Hyundai Motor America (Hyundai) is recalling certain 2011-2015 Elantra, Genesis Coupe, Sonata Hybrid, 2012-2015 Accent, Azera, Veloster, 2013-2015 Elantra Coupe, Santa Fe, 2014-2015 Equus, 2010-2012 Veracruz, 2010-2013 Tucson, 2015 Tucson Fuel Cell, and 2013 Santa Fe Sport vehicles. The Anti-Lock Brake System (ABS) module may leak brake fluid internally and cause an electrical short, which can result in an engine compartment fire while parked or driving.

Risk: An engine compartment fire while parked or driving can increase the risk of injury.

PARK OUTSIDE

2017 HYUNDAI SONATA HYBRID

469377 vehicles affected

21V749000

EXTERIOR LIGHTING:TURN SIGNAL

Hyundai Motor America (Hyundai) is recalling certain 2015-2017 Sonata, 2016-2017 Sonata Hybrid, and Sonata Plug-In Hybrid vehicles. The Smart Junction Box (SJB) software logic may not properly interpret the signals received from the multifunction switch, which could cause the turn signal to activate in the opposite direction of what the driver intended.

Risk: A turn signal that activates in the opposite direction of what was intended by the driver increases the risk of a crash.

2018 HYUNDAI SONATA HYBRID

348158 vehicles affected

21V619000

LATCHES/LOCKS/LINKAGES:TRUNK LID:LATCH

Hyundai Motor America (Hyundai) is recalling certain 2017-2018 Sonata, 2016-2018 Sonata Hybrid, 2018-2020 Accent, and 2016-2017 Azera vehicles. The trunk latch may become damaged, preventing the opening of the trunk from the inside. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 401, "Internal Trunk Release."

Risk: A person inside the trunk compartment may become trapped, increasing their risk of injury.

2017 HYUNDAI SONATA HYBRID

95515 vehicles affected

21V727000

ENGINE

Hyundai Motor America (Hyundai) is recalling certain 2017 Tucson and Sonata Hybrid vehicles. The connecting rod bearings inside the engine may wear prematurely, which can result in engine damage.

Risk: A damaged engine can increase the risk of a fire or it can cause an engine stall, increasing the risk of a crash.

2011 HYUNDAI SONATA HYBRID

272126 vehicles affected

20V393000

EQUIPMENT:ELECTRICAL

Hyundai Motor America (Hyundai) is recalling certain 2011-2012 Hyundai Elantra and Sonata Hybrid, 2012 Accent and Veloster vehicles. The 12V accessory socket outlet may have been over-tightened during installation, possibly disabling the thermal fuse and allowing the outlet to overheat with prolonged use, such as by using the Tire Mobility Kit air compressor to inflate a tire.

Risk: An overheated accessory outlet increases the risk of fire.

2016 HYUNDAI SONATA HYBRID

128948 vehicles affected

20V746000

ENGINE

Hyundai Motor America (Hyundai) is recalling certain 2015-2016 Veloster, 2012 Santa Fe, 2011-2013 Sonata Hybrid, and 2016 Sonata Hybrid vehicles. The connecting rod bearings inside the engine may wear prematurely, which over time can result in engine damage.

Risk: A damaged engine can increase the risk of a fire or it can cause an engine stall, increasing the risk of a crash.

2012 HYUNDAI SONATA HYBRID

580058 vehicles affected

18V137000

AIR BAGS

Hyundai Motor America (Hyundai) is recalling certain 2011-2013 Sonata and 2011-2012 Sonata Hybrid vehicles. On February 27, 2018, Hyundai Motor Company (Hyundai) notified NHTSA that they were recalling 154,753 model year 2011 Sonata vehicles. On April 18, 2018, Hyundai expanded the recall to include an additional 425,305 model year 2012-2013 Sonata and 2011-2012 Sonata Hybrid vehicles. In the event of a crash, the air bag control unit (ACU) may short circuit, preventing the frontal air bags, seat belt pretensioners, and side air bags from deploying.

Risk: If the frontal air bags, seat belt pretensioners, and side air bags are disabled, there is an increased risk of injury to the vehicle occupants in the event of a vehicle crash that necessitates deployment of these safety systems.

2015 HYUNDAI SONATA HYBRID

443545 vehicles affected

17V617000

SEAT BELTS:FRONT:ANCHORAGE

Hyundai Motor America (Hyundai) is recalling certain 2011-2014 Sonata and 2011-2015 Sonata Hybrid vehicles previously repaired under recall campaign 17V-152. The seat belt linkages for both front seat belts may detach from the seat belt anchor pretensioners.

Risk: If the seat belt linkage detaches from the seat belt anchorage, it can not properly restrain the occupant in the event of a crash, increasing the risk of injury.

2015 HYUNDAI SONATA HYBRID

977778 vehicles affected

17V152000

SEAT BELTS:FRONT:ANCHORAGE

Hyundai Motor America (Hyundai) is recalling certain 2011-2014 Sonata and 2011-2015 Sonata Hybrid vehicles. In the affected vehicles, the seat belt linkages for both front seat belts may detach from the seat belt anchor pretensioners.

Risk: In the event of a crash, if the seat belts detach from the anchor pretensioners, it can increase the risk of injury.

2016 HYUNDAI SONATA HYBRID

33 vehicles affected

16V232000

AIR BAGS:FRONTAL

Hyundai Motor Company (Hyundai) is recalling certain model year 2015-2016 Sonata vehicles manufactured May 29, 2014 to February 11, 2016, 2017 Elantra vehicles manufactured January 12, 2016 to February 22, 2016, and one 2016 Sonata Hybrid vehicle manufactured October 15, 2015. In these vehicles, the driver's frontal air bag may be missing a chemical enhancer required for the second stage air bag deployment, resulting in the second stage not deploying in certain crashes. The primary stage will deploy as intended.

Risk: An air bag that does not inflate increases the risk of injury.

Recent Complaints

2012 HYUNDAI SONATA HYBRID

ID: 2126396

ENGINE

The contact owned a 2012 Hyundai Sonata. The contact stated that while driving at 75 MPH on the highway, while depressing the accelerator pedal, the vehicle failed to accelerate. No warning lights illuminated. The contact veered over to the right side of the road, turned the vehicle off, and she noticed smoke coming from the engine. A bystander behind her noticed the flames coming up from the engine. The contact mentioned she exited the vehicle and called 911. No injuries were sustained. No medical attention was required. A police report was filed. The fire department extinguished the fire. The vehicle was destroyed. The vehicle was towed to Atow lot. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 160,000.

Fire

2016 HYUNDAI SONATA HYBRID

ID: 2119568

ENGINE

The contact owns a 2016 Hyundai Sonata Hybrid. The contact stated that while driving at 20 MPH, the message "Shut Down" was displayed, and the vehicle lost motive power. The contact was able to pull over to the side of the road; however, the vehicle failed to restart. The vehicle was towed to the dealer, where it was diagnosed with engine failure, and the contact was informed that the engine needed to be replaced. The vehicle was not repaired due to the cost. The manufacturer was notified of the failure and declined to cover the repair under warranty. The failure mileage was approximately 140,600.

2017 HYUNDAI SONATA HYBRID

ID: 2100550

ELECTRICAL SYSTEM:INSTRUMENT PANEL:SPEEDOMETER/ODOMETER

Odometer Fraud. The contact stated that while attempting to purchase a 2017 Hyundai Sonata Hybrid, it was later discovered that there was a mileage discrepancy. The vehicle was not yet purchased. The vehicle mileage was 87,000, but the contact later discovered that the mileage was 105,000.

2017 HYUNDAI SONATA HYBRID

ID: 2098940

ENGINE AND ENGINE COOLING

The contact owns a 2017 Hyundai Sonata Hybrid. The contact stated while driving at various speeds, the contact noticed an abnormal ticking sound coming from the engine. There was no warning light illuminated. The vehicle was taken to the dealer, where it was diagnosed with engine failure due to the rod bearings failure. The dealer determined that the engine needed to be replaced and informed the contact that the repair was not covered under an unknown recall due to the mileage. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 183,000.

2016 HYUNDAI SONATA HYBRID

ID: 2089218

ENGINE

The contact owns a 2016 Hyundai Sonata Hybrid. The contact stated that while driving at an undisclosed speed, the vehicle went into LIMP Mode with several unknown warning lights illuminated. The vehicle was towed to the dealer and was diagnosed with engine failure. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 70,000.

2016 HYUNDAI SONATA HYBRID

ID: 2087958

ELECTRICAL SYSTEM

The contact owns a 2016 Hyundai Sonata Hybrid. The contact stated that while driving at an undisclosed speed, the vehicle inadvertently lost motive power. The contact was able to pull over to the shoulder of the roadway, and the message "Warning - Do not Attempt to Restart" was displayed. No warning lights were illuminated. The vehicle was towed to the dealer, who diagnosed a failure of the engine wiring harness. The vehicle was repaired, but the failure reoccurred. The vehicle was taken back to the dealer and was diagnosed as a failure with the engine wiring harness. The vehicle was not repaired. The vehicle had been back to the dealer several times. Recently, the contact was informed that the wiring harness was soy-based insulated, and rodents were causing damage to the wiring harness due to the smell. The manufacturer was notified of the failure but provided no assistance. The failure mileage was 80,000. The VIN was not available.

2011 HYUNDAI SONATA HYBRID

ID: 2086598

ENGINE AND ENGINE COOLING

The contact owns a 2011 Hyundai Sonata. The contact stated that while driving on the highway at 60 MPH, there was smoke coming from the rear of the vehicle. The contact immediately pulled over to inspect the vehicle. Upon checking under the hood, the contact noticed that the coolant level was low. The contact attempted to restart the vehicle; however, the vehicle failed to start. The vehicle was towed to a dealer, where it was diagnosed, and the contact was advised that the engine had overheated and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 130,000.

2015 HYUNDAI SONATA HYBRID

ID: 2081405

ENGINE AND ENGINE COOLING

The contact owns a 2015 Hyundai Sonata Hybrid. The contact stated that while driving 5 MPH and making a left turn, the vehicle made an abnormal knocking sound. The contact stated that upon pulling into an apartment complex parking lot, the contact noticed that there was smoke coming out from underneath the hood. There was no warning light illuminated. The contact immediately parked and exited the vehicle. The contact stated that upon opening the hood, the contact noticed a small fire and was able to extinguish the fire with a water bottle. The contact was able to push the vehicle into a parking space with the assistance of her son. There was no injury sustained. No police report was filed. The vehicle was towed to an independent mechanic, where it was diagnosed that a fluid leak from an unknown hose had caused the fire, and there was a hole in the engine block. The contact also stated that there was a puddle of fluid on the ground. The vehicle was not repaired. The contact became aware that the VIN was included in NHTSA Campaign Number: 23V651000(Service Brakes, Hydraulic), which the contact related to the failure. The dealer and the manufacturer were not notified of the failure. The failure mileage was approximately 115,395.

Fire

2015 HYUNDAI SONATA HYBRID

ID: 2081404

SERVICE BRAKES, HYDRAULIC

Fire

2017 HYUNDAI SONATA HYBRID

ID: 2074691

ENGINE

FAIL/MALFUNCTION 3/18/25: Internal engine failure diagnosed by local Avondale, AZ Hyundai dealership service - rod bearing failure suspected. Vehicle currently undergoing Bearing Clearance Test to affirm this or any connecting rod issues, with possible need for total engine replacement. When googling "Hyundai Sonata hybrid 2017 internal engine failure," masses of reports generate from consumers with this model, complaining of same defect, as do numerous recalls for such defects that have been mandated for the model with range of years including 2017.Yet when searching with my VIN, it says no recalls have been mandated, in spite of the undeniable, widespread identical defect. Available for inspection. SAFETY RISK: Driving on the freeway in city traffic at 70-75mph, the engine completely stopped and all dash lights lit up at once. Vehicle had to be coasted to shoulder to wait for roadside assistance. Extremely hazardous to us in vehicle and to all around us with sudden, dramatic speed change in moving, constant freeway traffic. First time: Our usual mechanics at Pep Boys did diagnostic but found nothing, the vehicle drove normally for them, yet they did our regular tune-up, oil change, etc. Two weeks later, the same event happened on freeway, identical to first time. We were very lucky that no crashes happened either time. Pep Boys advised that Hyundai investigate the issue. PRIOR SYMPTOMS: No warning lights or sounds presented until the events themselves, when the entire dash lit up. However, in the couple of months before, there were occasional, slight hesitation moments in the motion while driving at any speed. CONCERNS: 1) It seems Hyundai is on track to want to charge me for an entire engine replacement, or for whatever engine repairs they deem, e.g. connecting rods, for manufacturing defects that they are entirely responsible for, 2) no recall seems to be mandated YET for this VIN batch, and 3) too many consumers are in danger - physically and financially.