2014 HYUNDAI TUCSON

SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP:CONTROL UNIT/MODULE

Hyundai Motor America (Hyundai) is recalling certain 2016-2018 Santa Fe, 2017-2018 Santa Fe Sport, 2019 Santa Fe XL, and 2014-2015 Tucson vehicles. The Anti-Lock Brake System (ABS) module could malfunction and cause an electrical short, which could result in an engine compartment fire.

Risk: An engine compartment fire while parked or driving can increase the risk of injury.

POWER TRAIN

The engine experienced catastrophic failure. A piston punctured the engine block, likely due to failure of the connecting rods, an issue known to be associated with the recalled Theta II engine. The engine is still in the vehicle and available for inspection upon request. We were scared and felt seriously endangered during the incident. The engine failed suddenly while we were driving on a busy highway. After a loud clunk, the vehicle immediately lost acceleration and would not respond to throttle input. We had to quickly pull over onto the shoulder while traffic sped past us at high speeds. The sudden loss of power in fast-moving traffic put us at serious risk of being rear-ended or causing an accident. It was a frightening experience that could have resulted in injury or worse. An independent mechanic inspected the vehicle and confirmed there is a hole in the engine block caused by a piston. We brought the vehicle to a Hyundai dealership for further inspection. Still, their communication has been poor, and they have not yet confirmed whether they acknowledge the issue or its relation to the Theta II engine recall. Our independent mechanic has inspected the vehicle and is currently with a Hyundai dealership for inspection. It has not been checked by police or insurance representatives. No third-party inspector has been involved beyond the dealer and mechanic. There were no warning lights, error messages, noises, or performance symptoms before the failure. The engine failure was sudden and occurred without any prior indication of a problem.

ENGINE

The engine experienced catastrophic failure. A piston punctured the engine block, likely due to failure of the connecting rods, an issue known to be associated with the recalled Theta II engine. The engine is still in the vehicle and available for inspection upon request. We were scared and felt seriously endangered during the incident. The engine failed suddenly while we were driving on a busy highway. After a loud clunk, the vehicle immediately lost acceleration and would not respond to throttle input. We had to quickly pull over onto the shoulder while traffic sped past us at high speeds. The sudden loss of power in fast-moving traffic put us at serious risk of being rear-ended or causing an accident. It was a frightening experience that could have resulted in injury or worse. An independent mechanic inspected the vehicle and confirmed there is a hole in the engine block caused by a piston. We brought the vehicle to a Hyundai dealership for further inspection. Still, their communication has been poor, and they have not yet confirmed whether they acknowledge the issue or its relation to the Theta II engine recall. Our independent mechanic has inspected the vehicle and is currently with a Hyundai dealership for inspection. It has not been checked by police or insurance representatives. No third-party inspector has been involved beyond the dealer and mechanic. There were no warning lights, error messages, noises, or performance symptoms before the failure. The engine failure was sudden and occurred without any prior indication of a problem.

FUEL/PROPULSION SYSTEM

The high pressure fuel line began leaking gasoline after warrantee replacement of engine.

ENGINE

I purchased a 2014 Hyundai Tucson with the 2.4L Theta II engine, which has since experienced complete engine failure due to bearing wear. The Hyundai dealership diagnosed this as the same defect covered under Recall 20V-520 and the Kinnick & Coats v. Hyundai class-action settlement (Case No. 8:17-cv-00838-JLS-JDE). Under the terms of that class action, this defect — specifically premature bearing wear leading to engine seizure — should be covered. However, Hyundai Corporate denied my repair, stating that my vehicle did not qualify under the 953 recall. I was never notified of this recall, as I had recently purchased the vehicle used and was unaware of the outstanding recall eligibility or class-action timelines. I maintain my vehicles meticulously, including regular oil changes every 3,000 miles, and this failure occurred under normal driving conditions. Given that the dealership confirmed the defect is exactly what’s outlined in the recall and lawsuit, and the fact that the recall should have applied to my engine based on symptoms and model, I am requesting an expansion of recall coverage or support through warranty or settlement coverage. I have already contacted Hyundai and was denied support. I am requesting investigation into why my VIN is not included and believe the recall scope should be extended.

ENGINE

While I was driving ,my vehicle unexpectedly shut off without warning ,creating a dangerous situation ,thankfully I was able to safely pull over .Due to this issue I had my car towed to dealership for inspection I discovered my car is included a recall number 22v056000 Hyundai refusal to honor a recall that directly affected my car Hyundai have denied the recall on my car for no reason

ENGINE

As with many Hyundai vehicles, soon after I hit 100,000 miles, there was unbeknownst to me and oil leak that caused the engine to seize. There was no indicatior lights warning of the issue. My car’s has been maintained, and although this is under warranty, Hyundai is refusing to fix the issue because I cannot produce oil receipts for the past 4 1/2 years that I’ve owned the car. Those that I have produced, they say are not enough. The service station that I normally had my oil changed at has shuttered. So I cannot get as many oil change receipts as they want. Besides, who keeps receipts of this nature and what if oil changes were done privately?