Feb. 28, Hyundai replaced the Air bag. STS light came on. Picked the car up Monday. Today [XXX] Thursday) the STS Airbag light came on again. The bag was replaced again. [XXX] the front collision sys emergency stop sys alerted again. Again, Hyundai declared they could not duplicate. This is an unsafe car. A death trap. Hyundai warns death may occur if using while driving can cause death. They also warn us using the emergency brake while driving may damage the brakes or cause a collision. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

AIR BAGS

Owner [XXX] [XXX] . Driver [XXX] [XXX] ) [XXX] All of a sudden my 2024 Tucson vin: [XXX] gages indicated emergency braking for about 1 to 3 seconds and the front end went down ,(my wife and I went foward ) as though I was stopping (scared me ). It was the forward collision avoidance sys. I was so happy no one was behind me. Avoided a rear end collision. [XXX] we were Traveling west in the left lane of a three lane highway. I released the gas pedal to make a left turn in a left turn lane. The light was red. No one really behind me or to my left. Only one car to the right of me in another lane. This is dangerous! This is my wife’s car. Enough said!!!! Car was at the dealer for a couple of hours. They could not duplicate. Said it could have been my floor mat “that made my emergency lights come on the dash.” “STUPID” This occurred the day after picking up my car from the dealer. Feb. 28, Hyundai replaced the Air bag. STS light came on. Picked the car up Monday. Today [XXX] Thursday) the STS Airbag light came on again. The bag was replaced again. [XXX] the front collision sys emergency stop sys alerted again. Again, Hyundai declared they could not duplicate. This is an unsafe car. A death trap. Hyundai warns death may occur if using while driving can cause death. They also warn us using the emergency brake while driving may damage the brakes or cause a collision. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

ELECTRICAL SYSTEM

The contact owns a 2024 Hyundai Tucson. The contact stated while driving approximately 60 MPH, the vehicle stalled. The contact stated that before the vehicle stalled, there were several unknown warning lights illuminated before the instrument cluster went black. The contact pulled over and shifted to park(P) and was able to restart the vehicle after several attempts. The contact stated that the failure had occurred intermittently and at various speeds. The vehicle also occurred while stopped at a traffic signal. The contact had taken the vehicle to a local dealer who was unable to duplicate the failure. The vehicle was not repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 18,000.

ENGINE

The contact owns a 2024 Hyundai Tucson. The contact stated while driving approximately 60 MPH, the vehicle stalled. The contact stated that before the vehicle stalled, there were several unknown warning lights illuminated before the instrument cluster went black. The contact pulled over and shifted to park(P) and was able to restart the vehicle after several attempts. The contact stated that the failure had occurred intermittently and at various speeds. The vehicle also occurred while stopped at a traffic signal. The contact had taken the vehicle to a local dealer who was unable to duplicate the failure. The vehicle was not repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 18,000.

FORWARD COLLISION AVOIDANCE: WARNINGS

Driving 70 on the interstate without any cars in front or side of me and car auto hard braked down to 60 and red emergency brake light was on. An 18 wheeler was behind me. Luckily no injuries or accidents happened.

SEAT BELTS

My grandchild just went from a car seat to a booster seat. The back seatbelt buckle is so recessed that you cannot buckle it without 20 minutes of fighting with it! This is a major problem because a child could not get themselves buckled. And it takes an adult 20 minutes to try and buckle the shoulder belt into The seat buckle because it’s so recessed in the backseat. I looked on the Internet to see if there was a way to loosen the belts or extend them from the back and there is nothing so I went to a Hyundai Tucson forum and I see there have been many complaints About the recessed seat buckle not being accessible. This is a major concern for anyone transporting children and their grand grandchildren. I’ve already complained to Hyundai about the car randomly shutting off. Hyundai needs to put out a fix for this or provide Hyundai owners with some kind of extension for that buckle. I also understand that taking it into the dealership didn’t help, because they couldn’t buckle it either.

FORWARD COLLISION AVOIDANCE: WARNINGS

As I am driving on the Garden State Parkway on sunny days and rainy days at approx 70-75 mph the Emergency Braking System notification activated on the dashboard in red, a noise activates and the car feels like it is going to stop short. This seems to occur about one and a half hours into my ride There are no cars in front of me or directly next to me. This occurs randomly and has happened seven or eight times since I leased the car in December 2024. It is very scary and the service techs at the dealership where I leased it cannot duplicate the occurrence because it is random. I feel unsafe driving the car because I am afraid at some point the car may stop on the highway. As it is now it feels like it is going to stop because it slows down.

VISIBILITY/WIPER

Automatic headlight system causes the vehicle headlights to turn on and off during daylight conditions. The LCD display in the dashboard also dims to the point that the information presented cannot be read. This typically happens on bright, sunny days with a clear sky. Vehicle has been to the dealership in excess of seven times where they've made multiple attempts to repair it. The light sensor behind the windshield has been replaced. The body control module has been replaced. The technician also tried to make modifications to the light sensor, but the problem persists. There are a number of other instances of this exact issue involving Hyundai Tucsons, Santa Fe. and Santa Cruz vehicles shown on the NHTSA site, and also when searching other sites online. Dealer technician has repeatedly documented that the problem exists. Dealer tech reported that the Tech at the Hyundai helpline suggested that the auto headlight feature not be used as a resolution. While not a solution under any conditions, even with auto headlight feature turned to off, the dashboard displays continue to dim during the day. The flashing headlights represent a serious safety issue as when following another vehicle, that driver may misinterpret the flashing headlight problem as an aggressive gesture and trigger a road rage type response. The call taker I spoke with at Hyundai when I opened a customer service case said that he personally had that very issue with another driver due to flashing headlights.

ELECTRICAL SYSTEM

Automatic headlight system causes the vehicle headlights to turn on and off during daylight conditions. The LCD display in the dashboard also dims to the point that the information presented cannot be read. This typically happens on bright, sunny days with a clear sky. Vehicle has been to the dealership in excess of seven times where they've made multiple attempts to repair it. The light sensor behind the windshield has been replaced. The body control module has been replaced. The technician also tried to make modifications to the light sensor, but the problem persists. There are a number of other instances of this exact issue involving Hyundai Tucsons, Santa Fe. and Santa Cruz vehicles shown on the NHTSA site, and also when searching other sites online. Dealer technician has repeatedly documented that the problem exists. Dealer tech reported that the Tech at the Hyundai helpline suggested that the auto headlight feature not be used as a resolution. While not a solution under any conditions, even with auto headlight feature turned to off, the dashboard displays continue to dim during the day. The flashing headlights represent a serious safety issue as when following another vehicle, that driver may misinterpret the flashing headlight problem as an aggressive gesture and trigger a road rage type response. The call taker I spoke with at Hyundai when I opened a customer service case said that he personally had that very issue with another driver due to flashing headlights.

EXTERIOR LIGHTING

Automatic headlight system causes the vehicle headlights to turn on and off during daylight conditions. The LCD display in the dashboard also dims to the point that the information presented cannot be read. This typically happens on bright, sunny days with a clear sky. Vehicle has been to the dealership in excess of seven times where they've made multiple attempts to repair it. The light sensor behind the windshield has been replaced. The body control module has been replaced. The technician also tried to make modifications to the light sensor, but the problem persists. There are a number of other instances of this exact issue involving Hyundai Tucsons, Santa Fe. and Santa Cruz vehicles shown on the NHTSA site, and also when searching other sites online. Dealer technician has repeatedly documented that the problem exists. Dealer tech reported that the Tech at the Hyundai helpline suggested that the auto headlight feature not be used as a resolution. While not a solution under any conditions, even with auto headlight feature turned to off, the dashboard displays continue to dim during the day. The flashing headlights represent a serious safety issue as when following another vehicle, that driver may misinterpret the flashing headlight problem as an aggressive gesture and trigger a road rage type response. The call taker I spoke with at Hyundai when I opened a customer service case said that he personally had that very issue with another driver due to flashing headlights.

FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING

All of a sudden my 2024 Tucson gages indicated emergency braking for about 1 to 3 seconds and the front end went down as though I was stopping (scared me ). I was so happy no one was behind me. No one really behind me or to my left. Only one car to the right of me in another lane. Also, had to replace air bag at 6176 miles

SERVICE BRAKES

All of a sudden my 2024 Tucson gages indicated emergency braking for about 1 to 3 seconds and the front end went down as though I was stopping (scared me ). I was so happy no one was behind me. No one really behind me or to my left. Only one car to the right of me in another lane. Also, had to replace air bag at 6176 miles

AIR BAGS

All of a sudden my 2024 Tucson gages indicated emergency braking for about 1 to 3 seconds and the front end went down as though I was stopping (scared me ). I was so happy no one was behind me. No one really behind me or to my left. Only one car to the right of me in another lane. Also, had to replace air bag at 6176 miles

FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING

Forward Collision Emergency Braking. Have had this happen on 5 different occasions. Very dangerous. The vehicle without warning slams on the emergency brakes and issues a warning. Took into dealer and they could find NO error codes and did nothing. First time this happened I thought maybe a bag or something flew up and obscured the forward facing sensors. Pulled over and checked nothing. Then 3 times it happened within 5 minutes. Pulled over and sensors looked fine no dirt or anything on the sensors. Can not drive car with this and so have been disabling the system except for a warning tone. Today it activated it again. Usually when I approach something the sensors turn yellow and then red when getting real close to an object. But today when it activated when not close to anything and driving down the road all the forward sensors activated with the warning but it was gray. (not yellow or red) Since I had it on warning only the brakes did not activate. This is very dangerous and unless you disable the automatic emergency braking could lead someone to plow into the backend of the SUV and it evidentially does not cause error codes. Yes,someone can contact me concerning this. This has happened multiple times. Intermittently.

FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING

My car automatically braked in the middle of an intersection and caused my vehicle to be rear-ended. This was the third time automatic braking engaged when it should not have been. In the most recent incident on [XXX] I was injured and had to have medical attention. I googled automatic braking and there were many reports of automatic braking being deployed when it should not have been. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

SERVICE BRAKES

My car automatically braked in the middle of an intersection and caused my vehicle to be rear-ended. This was the third time automatic braking engaged when it should not have been. In the most recent incident on [XXX] I was injured and had to have medical attention. I googled automatic braking and there were many reports of automatic braking being deployed when it should not have been. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

UNKNOWN OR OTHER

While driving my 2024 Hyundai Tucson at highway speeds on a clear day with no surrounding traffic, I was startled by an extremely loud bang that sounded like an explosion. Pieces of shattered glass rained down inside the passenger cabin, creating a potentially hazardous situation. This incident was a traumatic experience. The sudden and unexpected event had the potential to cause serious injury to the driver, as well as increase the risk of a collision due to the shock and distraction it caused. Additionally, other pieces of shattered glass were propelled from the vehicle, posing a risk of injury or damage to other drivers on the road. Upon physical inspection, it was noted that the glass from the panoramic sunroof was bowed upwards, which suggests the explosion originated from within the sunroof and NOT an external factor such as road debris or a rock. The vehicle, which is less than a year old, is currently at the Hyundai dealership pending an investigation. Given the severity of the incident and the potential risks to driver and passenger safety, I strongly recommend that a recall be issued or a comprehensive investigation be initiated by the NHTSA to prevent further occurrences of such dangerous incidents. Safety must be a priority, and swift action is necessary to ensure that no other drivers or passengers are at risk of similar events.

VISIBILITY/WIPER

While driving my 2024 Hyundai Tucson at highway speeds on a clear day with no surrounding traffic, I was startled by an extremely loud bang that sounded like an explosion. Pieces of shattered glass rained down inside the passenger cabin, creating a potentially hazardous situation. This incident was a traumatic experience. The sudden and unexpected event had the potential to cause serious injury to the driver, as well as increase the risk of a collision due to the shock and distraction it caused. Additionally, other pieces of shattered glass were propelled from the vehicle, posing a risk of injury or damage to other drivers on the road. Upon physical inspection, it was noted that the glass from the panoramic sunroof was bowed upwards, which suggests the explosion originated from within the sunroof and NOT an external factor such as road debris or a rock. The vehicle, which is less than a year old, is currently at the Hyundai dealership pending an investigation. Given the severity of the incident and the potential risks to driver and passenger safety, I strongly recommend that a recall be issued or a comprehensive investigation be initiated by the NHTSA to prevent further occurrences of such dangerous incidents. Safety must be a priority, and swift action is necessary to ensure that no other drivers or passengers are at risk of similar events.

VEHICLE SPEED CONTROL

Sudden loss of speed for no reason. was traveling at 35 mph when vehicle suddenly dropped to 22 mph. Stepped on gas with no response. I know the 22 mph because it showed up on warning illuminator. Car behind me almost hit me because he had no indication (prior warning). Turned off at closest exit, turned vehicle off then on restart things were normal. Took to dealer and they found nothing in computer code or mechanical to explain why this happened. Am an older women afraid what will happen if repeats on highway going 70+ mph. Please made Hyundia find and fix.